← New search

2010 Volkswagen Jetta

Owner reports · Recalls · Investigations

More warning signs than most Jetta years

Owner complaints for the 2010 Volkswagen Jetta are substantially higher than the model-year median of 68.

About this comparison →

When problems were reported

Mileage at the reported incident

779 reports with mileage · 73 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Diesel. Review the 166 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports5 fire reports10 injury reports

Fuel System, Diesel complaints

166 reports
Clear category filter
36,252 miles · Jul 27, 2011
Fuel System, Diesel

THE FOLLOWING EVENT OCCURRED ON 22 JULY 2011 IN A 2010 VW JETTA TDI WITH THE DSG. WEATHER WAS SUNNY, CLEAR AND APPROXIMATELY 94 DEGREES. TIME OF DAY WAS 1630 HOURS. I WAS LEAVING WORK AND I ATTEMPTED TO ENTER THE INTERSTATE TO GO HOME. I PRESSED ON THE ACCELERATOR TO MERGE INTO TRAFFIC. WHEN I PUSHED ON THE PEDAL, THE VEHIC…

Read full complaint

THE FOLLOWING EVENT OCCURRED ON 22 JULY 2011 IN A 2010 VW JETTA TDI WITH THE DSG. WEATHER WAS SUNNY, CLEAR AND APPROXIMATELY 94 DEGREES. TIME OF DAY WAS 1630 HOURS. I WAS LEAVING WORK AND I ATTEMPTED TO ENTER THE INTERSTATE TO GO HOME. I PRESSED ON THE ACCELERATOR TO MERGE INTO TRAFFIC. WHEN I PUSHED ON THE PEDAL, THE VEHICLE WOULD NOT INCREASE SPEED AND THE "CHECK ENGINE - SERVICE NOW' MESSAGE APPEARED IN THE MULTI-FUNCTION DISPLAY. ALSO, THE GLOW PLUG INDICATOR WAS ILLUMINATED. I PULLED TO THE SHOULDER, TURNED OFF THE VEHICLE AND CHECKED UNDER THE HOOD AND UNDER THE BODY. NOTHING APPEARED OUT OF PLACE, BROKEN, LEAKING OR ANY OTHER SYMPTOM WHICH WOULD BE UNUSUAL. I CLOSED THE HOOD, ENTERED THE VEHICLE AND RESTARTED IT. IT STARTED AND IDLED FINE. NO WARNING MESSAGES OR INDICATOR LAMPS APPEARED. I PUT THE CAR IN GEAR AND MERGED INTO TRAFFIC. AFTER DRIVING APPROXIMATELY 1 OR 2 MILES, THE "CHECK ENGINE - SERVICE NOW" MESSAGE REAPPEARED AND THE MIL LAMP WAS ILLUMINATED. ALSO, THE BATTERY LIGHT CAME ON AND THE ENGINE IMMEDIATELY STALLED. I COASTED TO THE SHOULDER AND PARKED THE VEHICLE. IT WOULD NOT RESTART. AGAIN, I EXITED THE VEHICLE, CHECKED UNDER THE HOOD AND UNDER THE BODY BUT THERE WERE NO SIGNS OF ANYTHING UNUSUAL. THIS WAS THE FIRST TIME THIS ISSUE HAS OCCURRED. THE VEHICLE IS CURRENTLY AT THE DEALER. THE DIAGNOSIS IS THE HIGH PRESSURE FUEL PUMP (HPFP) FAILED AND CAUSE METAL SHAVINGS TO BE SENT THROUGHOUT THE FUEL SYSTEM. THE DEALER STATED THEY ARE WAITING ON THE VOLKSWAGEN TECHNICIAN TO INFORM THEM ON THE CORRECT PARTS TO ORDER. *TR

NHTSA ODI #10415372

2,300 miles · Jul 24, 2011
Fuel System, Diesel

WE PURCHASED A 2010 VOLKSWAGEN JETTA SPORTWAGEN TDI IN JULY 2010. ON JULY 21, 2011, THE VEHICLE WAS GIVEN ITS FIRST SERVICE AT A VOLKSWAGEN DEALERSHIP IN MADISON, WI. THE NEXT DAY, JULY 22, 2011, THE CAR WAS TO BE DRIVEN FROM MADISON, WI, TO NASHVILLE, TN. JUST PAST URBANA, IL, THE VEHICLE BEGAN TO OVERHEAT, INCREASING TO 190…

