NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
137 reportsClear category filter35,310 miles · Sep 16, 2005
Fuel System, Gasoline
I HAVE 2003 VOLKSWAGEN PASSAT GLX V6. WITH 35310 MILES ON THE DASH & DRIVING ON A LOCAL ROAD IN NJ GOING 4O MILES A HOUR MY CAR JUST LOSS POWER & CUT OFF. I WAS ABLE TO TURN MY WHEEL HARD & PULLED OFF ON THE SIDE OF THE ROAD SAFELY. MY FUEL PUMP FAILED & WAS REPLACED UNDER WARRANTY. HOWEVER, IF I WAS ON THE HIGHWAY, I AM NOT SUR…
Read full complaint
I HAVE 2003 VOLKSWAGEN PASSAT GLX V6. WITH 35310 MILES ON THE DASH & DRIVING ON A LOCAL ROAD IN NJ GOING 4O MILES A HOUR MY CAR JUST LOSS POWER & CUT OFF. I WAS ABLE TO TURN MY WHEEL HARD & PULLED OFF ON THE SIDE OF THE ROAD SAFELY. MY FUEL PUMP FAILED & WAS REPLACED UNDER WARRANTY. HOWEVER, IF I WAS ON THE HIGHWAY, I AM NOT SURE WHAT WOULD HAVE HAPPENED. THIS IS A SERIOUS DEFECT & WOULD HATE THIS HAPPEN TO OTHERS. *NM
NHTSA ODI #10136806
47,500 miles · Sep 13, 2005
Fuel System, Gasoline
HAVE OWNED CAR ABOUT 10 MONTHS. BOUGHT WITH WARRANTY INTACT FROM A DEALER. WAS DRIVING, GOING ALONG AT 50 MPH WHEN CAR BEGAN DRAMATICALLY SLOWING DOWN. I HAD NO CONTROL OVER ENGINE SPEED, AND WAS FORCED TO SHIFT DOWN TO AVOID STALLING. CAR EVENTUALLY DIED AND WHEN I TRIED TO RESTART IT, IT WOULD ATTEMPT TO TURN OVER BUT WOULD TH…
Read full complaint
HAVE OWNED CAR ABOUT 10 MONTHS. BOUGHT WITH WARRANTY INTACT FROM A DEALER. WAS DRIVING, GOING ALONG AT 50 MPH WHEN CAR BEGAN DRAMATICALLY SLOWING DOWN. I HAD NO CONTROL OVER ENGINE SPEED, AND WAS FORCED TO SHIFT DOWN TO AVOID STALLING. CAR EVENTUALLY DIED AND WHEN I TRIED TO RESTART IT, IT WOULD ATTEMPT TO TURN OVER BUT WOULD THEN QUIT SUDDENLY AGAIN AFTER JUST A FEW SECONDS. I ENDED UP BEING TOWED, AND DIDN'T HAVE CAR FOR WEEK PLUS. TURNED OUT TO BE AN FUEL PUMP. UNDER WARRANTY, THIS WAS FREE, BUT HAD WE BEEN JUST A FEW THOUSAND MILES MORE WE WOULD HAVE HAD TO PAY 500 DOLLARS FOR THIS REPAIR. I BELIEVE IT IS TOTALLY UNACCEPTABLE FOR A FUEL PUMP TO GO AT 48,000 MILES, AND I CAN SEE THAT ON THIS WEB SITE ALONE THIS IS CLEARLY AN ISSUE! THIS SAME THING HAPPENED IMMEDIATELY AFTER WE BOUGHT THE CAR TOO BUT THAT TIME IT RESTARTED AFTER A FEW MINUTES. I FEEL VERY, VERY FORTUNATE THAT I WAS NOT IN TRAFFIC AT EITHER TIME!*JB
NHTSA ODI #10136418
40,000 miles · Aug 26, 2005
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
HAVE HAD NOTHING BUT PROBLEMS WITH THIS LEMON. * 500 MILES CRUISE CONTROL FAILS, HAS TO BE REPLACED. * 16,000 MILES IGNITION COIL FAILS, REPLACED COIL AND MASS AIR FLOW SENSOR. * 28,000 MILES FAN IN DASH DIAGNOSED AS FAULTY AND NEEDING TO BE REPLACED. PARTS ORDERED, NEVER INSTALLED. * 40,000 MILES OIL PUMP AND OIL HOSES ARE…
Read full complaint
HAVE HAD NOTHING BUT PROBLEMS WITH THIS LEMON. * 500 MILES CRUISE CONTROL FAILS, HAS TO BE REPLACED. * 16,000 MILES IGNITION COIL FAILS, REPLACED COIL AND MASS AIR FLOW SENSOR. * 28,000 MILES FAN IN DASH DIAGNOSED AS FAULTY AND NEEDING TO BE REPLACED. PARTS ORDERED, NEVER INSTALLED. * 40,000 MILES OIL PUMP AND OIL HOSES ARE REPLACED DUE TO OIL PRESSURE FAILURES. CAR BROKE DOWN ON ROAD. * 44,159 MILES OIL PRESSURE SWITCH REPLACED DUE TO OIL PRESSURE FAILURES. * 46,000 MILES FUEL PUMP FAILURE, REPLACED UNDER WARRANTY. CAR BROKE DOWN ON ROAD. VOLKSWAGEN HAS A PROBLEM WITH THESE CARS AND "OIL SLUDGE". VW REFUSES TO FIX MY CAR UNDER WARRANTY. LAST WORD WAS "WE RESERVE THE RIGHT TO REFUSE ANY WARRANY CLAIM, REGARDLESS OF DOCUMENTATION OF OIL CHANGES." I'VE TALKED TO SEVERAL DEALERSHIPS AND IT'S A #1 PROBLEM WITH THESE CARS COMMING IN FOR RUINED ENGINES AND OIL SLUDGE. VW IS REFUSING TO PAY FOR FIXING THE PROBLEMS IN MOST CASES. I'VE GOT ALL DOCUMENTATION, ORIGINAL PAPERWORK WHEN PURCHASED, ETC. *JB
