← New search

2010 Volkswagen Jetta

Owner reports · Recalls · Investigations

More warning signs than most Jetta years

Owner complaints for the 2010 Volkswagen Jetta are substantially higher than the model-year median of 68.

About this comparison →

When problems were reported

Mileage at the reported incident

779 reports with mileage · 73 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Diesel. Review the 166 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports5 fire reports10 injury reports

Power Train complaints

111 reports
Clear category filter
14,000 miles · Dec 1, 2011
Power Train

WHEN SITTING ON A UPHILL INCLINE PREPARING TO MERGE INTO TRAFFIC I PRESSED ON THE ACCELERATOR AND STARTED ROLLING BACKWARDS. THE TRANSMISSION FINALLY TOOK HOLD AFTER THE PEDAL WAS PRESSED A NUMBER OF TIMES TO THE FLOOR. THIS IS A SAFETY ISSUE! I HAVE READ ONLINE FORUMS AND NUMEROUS COMPLAINTS HAVE BEEN FILED. THE TRANSMISSION H…

Read full complaint

WHEN SITTING ON A UPHILL INCLINE PREPARING TO MERGE INTO TRAFFIC I PRESSED ON THE ACCELERATOR AND STARTED ROLLING BACKWARDS. THE TRANSMISSION FINALLY TOOK HOLD AFTER THE PEDAL WAS PRESSED A NUMBER OF TIMES TO THE FLOOR. THIS IS A SAFETY ISSUE! I HAVE READ ONLINE FORUMS AND NUMEROUS COMPLAINTS HAVE BEEN FILED. THE TRANSMISSION HAS A STALLING PROBLEM. I BOUGHT THE AUTO NEW. AS OF MY KNOWLEDGE NOW THERE IS NO RECALL,HOWEVER THIS IS A SERIOUS DEFECT!!! *TR

NHTSA ODI #10437934

35,650 miles · Nov 11, 2011
Engine And Engine CoolingFuel System, GasolinePower Train

2010 VW JETTA TDI WITH ROUGHLY 35,650 MILES. WHILE DRIVING UP THE ON-RAMP TO ENTER THE INTERSTATE, GLOW PLUG DASH LIGHT CAME ON AND WARNED TO "CHECK ENGINE NOW." WITHIN 20 SECONDS, THE CAR LOST ALL POWER, AND LUCKILY I WAS ABLE TO COAST OVER TO THE SHOULDER OF THE INTERSTATE (WITH DRIVERS FLYING BY AT 65+MPH AT 9:45PM). VEHICLE …

Read full complaint

2010 VW JETTA TDI WITH ROUGHLY 35,650 MILES. WHILE DRIVING UP THE ON-RAMP TO ENTER THE INTERSTATE, GLOW PLUG DASH LIGHT CAME ON AND WARNED TO "CHECK ENGINE NOW." WITHIN 20 SECONDS, THE CAR LOST ALL POWER, AND LUCKILY I WAS ABLE TO COAST OVER TO THE SHOULDER OF THE INTERSTATE (WITH DRIVERS FLYING BY AT 65+MPH AT 9:45PM). VEHICLE WOULD NOT RESTART AND HAD TO BE TOWED TO THE VW DEALERSHIP. SERVICE REP CLAIMED "FUEL CONTAMINATION," WITH METAL SHARDS ALL THROUGHOUT THE FUEL SYSTEM. ENTIRE FUEL SYSTEM HAS TO BE REPLACED ($10,000 REPAIR) WITH EQUIVALENT, NEW PARTS. ACCORDING TO VW SERVICE TECHNICIANS, THE PARTS HAVE NOT BEEN UPDATED DESPITE VW'S KNOWLEDGE OF THIS PROBLEM. AS A RESULT, "FUEL CONTAMINATION" COULD HAPPEN AGAIN, AND THE CAR COULD SHUT OFF WHILE DRIVING AT ANY TIME WITHOUT NOTICE. THIS IS A VERY SERIOUS SAFETY CONCERN. LUCKILY, BECAUSE I WAS DRIVING AT NIGHT, THERE WAS NOT A LOT OF CONGESTION ON THE ROAD. HAD THIS HAPPENED DURING RUSH HOUR, THERE VERY LIKELY WOULD HAVE BEEN A SEVERE ACCIDENT. VW CLAIMS THE PROBLEM IS A RESULT OF THE POOR QUALITY OF AMERICAN DIESEL FUEL SUPPLY, SAYING THE TDIS ARE DESIGNED IN GERMANY TO RUN ON 100% DIESEL THAT'S FOUND IN EUROPE. IF THIS IS THE CASE, WHY ARE THEY SELLING GERMAN DESIGNED CARS IN THE UNITED STATES THAT DOESN'T HAVE FUEL SUPPLIES THAT ARE 100% DIESEL? VOLKSWAGEN NEEDS TO ISSUE A RECALL OF THE 2009/2010 JETTA TDI. *TR

