NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
548 reportsMileage unknown · May 17, 2023
Fuel System, Gasoline
There is a confirmed evap recall for my year and model, recall number 20CQ. When I check against my vin, it says my vehicle has zero recalls however I have the exact symptoms and issues as described in the recall. The recall is for a faulty evap purge valve and I don't think it is coincidence that my vehicle has a check engine…
Read full complaint
There is a confirmed evap recall for my year and model, recall number 20CQ. When I check against my vin, it says my vehicle has zero recalls however I have the exact symptoms and issues as described in the recall. The recall is for a faulty evap purge valve and I don't think it is coincidence that my vehicle has a check engine light on for a Very small evap leak. I've had it checked my multiple mechanics and no one can identify what the issue is and we've tried multiple troubleshooting steps. At this point the most logical issue is the purge valve. I believe there are more affected cars with the same make and model than the recall is projecting.
NHTSA ODI #11522558
Mileage unknown · May 16, 2023
Electrical System
While driving my vehicle to a town 20 minutes away, as I was exiting the highway my vehicle turned off completely. Gave a “Ignition switched off, Please stop safely” message and shortly after popped up a “Please check starter system” message. This was on a fairly hot day. I was able to pull over, let it cool off and drive back h…
Read full complaint
While driving my vehicle to a town 20 minutes away, as I was exiting the highway my vehicle turned off completely. Gave a “Ignition switched off, Please stop safely” message and shortly after popped up a “Please check starter system” message. This was on a fairly hot day. I was able to pull over, let it cool off and drive back home. I called the Vorderman Volkswagen in Fort Wayne Indiana and they told me the issue was my battery, paid $500 for a new battery. 3 weeks later on May 12th as I’m driving home from work, my vehicle turns off again and gives the same messages. At this point I’m very irritated because I explained to the dealership what I believe it is because MULTIPLE others have had the same issue and they ignored me. I’ve tried to explain to them this second time that it has something to do with the ignition switch but they keep telling me “nothing is wrong” they want to give my vehicle back unfixed and I feel very unsafe driving something that turns off while I’m driving it and doesn’t work unless it’s cooler outside.
NHTSA ODI #11522341
Mileage unknown · May 12, 2023
Power Train
At ~44,000, in a vehicle we bought 3 months earlier from OffLeaseOnly, the clutch burned out and the car ceased forward propulsion on a deserted country road driven by a very experienced manual car driver who had not burned through a clutch in his driving career. There were no warning lights. It put three people at risk. OffLea…
Read full complaint
At ~44,000, in a vehicle we bought 3 months earlier from OffLeaseOnly, the clutch burned out and the car ceased forward propulsion on a deserted country road driven by a very experienced manual car driver who had not burned through a clutch in his driving career. There were no warning lights. It put three people at risk. OffLeaseOnly - had done a full inspection AND stood behind their sale by paying for the new clutch assembly. The clutch and associated mechanism was fully replaced by 12/17/2021 by Niello VW. Vehicle was driven from January - August by same driver. There were occasional clutch burning smells but mechanical inspection did not reveal any issue. The car was not driven regularly from Sept - March 2023. Prior to our daughter driving it starting at the end of March, we had it reviewed by a local mechanic who found no issues with the vehicle. At ~54,000 miles, on May 10, the vehicle was being driven on US HWY 280 between San Carlos and Redwood City, CA. Suddenly, the vehicle would not shift and would not go above 40 mph. The very new driver was able to successfully maneuver to the shoulder and bring the car to a stop. Her safety was definitely at risk as 280 is a congested, fast moving highway where the average speed is 75 mph. The clutch was burning. CA HWY Patrol pulled the car to a park in Woodside where it was collected by a flatbed and brought to Boardwalk VW. Once again, the clutch is completely burned out. Boardwalk VW is tearing down the transmission to see if there is a cause for the multiple clutch burnouts. We have multiple manual vehicles - this is only happening with the VW Jetta. I’ve driven manual cars since 1987 and this has NEVER happened with any of them. We are awaiting Boardwalk VW assessment of the cause. There were no warning lights. There were no symptoms of the problem until the car ceased to operate. Both times, we have brought the car to a VW dealer for inspection and repair.
NHTSA ODI #11521704
Mileage unknown · May 11, 2023
Electrical SystemEngine
THE CAR WILL JUST SHUT DOWN. IF THE CAR IS PARKED IN THE SUN IT WILL JUST RANDOMLY NOT START. SINCE THE TEMPATURES OUTSIDE HAVE GOTTEN WARMER IT HAS NOW DONE 3 TIMES: THE CAR WILL START FINE AS I AM DRIVING THE ELECTRICAL PANELS AND EVERYTHING SHUTS OFF BUT THE GAS STILL WORKS AND THE CAR SAYS CHECK STARTER SYSTEM. MY 16 YEAR OL…
Read full complaint
THE CAR WILL JUST SHUT DOWN. IF THE CAR IS PARKED IN THE SUN IT WILL JUST RANDOMLY NOT START. SINCE THE TEMPATURES OUTSIDE HAVE GOTTEN WARMER IT HAS NOW DONE 3 TIMES: THE CAR WILL START FINE AS I AM DRIVING THE ELECTRICAL PANELS AND EVERYTHING SHUTS OFF BUT THE GAS STILL WORKS AND THE CAR SAYS CHECK STARTER SYSTEM. MY 16 YEAR OLDS DRIVE THIS CAR. THE INSTRUMENT PANELS ALL TURN OFF. THE CAR HAS ALSO SHUT OFF THE ENGINE WHILE IN MOTION THIS IS VERY DANGEROUS. THE CHECK ENGINE LIGHT DOESNT SHOW AND BECAUSE IT IS RANDOM MY MECHANIC CANNOT FIND THE MAIN PROBLEM AND PARTS RELATED TO THIS ARE SOLD OUT WITH VW DUE TO IF YOU LOOK EVERYONE IS HAVING THIS ISSUE. SOMEONE IS GOING TO DIE PLEASE. MY CAR HAS SERVICE RECORDS JUST 50,000 MILES AND ITS BEEN AN ON GOING ISSUE FOR AWHILE. WE CANT TRADE IT IN FOR FINANCIAL REASONS BUT HAVE TO DRIVE IT. MY HUSBAND AND I HAVE OUR KIDS DRIVING OUR HYUNDAI AND WE DRIVE THIS JETTA CAUSE I WOULD RATHER IT SHUT DOWN IN THE MIDDLE OF AN INTERSECTION WITH HE OR I DRIVING THAN THEM. PLEASE THIS JETTA WILL KILL THE DRIVERS, PASSENGERS AND WHOEVER CRASHES INTO IT WHEN IT KEEP SHUTTING OFF. IT HAS BEEN AT THE SHOP FOR A WEEK AT A TIME AT TIMES TRYING TO FIX THIS
NHTSA ODI #11521570
Mileage unknown · May 4, 2023
Electrical System
When my car gets hot from the sun it turns off my whole electrical system in the car including my radio and speedometer
NHTSA ODI #11520503
119,000 miles · May 1, 2023
Engine
The contact owns a 2019 Volkswagen Jetta. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power with an unknown warning light illuminated and an unknown message displayed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of …
Read full complaint
The contact owns a 2019 Volkswagen Jetta. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power with an unknown warning light illuminated and an unknown message displayed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 119,000.
NHTSA ODI #11519802
Mileage unknown · Apr 29, 2023
Unknown Or Other
The windshield cracked while car was sitting in my driveway. At 8:30am it was fine. At 3pm there was a very large crack. No mark from rock, pebble or object of any kind is present. Car is available for inspection. Safety put at risk should the crack cause a weakened windshield to fall out of frame. No inspections have been per…
Read full complaint
The windshield cracked while car was sitting in my driveway. At 8:30am it was fine. At 3pm there was a very large crack. No mark from rock, pebble or object of any kind is present. Car is available for inspection. Safety put at risk should the crack cause a weakened windshield to fall out of frame. No inspections have been performed yet.
NHTSA ODI #11519621
Mileage unknown · Apr 26, 2023
Wheels
At approximately 44,000 miles TPMS light illuminated however all tire PSI were normal and not low. I reset TPMS light however it came back on around 20 miles later. I kept resetting TPMS light however it would keep coming on even though tire PSI were set. At around 46000 miles car was taken into dealer. Dealer reset light and at…
Read full complaint
At approximately 44,000 miles TPMS light illuminated however all tire PSI were normal and not low. I reset TPMS light however it came back on around 20 miles later. I kept resetting TPMS light however it would keep coming on even though tire PSI were set. At around 46000 miles car was taken into dealer. Dealer reset light and at around 20 miles light keeps coming back on.
NHTSA ODI #11519096
Mileage unknown · Apr 24, 2023
Electrical SystemEngineSteeringCrash
The vehicle steering has been off and alignment when driving. My gas gauge has been off constantly, since I've owned the vehicle. I documented this many times and reported this to the dealership under warranty and Volkswagen care.
NHTSA ODI #11518599
Mileage unknown · Apr 12, 2023
Electrical SystemExterior LightingUnknown Or Other
Vehicle parked under the sun, temperature reaching 85 degree, hotter inside the cabin. Vehicle started with no issues but "Check starter system" warning comes up and all the electrical component shut off its power, including all the gauge in the dashboard and radio. Headlight is not working as well after few min. Car drives (man…
Read full complaint
Vehicle parked under the sun, temperature reaching 85 degree, hotter inside the cabin. Vehicle started with no issues but "Check starter system" warning comes up and all the electrical component shut off its power, including all the gauge in the dashboard and radio. Headlight is not working as well after few min. Car drives (manual transmission) with no issues. When the car is placed under the shade/cools down, shows no problems. Some of owners reported the faulty ignition switch, part number 5Q1-905-865-A. Google search of "2019 Jetta check starter system" results in multiple complaints. The part in question is in national back order, suggesting the issue is more wide spread.
NHTSA ODI #11516763
Official recalls
11Feb 14, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
Sep 6, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Jetta vehicles. The instrument cluster may not provide an audible warning to let the driver know that the key is still in the ignition when the door is open. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 114, "Theft Protection."
Consequence & remedy
Consequence: Without an audible warning, the driver may be unaware that the key is left in the ignition, which can increase the risk of vehicle theft or a crash.
Remedy: Dealers will update the instrument cluster, free of charge. Owner notification letters are expected to be mailed November 3, 2023. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 90W7.
Aug 30, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Golf, Golf Alltrack, Golf Sportwagen, 2019-2020 Golf GTI, and Jetta vehicles equipped with a conventional ignition switch. The ignition switch may fail, especially in high temperature environments.
Consequence & remedy
Consequence: Ignition switch failure can cause the electrical system to shut down and the engine to stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the ignition switch, free of charge. Owner notification letters were mailed February 1, 2024. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 28H7.
Oct 31, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Volkswagen Tiguan LWB, Golf Sportswagen A7, Golf Alltrack, Golf R GP, Audi Q3, Audi A3 Cabriolet, 2019-2020 Jetta NF, Jetta GLI, Golf GTI, Atlas, Golf A7, Audi A3, 2020-2021 Atlas Cross Sport, and 2021 Atlas FL vehicles. The tire pressure monitoring system may not detect an air pressure loss in adequate time when deflating occurs among all four tires simultaneously. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: An undetected sudden loss of pressure in all four tires increases the risk of a crash.
Remedy: Dealers will update the TPMS software, free of charge. Owner notification letters were mailed November 18, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298 or Audis customer service at 1-800-253-2834. Volkswagen's numbers for this recall are (Audi) 45J7, and (VW) 45J6 and 45J8.
Dec 11, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Jetta GLI, Golf Alltrack, and Golf GTI vehicles. The front wheel bearings may have been improperly machined, potentially causing excessive stress on the wheel, wheel bolts, or wheel bearings.
Consequence & remedy
Consequence: The excessive stress can cause steering, traction or other stability issues or breakage relating to the front wheels, and increase the risk of a crash.
Remedy: Volkswagen has notified owners, and dealers will replace the wheel bearing assemblies, wheels, and wheel bolts, free of charge. The recall began December 11, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 40P1. Note: The affected owners are advised not to drive their vehicles until the repairs have been made.
Sep 25, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015 Golf Sportwagen, 2013 Golf, 2008-2010 and 2012-2013 Beetle and Beetle Convertible, 2008-2010 Beetle, and Beetle Convertible vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
Consequence & remedy
Consequence: If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Remedy: Volkswagen will notify owners and repurchase the affected vehicles. The recall began November 6, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01D7. Note: This recall is an expansion of NHTSA recall number 18V-329.
Mar 6, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Golf Sportwagen, 2019 Jetta, 2015-2019 Golf, and 2018-2019 Tiguan vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the rear axle coil springs, free of charge. The recall began April 12, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J5.
Feb 20, 2019
Volkswagen Group of America (Volkswagen) is recalling certain 2019 Jetta vehicles. An incorrect driver frontal airbag may have been installed during a service/repair visit.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, the wrong air bag may not work correctly, increasing the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will replace the driver frontal air bag with the correct part, free of charge. The recall began April 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69Y7.
Dec 19, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas, 2015 Volkswagen Golf SportWagen, and 2019 Volkswagen Jetta vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen has notified owners, and dealers will replace the rear axle coil springs, free of charge. The recall began January 31, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J2/42J3.
Nov 26, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas and Tiguan and 2019 Volkswagen Jetta vehicles that do not have keyless entry. The instrument cluster may not provide an audible warning to let the driver know that the key is still in the ignition when the door is open. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the driver is not notified by an audible noise that the key is left in the ignition, it can increase the risk of vehicle theft or crash.
Remedy: Volkswagen will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began December 13, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 90L3 and 90L4.
Sep 26, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Volkswagen Jetta vehicles equipped with LED headlights. The passenger side headlight may be incorrectly positioned, reducing the driver's visibility when it is dark. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: A reduction in the driver's visibility can increase the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the passenger side headlight, free of charge. The recall began November 2, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 94L1.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
Opened Dec 12, 2023 · Closed Jul 1, 2024
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage:evaporative Emissions:canister; Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Fuel System, Gasoline:storage:evaporative Emissions:canister
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP19003 · Vehicle Stalling - Manual Transmission
Opened Sep 3, 2019 · Closed Jun 30, 2020
Status: closed (inferred from source dates) · Engine; Power Train:manual Transmission
The Office of Defects Investigation (ODI) has completed its review of a defect petition received on 14 August 2019 requesting an investigation of an alleged defect of the manual transmissions in Model Year (MY) 2019 Volkswagen (VW) GTI, Golf GTI and Jetta GLI vehicles. The stalling incidents cited occurred without warning as the vehicle slows to a stop or prepares to make a turn across traffic with the clutch pressed in and the vehicle in neutral.The hazard posed by a vehicle stalling event is manifested in the inability of the vehicle to move with the flow of surrounding traffic. Two factors have a major impact on the potential hazard to the vehicle, its occupants and surrounding vehicles: the surrounding traffic speed and the subject vehicle's restart ability. In the case of the vehicles that are the subject of this petition, restart is immediate and the stalls occur when the vehicle is slowing to stop for a traffic signal, making a turn, or is completely stopped. These circumstances substantially reduce the risk of harm to the vehicle, its occupants and surrounding vehicles.As of March 2, 2020, out of the population of 11,333 subject vehicles, NHTSA has identified 214 consumer complaints in its database, with unique Vehicle Identification Numbers (VIN), citing engine stalling as vehicles are being brought to a stop and/or preparing to make a cross traffic turn. When combined with the warranty, field report and customer complaint data received from VW in response to the Information Request letter sent, NHTSA identified 413 unique VINs alleging low speed engine stalling.Volkswagen determined that the low speed / idle engine stall was the result of unwanted gases remaining in the cylinder caused by the intake valve camshaft not being in the correct position at idle. The intake camshaft is in an advanced position. This advanced position results in too much overlap with the position of the exhaust valve camshaft, allowing both the intake and exhaust valves to be open at the same time. The erroneous advanced position of the intake camshaft is a result of low oil pressure at idle and high oil temperatures, greater than or equal to 110?C/230?F combined with engine control algorithms in the Engine Control Module (ECM) that position the intake camshaft. Based on examination of returned engines, only engines manufactured at the Silao Mexico plant were affected due to a tolerance stack-up issue with the oil system of the engines.In December of 2019, VW initiated a Service Action (24FD) to remedy the stalling issue in the affected vehicles. The warranty for the affected vehicles was extended to December 31, 2025. The software in the Engine Control Module (ECM) will be updated with a new calibration value for the adaptation nodes of the regulation valve. This is a directed action with letters being sent to vehicle owners asking them to bring their vehicles to their dealership to have the software update installed in their vehicle. The letters were sent in December 2019.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Volkswagen in response to an information request and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that the stalling condition as alleged by the petitioner indicates the likelihood of a safety related defect that would warrant a formal investigation, therefore the petition is denied. Further specifics can be found in the Federal Register Notice.ODI complaint ID Numbers are listed on the attached sheet.
