1993 Volkswagen Passat

THE HEATER CORE RUPTURED AND FLOODED THE PASSENGER COMPARTMENT WITH STEAM AND HOT COOLANT. FORTUNATELY, THE CAR HAD JUST COME TO A COMPLETE STOP. THIS HAS OCCURED IN THE ONLY OTHER VW VEHICLE I HAVE OWNED, A 1986 JETTA GL. THAT VEHICLE WAS RECALLED FOR THIS VERY SAME PROBLEM. I FIND IT VERY DISTURBING THAT THE PASSENGER COMPARTMENT OF THE VEHICLE CAN BE AFFECTED BY SUCH AN EQUIPMENT FAILURE. I CAN ACCEPT THE HEATER CORE LEAKING IN THE PASSENGER COMPARTMENT, BUT NOT EXPLOIDING LIKE A BOMB. WITNESSESS THOUGHT THE CAR WAS ON FIRE. LUCKILY, MY WIFE AND CHILD WERE NOT CRUISING DOWN THE FREEWAY AT 65 MPH.

DRIVING TO AIRPORT THE TEMPERATOR INDICATOR LIGHT CAME ON, FLASHING, AND THE HEATER CORE EXPLODED. INTERIOR OF THE CAR FILLED WITH DENSE WHITE VAPOR. I WAS ABLE TO STOP THE CAR ON THE ROAD/SHOULDER AND MY WIFE AND I EVACUATED. ROAD AT THE TIME OF INCIDENT WAS BASICLY CLEAR OF OTHER VEHICLES OTHERWISE IT WOULD HAVE BEEN A PROBLEM OF OUR SURVIVAL. *AK

IGNITION : FOR THE LAST 9 MONTHS, INTERMITTENTLY, CAR WILL CONTINUE TO RUN AFTER THE IGNITION IS TURNED OFF AND KEY IS REMOVED... BEEN TO 3 VW DEALERSHIPS 5 TIMES TOTAL. ABS BRAKES NEVER WORKED SINCE NEW, WOULDN'T STOP ON SNOW OR ICE LIKE OTHER ABS BRAKE SYSTEMS .. AFTER MANY COMPLAINTS FOR 4 YEARS VW FIXED SOME OF THE ABS PROBLEMS BUT ABS WARNING LIGHT STILL COMES ON SOMETIMES. ALSO, PEDAL INTERMITTENTLY WILL GO TO FLOOR, AND SNOW AND ICE PERFORMANCE IS MUCH WORSE THAN OUR OTHER ABS PASSATS . SEAT BELTS: LAP BELT BUCKLE SEEMS LIKELY TO CAUSE INJURY IN AN ACCIDENT . AIR CONDITIONER : $150 SWITCH IN DASH HAS FAILED 3 TIMES (COMMON ON 1993-94 PASSATS). SUNROOF: SMALL PART BREAKS ON TRACK REQUIRES REPLACEMENT OF ENTIRE EXPENSIVE SUNROOF MECHANISM ... (SEEMS TO HAPPEN MANY 1993-94 PASSATS). FOG LIGHTS: CORRADO AND PASSAT LENSES FOG UP OR FILL UP WITH WATER AND THEN CRACK FROM HEAT. VW AND HELLA REDESIGNED LENS ON CORRADO MODEL BUT NOT ON PASSAT $26 TO $50 PER LENS, 11 LENSES SO FAR. *AK

MILES:1,519- DOESN'T TURN OVER - REPLACED BATTERY: 8602- CHECK ENGINE LIGHT STAYS ON- REPL BAD HOUSING CONNECTION:11,672-CHECK ENGINE LIGHT ON-RPL CAM POSITION SENSOR&ECM&AC CONTROLS:22,013-RATTLING WHINING NOISE-REPL FROZEN RADIATOR FAN MOTOR, BURNT FAN CONN/REPRODUCED WRING, O/RING, DEFECTIVE CAM POSITION, SENSOR;25,763 REPLACE BATTERY;34,677-SERPENTINE BELT REPL;36,800-REPL HALL/TCI CONTROL UNIT;50,610- REPL BATTERY, ALTERNATOR HARNESS;51,070 REPL AUXILIARY WATER PUMP;CONNECTOR,HOSES;53,190-AC CONTROL WITH OPEN CONNECTION & WIRING OVERHEATED,REPL CONTROLS & REPAIRED WIRING, HEATERCONTROL, CONNECTOR:60,523-REPL HEATER CORE, SEALS, THERMOSTATE, HOUSING, SEAL RING, 3 O-RINGS, SERPINTINE BELT; 63,782-REPL BATTERY, CRUISE CONTROL & SUNROOF NO LONGER WORK TOO COSTLY TO REPAIR, 66,035- REPL POWER SUPPLY RELAY, FUEL PUMP;71,000 TRANSMISSION PROBLEMS. DEALER INDICATES FULL REPLACEMENT OF TRANSMISSION. PURCHASED '88 JETTA. IN '97 DECIDED TO UPGRADE TO PASSAT GLX. WITH ALL THE PROBLEMS I HAVE HAD WITH THIS CAR I WOULD NOT RECOMMEND ANYONE BUY A VOLKSWAGEN. *AK