IllustrationFRONT CONTROL ARMS. *AK
1999 Volkswagen Passat
Owner reports · Recalls · Investigations
More warning signs than most Passat years
Owner complaints for the 1999 Volkswagen Passat are substantially higher than the model-year median of 110.
About this comparison →How this year compares
Owner complaints by model year
Compare all Passat years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
160–25K
4525–50K
12850–75K
11075–100K
74100–150K
18150K+
391 reports with mileage · 273 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 184 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 118 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports13 fire reports8 injury reports
Suspension complaints
118 reportsUPPER AND LOWER FRONT SUSPENSION CONTROL ARM BUSHING FAILURE. (LEFT AND RIGHT). *AK
LOWER CONTROL ARM FAILURE. VEHICLE PURCHASED FROM VW AS CERTIFIED LIKE NEW WITH WARRANTY TO SECOND OWNER. VEHICLE HAD APPROX 30000 MILES AT PURCHASE. NOW HAS 67K MILES. APPEARS TO FIT PATTERN RELATIVE TO DEFECTIVE - SHOULD BE RECALLED ISSUE IN WHICH THESE PARTS FAIL EVERY 30K MILES. AS NOTED ON OTHER INCIDENTS, NO OTHER VEHICLE …
Read full complaint
LOWER CONTROL ARM FAILURE. VEHICLE PURCHASED FROM VW AS CERTIFIED LIKE NEW WITH WARRANTY TO SECOND OWNER. VEHICLE HAD APPROX 30000 MILES AT PURCHASE. NOW HAS 67K MILES. APPEARS TO FIT PATTERN RELATIVE TO DEFECTIVE - SHOULD BE RECALLED ISSUE IN WHICH THESE PARTS FAIL EVERY 30K MILES. AS NOTED ON OTHER INCIDENTS, NO OTHER VEHICLE EXHIBITS THIS TYPE OF FAILURE MAKING THIS UNIQUE TO VW AND AUDI. THEREFORE MORE INDICITAVE OF FACTORY DEFECT AND CREATION OF HAZARDOUS DRIVING SITUATION. *AK
RECALL LETTER FOR REPLACEMENT OF TIE RODS ON 1999 VOLKSWAGEN PASSAT. *MR THE FRONT END OF THE VEHICLE SQUEAKED. THE TECHNICIAN FOUND LOWER AND UPPER CONTROL ARM DAMAGE, THE CONTROL ARM BOOTS WERE TORN OPEN WITH NO LUBRICATION WHICH CAUSED THE SQUEAK NOISE. THERE WAS ALSO A CAM SHAFT TENSIONER GASKET LEAK WHICH WAS REMOVED …
Read full complaint
RECALL LETTER FOR REPLACEMENT OF TIE RODS ON 1999 VOLKSWAGEN PASSAT. *MR THE FRONT END OF THE VEHICLE SQUEAKED. THE TECHNICIAN FOUND LOWER AND UPPER CONTROL ARM DAMAGE, THE CONTROL ARM BOOTS WERE TORN OPEN WITH NO LUBRICATION WHICH CAUSED THE SQUEAK NOISE. THERE WAS ALSO A CAM SHAFT TENSIONER GASKET LEAK WHICH WAS REMOVED AND REPLACED. *SCC. THE CONSUMER TOOK THE VEHICLE TO HAVE THE RODS REPLACED AFTER RECEIVING THE RECALL, HOWEVER, THE DEALER CALLED THE CONSUMER BACK AND INFORMED HIM, THE VEHICLE HAD BEEN INSPECTED AND IT WAS NOT NECESSARY FOR THE WORK TO BE DONE, EVEN THOUGH THE RECALL LETTER STATED IT THEY WOULD BE REPLACED TO PREVENT FUTURE PROBLEMS. *JB
