NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
628 reports84,000 miles · Dec 11, 2009
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 55 MPH THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO A SIDE ROAD. A TECHNICIAN FROM THE DEALER STATED THAT THE ENGINE NEEDED TO BE REPLACED BECAUSE OF AN OIL/SLUDGE PROBLEM. NO REPAIRS WERE MADE. A REPRESENTATIVE FROM THE MANUFACTURER STATED THAT THEY WO…
Read full complaint
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 55 MPH THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO A SIDE ROAD. A TECHNICIAN FROM THE DEALER STATED THAT THE ENGINE NEEDED TO BE REPLACED BECAUSE OF AN OIL/SLUDGE PROBLEM. NO REPAIRS WERE MADE. A REPRESENTATIVE FROM THE MANUFACTURER STATED THAT THEY WOULD NOT PROVIDE HER WITH ANY ASSISTANCE. THE CURRENT MILEAGE WAS 84,167. THE FAILURE MILEAGE WAS APPROXIMATELY 84,000.
NHTSA ODI #10295319
115,000 miles · Nov 24, 2009
Engine And Engine Cooling
2003 VW PASSAT HEATER CORE HAD TO BE REPLACED AND VW AMERICA REFUSED TO DO IT AT NO COST. *TR
NHTSA ODI #10293415
85,000 miles · Nov 23, 2009
Engine And Engine CoolingFire
MY 2003 VW PASSAT WAS HAVING PROBLEMS WITH COILS AND VALVE COVERS. MY CAR CAUGHT ON FIRE! LUCKILY THE FIRE WENT OUT ABOUT 10 MINUTES AFTER I STOPPED THE CAR! I CAN'T BELIEVE THIS HAPPENED! IS THERE ANYTHING I CAN DO? ARE THERE ANY RECALLS OUT THERE?! *TR
NHTSA ODI #10293321
50,000 miles · Oct 27, 2009
Power Train
CAR HAD SLUDGE IN 2007 DEALER CLEANED ENGINE AND SAID IT WAS FIXED. IN FEB 2009 THE SLUDGE CAME BACK AGAIN AND THE DEALER FIXED THE SLUDGE AGAIN. ON OCTOBER 2009 THE CAR OIL LIGHT CAME ON AGAIN THIS TIME THEY SAID IT WAS NOT SLUDGE BUT THE CAM SHAFT ADJUSTERS WHICH THEY SAID WAS NOT COVERED UNDER WARRANTY. MY RESEARCH SHOWS TH…
Read full complaint
CAR HAD SLUDGE IN 2007 DEALER CLEANED ENGINE AND SAID IT WAS FIXED. IN FEB 2009 THE SLUDGE CAME BACK AGAIN AND THE DEALER FIXED THE SLUDGE AGAIN. ON OCTOBER 2009 THE CAR OIL LIGHT CAME ON AGAIN THIS TIME THEY SAID IT WAS NOT SLUDGE BUT THE CAM SHAFT ADJUSTERS WHICH THEY SAID WAS NOT COVERED UNDER WARRANTY. MY RESEARCH SHOWS THAT CAM SHAFT ADJUSTERS ARE DAMAGED AND BREAK UP DUE TO LOW OIL PRESSURE WHICH IS A DIRECT RELATION TO SLUDGE IN YOUR ENGINE WHICH I HAD TWICE. DEALER NOW CLAIMS I DID NOT MAINTAIN MY CAR AND THIS IS WHY THEY ARE NOT COVERING IT UNDER WARRANTY. *TR
NHTSA ODI #10289967
149,000 miles · Oct 6, 2009
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THERE WAS A STRONG ODOR OF FUEL OUTSIDE OF THE VEHICLE WHILE IT WAS PARKED. THE CONTACT ALSO OBSERVED AN EXCESSIVE AMOUNT OF FUEL ON THE GROUND. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION AND THE TECHNICIAN STATED THAT THE FAILURE WAS CONTRIBUTED TO THE FUEL TANK…
Read full complaint
TL*THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THERE WAS A STRONG ODOR OF FUEL OUTSIDE OF THE VEHICLE WHILE IT WAS PARKED. THE CONTACT ALSO OBSERVED AN EXCESSIVE AMOUNT OF FUEL ON THE GROUND. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION AND THE TECHNICIAN STATED THAT THE FAILURE WAS CONTRIBUTED TO THE FUEL TANK VENTILATION VALVE. NHTSA CAMPAIGN ID NUMBER 08V156000 (FUEL SYSTEM, GASOLINE:DELIVERY) IS RELATED TO THE FAILURE; HOWEVER, THE VIN WAS EXCLUDED FROM THE RECALL. THE ESTIMATED REPAIR COST WAS $2,000. THE VEHICLE HAS NOT BEEN REPAIRED. THERE WAS CONCERN OF THE SIGNIFICANT SAFETY HAZARD. THE FAILURE AND CURRENT MILEAGES WERE 149,000.