NHTSA ODI #10435310

Mileage unknown · Nov 4, 2011
Power Train

WHEN ACCELERATING FROM A QUICK STOP THE CAR SOMETIMES EXPERIENCES A DELAYED RESPONSE. THE CAR WILL BEGIN TO ACCELERATE AT A CRAWL (AS IF I ONLY LET OFF THE BRAKE) EVEN THOUGH THE PEDAL IS PUSHED TO APPROXIMATELY 20% THEN WILL SUDDENLY ACCELERATE AS IF I PUSHED THE PEDAL TO 80% SOMETIMES CAUSING THE TIRES TO SLIP. THIS UNEXPECTED…

Read full complaint

WHEN ACCELERATING FROM A QUICK STOP THE CAR SOMETIMES EXPERIENCES A DELAYED RESPONSE. THE CAR WILL BEGIN TO ACCELERATE AT A CRAWL (AS IF I ONLY LET OFF THE BRAKE) EVEN THOUGH THE PEDAL IS PUSHED TO APPROXIMATELY 20% THEN WILL SUDDENLY ACCELERATE AS IF I PUSHED THE PEDAL TO 80% SOMETIMES CAUSING THE TIRES TO SLIP. THIS UNEXPECTED/UNDESIRED RESPONSE MAKES THE CAR APPEAR TO OTHER DRIVERS AS IF IT IS NOT PROCEEDING THROUGH THE INTERSECTION WHICH LEADS THEM TO START TO PROCEED AND THEN IT QUICKLY ACCELERATES. TO TRY AND PREVENT THIS I AM FORCED TO PUSH THE ACCELERATOR PEDAL TO 20% OR SO AND THEN QUICKLY REDUCE IT TO 5%. ADDITIONALLY WHEN SLIGHTLY LETTING OFF THE ACCELERATOR (LESS THAN A 5% CHANGE IN ACCELERATOR POSITION) WHILE DRIVING AT HIGHWAY SPEEDS THE CAR WILL SUDDENLY LOSE POWER AS IF IT WAS SHIFTED INTO NEUTRAL THEN WILL RESUME NORMAL OPERATION. THIS REDUCTION IN POWER LAST FOR LESS THAN A SECOND AND AS THE CAR IS WELL INTO ITS TOP GEAR AND IS NOT ASKED TO QUICKLY ACCELERATE DOES NOT MAKE SENSE. *TR

NHTSA ODI #10434182

15,000 miles · Aug 8, 2011
Power Train

I HAVE A 2010 VW JETTA TDI WITH DSG AUTOMATIC TRANSMISSION. VEHICLE HAS 15K MILES ON IT THUS FAR. WHEN PULLING OUT ONTO A STREET FROM A COMPLETE STOP THERE IS A DEFINITE AND HAZARDOUS HESITATION BEFORE THE VEHICLE WILL MOVE FORWARD. THIS ISSUE EXISTED SINCE THE CAR WAS NEW. SOMETIMES THE HESITATION IS VERY SHORT BEFORE THE CA…