STARTED TO FEEL AND HEAR A THUMPING, AND CREAKING FROM MY SUSPENSION. TOOK VEHICLE TO A VW DEALER AND THEY SAID THAT I NEEDED TO HAVE BOTH UPPER CONTROL ARMS REPLACED ON THE LEFT FRONT OF MY PASSAT. I CALLED VWOA AND THEY SAID THAT THEY WERE NOT GOING TO HELP PAY FOR IT B/C IT IS CONSIDERED A WEAR ITEM. A 99 PASSAT W/ LESS TH…
Read full complaint
STARTED TO FEEL AND HEAR A THUMPING, AND CREAKING FROM MY SUSPENSION. TOOK VEHICLE TO A VW DEALER AND THEY SAID THAT I NEEDED TO HAVE BOTH UPPER CONTROL ARMS REPLACED ON THE LEFT FRONT OF MY PASSAT. I CALLED VWOA AND THEY SAID THAT THEY WERE NOT GOING TO HELP PAY FOR IT B/C IT IS CONSIDERED A WEAR ITEM. A 99 PASSAT W/ LESS THAN 50K MILES! AND THEY CONSIDER THAT WEAR?!? FROM WHAT I HAVE RESEARCHED, I AM FAR FROM THE ONLY PERSON THAT THIS IS HAPPENING TO. NOW I HAVE TO DISH OUT $500 EASY TO GET IT FIXED. BUY ANOTHER VW? NOT ON YOUR LIFE. VW HAS BEEN HEARING THE COMPLAINTS ABOUT THIS SITUATION FOR YEARS NOW AND STILL WILL NOT HELP. I WOULD HATE TO SEE SOMETHING TRAGIC TO SOMEONE JUST FOR THEM TO FESS UP. *NLM
WHILE DRIVING AT 65MPH SUDDENLY VEHICLE START SHAKING/ LOST POWER, NEVER WENT OVER 40MPH. *AK
CONTROL ARMS AND BALL JOINTS NEED TO BE REPLACED WITH ONLY 43000 MILES ON THE VEHICLE. VOLKSWAGEN WENT BY RECOMMENDATION OF DEALER NOT TO HELP WITH THE COST OF REPAIR. *AK
1999 VW PASSAT REQUIRES REPLACEMENT OF FRONT SUSPENSION CONTROL ARMS AT 64.8K MILES. SYMPTOMS REPORTED INITIALLY AT 3 YEARS/49K MILES. APPEARS TO BE RELATED TO SERVICE BULLETIN 400101. PROBLEM WELL KNOWN AMONG PASSAT/AUDI OWNERS. DEALER ASKING $1200 FOR REPAIR. VWOA DECLINES TO HELP, STATING THAT SUSPENSION IS "2 YEAR 24K …
Read full complaint
1999 VW PASSAT REQUIRES REPLACEMENT OF FRONT SUSPENSION CONTROL ARMS AT 64.8K MILES. SYMPTOMS REPORTED INITIALLY AT 3 YEARS/49K MILES. APPEARS TO BE RELATED TO SERVICE BULLETIN 400101. PROBLEM WELL KNOWN AMONG PASSAT/AUDI OWNERS. DEALER ASKING $1200 FOR REPAIR. VWOA DECLINES TO HELP, STATING THAT SUSPENSION IS "2 YEAR 24K MILE COMPONENT". MILEAGE, EXISTENCE OF SERVICE BULLETIN, AND WIDESPREAD EXPERIENCE WITH THIS PROBLEM SUGGEST THAT THIS IS A DEFECTIVE COMPONENT AND SHOULD BE AT LEAST PARTIALLY COVERED BY VWOA. *NLM
FRONT CONTROL ARM FAILURE. *JB
1999 VW PASSAT. FRONT SUSPENSION PROBLEMS. REFER TO TSB 4001-01. I BROUGHT MY 1999 PASSAT TO THE DEALER REGARDING A NOISY FRONT SUSPENSION PROBLEM AND INFORMED THEM OF A TSB ON THE VEHICLE. I WAS INFORMED THAT VW PROVIDES A REPAIR KIT FOR THIS PROBLEM THAT REQUIRES THE REPLACEMENT OF THE LOWER CONTROL ARM ASSEMBLY. WHICH INC…
Read full complaint
1999 VW PASSAT. FRONT SUSPENSION PROBLEMS. REFER TO TSB 4001-01. I BROUGHT MY 1999 PASSAT TO THE DEALER REGARDING A NOISY FRONT SUSPENSION PROBLEM AND INFORMED THEM OF A TSB ON THE VEHICLE. I WAS INFORMED THAT VW PROVIDES A REPAIR KIT FOR THIS PROBLEM THAT REQUIRES THE REPLACEMENT OF THE LOWER CONTROL ARM ASSEMBLY. WHICH INCLUDES THE DEFECTIVE BALL JOINTS (BOTH SIDES). THE DEALER INFORMED ME THAT VW WILL NOT COVER THE REPAIR AND THAT THE COST TO ME WOULD BE $875.00. SPOKE WITH VW REPRESENTATIVES ON APRIL 2 AND WAS GIVEN A DECISION ON 4/9 THAT THEY WOULD NOT ASSIST WITH THE COST IN ANY WAY SINCE "THIS COULD ALSO BE CAUSED BY NORMAL WEAR AND TEAR". THIS ASSERTION, IN MY OPINION IS BOGUS SINCE A. VW KNOWS THERE IS A PROBLEM, HENCE THE TSB. PROVIDE A "KIT" TO REPAIR THE DEFECT. THE CASE NUMBER IS 30164333. SUSPENSIONS SHOULD NOT BE FALLING APART ON A 3 YEAR OLD VEHICLE WITH 50,000 MILES ON IT. AND THE COST ($875) IS QUITE EXCESSIVE. THE NOISE STARTED SHOWING UP IN EARLY JANUARY OF 2003. *NLM
Official recalls
508V156000 · Fuel System, Gasoline:delivery
Apr 7, 2008
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
Consequence & remedy
Consequence: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
02V026000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Jan 25, 2002
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
00V414000 · Steering:linkages:rod:relay:connecting
Dec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TIE RODS OF THE STEERING ASSEMBLY ARE PROTECTED ON EACH SIDE BY A SEAL TO PREVENT MOISTURE AND DUST PARTICLES FROM ENTERING THE SWIVEL BEARING MECHANISM. IT IS POSSIBLE THAT SOME TIE ROD SEALS MAY NOT SEAL PROPERLY.
Consequence & remedy
Consequence: IF MOISTURE AND/OR DUST PARTICLES ENTER THE SWIVEL BEARING MECHANISM, THE SWIVEL BEARING COULD WEAR OVER TIME DIMINISHING THE STEERING CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIE RODS.
99V248000 · Steering:linkages:rod:relay:connecting
Sep 13, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TIE RODS OF THE STEERING ASSEMBLY ARE PROTECTED ON EACH SIDE BY A SEAL TO PREVENT MOISTURE AND DUST PARTICLES FROM ENTERING THE SWIVEL BEARING MECHANISM. IT IS POSSIBLE THAT SOME TIE ROD SEALS MAY NOT SEAL PROPERLY.
Consequence & remedy
Consequence: IF MOISTURE AND/OR DUST PARTICLES ENTER THE SWIVEL BEARING MECHANISM, THE SWIVEL BEARING COULD WEAR OVER TIME DIMINISHING THE STEERING CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIE RODS.
99V131001 · Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
May 21, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. A CONTROL VALVE IN THE VACUUM HOSE CONNECTING THE BRAKE BOOSTER TO THE INTAKE MANIFOLD MAY NOT OPEN OR CLOSE FULLY AT TEMPERATURES BELOW -4 F UNDER CERTAIN DRIVING CONDITIONS.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE INSUFFICIENT VACUUM TO BE PROVIDED TO THE BRAKE BOOSTER.
Remedy: DEALERS WILL INSTALL A VACUUM BY-PASS SYSTEM INTO VEHICLES OPERATED IN THESE STATES WHICH IS DESIGNED TO PROVIDE SUFFICIENT VACUUM FOR FULL BRAKE ASSIST UNDER ALL WEATHER CONDITIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
DP05003 · Alleged Premature Tie Rod Failure
Opened Aug 8, 2005 · Closed Dec 9, 2005
Status: closed (inferred from source dates) · Steering:linkages:tie Rod Assembly
ON AUGUST 2, 2005, ODI RECEIVED A PETITION SUBMITTED BY MS. MIRIAM SCHNEIDER OF OLNEY, MD, REQUESTING AN INVESTIGATION OF ALLEGEDLY DEFECTIVE TIE RODS IN CERTAIN MODEL YEAR (MY) 1999 VOLKSWAGEN PASSAT VEHICLES NOT INCLUDED IN TWO PREVIOUS SAFETY RECALL CAMPAIGNS (IDENTIFIED HENCEFORTH AS THE SUBJECT VEHICLES).IN A SEPTEMBER 1999 LETTER, VOLKSWAGEN OF AMERICA, INC. (VW) NOTIFIED THE AGENCY THAT AN UNDETERMINED PERCENTAGE OF MY 1998-1999 VOLKSWAGEN PASSAT AND AUDI A4, A6, AND A8 VEHICLES CONTAINED A SAFETY-RELATED DEFECT AFFECTING ALUMINUM TIE ROD ENDS IN THE STEERING SYSTEM.VW INDICATED THAT IT WAS POSSIBLE THAT SOME TIE RODS WOULD NOT SEAL PROPERLY WHICH COULD ALLOW MOISTURE AND DUST PARTICLES TO ENTER THE SWIVEL BEARING MECHANISM, RESULTING IN PREMATURE WEAR.THE APPROXIMATELY 22,200 VOLKSWAGEN AND 29,700 AUDI VEHICLES AFFECTED BY THIS RECALL (IDENTIFIED BY NHTSA RECALL NO. 99V-248) WERE BUILT FROM JANUARY 1998 THROUGH JULY 1998 AND FELL WITHIN A SPECIFIC VEHICLE IDENTIFICATION NUMBER (VIN) RANGE.IN NOVEMBER 2000, VW CHOSE TO EXPAND THE SCOPE OF THE RECALL (IDENTIFIED BY NHTSA RECALL NO. 00V-414) AFTER IT DETERMINED THAT SOME POTENTIALLY DEFECTIVE ALUMINUM TIE ROD ENDS MAY HAVE BEEN INSTALLED IN AN ADDITIONAL 44,000 VOLKSWAGEN AND 39,000 AUDI VEHICLES BUILT FROM AUGUST 1998 THROUGH APRIL 1999.THESE SUBJECT RECALL ACTIONS WERE NOT INFLUENCED BY ODI.INSTEAD, VW MADE AN INDEPENDENT DETERMINATION TO CONDUCT A RECALL AFTER GERMAN VEHICLE INSPECTION AUTHORITIES NOTIFIED IT OF ?WORN? TIE RODS AND FACTORY INSPECTION OF SOME ?WORN? TIE RODS REVEALED IMPROPER SEALING.ACCORDING TO A DECEMBER 2004 REPORT, THE PETITIONER BROUGHT HER MY 1999 PASSAT TO AN AUTHORIZED VOLKSWAGEN DEALER FOR AN UNRELATED RECALL REPAIR WHERE SHE WAS NOTIFIED BY SERVICE PERSONNEL THAT, AFTER 59,000 MILES TRAVELED, THE TIE RODS ?HAVE TOO MUCH PLAY,? AND THE RECOMMENDED REPAIRS WOULD NOT BE COVERED FREE OF CHARGE BECAUSE HER VIN (WVWNA63B1XE499116) WAS OUTSIDE THE RECALL RANGE.IN JUNE 2005, AFTER 65,400 MILES TRAVELED, THE PETITIONER PAID $588.59 TO REPLACE WORN INNER AND OUTER TIE ROD ENDS ON BOTH SIDES OF THE VEHICLE.THE PETITION LETTER SPECIFICALLY REQUESTS THAT THE SCOPE OF VW?S RECALL BE EXPANDED TO INCLUDE THE PETITIONER?S VEHICLE AND THAT SHE BE REIMBURSED FOR THE COST OF THE REPAIRS.THERE ARE A TOTAL OF 191 NON-DUPLICATIVE COMPLAINTS TO ODI AND VW THAT ALLEGE PREMATURE WEAR OF EITHER ONE OR BOTH OUTER TIE ROD ENDS IN THE SUBJECT VEHICLES.AS OF NOVEMBER 18, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS OF TIE ROD SEPARATIONS RESULTING IN A LOSS OF VEHICLE CONTROL, CRASH OR INJURY IN THE SUBJECT VEHICLES.THE PETITIONER?S VEHICLE WAS MANUFACTURED ON JUNE 8, 1999 USING REVISED STEEL TIE ROD ENDS AND THEREFORE WAS ALREADY EQUIPPED WITH THE TIE ROD ENDS USED TO REMEDY DEFECTIVE VEHICLES IN THE SUBJECT RECALLS.ANALYSIS INDICATES THAT THERE DOES NOT APPEAR TO BE A SAFETY-RELATED DEFECT TREND WITH RESPECT TO THE STEEL TIE ROD ENDS USED IN THE SUBJECT VEHICLES.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
EA04017 · STUCK-OPEN Throttle
Opened Jun 30, 2004 · Closed Feb 10, 2005
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System
VWOA HAS RECALLED APPROXIMATELY 28,300 MY 1998-99 A6 VEHICLES IN COLD WEATHER STATES THAT EXPERIENCED THE HIGHEST RATE OF THROTTLE ICING INCIDENTS IN THE SUBJECT VEHICLES (04V-495).THE FAILURE RATE IN THE A4 AND PASSAT VEHICLES IS MUCH LOWER THAN IN THE RECALLED VEHICLES.ODI WILL CONTINUE TO MONITOR THE EXPERIENCE IN THE A4 AND PASSAT VEHICLES.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS FOR THE AUDI A4 OR VW PASSAT VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY A CHANGE IN CIRCUMSTANCES. FOR FURTHER DETAILS SEE THE ATTACHED CLOSING REPORT.
EA03020 · Passenger Air Bag Lid Failure
Opened Oct 7, 2003 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Additional source detail variants (2)
Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Air Bags
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
PE03021 · Passenger Sir Door Mounting Stud Failure
Opened May 23, 2003 · Closed Oct 7, 2003
Status: closed (inferred from source dates) · Air Bags:frontal
ODI OPENED A PRELIMINARY EVALUATION (PE03-021) BASED ON TWO REPORTS OF FAILED BOLT STUDS THAT ATTACH THE PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) DOOR COVER TO THE INSTRUMENT PANEL (IP) ON THE VOLKSWAGEN (VW) PASSAT (MODEL YEARS 2000, 2002).VW HAS INDICATED TO ODI THAT IT HAS NO ADDITIONAL REPORTS.VW IMPLEMENTED A PROCESS CHANGE ON MARCH 1, 2002.THIS PROCESS CHANGE CONSISTED OF CHANGING THE BOLT APPLICATION THAT FASTENS THE PSIR DOOR TO THE IP FROM A WELD ON APPLICATION TO A PRESS ON APPLICATION.VW ALSO CHANGED THE MATERIAL OF THE BOLT.VW STATED THAT THE CHANGES WERE MADE TO EASE PRODUCTION BY ELIMINATING A WELDING PROCESS.ODI HAS UPGRADED ITS INVESTIGATION TO ENGINEERING ANALYSIS (EA03-020).
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
RQ99008 · Power Brake Booster Vacuum BY-PASS
Opened Jun 1, 1999 · Closed Nov 14, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available