NHTSA ODI #10134278
59,200 miles · Aug 16, 2005
Fuel System, Gasoline
CAR STOPPED RUNNING WHILE TRAVELING ON A BUSY HIGHWAY DOING 70 MPH. TOWED TO VW DEALERSHIP AND FUEL PUMP WAS REPLACED. CAR HAD 59000 MILES ON IT. *JB
NHTSA ODI #10133109
58,000 miles · Aug 11, 2005
Fuel System, Gasoline
WHILE MY HUSBAND WAS DRIVING HIS 2003 VW PASSAT THE ENGINE WITHOUT WARNING STALLED. HE WAS ABLE TO RESTART IT, BUT 3 MILES DOWN THE ROAD IT DIED AGAIN. HE WAS TRAVELING DURING RUSH HOUR ON A BUSY FREEWAY. WE SUSPECT IT IS A FAULTY FUEL PUMP. WE HAVE READ OF SEVERAL OTHERS HAVING THIS PROBLEM AND I BELIEVE THIS IS A HUGE SAFE…
Read full complaint
WHILE MY HUSBAND WAS DRIVING HIS 2003 VW PASSAT THE ENGINE WITHOUT WARNING STALLED. HE WAS ABLE TO RESTART IT, BUT 3 MILES DOWN THE ROAD IT DIED AGAIN. HE WAS TRAVELING DURING RUSH HOUR ON A BUSY FREEWAY. WE SUSPECT IT IS A FAULTY FUEL PUMP. WE HAVE READ OF SEVERAL OTHERS HAVING THIS PROBLEM AND I BELIEVE THIS IS A HUGE SAFETY ISSUE AS MORE CARS OF THIS YEAR GAIN MORE MILEAGE. THE CAR HAS ABOUT 58,000 MILES ON IT. *JB
NHTSA ODI #10132323
37,001 miles · Aug 2, 2005
Fuel System, Gasoline
NO WARNING BEFORE FUEL PUMP FAILURE AT 37,000 MILES. MY WIFE WAS STRANDED AND HAD TO GET A TOW. THE PART WAS REPLACED UNDER WARRANTY AND THE TOWING COST IS SUPPOSED TO BE REIMBURSED BY VW. I HAVE NO COMPLAINT AGAINST THE DEALER BUT A FUEL PUMP FAILURE AT 37,000 MILES IS UNACCEPTABLE. *JB
NHTSA ODI #10131122
60,000 miles · Aug 2, 2005
Fuel System, Gasoline
I WAS DRIVING DOWN THE HIGHWAY WHEN ALL OF A SUDDEN MY 2003 VOLKSWAGEN PASSAT ENGINE TURNED OFF. THE FUEL PUMP HAD STOPPED FUNCTIONING, SO THE ENGINE WAS NO LONGER RECEIVING FUEL. MY CAR IS ONLY 2 YEARS AND 3 MONTHS OLD WITH 60,000 MILES. I HAVE TALKED TO NUMEROUS OTHER 2003 PASSAT OWNERS WHO HAVE EXPERIENCED A SIMILAR FUEL P…
Read full complaint
I WAS DRIVING DOWN THE HIGHWAY WHEN ALL OF A SUDDEN MY 2003 VOLKSWAGEN PASSAT ENGINE TURNED OFF. THE FUEL PUMP HAD STOPPED FUNCTIONING, SO THE ENGINE WAS NO LONGER RECEIVING FUEL. MY CAR IS ONLY 2 YEARS AND 3 MONTHS OLD WITH 60,000 MILES. I HAVE TALKED TO NUMEROUS OTHER 2003 PASSAT OWNERS WHO HAVE EXPERIENCED A SIMILAR FUEL PUMP FAILURE. THIS IS A $700 SERVICE JOB. FROM TALKING TO OTHER 2003 PASSAT OWNERS, THIS SEEMS LIKE IT IS A FREQUENT PROBLEM THAT VW SHOULD OFFER TO FIX. THIS PROBLEM IS VERY DANGEROUS SINCE THE CAR JUST STOPS WORKING WHILE YOU ARE DRIVING, THERE IS NO WARNING IT IS GOING TO HAPPEN OR NOTHING YOU CAN DO TO PREVENT IT. *JB
NHTSA ODI #10131120
47,000 miles · Jul 25, 2005
Air BagsElectrical SystemFuel System, Gasoline
I PURCHASE A NEW 2003 VOLKSWAGEN PASSAT FROM BURLINGTON VOLKSWAGEN 2 YEARS AGO AND HAVE TAKEN IT BACK TO THE DEALERSHIP AT LEAST 7 TIMES SINCE THEN FOR A MYRIAD OF PROBLEMS, FROM AIRBAG LIGHTS COMING ON TO CHECK ENGINGE LIGHT TO THE LATEST OF THE CAR SHUTTING OFF IN THE MIDDLE OF THE ROAD.