Read full complaint

I HAVE A 2010 VW JETTA TDI WITH DSG AUTOMATIC TRANSMISSION. VEHICLE HAS 15K MILES ON IT THUS FAR. WHEN PULLING OUT ONTO A STREET FROM A COMPLETE STOP THERE IS A DEFINITE AND HAZARDOUS HESITATION BEFORE THE VEHICLE WILL MOVE FORWARD. THIS ISSUE EXISTED SINCE THE CAR WAS NEW. SOMETIMES THE HESITATION IS VERY SHORT BEFORE THE CAR WILL MOVE, OTHER TIMES IT TAKES THE CAR A MOMENT AS IF THE CAR HAS TO "THINK" ABOUT WHAT IT IS SUPPOSED TO DO. WHEN I PUSH THE ACCELERATOR PEDAL THE CAR JUST SITS THERE! THE LONGER HESITATIONS ARE FAIRLY FREQUENT AND ARE A DANGER TO OTHER VEHICLES, MY FAMILY AND MYSELF. I DON'T TRUST THIS CAR TO BE ABLE TO QUICKLY MOVE OUT OF HARM'S WAY IN AN EMERGENCY AND ALSO DON'T TRUST IT TO PULL ONTO A STREET IN FRONT OF ANY OTHER VEHICLE NO MATTER HOW FAR AWAY THE OTHER VEHICLE IS DOWN THE ROAD. IT'S JUST NOT SAFE TO DO SO! VW SHOULD BE FORCED TO ADDRESS THIS PROBLEM AND PROVIDE A FIX FOR THIS COMMON ISSUE AND COMPLAINT THAT CAN BE READ ABOUT ON VARIOUS VW FORUMS ALL OVER THE INTERNET. NO INJURIES YET FROM THIS ISSUE WITH MY VEHICLE BECAUSE I KNOW BETTER THAN TO TRY TO PULL OUT INTO ONCOMING TRAFFIC. *TR

NHTSA ODI #10417994

Mileage unknown · Jul 26, 2011
Power Train

2010 VOLKSWAGEN JETTA. CONSUMER STATES KNOCKING NOISE BY GEARBOX WHILE DRIVING *TGW THE CONSUMER WAS INFORMED THE CLUTCHING SYSTEM NEEDED TO BE REPLACED. THE CONSUMER STATED HE HAD TO WAIT TWO MONTHS FOR THE PART. THE CONSUMER STATED THREE TO FOUR DAYS LATER, AFTER THE VEHICLE WAS FIXED, THE NOISE RESURFACED. THE PART WAS REPLA…

Read full complaint

2010 VOLKSWAGEN JETTA. CONSUMER STATES KNOCKING NOISE BY GEARBOX WHILE DRIVING *TGW THE CONSUMER WAS INFORMED THE CLUTCHING SYSTEM NEEDED TO BE REPLACED. THE CONSUMER STATED HE HAD TO WAIT TWO MONTHS FOR THE PART. THE CONSUMER STATED THREE TO FOUR DAYS LATER, AFTER THE VEHICLE WAS FIXED, THE NOISE RESURFACED. THE PART WAS REPLACED AGAIN AND THE SAME NOISE RETURNED.

NHTSA ODI #10415857

33,000 miles · Jul 22, 2011
Power Train

MY 2010 VW JETTA SPORTS WAGON WITH THE DSG AUTOMATIC IS CURRENTLY HAVING A SEVERE HESITATION WHEN STARTING FROM A STOP. I LET OFF THE BREAK AND STEP ON THE GAS AND IT DOES NOT MOVE FOR A SECOND THEN LURCHES FORWARD. THIS IS DANGEROUS WHEN PULLING OUT IN TRAFFIC. IT SEEMS AS THE CAR DRIVES LONGER IT GET WORSE. THE CAR HAS STALLED…

Read full complaint

MY 2010 VW JETTA SPORTS WAGON WITH THE DSG AUTOMATIC IS CURRENTLY HAVING A SEVERE HESITATION WHEN STARTING FROM A STOP. I LET OFF THE BREAK AND STEP ON THE GAS AND IT DOES NOT MOVE FOR A SECOND THEN LURCHES FORWARD. THIS IS DANGEROUS WHEN PULLING OUT IN TRAFFIC. IT SEEMS AS THE CAR DRIVES LONGER IT GET WORSE. THE CAR HAS STALLED DURING THIS HESITATION AS WELL. WHEN IT STALLS YOU HAVE TO PUT THE CAR IN PARK THEN TURN THE KEY OFF AND RESTART THE CAR. THIS IS A VERY UNEASY FEELING WHILE AT AN INTERSECTION. THE CAR ALSO LURCHES FORWARD WHEN COMING TO A COMPLETE STOP, THIS HAS ALMOST MADE ME HIT A CAR IN FRONT OF ME. THIS IS A DAILY ISSUE. *TT

