← New search

2010 Volkswagen Jetta

Owner reports · Recalls · Investigations

More warning signs than most Jetta years

Owner complaints for the 2010 Volkswagen Jetta are substantially higher than the model-year median of 68.

About this comparison →

When problems were reported

Mileage at the reported incident

779 reports with mileage · 73 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Diesel. Review the 166 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports5 fire reports10 injury reports

What owners actually said

852 reports
7,550 miles · Jul 24, 2011
Fuel System, Gasoline

WAS TRAVELING ON A CITY BLOCK IN SAN FRANCISCO WHEN THE ENGINE LIGHT WENT ON. THERE WAS A SLIGHT POWER SURGE BUT NO STALL. DRIVING INTO THE NEXT CITY BLOCK THE CAR COMPLETELY DIED AND I PULLED OVER TO CURB. UNABLE TO START AGAIN. CAR WAS TOWED TO VW DEALER. WAS TOLD THE FUEL PUMP IN THE TANK HAD MALFUNCTIONED, AND CONTAMINATED T…

Read full complaint

WAS TRAVELING ON A CITY BLOCK IN SAN FRANCISCO WHEN THE ENGINE LIGHT WENT ON. THERE WAS A SLIGHT POWER SURGE BUT NO STALL. DRIVING INTO THE NEXT CITY BLOCK THE CAR COMPLETELY DIED AND I PULLED OVER TO CURB. UNABLE TO START AGAIN. CAR WAS TOWED TO VW DEALER. WAS TOLD THE FUEL PUMP IN THE TANK HAD MALFUNCTIONED, AND CONTAMINATED THE FUEL TANK. ENTIRE FUEL PUMP, TANK, SYSTEM IS BEING REPLACED UNDER WARRANTY.

NHTSA ODI #10415850

2,300 miles · Jul 24, 2011
Fuel System, Diesel

WE PURCHASED A 2010 VOLKSWAGEN JETTA SPORTWAGEN TDI IN JULY 2010. ON JULY 21, 2011, THE VEHICLE WAS GIVEN ITS FIRST SERVICE AT A VOLKSWAGEN DEALERSHIP IN MADISON, WI. THE NEXT DAY, JULY 22, 2011, THE CAR WAS TO BE DRIVEN FROM MADISON, WI, TO NASHVILLE, TN. JUST PAST URBANA, IL, THE VEHICLE BEGAN TO OVERHEAT, INCREASING TO 190…

Read full complaint

WE PURCHASED A 2010 VOLKSWAGEN JETTA SPORTWAGEN TDI IN JULY 2010. ON JULY 21, 2011, THE VEHICLE WAS GIVEN ITS FIRST SERVICE AT A VOLKSWAGEN DEALERSHIP IN MADISON, WI. THE NEXT DAY, JULY 22, 2011, THE CAR WAS TO BE DRIVEN FROM MADISON, WI, TO NASHVILLE, TN. JUST PAST URBANA, IL, THE VEHICLE BEGAN TO OVERHEAT, INCREASING TO 190 DEGREES. IN ADDITION, THE ACCELERATION ABILITY BEGAN DECREASING UNTIL THE VEHICLE WOULD NOT GO MORE THAN 72 MPH. THE CHECK ENGINE LIGHT CAME ON AND BEGAN FLASHING. DRIVING THE VEHICLE BECAME DANGEROUS, AND THE VEHICLE WAS DRIVEN INTO A REST STOP AND TURNED OFF. VOLKSWAGEN ROADSIDE ASSISTANCE TOOK THE VEHICLE TO THE NEAREST DEALERSHIP WHICH WAS IN URBANA, IL. O'BRIEN VOLKSWAGEN DETERMINED ON JULY 23, 2011, THAT THE FUEL PUMP LOCATED IN THE GAS TANK WAS NOT OPERATING PROPERLY. THE REPLACEMENT TANK/PUMP HAS BEEN ORDERED AND IS SCHEDULED TO BE REPLACED IN THE VEHICLE ON JULY 26, 2011. WE FOUND THAT THIS COMPLAINT HAS BEEN MADE BY OTHERS, AND WE HOPE THAT THIS WILL BECOME AN OFFICIAL RECALL. IF IT HAD BEEN UNDER RECALL WHEN THE VEHICLE RECEIVED ITS SERVICE ON JULY 21, THE PART(S) COULD HAVE BEEN REPLACED AT THAT TIME, AND THE DANGEROUS DRIVING CONDITIONS COULD HAVE BEEN AVOIDED. *TR

NHTSA ODI #10414936

33,000 miles · Jul 22, 2011
Power Train

MY 2010 VW JETTA SPORTS WAGON WITH THE DSG AUTOMATIC IS CURRENTLY HAVING A SEVERE HESITATION WHEN STARTING FROM A STOP. I LET OFF THE BREAK AND STEP ON THE GAS AND IT DOES NOT MOVE FOR A SECOND THEN LURCHES FORWARD. THIS IS DANGEROUS WHEN PULLING OUT IN TRAFFIC. IT SEEMS AS THE CAR DRIVES LONGER IT GET WORSE. THE CAR HAS STALLED…

Read full complaint

MY 2010 VW JETTA SPORTS WAGON WITH THE DSG AUTOMATIC IS CURRENTLY HAVING A SEVERE HESITATION WHEN STARTING FROM A STOP. I LET OFF THE BREAK AND STEP ON THE GAS AND IT DOES NOT MOVE FOR A SECOND THEN LURCHES FORWARD. THIS IS DANGEROUS WHEN PULLING OUT IN TRAFFIC. IT SEEMS AS THE CAR DRIVES LONGER IT GET WORSE. THE CAR HAS STALLED DURING THIS HESITATION AS WELL. WHEN IT STALLS YOU HAVE TO PUT THE CAR IN PARK THEN TURN THE KEY OFF AND RESTART THE CAR. THIS IS A VERY UNEASY FEELING WHILE AT AN INTERSECTION. THE CAR ALSO LURCHES FORWARD WHEN COMING TO A COMPLETE STOP, THIS HAS ALMOST MADE ME HIT A CAR IN FRONT OF ME. THIS IS A DAILY ISSUE. *TT

NHTSA ODI #10414641

8,891 miles · Jul 18, 2011
Engine And Engine Cooling

AS I WAS DRIVING ON THE HIGHWAY AND I WAS ABOUT TO SHIFT TO A LOWER GEAR TO SLOW DOWN, THE ENGINE STALLED AND DIED. LUCKILY I WAS ABLE TO COME TO A COMPLETE STOP, AND RESTARTED THE ENGINE AGAIN. I DRIVE A DIESEL MANUAL TRANSMISSION ENGINE.

NHTSA ODI #10414248

15,000 miles · Jul 18, 2011
Vehicle Speed Control

UNEXPECTED ACCELERATION ON CRUISE CONTROL. WHEN THE CRUISE CONTROL IS SET, PRESSING THE 'COAST/DECELERATE' BUTTON SEVERAL TIMES CAUSES THE CRUISE CONTROL UNIT TO JUMP BY SEVERAL MPH, I.E. ACCELERATE. EXAMPLE: CRUISE IS SET AT 55 MPH. PRESS THE COAST BUTTON THREE OR FOUR TIMES (CAR SHOULD DECELERATE BY 1 MPH FOR EACH PRESS OF …

Read full complaint

UNEXPECTED ACCELERATION ON CRUISE CONTROL. WHEN THE CRUISE CONTROL IS SET, PRESSING THE 'COAST/DECELERATE' BUTTON SEVERAL TIMES CAUSES THE CRUISE CONTROL UNIT TO JUMP BY SEVERAL MPH, I.E. ACCELERATE. EXAMPLE: CRUISE IS SET AT 55 MPH. PRESS THE COAST BUTTON THREE OR FOUR TIMES (CAR SHOULD DECELERATE BY 1 MPH FOR EACH PRESS OF THE BUTTON), THE CRUISE SPEED WILL SET AT A HIGHER SPEED, SUCH AS 58 MPH. THIS CAN BE OBSERVED BY LOOKING AT THE DISPLAY WHICH SHOWS THE SPEED AT WHICH THE CRUISE CONTROL IS SET, AS WELL AS THE ACCELERATION OF THE CAR. THIS BEHAVIOR CAN BE EASILY REPLICATED AND DEMONSTRATED, THOUGH IT DOES NOT OCCUR EVERY TIME. THIS HAS BEEN OBSERVED FOR THE PAST SEVERAL MONTHS. *KB

NHTSA ODI #10413274

30,000 miles · Jul 15, 2011
Service Brakes, Hydraulic

BRAKES ON 2010 VOLKSWAGEN JETTA SPORTWAGON TDI WEARING UNEVENLY. 90 % FRONT BRAKE PAD LEFT AND 15% PAD LEFT ON THE REAR. VOLKSWAGEN SHOP REPORTS TO ME THIS HAPPENS ALL THE TIME AND IS NORMAL. VOLKSWAGEN SHOP MANAGER STATES IT IS DUE TO UNDERSIZED REAR BRAKE PAD CAUSING IT TO WEAR OUT QUICKLY. MANAGER ALSO AGREED THAT 8 OR 9 …

Read full complaint

BRAKES ON 2010 VOLKSWAGEN JETTA SPORTWAGON TDI WEARING UNEVENLY. 90 % FRONT BRAKE PAD LEFT AND 15% PAD LEFT ON THE REAR. VOLKSWAGEN SHOP REPORTS TO ME THIS HAPPENS ALL THE TIME AND IS NORMAL. VOLKSWAGEN SHOP MANAGER STATES IT IS DUE TO UNDERSIZED REAR BRAKE PAD CAUSING IT TO WEAR OUT QUICKLY. MANAGER ALSO AGREED THAT 8 OR 9 SETS OF REAR PADS TO ONE SET OF FRONT PADS IS ABOUT THE CORRECT RATIO. PREMATURE PAD WEAR OUT CAN CAUSE LOSS OF REAR WHEEL BREAKING RESULTING IN LOSS OF BREAKING AND MAY RESULT IN ACCIDENT DUE TO LONGER STOPPING DISTANCES. *TT

NHTSA ODI #10413086

200 miles · Jul 7, 2011
Unknown Or Other

VEHICLE STUMBLES USUALLY WITHIN THE FIRST COUPLE OF MILES OF TRAVEL AFTER STARTING THE VEHICLE. USUALLY OCCURS DURING MILD ACCELERATION AND AROUND 30-45 MPH. VEHICLE DOES THIS VERY OFTEN. I HAVE READ MUCH ABOUT THIS PROBLEM ON LINE AND HAVE BEEN WAITING TO HEAR ABOUT A FIX FOR THE PROBLEM. SOUNDS LIKE VW HAS STILL NOT OFFERE…

Read full complaint

VEHICLE STUMBLES USUALLY WITHIN THE FIRST COUPLE OF MILES OF TRAVEL AFTER STARTING THE VEHICLE. USUALLY OCCURS DURING MILD ACCELERATION AND AROUND 30-45 MPH. VEHICLE DOES THIS VERY OFTEN. I HAVE READ MUCH ABOUT THIS PROBLEM ON LINE AND HAVE BEEN WAITING TO HEAR ABOUT A FIX FOR THE PROBLEM. SOUNDS LIKE VW HAS STILL NOT OFFERED UP A SOLUTION TO THE PROBLEM AFTER MANY MONTHS SO I NOW WISH TO FILE THIS COMPLAINT. I HAD CONVERSATION WITH VW IN WHICH I WAS TOLD THAT THIS IS A DIESEL "PERSONALITY TRAIT". WELL I BELIEVE THIS PERSONALITY TRAIT MAY ALSO BE RESPONSIBLE FOR SEVERAL OCCASIONS OF STALLING OF THE VEHICLE WHEN TAKING OFF FROM A START. THE SO CALLED PERSONALITY TRAIT CAN OCCUR WHEN YOU ARE ENGAGING THE CLUTCH FROM A STANDING STILL POSITION. IF THIS HAPPENS IT CAUSES THE VEHICLE TO STALL. THIS IS NOT SAFE. IF TRUE HOWEVER I HAVE NO WAY TO PROVE IT. THE ONLY PROOF THAT IS REPEATABLE IS THE STUMBLING ISSUE.

NHTSA ODI #10411396

3,000 miles · Jul 6, 2011
Electrical SystemEngine And Engine Cooling

MY VW JETTA TDI STALLED WHILE COMING TO A STOP SIGN AFTER THE CLUTCH WAS DEPRESSED. IT DID THIS OCCASIONALLY DURING THE FIRST YEAR OF OWNERSHIP. AFTER A YEAR OF OWNERSHIP AND A DOZEN OR SO INCIDENTS, THE CAR STARTED TO STALL MULTIPLE TIMES DURING A ONE HALF-HOUR COMMUTE. TWICE RECENTLY, ONCE ON MY WAY TO WORK AND ONCE ON MY WAY…

Read full complaint

MY VW JETTA TDI STALLED WHILE COMING TO A STOP SIGN AFTER THE CLUTCH WAS DEPRESSED. IT DID THIS OCCASIONALLY DURING THE FIRST YEAR OF OWNERSHIP. AFTER A YEAR OF OWNERSHIP AND A DOZEN OR SO INCIDENTS, THE CAR STARTED TO STALL MULTIPLE TIMES DURING A ONE HALF-HOUR COMMUTE. TWICE RECENTLY, ONCE ON MY WAY TO WORK AND ONCE ON MY WAY BACK, THE CAR STALLED TWO AND THREE TIMES RESPECTIVELY. IT EVEN STALLED ON THE HIGHWAY GOING 65 MPH WHEN THE CLUTCH WAS DEPRESSED. USUALLY, IT STALLS WHEN COMING TO A RED LIGHT OR STOP SIGN WHEN THE CLUTCH IS DEPRESSED IN ORDER TO TAKE THE CAR OUT OF GEAR. AT 12000 MILES, THE ENGINE LIGHT CAME ON AND OFF A FEW TIMES AND THEN REMAINED ON. THE DIESEL PARTICULATE FILTER AND EGR VALVE WERE REPLACED WHICH IS HIGHLY UNUSUAL FOR A CAR WITH SUCH LOW MILEAGE. ALSO, AFTER MY 20000 MILE SERVICE THE ENGINE LIGHT WENT ON AGAIN AND THE DEALER REPLACED THE #4 EXHAUST GAS TEMPERATURE SENSOR. BEFORE THE 20K SERVICE I HAD CALLED THE DEALER THE DAY I STALLED 3 TIMES AND REPORTED MY ENGINE LIGHT WENT ON. I WENT TO THE DEALER A FEW DAYS LATER, THURSDAY, FOR THE SERVICE AND THE LIGHT HAD GONE OUT BY THEN. THE DEALER SAID THERE WAS A SOFTWARE UPDATE FOR THE ECM TO BE DONE IN ADDITION TO THE REGULAR SERVICE. I LEFT THE DEALER AFTER THE 20K SERVICE ONLY TO HAVE MY ENGINE LIGHT GO ON AGAIN AND THE CAR STALL AGAIN. SO I WENT BACK TO THE DEALER AND THAT IS WHEN THEY CHANGED THE #4 EXHAUST GAS TEMPERATURE SENSOR. IT DID NOT SOUND TO ME LIKE A PROPER FIX FOR THIS PROBLEM AS I BELIEVE IT COULD BE EITHER AN ELECTRONIC GLITCH WITH THE ECM OR OTHER ELECTRICAL COMPONENTS OR SOME FUEL SYSTEM PROBLEM WHEREBY FUEL FLOW IS INTERRUPTED WHEN GOING FROM LOAD TO NO LOAD SCENARIOS, I.E. CLUTCH ENGAGED. ANYHOW, I STALLED AGAIN TWO MILES FROM THE DEALER FROM WHICH I HAD DRIVEN. THE DEALER SAYS THEY CAN'T DUPLICATE IT OR FIND ANY CODES RELATED TO IT. THEY WILL CALL VW AGAIN.

NHTSA ODI #10411311

18,325 miles · Jun 29, 2011
Engine And Engine Cooling

MY 2010 VW JETTA TDI HAS HAD 5 EPISODES OF STALLING (ACTUALLY IT DOES NOT STALL IN THE NORMAL SENSE OF THE WORD, THE ENGINE JUST STOPS RUNNING). IN ALL 5 INCIDENTS THE CAR NEEDED TO BE PLACED IN PARK, THE IGNITION NEEDED TO BE TURNED OFF AND THEN THE CAR COULD BE RESTARTED AND RAN NORMALLY. IN 4 OF THE INCIDENTS IT WAS EITHER RA…

Read full complaint

MY 2010 VW JETTA TDI HAS HAD 5 EPISODES OF STALLING (ACTUALLY IT DOES NOT STALL IN THE NORMAL SENSE OF THE WORD, THE ENGINE JUST STOPS RUNNING). IN ALL 5 INCIDENTS THE CAR NEEDED TO BE PLACED IN PARK, THE IGNITION NEEDED TO BE TURNED OFF AND THEN THE CAR COULD BE RESTARTED AND RAN NORMALLY. IN 4 OF THE INCIDENTS IT WAS EITHER RAINING OR HAD JUST RECENTLY RAINED. THE 5TH INCIDENT HAD HIGH HUMIDITY. THE O2 SENSOR HAS BEEN UPDATED TWICE. THE FIRST TIME AS A RESPONSE TO THE PROBLEM, THE SECOND TIME AS PART OF NORMAL MAINTENANCE. *TR

NHTSA ODI #10409299

30 miles · Jun 26, 2011
Seats

HEADREST IS VERY UNCOMFORTABLE TO THE POINT WHERE I REVERSED IT WHICH MAKES IT VERY UNSAFE. IN THE NORMAL POSITION IT CAUSES SIGNIFICANT NECK PAIN. PLEASE CHANGE THE SAFETY LAWS TO THE OLD VERSION FOR HEADRESTS. MY 2000 VOLKSWAGEN JETTA HAD VERY COMFORTABLE HEADRESTS. *TR

NHTSA ODI #10408953

Official recalls

4

16V913000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Dec 20, 2016

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence & remedy

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional source detail variants (2)

Electronic Stability Control (esc)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

11V490000 · Fuel System, Diesel

Oct 3, 2011

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence & remedy

Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

10V621000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 10, 2010

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

Consequence & remedy

Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

09V333000 · Power Train:automatic Transmission

Aug 20, 2009

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.

Consequence & remedy

Consequence: THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: VOLKSWAGEN WILL REPROGRAM THE TRANSMISSION CONTROL MODULE WITH UPDATED SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA18003 · Air Bag Clockspring Failure

Opened Apr 18, 2018 · No close date supplied

Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Additional source detail variants (3)

Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags:frontal

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

PE11023 · Diesel Fuel Injector Line Leakage

Opened Aug 2, 2011 · Closed Dec 2, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.

EA11003 · High-Pressure Fuel Pump Failure

Opened Feb 7, 2011 · Closed Mar 27, 2015

Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Additional source detail variants (2)

Fuel System, Diesel

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

PE10034 · High Pressure Fuel Pump Failure (hpfp)

Opened Aug 26, 2010 · Closed Feb 8, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

The Office of Defects Investigation (ODI) and Volkswagen (VW) have received a total of 160 complaints and field reports alleging incidents of engine stall and/or loss of power that appear to be related to high pressure fuel pump (HPFP) failures in certain model year (MY) 2009 through 2010 Volkswagen Jetta and MY 2010 Volkswagen Golf and Audi A3 vehicles equipped with TDI clean diesel engines.Approximately half of the reports indicate that the failure resulted in an engine stall incident, with many of these alleging stall incidents at highway speeds in traffic with no restart.There has been one minor crash alleged to have resulted from HPFP failure in the subject vehicles.In response to ODI's information request for PE10-034, VW indicated that it had found no defect related to motor vehicle safety with relation to the TDI Clean Diesel fuel system at issue in this investigation and attributed problems with HPFP failure to operation with gasoline contaminated diesel fuel.Volkswagen stated that even a small amount of gasoline in the diesel fuel may disrupt the necessary lubrication required and may cause the HPFP to fail.In response to concerns that fuel contamination was the major cause of HPFP and related fuel system failures, VW issued a Technical Service Bulletin in May 2010 (VW TB V011011 2023624 and Audi TB A011008 2023360-1), with instructions to inspect the diesel fuel for vehicles requiring fuel system service that have symptoms associated with HPFP failure.The bulletin states that fuel system damage incurred by use of fuel not complying to ASTM-D-975 Grade 2 S15 (B5 or less biodiesel content) standards will not be covered under warranty. Volkswagen also provided information about 121 mis-fueling incidents reportedly acknowledged by consumers or dealers and test results for about 50 diesel fuel samples taken from complaint vehicles in late-August through early-October 2010.The mis-fueling incidents include about 20 reports involving incorrect fueling by dealer sales or service personnel and generally report symptoms such as rough running, stalling and/or no start within a few miles of refueling the vehicle with gasoline.Volkswagen indicated that the testing of fuel samples from complaint vehicles found that nearly 90 percent contained high amounts of gasoline.Volkswagen implemented design changes for the HPFP in May 2008, September 2009 and November 2010 to improve the robustness of the pump when used with poor quality fuel.ODI analysis of HPFP failures identified from all sources shows failure rates of 0.53% for MY 2009 vehicles and 0.11% for MY 2010 vehicles.This investigation has been upgraded to an Engineering Analysis (EA11-003) to continue to investigate the issues with mis-fueling and HPFP design identified during the Preliminary Evaluation.