Additional source detail variants (2)
Engine
The Office of Defects Investigation (ODI) has completed its review of a defect petition received on 14 August 2019 requesting an investigation of an alleged defect of the manual transmissions in Model Year (MY) 2019 Volkswagen (VW) GTI, Golf GTI and Jetta GLI vehicles. The stalling incidents cited occurred without warning as the vehicle slows to a stop or prepares to make a turn across traffic with the clutch pressed in and the vehicle in neutral.The hazard posed by a vehicle stalling event is manifested in the inability of the vehicle to move with the flow of surrounding traffic. Two factors have a major impact on the potential hazard to the vehicle, its occupants and surrounding vehicles: the surrounding traffic speed and the subject vehicle's restart ability. In the case of the vehicles that are the subject of this petition, restart is immediate and the stalls occur when the vehicle is slowing to stop for a traffic signal, making a turn, or is completely stopped. These circumstances substantially reduce the risk of harm to the vehicle, its occupants and surrounding vehicles.As of March 2, 2020, out of the population of 11,333 subject vehicles, NHTSA has identified 214 consumer complaints in its database, with unique Vehicle Identification Numbers (VIN), citing engine stalling as vehicles are being brought to a stop and/or preparing to make a cross traffic turn. When combined with the warranty, field report and customer complaint data received from VW in response to the Information Request letter sent, NHTSA identified 413 unique VINs alleging low speed engine stalling.Volkswagen determined that the low speed / idle engine stall was the result of unwanted gases remaining in the cylinder caused by the intake valve camshaft not being in the correct position at idle. The intake camshaft is in an advanced position. This advanced position results in too much overlap with the position of the exhaust valve camshaft, allowing both the intake and exhaust valves to be open at the same time. The erroneous advanced position of the intake camshaft is a result of low oil pressure at idle and high oil temperatures, greater than or equal to 110?C/230?F combined with engine control algorithms in the Engine Control Module (ECM) that position the intake camshaft. Based on examination of returned engines, only engines manufactured at the Silao Mexico plant were affected due to a tolerance stack-up issue with the oil system of the engines.In December of 2019, VW initiated a Service Action (24FD) to remedy the stalling issue in the affected vehicles. The warranty for the affected vehicles was extended to December 31, 2025. The software in the Engine Control Module (ECM) will be updated with a new calibration value for the adaptation nodes of the regulation valve. This is a directed action with letters being sent to vehicle owners asking them to bring their vehicles to their dealership to have the software update installed in their vehicle. The letters were sent in December 2019.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Volkswagen in response to an information request and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that the stalling condition as alleged by the petitioner indicates the likelihood of a safety related defect that would warrant a formal investigation, therefore the petition is denied. Further specifics can be found in the Federal Register Notice.ODI complaint ID Numbers are listed on the attached sheet.
Power Train:manual Transmission
The Office of Defects Investigation (ODI) has completed its review of a defect petition received on 14 August 2019 requesting an investigation of an alleged defect of the manual transmissions in Model Year (MY) 2019 Volkswagen (VW) GTI, Golf GTI and Jetta GLI vehicles. The stalling incidents cited occurred without warning as the vehicle slows to a stop or prepares to make a turn across traffic with the clutch pressed in and the vehicle in neutral.The hazard posed by a vehicle stalling event is manifested in the inability of the vehicle to move with the flow of surrounding traffic. Two factors have a major impact on the potential hazard to the vehicle, its occupants and surrounding vehicles: the surrounding traffic speed and the subject vehicle's restart ability. In the case of the vehicles that are the subject of this petition, restart is immediate and the stalls occur when the vehicle is slowing to stop for a traffic signal, making a turn, or is completely stopped. These circumstances substantially reduce the risk of harm to the vehicle, its occupants and surrounding vehicles.As of March 2, 2020, out of the population of 11,333 subject vehicles, NHTSA has identified 214 consumer complaints in its database, with unique Vehicle Identification Numbers (VIN), citing engine stalling as vehicles are being brought to a stop and/or preparing to make a cross traffic turn. When combined with the warranty, field report and customer complaint data received from VW in response to the Information Request letter sent, NHTSA identified 413 unique VINs alleging low speed engine stalling.Volkswagen determined that the low speed / idle engine stall was the result of unwanted gases remaining in the cylinder caused by the intake valve camshaft not being in the correct position at idle. The intake camshaft is in an advanced position. This advanced position results in too much overlap with the position of the exhaust valve camshaft, allowing both the intake and exhaust valves to be open at the same time. The erroneous advanced position of the intake camshaft is a result of low oil pressure at idle and high oil temperatures, greater than or equal to 110?C/230?F combined with engine control algorithms in the Engine Control Module (ECM) that position the intake camshaft. Based on examination of returned engines, only engines manufactured at the Silao Mexico plant were affected due to a tolerance stack-up issue with the oil system of the engines.In December of 2019, VW initiated a Service Action (24FD) to remedy the stalling issue in the affected vehicles. The warranty for the affected vehicles was extended to December 31, 2025. The software in the Engine Control Module (ECM) will be updated with a new calibration value for the adaptation nodes of the regulation valve. This is a directed action with letters being sent to vehicle owners asking them to bring their vehicles to their dealership to have the software update installed in their vehicle. The letters were sent in December 2019.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Volkswagen in response to an information request and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that the stalling condition as alleged by the petitioner indicates the likelihood of a safety related defect that would warrant a formal investigation, therefore the petition is denied. Further specifics can be found in the Federal Register Notice.ODI complaint ID Numbers are listed on the attached sheet.
Illustration