Read full complaint

WE PURCHASED A 2010 VOLKSWAGEN JETTA SPORTWAGEN TDI IN JULY 2010. ON JULY 21, 2011, THE VEHICLE WAS GIVEN ITS FIRST SERVICE AT A VOLKSWAGEN DEALERSHIP IN MADISON, WI. THE NEXT DAY, JULY 22, 2011, THE CAR WAS TO BE DRIVEN FROM MADISON, WI, TO NASHVILLE, TN. JUST PAST URBANA, IL, THE VEHICLE BEGAN TO OVERHEAT, INCREASING TO 190 DEGREES. IN ADDITION, THE ACCELERATION ABILITY BEGAN DECREASING UNTIL THE VEHICLE WOULD NOT GO MORE THAN 72 MPH. THE CHECK ENGINE LIGHT CAME ON AND BEGAN FLASHING. DRIVING THE VEHICLE BECAME DANGEROUS, AND THE VEHICLE WAS DRIVEN INTO A REST STOP AND TURNED OFF. VOLKSWAGEN ROADSIDE ASSISTANCE TOOK THE VEHICLE TO THE NEAREST DEALERSHIP WHICH WAS IN URBANA, IL. O'BRIEN VOLKSWAGEN DETERMINED ON JULY 23, 2011, THAT THE FUEL PUMP LOCATED IN THE GAS TANK WAS NOT OPERATING PROPERLY. THE REPLACEMENT TANK/PUMP HAS BEEN ORDERED AND IS SCHEDULED TO BE REPLACED IN THE VEHICLE ON JULY 26, 2011. WE FOUND THAT THIS COMPLAINT HAS BEEN MADE BY OTHERS, AND WE HOPE THAT THIS WILL BECOME AN OFFICIAL RECALL. IF IT HAD BEEN UNDER RECALL WHEN THE VEHICLE RECEIVED ITS SERVICE ON JULY 21, THE PART(S) COULD HAVE BEEN REPLACED AT THAT TIME, AND THE DANGEROUS DRIVING CONDITIONS COULD HAVE BEEN AVOIDED. *TR

NHTSA ODI #10414936

3,236 miles · Jun 21, 2011
Fuel System, Diesel

I WANT TO MAKE SURE MY VEHICLE IS INCLUDED IN NHTSA INVESTIGATION EA11003 - VOLKSWAGEN DIESEL HIGH PRESSURE FUEL PUMP FAILURES. NOTE: VW USES A FOAM CUP TEST TO VERIFY PRESENCE OF GASOLINE IN THE DIESEL FUEL. BIODIESEL WILL MELT FOAM THE SAME WAY GASOLINE DOES SO THE FOAM CUP TEST WILL SHOW THE SAME RESULTS IF THE DIESEL FUEL I…