NHTSA ODI #10414641

8,004 miles · Jun 18, 2011
Power Train

CAR NEARLY STALLS, AND THEN WHEN STEPPING ON THE GAS, THE RPM RISES REALLY HIGH TO 4000 RPM, THEN THE GEAR SHIFTS INTO 1ST CAUSING THE CAR TO DANGEROUSLY LURCH FORWARD. THIS CAN CAUSE A COLLISION. IT ALSO HAS A VERY NOTICEABLE DELAY TO SHIFT OUT OF NEUTRAL TO 1ST GEAR, SO WHEN MAKING A LEFT TURN AT AN INTERSECTION, THIS CAN BE…

Read full complaint

CAR NEARLY STALLS, AND THEN WHEN STEPPING ON THE GAS, THE RPM RISES REALLY HIGH TO 4000 RPM, THEN THE GEAR SHIFTS INTO 1ST CAUSING THE CAR TO DANGEROUSLY LURCH FORWARD. THIS CAN CAUSE A COLLISION. IT ALSO HAS A VERY NOTICEABLE DELAY TO SHIFT OUT OF NEUTRAL TO 1ST GEAR, SO WHEN MAKING A LEFT TURN AT AN INTERSECTION, THIS CAN BE DANGEROUS AS WELL. THE CAR HAS BEEN IN THE SHOP TWICE FOR THE SAME PROBLEMS. THIS WILL BE THE THIRD ATTEMPT TO FIX THE PROBLEM. *TR

NHTSA ODI #10407343

7,000 miles · May 13, 2011
Power Train

THE MECHATRONIC UNIT ON THE DSG FAILED CAUSING THE TRANSMISSION TO LURCH FORWARD WHEN IN 1ST GEAR, AND REMAINING IN NEUTRAL FOR AN EXTENDED PERIOD WHICH IS NOT NORMAL. THIS IS A SAFETY ISSUE AS IT CAN CAUSE AN ACCIDENT IN THE FAILURE TO CLEAR AN INTERSECTION ESPECIALLY MAKING A LEFT TURN, AND POTENTIALLY CAUSE REAR ENDING A…

Read full complaint

THE MECHATRONIC UNIT ON THE DSG FAILED CAUSING THE TRANSMISSION TO LURCH FORWARD WHEN IN 1ST GEAR, AND REMAINING IN NEUTRAL FOR AN EXTENDED PERIOD WHICH IS NOT NORMAL. THIS IS A SAFETY ISSUE AS IT CAN CAUSE AN ACCIDENT IN THE FAILURE TO CLEAR AN INTERSECTION ESPECIALLY MAKING A LEFT TURN, AND POTENTIALLY CAUSE REAR ENDING ANOTHER VEHICLE AND OR CAUSING UNEXPECTED ACCELERATION. RIGHT NOW, THE VEHICLE IS IN THE SHOP WAITING FOR A WHOLE NEW MECHATRONIC UNIT TO BE REPLACED. CURRENTLY WAITING ON ORDER. THE VEHICLE IS COVERED UNDER WARRANTY AS IT ONLY HAS 7K MILES ON IT. *TR

NHTSA ODI #10400818

Mileage unknown · May 10, 2011
Engine And Engine CoolingPower Train

I PURCHASED MY 2010 JETTA TDI NEW AT THE END OF SEPTEMBER 2009. IT IS A MANUAL TRANSMISSION. I'M A PRETTY CONSERVATIVE DRIVER AND ATTEMPT TO MAXIMIZE MY MPG. EACH DAY AFTER THE VEHICLE HAS BEEN SETTING OVERNIGHT AND IS COLD, I START UP AND DRIVE TO THE STORE, A 4 MILE DRIVE, THE ENGINE WILL PAUSE USUALLY WITHIN THAT 4 MILE DR…