NHTSA ODI #10286560
83,000 miles · Sep 30, 2009
Electrical SystemFire
TL*THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING 40 MPH THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER, AND A TECHNICIAN REPLACED THE IGNITION COIL AT AN EXPENSE OF $403.00. THE FAILURE RESURFACED ONE YEAR AFTER THE VEHICLE WAS REPAIRED. AN AUTHORIZED TECHNICIAN CONCLUDED THAT THE IGNITION COIL FAILED AND CA…
Read full complaint
TL*THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING 40 MPH THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER, AND A TECHNICIAN REPLACED THE IGNITION COIL AT AN EXPENSE OF $403.00. THE FAILURE RESURFACED ONE YEAR AFTER THE VEHICLE WAS REPAIRED. AN AUTHORIZED TECHNICIAN CONCLUDED THAT THE IGNITION COIL FAILED AND CAUSED THE WIRING HARNESS, AND THE ENGINES COMPUTER TO BURN. THE VEHICLE WAS REPAIRED AT AN EXPENSE OF $887.97. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 83,000 AND THE CURRENT MILEAGE WAS 92,000. UPDATED 10/21/09. *LJ UPDATED 12/07/09. *LJ THE CONSUMER STATED IN ADDITION TO THE OTHER PROBLEM, THE FAILED STALLED ON THE HIGHWAY AND THE THE LIGHTS ON THE DASHBOARD ILLUMINATED. UPDATED 12/08/09
NHTSA ODI #10285807
95,500 miles · Sep 8, 2009
Engine And Engine CoolingFire
OUR 2003 PASSAT WAGON (4 CYL 1.8 ENGINE) HAD A FIRE IN THE ENGINE LAST WEEK. AFTER DRIVING ABOUT 20 MINUTES AND PARKING, MY HUSBAND NOTICED THE CHECK ENGINE LIGHT AND THEN SMOKE COMING OUT FROM UNDER THE HOOD. HE OPENED THE HOOD AND SAW A FIRE IN THE ENGINE. HE WAS IN A PARKING SPACE AND DROVE IT A BLOCK TO A SERVICE STATION, WH…
Read full complaint
OUR 2003 PASSAT WAGON (4 CYL 1.8 ENGINE) HAD A FIRE IN THE ENGINE LAST WEEK. AFTER DRIVING ABOUT 20 MINUTES AND PARKING, MY HUSBAND NOTICED THE CHECK ENGINE LIGHT AND THEN SMOKE COMING OUT FROM UNDER THE HOOD. HE OPENED THE HOOD AND SAW A FIRE IN THE ENGINE. HE WAS IN A PARKING SPACE AND DROVE IT A BLOCK TO A SERVICE STATION, WHERE THE MECHANIC PUT OUT THE FIRE WITH WATER. THE FIRE HAD STARTED IN THE IGNITION COILS (WHICH HAD BEEN REPLACED IN 4/2003, BEFORE THE RECALL) AND WOULD HAVE REQUIRED THE REPLACEMENT/REBUILDING OF THE ENGINE HARNESS. OUR INSURANCE COMPANY DECLARED THE CAR A TOTAL LOSS. *TR
NHTSA ODI #10283274
54,800 miles · Aug 21, 2009
Vehicle Speed ControlCrashInjury
TL*THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED WHILE DRIVING WITH THE CRUISE CONTROL FUNCTION AT 72 MPH AND ATTEMPTING TO DECREASE SPEED, THE CRUISE CONTROL WOULD NOT DISENGAGE. SHE APPLIED PRESSURE TO THE BRAKES AND THE VEHICLE ACCELERATED. THE CONTACT WAS FORCED TO DRIVE INTO A MEDIAN; HOWEVER, THE BRAKES FAI…
Read full complaint
TL*THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED WHILE DRIVING WITH THE CRUISE CONTROL FUNCTION AT 72 MPH AND ATTEMPTING TO DECREASE SPEED, THE CRUISE CONTROL WOULD NOT DISENGAGE. SHE APPLIED PRESSURE TO THE BRAKES AND THE VEHICLE ACCELERATED. THE CONTACT WAS FORCED TO DRIVE INTO A MEDIAN; HOWEVER, THE BRAKES FAILED TO STOP THE VEHICLE WHICH CAUSED THE DRIVER TO CRASH INTO TWO METAL POLES CAUSING THE AIR BAGS TO DEPLOY. THE CONTACT SUSTAINED MINOR INJURIES OF POWDER BURN FROM THE AIR BAG. A POLICE REPORT WAS FILED. THE VEHICLE WAS INSPECTED BY AN INSURANCE ADJUSTER WHO DETERMINED THAT THE VEHICLE WAS DESTROYED; HOWEVER, THE FAILURE IS STILL UNDER INVESTIGATION. THE CONTACT IS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 54,800.
NHTSA ODI #10281306
102,500 miles · Aug 4, 2009
SeatsFireInjury
TL*THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING AT AN UNKNOWN SPEED WITH THE HEATED SEAT FEATURE ACTIVATED, THE CONTACT NOTICED THAT THE HEATER BURNED THROUGH THE SEAT AND THROUGH HIS CLOTHING. HIS LEG WAS BURNED. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE HEATED SEAT MOTOR NEEDED TO BE REPLACED.…
Read full complaint
TL*THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING AT AN UNKNOWN SPEED WITH THE HEATED SEAT FEATURE ACTIVATED, THE CONTACT NOTICED THAT THE HEATER BURNED THROUGH THE SEAT AND THROUGH HIS CLOTHING. HIS LEG WAS BURNED. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE HEATED SEAT MOTOR NEEDED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 102,500.
NHTSA ODI #10279372
25,000 miles · Jul 18, 2009
Structure
SUNROOF DRAINS/OR OTHER SOURCE ALLOWS WATER TO LEAK INTO CAR SATURATING THE INTERIOR CARPET UNDER LEFT DRIVERS SEAT AND FLOORBOARD AREA. CONVENIENCE MODULE WAS REPLACED ONCE UNDER WARRANTY IN 2006, BUT WATER LEAK HAS RETURNED. THIS IS A GARAGED VEHICLE AND THIS WATER LEAK OCCURS IF CAR IS PARKED OUTSIDE AT WORK (NO TREES OF LE…
Read full complaint
SUNROOF DRAINS/OR OTHER SOURCE ALLOWS WATER TO LEAK INTO CAR SATURATING THE INTERIOR CARPET UNDER LEFT DRIVERS SEAT AND FLOORBOARD AREA. CONVENIENCE MODULE WAS REPLACED ONCE UNDER WARRANTY IN 2006, BUT WATER LEAK HAS RETURNED. THIS IS A GARAGED VEHICLE AND THIS WATER LEAK OCCURS IF CAR IS PARKED OUTSIDE AT WORK (NO TREES OF LEAF DEBRIS) WITH ROOF CLOSED. DEALER WAS AWARE OF PROBLEM WHEN THE CAR WAS REPAIRED ORIGINALLY IN 2007 AND SAID THE DRAIN HOSE WAS COLLAPSING ON ITSELF. *TR
NHTSA ODI #10277301
Official recalls
6Jun 13, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator, free of charge. The recall began May 2, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69X3.
Apr 7, 2008
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
Consequence & remedy
Consequence: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Aug 28, 2007
ON CERTAIN VEHICLES EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
Consequence & remedy
Consequence: IF FUEL FLOW TO THE ENGINE IS INTERRUPTED, THE VEHICLE COULD STALL WITHOUT WARNING AND THUS PRESENT A POTENTIAL RISK OF CRASH.
Remedy: DEALERS WILL INSTALL NEW FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 28, 20007. OWNERS MAY CONTACT VW AT 1-800-222-8987 OR AUDI AT 1-800-822-2834. THIS RECALL IS A SUPPLEMENT TO A PREVIOUS CAMPAIGN (PLEASE SEE 06V017).
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Jan 23, 2006
ON CERTAIN VEHICLES PRODUCED FROM SEPTEMBER 2002 - MARCH 2003, EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
Consequence & remedy
Consequence: IF FUEL FLOW TO THE ENGINE IS INTERRUPTED, THE VEHICLE COULD STALL WITHOUT WARNING AND THUS PRESENT A POTENTIAL RISK OF CRASH.
Remedy: DEALERS WILL INSTALL NEW FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 10, 2006. OWNERS MAY CONTACT VW AT 1-800-222-8987 OR AUDI AT 1-800-822-2834.
Jan 25, 2002
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA11002 · Engine Compartment Fire
Opened Jan 26, 2011 · Closed Feb 17, 2012
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Additional source detail variants (2)
Electrical System
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
PE10027 · Engine Compartment Fire
Opened Jul 26, 2010 · Closed Feb 7, 2011
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s). Some of the complaints indicated that the ignition coils were replaced more than once.The scope of PE10-027 focused on Model Years (MY)2002-2003 Passat vehicles.Volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles as well as other MY Passat vehicles.ODI needs to further investigate this issue.To facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an Engineering Analysis, EA11-002.
Additional source detail variants (2)
Electrical System
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s). Some of the complaints indicated that the ignition coils were replaced more than once.The scope of PE10-027 focused on Model Years (MY)2002-2003 Passat vehicles.Volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles as well as other MY Passat vehicles.ODI needs to further investigate this issue.To facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an Engineering Analysis, EA11-002.
Engine And Engine Cooling
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s). Some of the complaints indicated that the ignition coils were replaced more than once.The scope of PE10-027 focused on Model Years (MY)2002-2003 Passat vehicles.Volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles as well as other MY Passat vehicles.ODI needs to further investigate this issue.To facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an Engineering Analysis, EA11-002.
PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
PE07024 · Passenger/engine Compartment Fires
Opened May 10, 2007 · Closed Sep 28, 2007
Status: closed (inferred from source dates) · Electrical System:ignition
MANY OF THE FIRE REPORTS ALLEGE THAT THE VEHICLE FIRE WAS ATTRIBUTED TO IGNITION COIL FAILURE.VW PROVIDED ADDITIONAL DATA REGARDING ITS ANALYSIS OF VEHICLE FIRES AND A DETAILED DESCRIPTION OF THE THREE DIFFERENT ENGINES AND IGNITION SYSTEMS FOR THE SUBJECT VEHICLES.ODIFINDS THE NEED TO FURTHER INVESTIGATE THIS ISSUE.TO FACILITATE ACQUISITION AND ANALYSIS OF ADDITIONAL INFORMATION, THIS INVESTIGATIONHAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-014).
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration