← New search

2010 Volkswagen Jetta

Owner reports · Recalls · Investigations

More warning signs than most Jetta years

Owner complaints for the 2010 Volkswagen Jetta are substantially higher than the model-year median of 68.

About this comparison →

When problems were reported

Mileage at the reported incident

779 reports with mileage · 73 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Diesel. Review the 166 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports5 fire reports10 injury reports

What owners actually said

852 reports
94,000 miles · Jun 23, 2014
Electrical SystemEquipment Adaptive/mobility

I GOT IN TO MY CAR AFTER WORK ON SATURDAY I TURNED ON THE CAR AND NO RADIO. I CHECKED THE FUSES AND THEY WERE FINE. YES, THERE WASN'T ONE IN THE PLUG (18) BUT I PUT ONE IN THERE TO SEE IF THAT WOULD WORK FOR ME AND IT DID NOT. THEN MY WINDSHIELD WIPERS WERE NOT WORKING EITHER. I TURNED THE CAR OFF AND BACK ON AND THE WIPERS STAR…

Read full complaint

I GOT IN TO MY CAR AFTER WORK ON SATURDAY I TURNED ON THE CAR AND NO RADIO. I CHECKED THE FUSES AND THEY WERE FINE. YES, THERE WASN'T ONE IN THE PLUG (18) BUT I PUT ONE IN THERE TO SEE IF THAT WOULD WORK FOR ME AND IT DID NOT. THEN MY WINDSHIELD WIPERS WERE NOT WORKING EITHER. I TURNED THE CAR OFF AND BACK ON AND THE WIPERS STARTED WORKING. IT'S RAINY SEASON HERE. SO I HOPE THEY CONTINUE TO WORK. . THIS MORNING I CALLED THE DEALER AND THEY SAID THAT MY CAR WAS NOT COVERED UNDER THE EXTENDED WARRANTY FOR THE RADIO. MANY OTHER VW CUSTOMERS ARE HAVING THE SAME PROBLEM. HTTP://WWW.CARGURUS.COM/CARS/DISCUSSION-T36009_DS552583. *TR

NHTSA ODI #10605427

80,000 miles · Jun 23, 2014
Power Train

MY ENGINE STARTED TO RUN LOUDER THAN USUAL. WHEN I TOOK IT IN FOR A OIL CHANGE I ASKED IF THEY CAN TELL ME WHY MY CAR WAS RUNNING SO LOUD. WHEN THE OIL CHANGE WAS DONE THEY CAME AND TOLD ME THAT THE REASON WHY MY CAR WAS RUNNING LOUDER THAN NORMAL WAS I NEED TO REPLACE THE DUAL MASS FLYWHEEL. MY VOLKSWAGEN DEALER SAID THAT I DO…

Read full complaint

MY ENGINE STARTED TO RUN LOUDER THAN USUAL. WHEN I TOOK IT IN FOR A OIL CHANGE I ASKED IF THEY CAN TELL ME WHY MY CAR WAS RUNNING SO LOUD. WHEN THE OIL CHANGE WAS DONE THEY CAME AND TOLD ME THAT THE REASON WHY MY CAR WAS RUNNING LOUDER THAN NORMAL WAS I NEED TO REPLACE THE DUAL MASS FLYWHEEL. MY VOLKSWAGEN DEALER SAID THAT I DO NOT REPLACE IT RIGHT AWAY IT WILL END UP BREAKING AND RUINING MY WHOLE TRANSMISSION. *TR

NHTSA ODI #10605422

105,780 miles · Jun 21, 2014
Power Train

I HAVE A 2010 JETTA TDI WITH THE DSG TRANSMISSION. WHEN I WAS DRIVING YESTERDAY, I NOTICED THE "D" FLASHING AS I LOST POWER TO THE WHEELS. IT WAS ACTING AS IF IT WAS IN NEUTRAL. I TRIED TO SHIFT IT TO "N" AND BACK TO "D" WITH NO SUCCESS. I PULLED OFF THE ROAD, TURNED THE SWITCH OFF, WAITED FOR IT TO COMPLETELY POWER DOWN AND R…

Read full complaint

I HAVE A 2010 JETTA TDI WITH THE DSG TRANSMISSION. WHEN I WAS DRIVING YESTERDAY, I NOTICED THE "D" FLASHING AS I LOST POWER TO THE WHEELS. IT WAS ACTING AS IF IT WAS IN NEUTRAL. I TRIED TO SHIFT IT TO "N" AND BACK TO "D" WITH NO SUCCESS. I PULLED OFF THE ROAD, TURNED THE SWITCH OFF, WAITED FOR IT TO COMPLETELY POWER DOWN AND RESTARTED IT. IT WENT A COUPLE OF MINUTES DOWN THE ROAD AND THE "D" STARTED FLASHING AGAIN, THE TRANSMISSION DISENGAGED AGAIN (FALSE NEUTRAL). THIS CYCLE WENT ON SEVERAL TIMES BEFORE I WAS ABLE TO GET IT HOME. WHEN IT WAS FLASHING, IT WOULD FLASH IN ANY GEAR SELECTED (PRNDS) AND IT WAS CONTINUOUS UNTIL I TURNED THE KEY OFF. THERE WERE TIMES THAT I DIDN'T HAVE A SAFE PLACE TO PULL OFF THE ROAD. THIS IS A BIG SAFETY ISSUE, IT CAN CAUSE PEOPLE TO BE PUT IN A VERY DANGEROUS SITUATION. THIS ISSUE CAN HAPPEN AT ANY TIME AND CAUSE A FATAL WRECK. DURING THE FAILURE, THERE WAS NO POWER TO THE WHEELS AT ALL, IT FAILED TO GO INTO A LIMP MODE TO SAFELY MOVE THE VEHICLE. *TR

NHTSA ODI #10604930

69,000 miles · Jun 18, 2014
Electrical System

WHILE PICKING UP A FRIEND WITH CAR RUNNING. SWITCHED FROM CD TO RADIO. RADIO UNIT WENT COMPLETELY INOP. NO BACKLIGHT TO BUTTONS NO CLOCK NO NOTHING COMPLETELY DARK. ALONG WITH AUDIBLE SPEAKER POPPING NOISE. EVEN WHEN CAR SHUT OFF AND KEY PULLED FROM IGNITION AND DOORS LOCKED STILL MAKES AUDIBLE POPPING NOISE. HAD TO DISCONNECT B…

Read full complaint

WHILE PICKING UP A FRIEND WITH CAR RUNNING. SWITCHED FROM CD TO RADIO. RADIO UNIT WENT COMPLETELY INOP. NO BACKLIGHT TO BUTTONS NO CLOCK NO NOTHING COMPLETELY DARK. ALONG WITH AUDIBLE SPEAKER POPPING NOISE. EVEN WHEN CAR SHUT OFF AND KEY PULLED FROM IGNITION AND DOORS LOCKED STILL MAKES AUDIBLE POPPING NOISE. HAD TO DISCONNECT BATTERY TO GET NOISE TO STOP. LOOKED AROUND ONLINE AND SEEN THAT THIS IS A CHRONIC PROBLEM WITH THIS HEAD UNIT. I HAVE YET TO CHECK FOR C/B'S OR FUSES LOCATED INSIDE THE CABIN. PLEASE HELP. CONTACT INFO 3012541365. VW 2010 JETTA WOLFBURG MANUAL. *TR

NHTSA ODI #10604415

64,650 miles · Jun 17, 2014
EngineFuel System, Diesel

2010 VW JETTA SPORTWAGEN TDI. CAR LOST POWER AT HIGHWAY SPEEDS. "GLOW PLUG" INDICATOR ILLUMINATED AND HUD DISPLAYED "SERVICE IMMEDIATELY." WAS ABLE TO SAFELY PULL OVER TO SHOULDER. CAR WOULD NOT RESTART. HAD TO BE TOWED TO NEARBY DEALERSHIP. INFORMED TODAY THAT HIGH PRESSURE FUEL PUMP (HPFP) HAD FAILED AND WOULD BE COVERED UNDER…

Read full complaint

2010 VW JETTA SPORTWAGEN TDI. CAR LOST POWER AT HIGHWAY SPEEDS. "GLOW PLUG" INDICATOR ILLUMINATED AND HUD DISPLAYED "SERVICE IMMEDIATELY." WAS ABLE TO SAFELY PULL OVER TO SHOULDER. CAR WOULD NOT RESTART. HAD TO BE TOWED TO NEARBY DEALERSHIP. INFORMED TODAY THAT HIGH PRESSURE FUEL PUMP (HPFP) HAD FAILED AND WOULD BE COVERED UNDER EXTENDED WARRANTY. WILL BE WITHOUT CAR FOR 5-10 DAYS. CAR IS LOCATED 1 HOUR AWAY FROM HOME. RENTAL CAR WAS OFFERED, BUT I WOULD HAVE TO GET OUT TO DEALERSHIP TO PICKUP. THIS IS THE SECOND OCCURRENCE OF HPFP FAILURE ON VEHICLE. SIMILAR OCCURRENCE (LOSS OF POWER ON HIGHWAY) HAPPENED ON MARCH 24, 2011. AGAIN, CAR WAS STUCK IN DEALERSHIP FAR FROM HOME. *TR

NHTSA ODI #10599003

62,000 miles · Jun 16, 2014
Seat Belts

REAR SEAT BELT, BEHIND DRIVER, NOT WORKING. STUCK IN LOCKED POSITION. THIS SEATBELT IS USED BY A 5 YEAR OLD CHILD ON A DAILY BASIS. OTHER SIDE IS USED BY HIS 8 YEAR OLD BROTHER. SEATBELT WILL NOT PULL OUT. I TOOK IT TO VW DEALER AND THEY WANT $613 TO REPAIR IT. THEY SAID A NEW ONE IS REQUIRED AND THAT THE SEATBELT MECHANIS…

Read full complaint

REAR SEAT BELT, BEHIND DRIVER, NOT WORKING. STUCK IN LOCKED POSITION. THIS SEATBELT IS USED BY A 5 YEAR OLD CHILD ON A DAILY BASIS. OTHER SIDE IS USED BY HIS 8 YEAR OLD BROTHER. SEATBELT WILL NOT PULL OUT. I TOOK IT TO VW DEALER AND THEY WANT $613 TO REPAIR IT. THEY SAID A NEW ONE IS REQUIRED AND THAT THE SEATBELT MECHANISM IS WITHIN A STEEL CASE THAT HAS EXPLOSIVES IN IT. I WAS SHOCKED TO HEAR THIS AND AM STUCK WITHOUT A CAR BECAUSE I CANNOT DRIVE WITH MY CHILDREN. I HAVE PRICED THE SEATBELT OUT AT AUTO BODYSHOPS AND THE PRICE IS AROUND $425. STILL NOT MONEY I HAD READILY AVAILABLE TO DISH OUT. AFTER LOOKING INTO IT I FOUND THAT THIS IS A COMMON OCCURRENCE WITH THIS MAKE AND YEAR OF VW JETTA. SOMETHING NEEDS TO BE DONE ABOUT THIS, IT IS A LIFE SAFETY ISSUE!! *TR

NHTSA ODI #10598572

76,000 miles · Jun 16, 2014
Engine

ON 6/7/14 AT SPEED AND IN TRAFFIC CAR SUDDENLY DIED, GLOW PLUG INDICATOR FLASHED AND SERVICE ENGINE IMMEDIATELY MESSAGE APPEARED ON THE DASH. CAR RESTARTED RIGHT AWAY AND WAS ABLE TO FINISH TRIP WITHOUT FURTHER INCIDENT, TOOK TO DEALER SERVICE CENTER AND THEY REPLACED GLOW PLUG AND WIRING HARNESS. ON 6/10/14 ALSO AT SPEED AND …

Read full complaint

ON 6/7/14 AT SPEED AND IN TRAFFIC CAR SUDDENLY DIED, GLOW PLUG INDICATOR FLASHED AND SERVICE ENGINE IMMEDIATELY MESSAGE APPEARED ON THE DASH. CAR RESTARTED RIGHT AWAY AND WAS ABLE TO FINISH TRIP WITHOUT FURTHER INCIDENT, TOOK TO DEALER SERVICE CENTER AND THEY REPLACED GLOW PLUG AND WIRING HARNESS. ON 6/10/14 ALSO AT SPEED AND IN TRAFFIC CAR SUDDENLY DIED ONCE AGAIN, GLOW PLUG INDICATOR FLASHED, NO MESSAGE AND NO CHECK ENGINE LIGHT. ONCE WE CAME TO A COMPLETE STOP, THE CAR RESTARTED AND WE FINISH TRIP WITHOUT FURTHER INCIDENT. I HAVE SCHEDULED ANOTHER APPOINTMENT WITH VW SERVICE DEPARTMENT. *TR

NHTSA ODI #10598570

88,112 miles · Jun 13, 2014
Fuel/propulsion System

UPON CHANGING THE FUEL FILTER, THE MECHANIC NOTED THAT THERE WERE VISIBLE METAL PARTICLES IN THE FILTER HOUSING. THIS IS THE SECOND FUEL FILTER CHANGE TO SHOW METAL FILINGS. TWO DIFFERENT CERTIFIED MECHANICS NOTED THAT THIS IS A SYMPTOM OF HIGH PRESSURE FUEL PUMP FAILURE AND IF THE FUEL PUMP FAILS AT HIGH SPEED IT COULD BE A SAF…

Read full complaint

UPON CHANGING THE FUEL FILTER, THE MECHANIC NOTED THAT THERE WERE VISIBLE METAL PARTICLES IN THE FILTER HOUSING. THIS IS THE SECOND FUEL FILTER CHANGE TO SHOW METAL FILINGS. TWO DIFFERENT CERTIFIED MECHANICS NOTED THAT THIS IS A SYMPTOM OF HIGH PRESSURE FUEL PUMP FAILURE AND IF THE FUEL PUMP FAILS AT HIGH SPEED IT COULD BE A SAFETY HAZARD. VOLKSWAGEN REFUSES TO PROACTIVELY REPLACE THE FAILING FUEL PUMP. *JS

NHTSA ODI #10598190

50,000 miles · Jun 11, 2014
Power Train

DSG TRANSMISSION DROPPED OUT OF GEAR (LIKE IN NEUTRAL) SEVERAL TIMES OVER PERIOD OF 1 WEEK. SPEEDS ~20MPH AND 65 MPH. REQUIRED DRIFTING TO SAFE AREA, STOPPING, AND RESTARTING CAR TO GET TRANSMISSION TO WORK. DURING FAILURE THE EP WAS ILLUMINATED, SHIFTING BETWEEN GEARS DID NOTHING. VW DEALER REPROGRAMMED TRANNY BETWEEN FAI…

Read full complaint

DSG TRANSMISSION DROPPED OUT OF GEAR (LIKE IN NEUTRAL) SEVERAL TIMES OVER PERIOD OF 1 WEEK. SPEEDS ~20MPH AND 65 MPH. REQUIRED DRIFTING TO SAFE AREA, STOPPING, AND RESTARTING CAR TO GET TRANSMISSION TO WORK. DURING FAILURE THE EP WAS ILLUMINATED, SHIFTING BETWEEN GEARS DID NOTHING. VW DEALER REPROGRAMMED TRANNY BETWEEN FAILURES. HAVE BEEN USING THE SHIFT MODE FOR ~ 1WEEK WITHOUT ISSUE. SAW SEVERAL YOUTUBE VIDEOS OF SAME PROBLEM - "FALSE NEUTRAL". NUMEROUS POSTS ON TDICLUB. *TR

NHTSA ODI #10597787

56,309 miles · Jun 7, 2014
Fuel System, Diesel

MY 2010 JETTA SPORTSWAGEN TDI DIESEL STALLED WHILE MOVING FROM A DRIVEWAY ONTO A RESIDENTIAL STREET. THERE WAS NO WARNING OF IMMINENT DISABLEMENT EXCEPT FOR A 5 SECONDS OF ENGINE "SPUTTER". THE WEATHER WAS WARM AND DRY, AND THE BATTERY HAD JUST BEEN REPLACED. THE VEHICLE WAS TRUCKED TO THE VW DEALERSHIP IN CERRITOS CA. THE SERVI…

Read full complaint

MY 2010 JETTA SPORTSWAGEN TDI DIESEL STALLED WHILE MOVING FROM A DRIVEWAY ONTO A RESIDENTIAL STREET. THERE WAS NO WARNING OF IMMINENT DISABLEMENT EXCEPT FOR A 5 SECONDS OF ENGINE "SPUTTER". THE WEATHER WAS WARM AND DRY, AND THE BATTERY HAD JUST BEEN REPLACED. THE VEHICLE WAS TRUCKED TO THE VW DEALERSHIP IN CERRITOS CA. THE SERVICE MANAGER SEEMED TO SENSE THE NATURE OF THE PROBLEM, AND THE CAR WAS INSPECTED BY A VWOA REPRESENTATIVE ON THE FOLLOWING BUSINESS DAY. METAL CONTAMINATION WAS FOUND IN THE FUEL SYSTEM. THE FUEL SYSTEM WAS REPLACED, INCLUDING THE FUEL PUMP, AFTER ONE EXTRA DAY OF WAITING FOR THE DELIVERY OF THE NECESSARY PARTS. ALTHOUGH THE VEHICLE WAS OUT OF WARRANTY, VWOA APPROVED THE REPAIR AT THEIR EXPENSE. I FEEL THAT THIS TYPE OF ABRUPT ENGINE FAILURE IS A SERIOUS SAFETY ISSUE THAT COULD HAVE CAUSED A CRASH IF IT OCCURRED ON A MORE HEAVILY TRAVELED ROADWAY. *TR

NHTSA ODI #10596790

Official recalls

4

16V913000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Dec 20, 2016

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence & remedy

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional source detail variants (2)

Electronic Stability Control (esc)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

11V490000 · Fuel System, Diesel

Oct 3, 2011

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence & remedy

Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

10V621000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 10, 2010

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

Consequence & remedy

Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

09V333000 · Power Train:automatic Transmission

Aug 20, 2009

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.

Consequence & remedy

Consequence: THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: VOLKSWAGEN WILL REPROGRAM THE TRANSMISSION CONTROL MODULE WITH UPDATED SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA18003 · Air Bag Clockspring Failure

Opened Apr 18, 2018 · No close date supplied

Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Additional source detail variants (3)

Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags:frontal

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

PE11023 · Diesel Fuel Injector Line Leakage

Opened Aug 2, 2011 · Closed Dec 2, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.

EA11003 · High-Pressure Fuel Pump Failure

Opened Feb 7, 2011 · Closed Mar 27, 2015

Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Additional source detail variants (2)

Fuel System, Diesel

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

PE10034 · High Pressure Fuel Pump Failure (hpfp)

Opened Aug 26, 2010 · Closed Feb 8, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

The Office of Defects Investigation (ODI) and Volkswagen (VW) have received a total of 160 complaints and field reports alleging incidents of engine stall and/or loss of power that appear to be related to high pressure fuel pump (HPFP) failures in certain model year (MY) 2009 through 2010 Volkswagen Jetta and MY 2010 Volkswagen Golf and Audi A3 vehicles equipped with TDI clean diesel engines.Approximately half of the reports indicate that the failure resulted in an engine stall incident, with many of these alleging stall incidents at highway speeds in traffic with no restart.There has been one minor crash alleged to have resulted from HPFP failure in the subject vehicles.In response to ODI's information request for PE10-034, VW indicated that it had found no defect related to motor vehicle safety with relation to the TDI Clean Diesel fuel system at issue in this investigation and attributed problems with HPFP failure to operation with gasoline contaminated diesel fuel.Volkswagen stated that even a small amount of gasoline in the diesel fuel may disrupt the necessary lubrication required and may cause the HPFP to fail.In response to concerns that fuel contamination was the major cause of HPFP and related fuel system failures, VW issued a Technical Service Bulletin in May 2010 (VW TB V011011 2023624 and Audi TB A011008 2023360-1), with instructions to inspect the diesel fuel for vehicles requiring fuel system service that have symptoms associated with HPFP failure.The bulletin states that fuel system damage incurred by use of fuel not complying to ASTM-D-975 Grade 2 S15 (B5 or less biodiesel content) standards will not be covered under warranty. Volkswagen also provided information about 121 mis-fueling incidents reportedly acknowledged by consumers or dealers and test results for about 50 diesel fuel samples taken from complaint vehicles in late-August through early-October 2010.The mis-fueling incidents include about 20 reports involving incorrect fueling by dealer sales or service personnel and generally report symptoms such as rough running, stalling and/or no start within a few miles of refueling the vehicle with gasoline.Volkswagen indicated that the testing of fuel samples from complaint vehicles found that nearly 90 percent contained high amounts of gasoline.Volkswagen implemented design changes for the HPFP in May 2008, September 2009 and November 2010 to improve the robustness of the pump when used with poor quality fuel.ODI analysis of HPFP failures identified from all sources shows failure rates of 0.53% for MY 2009 vehicles and 0.11% for MY 2010 vehicles.This investigation has been upgraded to an Engineering Analysis (EA11-003) to continue to investigate the issues with mis-fueling and HPFP design identified during the Preliminary Evaluation.