NHTSA ODI #10129949
59,300 miles · Jul 23, 2005
Fuel System, Gasoline
VW PASSAT MAINLY 2003 EXPERIENCE FUEL PUMP FAILURE WITHOUT ANY WARNING . THE CAR BECOMES UNMANAGEABLE, SHUTS DOWN AND STOPS. THIS COULD BE POTENTIALLY DANGEROUS IN THE HIGHER DENSITY TRAFFIC RESULTING IN PROPERTY DAMAGES AND INJURIES.
NHTSA ODI #10129805
32,247 miles · Jun 29, 2005
Fuel System, Gasoline
PASSAT STATION WAGON ENGINE STOPPED AND FAILED TO RESTART.***NO ANSWER REQUIRED***. *MR THE PROBLEM WAS DIAGNOSED AS A FAILED FUEL PUMP. *JB *SC
NHTSA ODI #10128041
Official recalls
6Jun 13, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator, free of charge. The recall began May 2, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69X3.
Apr 7, 2008
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
Consequence & remedy
Consequence: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Aug 28, 2007
ON CERTAIN VEHICLES EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
Consequence & remedy
Consequence: IF FUEL FLOW TO THE ENGINE IS INTERRUPTED, THE VEHICLE COULD STALL WITHOUT WARNING AND THUS PRESENT A POTENTIAL RISK OF CRASH.
Remedy: DEALERS WILL INSTALL NEW FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 28, 20007. OWNERS MAY CONTACT VW AT 1-800-222-8987 OR AUDI AT 1-800-822-2834. THIS RECALL IS A SUPPLEMENT TO A PREVIOUS CAMPAIGN (PLEASE SEE 06V017).
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Jan 23, 2006
ON CERTAIN VEHICLES PRODUCED FROM SEPTEMBER 2002 - MARCH 2003, EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
Consequence & remedy
Consequence: IF FUEL FLOW TO THE ENGINE IS INTERRUPTED, THE VEHICLE COULD STALL WITHOUT WARNING AND THUS PRESENT A POTENTIAL RISK OF CRASH.
Remedy: DEALERS WILL INSTALL NEW FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 10, 2006. OWNERS MAY CONTACT VW AT 1-800-222-8987 OR AUDI AT 1-800-822-2834.
Jan 25, 2002
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA11002 · Engine Compartment Fire
Opened Jan 26, 2011 · Closed Feb 17, 2012
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Additional source detail variants (2)
Electrical System
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
PE10027 · Engine Compartment Fire
Opened Jul 26, 2010 · Closed Feb 7, 2011
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s). Some of the complaints indicated that the ignition coils were replaced more than once.The scope of PE10-027 focused on Model Years (MY)2002-2003 Passat vehicles.Volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles as well as other MY Passat vehicles.ODI needs to further investigate this issue.To facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an Engineering Analysis, EA11-002.
Additional source detail variants (2)
Electrical System
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s). Some of the complaints indicated that the ignition coils were replaced more than once.The scope of PE10-027 focused on Model Years (MY)2002-2003 Passat vehicles.Volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles as well as other MY Passat vehicles.ODI needs to further investigate this issue.To facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an Engineering Analysis, EA11-002.
Engine And Engine Cooling
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s). Some of the complaints indicated that the ignition coils were replaced more than once.The scope of PE10-027 focused on Model Years (MY)2002-2003 Passat vehicles.Volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles as well as other MY Passat vehicles.ODI needs to further investigate this issue.To facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an Engineering Analysis, EA11-002.
PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
PE07024 · Passenger/engine Compartment Fires
Opened May 10, 2007 · Closed Sep 28, 2007
Status: closed (inferred from source dates) · Electrical System:ignition
MANY OF THE FIRE REPORTS ALLEGE THAT THE VEHICLE FIRE WAS ATTRIBUTED TO IGNITION COIL FAILURE.VW PROVIDED ADDITIONAL DATA REGARDING ITS ANALYSIS OF VEHICLE FIRES AND A DETAILED DESCRIPTION OF THE THREE DIFFERENT ENGINES AND IGNITION SYSTEMS FOR THE SUBJECT VEHICLES.ODIFINDS THE NEED TO FURTHER INVESTIGATE THIS ISSUE.TO FACILITATE ACQUISITION AND ANALYSIS OF ADDITIONAL INFORMATION, THIS INVESTIGATIONHAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-014).
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration