NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
135 reportsClear category filter38,000 miles · Nov 4, 2005
Engine And Engine Cooling
DT: THE CONTACT STATED 10 DAYS AGO THE VEHICLE BEGAN TO SMELL OF OIL. THE DEALER ATTEMPTED TO REPAIR THE VEHICLE, BUT ONCE THE VEHICLE WAS RETURNED, THE SMELL WAS STILL THERE. SHE TOOK THE VEHICLE BACK TO THE SERVICE DEALER FOR REPAIR. THIS TIME THE DEALER SAID A GASKET WAS LOOSE. THE DEALER REPLACED THE GASKET, AND IT SEEM…
Read full complaint
DT: THE CONTACT STATED 10 DAYS AGO THE VEHICLE BEGAN TO SMELL OF OIL. THE DEALER ATTEMPTED TO REPAIR THE VEHICLE, BUT ONCE THE VEHICLE WAS RETURNED, THE SMELL WAS STILL THERE. SHE TOOK THE VEHICLE BACK TO THE SERVICE DEALER FOR REPAIR. THIS TIME THE DEALER SAID A GASKET WAS LOOSE. THE DEALER REPLACED THE GASKET, AND IT SEEMED TO HAVE REPAIRED THE PROBLEM. *AK
NHTSA ODI #10141774
80,000 miles · Sep 28, 2005
Engine And Engine CoolingStructure
I WAS DRIVING MY 2002 VOLKSWAGEN PASSAT WHEN MY ENGINE LIGHT CAME ON. I IMMEDIATELY PULLED OVER. I WAS IN NEW YORK AT THE TIME SO I HAD THE CAR TOWED TO THE NEAREST VW DEALERSHIP, WHICH WAS ROMANO VW IN FAYETVILLE, NY. I HAD DID SOME RESEARCH AND FOUND THAT THE VW HAS A PROBLEM WITH THE POLLEN HOUSING FILTER. I ASKED THE SER…
Read full complaint
I WAS DRIVING MY 2002 VOLKSWAGEN PASSAT WHEN MY ENGINE LIGHT CAME ON. I IMMEDIATELY PULLED OVER. I WAS IN NEW YORK AT THE TIME SO I HAD THE CAR TOWED TO THE NEAREST VW DEALERSHIP, WHICH WAS ROMANO VW IN FAYETVILLE, NY. I HAD DID SOME RESEARCH AND FOUND THAT THE VW HAS A PROBLEM WITH THE POLLEN HOUSING FILTER. I ASKED THE SERVICE MANAGER OMAR TO CHECK THE FILTER, WHICH IN RETURN HE STATED IT WAS FINE. THE PROBLEM WAS THE OIL PUMP, AND THE COMPUTER. I EVENTUALLY FOUND OUT THAT THE COMPUTER FAILED DO TO A WATER LEAK ON THE PASSENGER SIDE OF THE CAR, WHICH IS WHERE THE COMPUTER IS LOCATED. ROMANO VW SAID THERE WAS A WATER LEAK BUT IT WAS NOT CAUSED BY THE FILTER. I HAVE BEEN FIGHTING WITH VW CUSTOMER CARE AND THEY KEEP DENYING MY CLAIM. I EVENTUALLY HAD MY CAR FIXED AND PICKED THE CAR UP AND DROVE HOME. ONCE I GOT HOME THE ENGINE LIGHT CAME ON AGAIN. I TOOK THE CAR TO PRESTIGE VW IN TURNERSVILLE, NJ AND THEY STATED THAT THE PROBLEM IS CAUSE FROM THE POLLEN HOUSING FILTER. VW CUSTOMER CARE HAS STILL DENIED MY CLAIM. AFTER DOING MORE RESEARCH IT TURNS OUT THE POLLEN HOUSING FILTER IS A MAJOR ISSUE IN THE VOLKSWAGEN, BUT VW THEMSELVES DO NOT AGREE. *NM
NHTSA ODI #10138063
41,000 miles · Sep 9, 2005
Engine And Engine Cooling
OIL PRESSURE LIGHT COMING ON AND TELLING ME TO TURN THE VEHICLE OFF IMMEDIATELY. FOUND OUT IT IS A OIL SLUDGE ISSUE WITH THE 1.8T ENGINE. IT IS A $1,600 BILL TO FIX THE VEHICLE. VOLKSWAGEN WILL NOT COVER THE EXPENSES UNLESS WE SHOW A COPY OF OUR OIL CHANGE RECEIPTS SINCE WE HAVE OWNED THE CAR. WELL, WE HAVE OWNED THE CAR FOR 3.…
Read full complaint
OIL PRESSURE LIGHT COMING ON AND TELLING ME TO TURN THE VEHICLE OFF IMMEDIATELY. FOUND OUT IT IS A OIL SLUDGE ISSUE WITH THE 1.8T ENGINE. IT IS A $1,600 BILL TO FIX THE VEHICLE. VOLKSWAGEN WILL NOT COVER THE EXPENSES UNLESS WE SHOW A COPY OF OUR OIL CHANGE RECEIPTS SINCE WE HAVE OWNED THE CAR. WELL, WE HAVE OWNED THE CAR FOR 3.5 YEARS AND WE DON'T HANG ONTO RECEIPTS FOR MORE THAN 3 MONTHS. SO, THEY ARE NOT GOING TO COVER THE DAMAGE TO THE VEHICLE. I HAVE FOUND OUT THAT VOLKSWAGEN HAS KNOWN OF A SLUDGING PROBLEM WITH THE 1.8T ENGINE SINCE LATE 2004. WE BOUGHT THE CAR EARLY 2002. *JB
NHTSA ODI #10136056
Mileage unknown · Sep 9, 2005
Engine And Engine Cooling
SLUDGE IN THE MOTOR WAS FOUND. I CHANGED TO SYNTHETIC OIL SOON AFTER MY WARRANTY WAS OVER BUT WAS NEVER TOLD TO CHANGE TO SYNTHETIC BECAUSE OF POSSIBLE SLUDGE. I WAS NEVER TOLD THAT THIS PROBLEM WAS COMMON IN VW 1.8T ENGINES. THIS PROBLEM WILL COST ME $2,000 SO FAR. I HAVE KEPT GREAT CARE OF THE CAR AND HAVE RECORDS EXCEPT THOS…
Read full complaint
SLUDGE IN THE MOTOR WAS FOUND. I CHANGED TO SYNTHETIC OIL SOON AFTER MY WARRANTY WAS OVER BUT WAS NEVER TOLD TO CHANGE TO SYNTHETIC BECAUSE OF POSSIBLE SLUDGE. I WAS NEVER TOLD THAT THIS PROBLEM WAS COMMON IN VW 1.8T ENGINES. THIS PROBLEM WILL COST ME $2,000 SO FAR. I HAVE KEPT GREAT CARE OF THE CAR AND HAVE RECORDS EXCEPT THOSE WHO WERE SERVICE BY THE DEALERSHIP BECAUSE THOSE ARE STAMPED IN MY BOOK (THE ONE THAT IS GIVEN TO YOU AT THE DEALERSHIP) THE INFORMATION SHOULD BE ENOUGH FOR THE WARRANTY. I HAVE YET TO SOLVE THIS , BUT IN DEALING WITH THE OTHER DEALERSHIPS THEY ONLY KEEP RECORDS FOR A FEW YEARS. *JB
NHTSA ODI #10136036
Mileage unknown · Sep 7, 2005
Engine And Engine Cooling
ON SEPT 1,2005 ON MY WAY TO THE E.R. AT A LOCAL HOSPITAL THE OIL LIGHT CAME ON TELLING ME TO STOP ENGINE/CHECK OIL PRESSURE. I TURNED ENGINE OFF, AND CHECKED OIL LEVEL, ALL OK. TRIED TO START ENGINE TO GET OFF OF NEW YORK STATE THRUWAY, ENGINE MAKING TERRIBLE NOISE, TURNED OFF HAD CAR TOWED TO DEALER. WAS TOLD BY DEALER IT WOULD…
Read full complaint
ON SEPT 1,2005 ON MY WAY TO THE E.R. AT A LOCAL HOSPITAL THE OIL LIGHT CAME ON TELLING ME TO STOP ENGINE/CHECK OIL PRESSURE. I TURNED ENGINE OFF, AND CHECKED OIL LEVEL, ALL OK. TRIED TO START ENGINE TO GET OFF OF NEW YORK STATE THRUWAY, ENGINE MAKING TERRIBLE NOISE, TURNED OFF HAD CAR TOWED TO DEALER. WAS TOLD BY DEALER IT WOULD BE AT LEAST $400.00 TO LOOK AT THE CAR AND DIAGNOSE IT. AFTER ONE WEEK DEALER CALLED AND SAID IT WOULD COST $9000.00 TO REPLACE ENTIRE MOTOR, ON SEPT. 2 2005 CALLED V.W. OF AMERICA THEY STATED TO ME AT THAT TIME THAT THEY WERE AWARE OF THE PROBLEM WITH THE 1.8 TURBO BUILDING UP OIL SLUDGE IN THE MOTOR, AND THAT THEY HAD EXTENDED THE WARRANTY ON THE ENGINE. THEY SAID THAT THEY NEEDED MAINTENANCE RECORDS TO PROVE MY CASE, THEY GAVE ME A FAX # WHICH WAS THE WRONG #. AFTER THE LONG HOLIDAY WEEKEND I PHONED V.W. OF AMERICA AGAIN AND THEY STATED , TO FAX THE DOCUMENTS DIRECTLY TO THE DEALER THAT THEY DID NOT RECEIVE THEM, THE CONSUMER ADVOCATE THAT I WAS SPEAKING WITH WAS NEW AND DID NOT KNOW THE FAX #. THE DEALER STATED THAT MY RECORDS WERE NOT DETAILED ENOUGH AND THAT I WAS MISSING SIX RECEIPTS, I MOVED ONE YEAR AGO AND THE VALVOLINE STATION WHERE I HAD THE OIL CHANGED FAITHFULLY STATED THAT IF YOU DO NOT USE THERE SERVICES FOR 6 MONTHS THAT THE COMPUTER AUTOMATICALLY DROPS YOUR RECORDS. I SEEM TO BE CAUGHT BETWEEN A ROCK AND A HARD PLACE, V.W. AND THE DEALER KEEP SHUFFLING ME BACK AND FORTH, IN THE MEAN TIME I HAVE NO VEHICLE AND I AM RENTING A CAR TO GET BACK AND FORTH TO WORK. AFTER SEARCHING YOUR WEB SITE I FOUND 8 COMPLAINTS INCLUDING MY OWN OUT OF 50 THAT'S ALMOST 20% OF THE COMPLAINTS FOR THE SAME PROBLEM, AND THE OTHER PEOPLE ARE GIVEN THE SAME RUN AROUND. THIS HAS TO STOP SOMEWHERE AND SOME ONE HAS TO TAKE RESPONSIBILITY FOR AN OBVIOUSLY DEFECTIVE PRODUCT. I HAVE CONTACTED AN ATTORNEY AND ARE PREPARED TO LITIGATE IF NECESSARY. *NM
NHTSA ODI #10135529
50,100 miles · Aug 19, 2005
Engine And Engine Cooling
ON AUGUST 12, 2005 I WAS DRIVING MY 2002 PASSAT TO WORK WHEN MY OIL PRESSURE LIGHT CAME ON. I HAD THE CAR TOWED TO THE NEAREST VW DEALER WHEN THEY TOLD ME THAT MY CAR HAD OIL SLUDGE DUE TO MANUFACTURER ERROR. THE CAR HAS 50,100 MILES AND IS COMPLETELY RUINED. VW WILL NOT REPLACE WITHOUT ALL OIL RECEIPTS. I AM MISSING 2 RECEI…
Read full complaint
ON AUGUST 12, 2005 I WAS DRIVING MY 2002 PASSAT TO WORK WHEN MY OIL PRESSURE LIGHT CAME ON. I HAD THE CAR TOWED TO THE NEAREST VW DEALER WHEN THEY TOLD ME THAT MY CAR HAD OIL SLUDGE DUE TO MANUFACTURER ERROR. THE CAR HAS 50,100 MILES AND IS COMPLETELY RUINED. VW WILL NOT REPLACE WITHOUT ALL OIL RECEIPTS. I AM MISSING 2 RECEIPTS. I DO NOT UNDERSTAND HOW A CAR WITH 50000 MILES ON IT CAN RUIN SO EASILY.
NHTSA ODI #10133552
38,000 miles · Jun 24, 2005
Engine And Engine Cooling
I HAD TO HAVE MY ENGINE REPLACED BY VW AND MY CAR STILL ISN'T RIGHT. I BOUGHT MY CAR IN GERMANY NOT THE US. BUT IT IS REGISTERED WITH VWOA I FEEL LIKE THEY SOLD ME A DEFECTIVE PRODUCT. THEY WOULD NOT EVEN CONSIDER LISTENING TO MY COMPLAINTS ON THE OIL SLUDGE PROBLEM. THIS COST ME $7000.00 TO REPLACE MY WHOLE ENGINE AND TIME MI…
Read full complaint
I HAD TO HAVE MY ENGINE REPLACED BY VW AND MY CAR STILL ISN'T RIGHT. I BOUGHT MY CAR IN GERMANY NOT THE US. BUT IT IS REGISTERED WITH VWOA I FEEL LIKE THEY SOLD ME A DEFECTIVE PRODUCT. THEY WOULD NOT EVEN CONSIDER LISTENING TO MY COMPLAINTS ON THE OIL SLUDGE PROBLEM. THIS COST ME $7000.00 TO REPLACE MY WHOLE ENGINE AND TIME MISSED FROM WORK. (LOST INCOME) WHAT CAN BE DONE?
NHTSA ODI #10126476
58,500 miles · Mar 16, 2005
Engine And Engine Cooling
THE ENGINE CHECK LIGHT CAME ON, AND THEN SMOKE STARTED COMING OUT OF THE TAIL PIPE. CONSUMER LATER HAD THE VEHICLE TOWED TO THE DEALER, AND THEY FOUND OUT THAT THERE WAS OIL SLUDGE IN THE ENGINE. THE DEALER ASKED FOR MAINTENANCE RECORD. DEALER TOLD THE CONSUMER THEY WOULD NOT PROVIDE SERVICE UNTIL ALL RECEIPTS WERE PROVIDE…
Read full complaint
THE ENGINE CHECK LIGHT CAME ON, AND THEN SMOKE STARTED COMING OUT OF THE TAIL PIPE. CONSUMER LATER HAD THE VEHICLE TOWED TO THE DEALER, AND THEY FOUND OUT THAT THERE WAS OIL SLUDGE IN THE ENGINE. THE DEALER ASKED FOR MAINTENANCE RECORD. DEALER TOLD THE CONSUMER THEY WOULD NOT PROVIDE SERVICE UNTIL ALL RECEIPTS WERE PROVIDED, SHOWING OIL CHANGES.*AK
NHTSA ODI #10115249
13,000 miles · Feb 24, 2005
Engine And Engine Cooling
VW PASSAT 2002. MALFUNCTION INDICATOR LIGHT INDICATING PROBLEM WITH ENGINE. RETURNED TO DEALERSHIP FOR REPAIR. LEASE ABOUT TO EXPIRE, BROUGHT IN (3) PRIOR TIMES.. 2/21 TOWED TO NEAREST DEALER, BEING TOLD DON'T KNOW WHAT IS WRONG, NEEDS ALL OIL CHANGE RECEIPTS, NEEDS PERMISSION FROM MANUFACTURER TO OK REPAIR UNDER WARRANTY. W…
Read full complaint
VW PASSAT 2002. MALFUNCTION INDICATOR LIGHT INDICATING PROBLEM WITH ENGINE. RETURNED TO DEALERSHIP FOR REPAIR. LEASE ABOUT TO EXPIRE, BROUGHT IN (3) PRIOR TIMES.. 2/21 TOWED TO NEAREST DEALER, BEING TOLD DON'T KNOW WHAT IS WRONG, NEEDS ALL OIL CHANGE RECEIPTS, NEEDS PERMISSION FROM MANUFACTURER TO OK REPAIR UNDER WARRANTY. WARRANTY IS EXTENDED FOR 8 YEARS IN WRITING. MANUFACTURE BLAMES DEALER, DEALER BLAMES CUSTOMER. CAR IS A LEMON. SEE ARTICLE AUTOWEEK 2/7/2005 AND PRIOR ARTICLES. CUSTOMERS ARE WELL AWARE THERE IS AN ENGINE PROBLEM AND NOW CAUSING OIL SLUDGE RELATED PROBLEMS. ABSOLUTELY OUTRAGEOUS. SINCE 2002 UNTIL NOW, PAYMENTS BEING MADE FOR A DEFECTIVE CAR DUE TO FAULTY ENGINEERING! AND NOW THE CUSTOMERS MUST PAY FOR IT! NO WAY. *NM
NHTSA ODI #10112113
Mileage unknown · Feb 22, 2005
Engine And Engine Cooling
THIS IS THE EMAIL I SENT TO VOLKSWAGEN OF AMERICA. WE HAD TO SLOW DOWN ON THE INTERSTATE TO LOOK FOR AN EXIT BECAUSE OF THE WARNING LIGHT COMING ON. I FELT IN GREAT DANGER AT THE TIME. I AM 58 YEARS OLD AND HAVE PURCHASED A NUMBER OF NEW AUTOMOBILES IN MY LIFE. NEVER HAVE I HAD SUCH A TERRIBLE EXPERIENCE. I HAVE A PASSAT PARKED…
Read full complaint
THIS IS THE EMAIL I SENT TO VOLKSWAGEN OF AMERICA. WE HAD TO SLOW DOWN ON THE INTERSTATE TO LOOK FOR AN EXIT BECAUSE OF THE WARNING LIGHT COMING ON. I FELT IN GREAT DANGER AT THE TIME. I AM 58 YEARS OLD AND HAVE PURCHASED A NUMBER OF NEW AUTOMOBILES IN MY LIFE. NEVER HAVE I HAD SUCH A TERRIBLE EXPERIENCE. I HAVE A PASSAT PARKED BECAUSE THE OIL LIGHT IS WARNING ME I WAS SOLD A DEFECTIVE MOTOR. THIS HAS BEEN A HORRIFIC EXPERIENCE. I AM MAKING AUTOMOBILE PAYMENTS TO VOLKSWAGEN CREDIT EVEN THOUGH I AM AFRAID TO START THE ENGINE. I WAS SENT A LETTER STATING THE CAR WAS DEFECTIVE BUT I WOULD NEED EACH AND EVERY OIL CHANGE RECEIPT FOR VOLKSWAGEN TO ADDRESS YOUR FAULTY ENGINE. THIS IS LUDICROUS. I TAKE EXCELLENT CARE OF MY AUTOMOBILES AND THUS REALIZE GOOD TRADE IN VALUE. I WILL BE STATING THE FACTS OF MY EXPERIENCE WITH THIS VOLKSWAGEN PURCHASE VIA THE INTERNET, AUTOMOBILE MAGAZINES, THE GREATER DALLAS CHAMBER OF COMMERCE, THE BETTER BUSINESS BUREAU AND WILL PURCHASE ONE QUARTER PAGE ADS IN THE DALLAS MORNING NEWS AND THE NEW YORK TIMES. THIS AUTOMOBILE HAS A MANUFACTURER'S DEFECT AND SHOULD JUST BE RECALLED BY VOLKSWAGEN. I WILL BE ON A CAMPAIGN UNTIL ETERNITY AND WILL SOLICIT OTHER VOLKSWAGEN OWNERS ACROSS THE WORLD TO JOIN ME. THIS IS THE WORSE AUTOMOBILE BUYING EXPERIENCE I CAN IMAGINE. LOUIS MCELROY DIRECTOR THE GREATER DALLAS CHAMBER. *AK
NHTSA ODI #10111957
NHTSA investigations
9EA11002 · Engine Compartment Fire
Opened Jan 26, 2011 · Closed Feb 17, 2012
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Additional source detail variants (2)
Electrical System
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
PE10027 · Engine Compartment Fire
Opened Jul 26, 2010 · Closed Feb 7, 2011
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s). Some of the complaints indicated that the ignition coils were replaced more than once.The scope of PE10-027 focused on Model Years (MY)2002-2003 Passat vehicles.Volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles as well as other MY Passat vehicles.ODI needs to further investigate this issue.To facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an Engineering Analysis, EA11-002.
Additional source detail variants (2)
Electrical System
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s). Some of the complaints indicated that the ignition coils were replaced more than once.The scope of PE10-027 focused on Model Years (MY)2002-2003 Passat vehicles.Volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles as well as other MY Passat vehicles.ODI needs to further investigate this issue.To facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an Engineering Analysis, EA11-002.
Engine And Engine Cooling
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s). Some of the complaints indicated that the ignition coils were replaced more than once.The scope of PE10-027 focused on Model Years (MY)2002-2003 Passat vehicles.Volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles as well as other MY Passat vehicles.ODI needs to further investigate this issue.To facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an Engineering Analysis, EA11-002.
PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
PE07024 · Passenger/engine Compartment Fires
Opened May 10, 2007 · Closed Sep 28, 2007
Status: closed (inferred from source dates) · Electrical System:ignition
MANY OF THE FIRE REPORTS ALLEGE THAT THE VEHICLE FIRE WAS ATTRIBUTED TO IGNITION COIL FAILURE.VW PROVIDED ADDITIONAL DATA REGARDING ITS ANALYSIS OF VEHICLE FIRES AND A DETAILED DESCRIPTION OF THE THREE DIFFERENT ENGINES AND IGNITION SYSTEMS FOR THE SUBJECT VEHICLES.ODIFINDS THE NEED TO FURTHER INVESTIGATE THIS ISSUE.TO FACILITATE ACQUISITION AND ANALYSIS OF ADDITIONAL INFORMATION, THIS INVESTIGATIONHAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-014).
PE07018 · Water/ice In Brake Booster
Opened Apr 3, 2007 · Closed Sep 4, 2007
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist:vacuum
DURING THIS INVESTIGATION, VOLKSWAGEN OF AMERICA (VW) IDENTIFIED A PROBLEM WITH WATER ACCUMULATION IN THE FRESH AIR PLENUM THAT COULD, IN CERTAIN CIRCUMSTANCES, RESULT IN REDUCED BRAKE POWER ASSIST IN MODEL YEAR (MY) 2002 PASSAT VEHICLES.VW INDICATED THAT PROBLEM IS CAUSED BY LEAVES AND OTHER DEBRIS CLOGGING THE PLENUM DRAINS, WHICH MAY RESULT IN WATER FILLING THE PLENUM TO THE LEVEL OF THE BRAKE BOOSTER AIR INTAKE.THE BOOSTER AIR INTAKE IS LOCATED IN THE FRESH AIR PLENUM IN THE MY 2002 PASSAT VEHICLES, BUT NOT IN THE MY 2001 OR 2003 VEHICLES WHICH DRAW BOOSTER AIR FROM THE CABIN.VW TESTING SHOWED THAT BRAKE ASSIST COULD BE REDUCED IF WATER ENTERS THE BOOSTER AND FREEZES.VW IS ADDRESSING THE PROBLEM WITH A SERVICE CAMPAIGN, WHICH BEGAN IN AUGUST 2007.THE FRESH AIR PLENUM IN THE SUBJECT VEHICLES IS AN ENCLOSED SPACE AT THE BASE OF THE WINDSHIELD FROM WHICH THE VEHICLE VENTILATION SYSTEM DRAWS THE FRESH AIR SUPPLY VIA A POLLEN FILTER.RAIN WATER THAT FLOWS OFF THE WINDSHIELD INTO THE PLENUM IS DRAINED THROUGH TWO VALVES LOCATED BELOW THE BATTERY AND BRAKE BOOSTER.STRAINERS AT THE BASE OF THE WINDSHIELD AND IN THE PANEL COVERING THE TOP OF THE PLENUM BLOCK LEAVES, PINE NEEDLES AND OTHER DEBRIS.OVER TIME, DEBRIS MAY ENTER THE PLENUM THROUGH OPENINGS IN THE PLENUM PANEL OR AROUND THE HOOD HINGES.IF CLOGGED DRAINS ALLOW APPROXIMATELY 3-4 GALLONS OF WATER TO ACCUMULATE IN THE PLENUM, THE WATER MAY ENTER THE BOOSTER THROUGH THE AIR INTAKE.WATER ACCUMULATION IN THE PLENUM MAY ALSO RESULT IN COMPLAINTS OF WET CARPETS IN THE VEHICLE INTERIOR IF THE WATER REACHES THE LEVEL OF THE FRESH AIR INTAKE/POLLEN FILTER. VW STATED THAT ITS TESTING SHOWED THAT BRAKE PERFORMANCE AND ACTUATING FORCE (I.E., PEDAL EFFORT) ARE NOT AFFECTED WHEN THE BOOSTER IS FILLED WITH THE MAXIMUM AMOUNT OF WATER POSSIBLE (UP TO THE HEIGHT OF THE BOOSTER ENGINE VACUUM CONNECTION, THROUGH WHICH WATER DRAWN INTO THE BOOSTER IS EVACUATED).VW'S TESTING SHOWED THAT BRAKE PERFORMANCE AND ACTUATING FORCE COULD BE AFFECTED BY WATER FREEZING IN THE BOOSTER.HOWEVER, WHEN TESTED WITH RELATIVELY LOW VOLUMES OF FROZEN WATER IN THE BOOSTER, VW SHOWED THAT THE EFFECTS WERE SIGNIFICANTLY LESS SEVERE THAN FOR CONDITIONS THAT RESULT IN A COMPLETE LOSS OF VACUUM ASSIST.WHILE VW INDICATED THAT THE EFFECTS WOULD BE MORE SEVERE WITH GREATER VOLUMES OF FROZEN WATER, IT MAINTAINED THAT THE CHANCES OF THIS OCCURRING WERE REMOTE AND WOULD BE READILY DISCERNABLE TO THE DRIVER UPON THE INITIAL BRAKE APPLICATION AFTER VEHICLE START-UP.ODI'S ANALYSIS OF COMPLAINTS AND WARRANTY DATA SHOWED DISPROPORTIONATE CONCENTRATIONS IN WINTER MONTHS AND IN NORTHERN STATES WITH COLDER WINTER CLIMATES. ODI IDENTIFIED THREE MINOR CRASHES RELATED TO THE ALLEGED DEFECT IN MY 2002 PASSAT VEHICLES.TWO OF THE CRASHES OCCURRED INGARAGES/DRIVEWAYS AND THE THIRD OCCURRED IN A DEALER SERVICE GARAGE.THERE WERE NO INJURIES ALLEGED IN THE CRASHES BUT A FOOT INJURY WAS ALLEGED IN A FOURTH INCIDENT WHERE EXCESSIVE BRAKE EFFORT REQUIRED DURING A HARD STOP. VOLKSWAGEN IS CONDUCTING A SERVICE CAMPAIGN TO REMEDY THIS CONDITION IN MY 2002 PASSAT AND AUDI A4 AND A6 VEHICLES.THE REMEDY PROCEDURE REQUIRES VW DEALERS TO INSPECT, CLEAN AND MODIFY THE AIR PLENUM DRAIN, AS WELL AS MODIFY THE SUNROOF DRAIN (IF EQUIPPED) AND INSTALL AN IMPROVED SEAL FOR THE POLLEN FILTER.IN ADDITION, VW HAS AGREED TO PROVIDE THE FOLLOWING INFORMATION TO ODI1. QUARTERLY COMPLETION REPORTS FOR ONE YEAR; AND 2. PROMPTLY REPORTING ALL CRASHES ATTRIBUTED TO THE ALLEGED DEFECT. THIS INVESTIGATION IS CLOSED BASED UPON THE ACTIONS TAKEN BY VW.THE CLOSING OF THIS INVESTIGATION DOES NOT C
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03020 · Passenger Air Bag Lid Failure
Opened Oct 7, 2003 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Additional source detail variants (2)
Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Air Bags
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
PE03021 · Passenger Sir Door Mounting Stud Failure
Opened May 23, 2003 · Closed Oct 7, 2003
Status: closed (inferred from source dates) · Air Bags:frontal
ODI OPENED A PRELIMINARY EVALUATION (PE03-021) BASED ON TWO REPORTS OF FAILED BOLT STUDS THAT ATTACH THE PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) DOOR COVER TO THE INSTRUMENT PANEL (IP) ON THE VOLKSWAGEN (VW) PASSAT (MODEL YEARS 2000, 2002).VW HAS INDICATED TO ODI THAT IT HAS NO ADDITIONAL REPORTS.VW IMPLEMENTED A PROCESS CHANGE ON MARCH 1, 2002.THIS PROCESS CHANGE CONSISTED OF CHANGING THE BOLT APPLICATION THAT FASTENS THE PSIR DOOR TO THE IP FROM A WELD ON APPLICATION TO A PRESS ON APPLICATION.VW ALSO CHANGED THE MATERIAL OF THE BOLT.VW STATED THAT THE CHANGES WERE MADE TO EASE PRODUCTION BY ELIMINATING A WELDING PROCESS.ODI HAS UPGRADED ITS INVESTIGATION TO ENGINEERING ANALYSIS (EA03-020).
Illustration