Read full complaint

I PURCHASED MY 2010 JETTA TDI NEW AT THE END OF SEPTEMBER 2009. IT IS A MANUAL TRANSMISSION. I'M A PRETTY CONSERVATIVE DRIVER AND ATTEMPT TO MAXIMIZE MY MPG. EACH DAY AFTER THE VEHICLE HAS BEEN SETTING OVERNIGHT AND IS COLD, I START UP AND DRIVE TO THE STORE, A 4 MILE DRIVE, THE ENGINE WILL PAUSE USUALLY WITHIN THAT 4 MILE DRIVE. SOMETIMES IT IS A SHORT JERK AND SOMETIMES IT IS A GREATER JERK. OTHER TIMES IT WILL HAPPEN ON THE RETURN TRIP HOME. BUT IT'LL HAPPEN ONLY ONCE UNTIL IT SETS AND COOLS OFF. I HAVE HAD IT IN THE SHOP TWICE WITH NO HELP. MY RESEARCH FINDS SOME PROBLEMS WITH THE HIGH PRESSURE FUEL PUMP WHICH MAY BE THE ISSUE, BUT I HAVEN'T BEEN ABLE TO TALK TO VW AMERICA TO SEE IF THEY WILL CONFIRM OR DENY THIS. THIS PROBLEM HAS HAPPENED SINCE I'VE HAD THE VEHICLE. IT HAS 6,500 MILES ON IT AND I'M HOPING TO GET IT FIXED BEFORE THE WARRANTY EXPIRES. NOT SURE WHAT WILL HAPPEN WHEN THE MILEAGE GETS HIGHER.

NHTSA ODI #10400490

10,500 miles · Mar 1, 2011
Electrical SystemEngine And Engine CoolingPower TrainCrash

I PURCHASED A 6-SPEED MANUAL TRANSMISSION JETTA-TDI AT THE END OF DECEMBER OF 2009. I HAVE BEEN DRIVING MANUAL TRANSMISSION CARS SINCE 1975, AND I WAS UPSET THAT MY CAR WAS STALLING EITHER JUST STARTING OUT IN FIRST OR IN THE LOWER RPM RANGE OF THE LOWER GEARS WHEN TURNING AND MOVING THROUGH INTERSECTIONS OR TRYING TO GO UPHI…

Read full complaint

I PURCHASED A 6-SPEED MANUAL TRANSMISSION JETTA-TDI AT THE END OF DECEMBER OF 2009. I HAVE BEEN DRIVING MANUAL TRANSMISSION CARS SINCE 1975, AND I WAS UPSET THAT MY CAR WAS STALLING EITHER JUST STARTING OUT IN FIRST OR IN THE LOWER RPM RANGE OF THE LOWER GEARS WHEN TURNING AND MOVING THROUGH INTERSECTIONS OR TRYING TO GO UPHILL WHEN THE RPMS WERE IN THE LOWER RANGE. KEEPING THE RPMS UP A BIT SEEMS TO HAVE HELPED, AS I AM NOT HAVING IT STALL AS MUCH AS BEFORE. I ALSO NOTICED WHAT SEEMED LIKE A SLIGHT HESITATION OR JERKING WHEN CRUISING . IT WOULD BE JUST FOR A SPLIT SECOND AND THEN BE GONE MY ACCIDENT OCCURRED WHEN I WAS PARALLEL PARKING ON A HILL. I WENT TO BACK UP A BIT TO STRAIGHTEN OUT MY CAR AND IT STALLED, ROLLING FORWARD INTO THE CAR PARKED IN FRONT OF ME. FORTUNATELY, NO ONE WAS INJURED. DAMAGE WAS MINOR, BUT WAS SUBMITTED TO MY INSURANCE COMPANY. AT THIS POINT I WAS JUST BLAMING MYSELF FOR NOT BEING ABLE TO ADJUST TO THE DIFFERENCE OF CLUTCHING WITH A DIESEL ENGINE BECAUSE I COULDN'T FIGURE OUT HOW TO EXPLAIN IT. THEN A HEARD 2 RADIO REPORTS ABOUT THE COMPLAINTS BEING FILED. I CALLED VW OF AMERICA WHO LISTENED TO MY STORY. THEY TOLD ME THAT IN ORDER TO BE COMPENSATED FOR MY ACCIDENT, THAT I WOULD HAVE NEEDED TO HAVE HAD THE CAR TOWED IMMEDIATELY TO A DEALERSHIP AND HAD IT DIAGNOSED. SHE SUGGESTED THAT I TAKE IT TO BE DIAGNOSED. I TOOK IT TO THE DEALER WHO KEPT IT FOR TWO DAYS AND COULD NOT FIND ANYTHING WRONG. A WEEK LATER, I WAS COMING TO A STOP FOR A RED LIGHT AND THE RPMS BEGAN TO FLUCTUATE LIKE IT WAS GOING TO STALL AND THEN IT WOULD COME BACK TO NORMAL RPMS. WHEN I STARTED TO DRIVE IT WAS A LITTLE ROUGH, THEN SMOOTHED OUT. I CALLED VW OF AMERICA WHO RECOMMENDED THAT I TAKE IT BACK TO THE DEALER. I AM WAITING FOR THEM TO RETURN MY CALL. I HAVE ALSO 3 INTERMITTENT PROBLEMS WITH MY AM RADIO CUTTING OUT--ARE THE PROBLEMS CONNECTED?

NHTSA ODI #10387229

Official recalls

4

16V913000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Dec 20, 2016

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence & remedy

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional source detail variants (2)

Electronic Stability Control (esc)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

11V490000 · Fuel System, Diesel

Oct 3, 2011

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence & remedy

Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

10V621000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 10, 2010

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

Consequence & remedy

Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

09V333000 · Power Train:automatic Transmission

Aug 20, 2009

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.

Consequence & remedy

Consequence: THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: VOLKSWAGEN WILL REPROGRAM THE TRANSMISSION CONTROL MODULE WITH UPDATED SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA18003 · Air Bag Clockspring Failure

Opened Apr 18, 2018 · No close date supplied

Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Additional source detail variants (3)

Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags:frontal

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

PE11023 · Diesel Fuel Injector Line Leakage

Opened Aug 2, 2011 · Closed Dec 2, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.

EA11003 · High-Pressure Fuel Pump Failure

Opened Feb 7, 2011 · Closed Mar 27, 2015

Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Additional source detail variants (2)

Fuel System, Diesel

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

PE10034 · High Pressure Fuel Pump Failure (hpfp)

Opened Aug 26, 2010 · Closed Feb 8, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

The Office of Defects Investigation (ODI) and Volkswagen (VW) have received a total of 160 complaints and field reports alleging incidents of engine stall and/or loss of power that appear to be related to high pressure fuel pump (HPFP) failures in certain model year (MY) 2009 through 2010 Volkswagen Jetta and MY 2010 Volkswagen Golf and Audi A3 vehicles equipped with TDI clean diesel engines.Approximately half of the reports indicate that the failure resulted in an engine stall incident, with many of these alleging stall incidents at highway speeds in traffic with no restart.There has been one minor crash alleged to have resulted from HPFP failure in the subject vehicles.In response to ODI's information request for PE10-034, VW indicated that it had found no defect related to motor vehicle safety with relation to the TDI Clean Diesel fuel system at issue in this investigation and attributed problems with HPFP failure to operation with gasoline contaminated diesel fuel.Volkswagen stated that even a small amount of gasoline in the diesel fuel may disrupt the necessary lubrication required and may cause the HPFP to fail.In response to concerns that fuel contamination was the major cause of HPFP and related fuel system failures, VW issued a Technical Service Bulletin in May 2010 (VW TB V011011 2023624 and Audi TB A011008 2023360-1), with instructions to inspect the diesel fuel for vehicles requiring fuel system service that have symptoms associated with HPFP failure.The bulletin states that fuel system damage incurred by use of fuel not complying to ASTM-D-975 Grade 2 S15 (B5 or less biodiesel content) standards will not be covered under warranty. Volkswagen also provided information about 121 mis-fueling incidents reportedly acknowledged by consumers or dealers and test results for about 50 diesel fuel samples taken from complaint vehicles in late-August through early-October 2010.The mis-fueling incidents include about 20 reports involving incorrect fueling by dealer sales or service personnel and generally report symptoms such as rough running, stalling and/or no start within a few miles of refueling the vehicle with gasoline.Volkswagen indicated that the testing of fuel samples from complaint vehicles found that nearly 90 percent contained high amounts of gasoline.Volkswagen implemented design changes for the HPFP in May 2008, September 2009 and November 2010 to improve the robustness of the pump when used with poor quality fuel.ODI analysis of HPFP failures identified from all sources shows failure rates of 0.53% for MY 2009 vehicles and 0.11% for MY 2010 vehicles.This investigation has been upgraded to an Engineering Analysis (EA11-003) to continue to investigate the issues with mis-fueling and HPFP design identified during the Preliminary Evaluation.