2007 Volkswagen Passat

ENGINE FAILURE AT 170,000 DUE TO TIMING CHAIN TENSIONER FAILURE. ENGINE DIED AT 170,000 MILES DUE TO THE FAILURE OF A PART THAT HAS FAILED. IF WE HAD KNOWN THAT THIS IS A ISSUE WE WOULD HAVE REPLACED THE INEXPENSIVE PART AT THE TIMING BELT REPLACEMENT INTERVAL FOR A NOMINAL AMOUNT. ENGINE FAILURE WHILE VEHICLE WAS IN MOTION ON A CITY STREET. NOW WE HAVE A CAR WORTH NOTHING.

SON WAS DRIVING DOWN HIGHWAY AND FRONT END OF VEHICLE STARTED TO SHAKE THEN STALLED AND WOULD NOT START. TOWED TO INDEPENDENT MECHANIC. REPLACED HPFP ($1500). NOW TOLD THE TIMING CHAIN JUMPED AND HAS TO BE REPLACED WITH TIMING SPROCKET, TIMING TENSIONER, AND INTAKE CAME SHAFT. NOT SURE IF THERE IS DAMAGE ON ENGINE BOTTOM AS WELL. THE COST IS OVER $2000. VW DOES NOTHING BUT DOES ACKNOWLEDGE FAULTY PARTS. MY SN COULD HAVE BEEN KILLED ON THE HIGHWAY. THIS CAR HAS 78,000 MILES. IT SHOULD NOT STALL AT 65 MPH.

TL* THE CONTACT OWNS A 2007 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE WAS IN THE DRIVEWAY AT THE CONTACT'S RESIDENCE. THE CONTACT STARTED THE ENGINE, AND IT IMMEDIATELY STALLED. THE CONTACT RESTARTED THE ENGINE AND NOTICED THAT THERE WAS SMOKE COMING FROM THE DASHBOARD. THE CONTACT DISCONNECTED THE BATTERY AND LEFT THE DOORS OPEN. THE VEHICLE WAS TOWED TO THE LOCAL DEALER BEGLEY AUTO REPAIR LOCATED AT 3401 MANATEE AVE W, BRADENTON, FL 34205; PHONE NUMBER: (941) 748-3297 WHERE IT WAS DIAGNOSED THAT THE WHOLE WIRING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 72,000. ...UPDATED 11/15/17 *BF THE CONSUMER STATED THE VEHICLE WAS DECLARED A TOTAL LOSS. *JS

WHILE DRIVING MY CAR AFTER EXITING THE HIGHWAY, MY CAR SUDDENLY LOST POWER AND WENT FROM BEING OKAY -- TO NOT ABLE TO ACCELERATE TO FASTER THAN 20 MILES PER HOUR AND RUNNING EXTREMELY ROUGH. I WAS ON A BUSY STREET AND THIS WAS QUITE FRIGHTENING. TOOK THE CAR TO A MECHANIC AND AFTER $1600 OF OTHER REPAIRS WITH NO RESULT HE FINALLY DIAGNOSED THE PROBLEM AS THE TIMING BELT SLIPPING DUE TO A FAULTY OIL PUMP BOLT. APPARENTLY THIS OIL PUMP BOLT IS FAILING ON LOTS OF PASSAT 3.6 VORTEX ENGINE AND SHOULD BE UNDER RECALL -- SINCE THE FIX IS A RIDICULOUSLY HIGH AMOUNT. I WILL NOT BE ABLE TO AFFORD TO FIX THIS VEHICLE AND WILL BE PAYING FOR A CAR I CAN'T DRIVE.

CURRENTLY MY 2.0T 4 CYLINDER ENGINE IS EXPERIENCING FAILURES NOTED BY THE DIAGNOSTIC SYSTEM WITH FAULT CODE P2181 COOLING SYSTEM PERFORMANCE ALONG WITH A CYLINDER 1 AND CYLINDER 4 MISFIRE. THE SUGGESTED REMEDY FOR THE P2181 ERROR IS TO REPLACE THE THERMOSTAT AND/OR THE WATER PUMP. IN RESEARCHING COMMUNITY FORUMS, THIS PAIRING OF ISSUES APPEARS WIDESPREAD. THERE IS A POSSIBLE MANUFACTURING DESIGN FLAW THAT CORRELATES THE FAILURE OF ENGINE COILS AND/OR PLUGS WITH FAILURE OF THE WATER PUMP AS THE WATER PUMP IS DRIVEN BY THE TIMING BELT. FURTHERMORE, THE FUNCTIONS ARE LINKED IN THIS WAY ALLOWING ONE TO CAUSE THE OTHER TO FAIL. THIS IS EVIDENT WITH A CHECK ENGINE LIGHT ON AT ALL TIMES AND WHILE DRIVING THE MISFIRE WILL OCCUR BETWEEN 2000-3000 RPM AND CAUSE THE VEHICLE TO JERK AND STUTTER. THE MISFIRE CAUSES LOSS OF POWER AND THE CHECK ENGINE LIGHT FLASHES.

TL* THE CONTACT OWNS A 2007 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE ENGINE FAILED AND THE VEHICLE HESITATED WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING, WHICH LOCATED A FAILURE CODE THAT THE ENGINE OIL CONTAINER HAD DEFECTIVE PLASTIC. THE FAILURE CAUSED THE ENGINE OIL TO SPILL ONTO THE TOP OF THE MANIFOLD. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.

WHILE DRIVING ON THE HIGHWAY THERE WAS A LOSS OF POWER AND THE ENGINE STARTED RUNNING ROUGH. THE CHECK ENGINE LIGHT CAME ON AND STAYED. THE CAR WOULDN'T GO OVER 10 MPH. CAR WAS TOWED TO A SHOP AND WAS ADVISED THAT AN ENGINE WAS NEEDED. THEY INFORMED ME OF A OIL PUMP BOLT COMING LOOSE AND THE ENGINE JUMPED TIME. THEY SAID THIS IS A COMMON FAILURE ON THESE ENGINES.

HTTP://WWW.PASSATWORLD.COM/FORUMS/VOLKSWAGEN-PASSAT-B6-DISCUSSION/327507-3-6-OIL-BOLT-FAILURE-REFERENCE-MATERIAL.HTML THE OIL BOLT HAS BACKED OUT OF ITS POSITION AND AFFECTED MY TIMING CHAIN. DUE TO THIS, MY CAR WAS UNABLE TO START. THIS IS A COMMON PROBLEM FROM THE 06-07 PASSAT, YET VW HAS DONE NOTHING TO REMEDY THIS ISSUE. *TR

TL* THE CONTACT OWNS A 2007 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THE ENGINE STALLED AND THE EPC WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 98,000.

WHILE DRIVING ON THE HIGHWAY THE CHECK OIL LIGHT CAME ON AND THE ENGINE MADE TERRIBLE SOUNDS. THE CAR WAS PULLED OVER IMMEDIATELY. HAD TO BE TOWED 60 MILES TO THE NEAREST TOWN (MISSOULA MT). THE ENGINE WAS SEIZED UP DUE TO A FAILED OIL PUMP. THE DEALERSHIP AND A LOCAL SHOP BOTH WERE FAMILIAR WITH THIS FAILURE MODE. A DEFECTIVE OIL PUMP BOLT CAME LOOSE, CASING THE PUMP TO FAIL AND DESTROYING THE ENGINE. THE CAR ONLY HAS 68,000 MILES ON IT. AS A KNOWN MANUFACTURING DEFECT, IT IS VERY DISAPPOINTING THAT VW DOES NOT RECALL THIS AND FIX THE PROBLEM. IT IS FORTUNATE THAT NO INJURIES WERE INCURRED, BUT AN ELDERLY WOMAN WAS STRANDED ALONG THE HIGHWAY IN A REMOTE AREA. THE ENGINE IS A VR6 CODE BLV, A 6-CYLINDER 24 VALVE ENGINE. THIS NEEDS TO BE CORRECTED. *TR