Read full complaint

I WANT TO MAKE SURE MY VEHICLE IS INCLUDED IN NHTSA INVESTIGATION EA11003 - VOLKSWAGEN DIESEL HIGH PRESSURE FUEL PUMP FAILURES. NOTE: VW USES A FOAM CUP TEST TO VERIFY PRESENCE OF GASOLINE IN THE DIESEL FUEL. BIODIESEL WILL MELT FOAM THE SAME WAY GASOLINE DOES SO THE FOAM CUP TEST WILL SHOW THE SAME RESULTS IF THE DIESEL FUEL IN THE VEHICLE CONTAINS BIODIESEL. MOST ALL STATIONS IN ILLINOIS SELL BIODIESEL BECAUSE OF STATE TAX INCENTIVES. I EXPLAINED THIS MULTIPLE TIMES TO MY DEALER BUT THEY WOULDN'T LISTEN. THEY WANTED ME TO PAY $200.00 TO SEND THE FUEL TO AN OUTSIDE LAB FOR TESTING SO I TURNED THE ISSUE OVER TO MY INSURANCE COMPANY. FINAL BILLL WAS $10035.77 OF MOSTLY UNNEEDED PARTS FOR THE REPAIR BECAUSE THERE WAS NOT GASOLINE IN THE FUEL. I HAVE A RECEIPT SHOWING WHAT PUMP I FILLED UP FROM AND A LETTER FROM THE ILLINOIS DEPARTMENT OF AGRICULTURE STATING THEY TESTED THE DIESEL FUEL FROM THE PUMP I FILLED UP AT AND IT TESTED WITHIN COMPLIANCE. I FILLED UP THREE DAYS PRIOR TO THE PUMP FAILURE AND THE ENGINE WAS RUNNING PERFECTLY UP TIL THE FAILURE. THE ONLY THING I WONDERED ABOUT IS THE COOLING FAN WASN'T RUNNING AND IT WAS 94 DEGREES OUT THAT DAY. THE DEALER WAS USELESS AND DISMISSED EVERYTHING I SAID CLAIMING I PUT GASOLINE IN THE CAR. I AM THE ONLY DRIVER IN MY HOUSEHOLD WHO HAD EVER FUELED IT UP AND I KNOW FOR A FACT I HAD NOT EVER PUT IN THE WRONG FUEL. I FEEL I AM OWED COMPENSATION FROM VOLKSWAGEN FOR THE WAY I WAS TREATED AND THE FACT I WAS NOT GIVEN A LOANER VEHICLE PER THE VEHICLE WARRANTY THEY DID NOT HONOR ON THE REPAIR. MY JETTA WAS BRAND NEW - ONLY 3236 MILES ON THE ODOMETER WHEN THE PUMP FAILED. THERE ARE MULTIPLE REPORTS OF THIS PROBLEM ALL OVER THE VW TDI FORUMS ON THE INTERNET. I WASN'T THE FIRST ONE THIS HAPPENED TO AND THERE HAVE BEEN MORE SINCE. PLEASE HELP PROTECT CONSUMERS FROM BEING PUT IN THE UNNECESSARY POSITION OF FIGHTING A HUGE COMPANY. I WOULD BE HAPPY TO SHARE MY DOCUMENTATION SO YOU REALLY SHOULD BE CONTACTING OWNERS FOR MORE INFO. *TR

NHTSA ODI #10407659

800 miles · Jun 8, 2011
Fuel System, Diesel

2010 JETTA DIESEL AUTOMOBILE. PROBLEMS WITH ENGINE STALLING AND/OR POWER DOWN PROBLEMS. ALMOST HIT BY ANOTHER VEHICLE IN A LEFT HAND TURN TWICE BECAUSE VEHICLE STALLED. WE HAVE RETURNED IT TO THE DEALERSHIP SEVERAL TIMES, BUT THEY DENY ANYTHING IS WRONG. IT DOES NOT HAPPEN ALL THE TIME, BUT VERY FRIGHTENING WHEN IT DOES HAPP…

Read full complaint

2010 JETTA DIESEL AUTOMOBILE. PROBLEMS WITH ENGINE STALLING AND/OR POWER DOWN PROBLEMS. ALMOST HIT BY ANOTHER VEHICLE IN A LEFT HAND TURN TWICE BECAUSE VEHICLE STALLED. WE HAVE RETURNED IT TO THE DEALERSHIP SEVERAL TIMES, BUT THEY DENY ANYTHING IS WRONG. IT DOES NOT HAPPEN ALL THE TIME, BUT VERY FRIGHTENING WHEN IT DOES HAPPEN. WE PURCHASED THE CAR IN DEC 2010 AND IT HAS HAPPENED 16 TIMES, 8 IN MAJOR TRAFFIC. *TR

NHTSA ODI #10405632

5,000 miles · May 30, 2011
Engine And Engine CoolingFuel System, Diesel

THE CAR CHRONICALLY STALLS IN FIRST OR SECOND GEAR IN STOP AND GO TRAFFIC, AT VERY SLOW SPEEDS OR WHEN COASTING. WHEN GIVING IT GAS AND LETTING OUT THE CLUTCH, IT JUST STALLS WITH NO WARNING. HAVE SPOKEN WITH OTHER JETTA TDI OWNERS AND THEY ACKNOWLEDGE SAME PROBLEM

NHTSA ODI #10404754

21,000 miles · May 16, 2011
Fuel System, Diesel

TL*THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 20 MPH THE VEHICLE LOST POWER. THE CONTACT NOTICED THE GLOW PLUG WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE AT A LOW SPEED TO THE NEAREST DEALER. THE TECHNICIANS STATED THE FUEL PUMP, THE INJECTORS, AND FUE…

Read full complaint

TL*THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 20 MPH THE VEHICLE LOST POWER. THE CONTACT NOTICED THE GLOW PLUG WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE AT A LOW SPEED TO THE NEAREST DEALER. THE TECHNICIANS STATED THE FUEL PUMP, THE INJECTORS, AND FUEL LINES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 21,000. UPDATED 07-06/11 *BF UPDATED 3/1/12 *CN

NHTSA ODI #10401084

12,000 miles · May 9, 2011
Fuel System, Diesel

ON MAY 8,2011 MY 2010 VW JETTA TDI DIESEL SHUT DOWN COMPLETELY AS I WAS DRIVING AT A SPEED OF 40 MILES PER HOUR. AFTER THE CAR CAME TO A COMPLETE STOP, I WAITED A FEW MINUTES AND THE CAR STARTED. THIS INCIDENT HAS HAPPENED AT LEAST 6 TIMES PRIOR TO THIS COMPLETE SHUTDOWN OF THE ENGINE. THIS PROBLEM STARTED IN THE FIRST THOUSAND …

Read full complaint

ON MAY 8,2011 MY 2010 VW JETTA TDI DIESEL SHUT DOWN COMPLETELY AS I WAS DRIVING AT A SPEED OF 40 MILES PER HOUR. AFTER THE CAR CAME TO A COMPLETE STOP, I WAITED A FEW MINUTES AND THE CAR STARTED. THIS INCIDENT HAS HAPPENED AT LEAST 6 TIMES PRIOR TO THIS COMPLETE SHUTDOWN OF THE ENGINE. THIS PROBLEM STARTED IN THE FIRST THOUSAND MILES OF USE. THE OTHER 5 INCIDENTS JUST INVOLVED THE CAR STALLING FOR A FEW SECONDS AND THEN STARTED WORKING AGAIN BEFORE THE CAR COMPLETELY STOPPED. THE CAR HAS BEEN FULLY MAINTAINED BY THE VW OF OLD SAYBROOK DEALERSHIP IN CT. THE CAR HAS APPROXIMATELY 12,000 MILES ON IT. THE CAR WAS JUST BROUGHT IN FOR ITS 10,000 MILE MAINTENANCE CHECK A FEW MONTHS AGO BAD FUEL IS NOT THE CASE AS I GO TO THE SAME STATION AND CONTINUED TO DO SO FOR AS LONG AS I HAVE HAD THE CAR. I BRING MY 2004 DIESEL TDI THERE AND HAVE NEVER HAD A PROBLEM AT ALL. THIS IS DEFINITELY A SAFETY ISSUE AS I DO A LOT OF HIGHWAY DRIVING WITH THIS CAR. *TR

NHTSA ODI #10399507

2,500 miles · Apr 26, 2011
Fuel System, Diesel

VEHICLE, A 2010 VOLKWAGEN JETTA SPORTWAGEN TDI DIESEL MODEL WITH ABOUT 2500 MILES ON IT (NEARLY NEW) STALLED IN BUSY TRAFFIC LEAVING MY WIFE STRANDED. VEHICLE HAD FAILURE OF HIGH-PRESSURE FUEL PUMP, REPORTED BY MANY OWNERS OF RECENT VOLKWAGEN TDI MODELS.

NHTSA ODI #10397916

37,700 miles · Apr 26, 2011
Fuel System, Diesel

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE STALLED. THE CONTACT RESTARTED THE VEHICLE BUT THE FAILURE RECURRED WITHIN A FEW MINUTES. AFTER THE SECOND FAILURE, THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS ADVISED THAT…

Read full complaint

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE STALLED. THE CONTACT RESTARTED THE VEHICLE BUT THE FAILURE RECURRED WITHIN A FEW MINUTES. AFTER THE SECOND FAILURE, THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS ADVISED THAT THE HIGH PRESSURE FUEL PUMP EXPLODED AND SENT METAL FRAGMENTS INTO THE ENGINE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 37,700.

NHTSA ODI #10397516

13,345 miles · Apr 13, 2011
Fuel System, Diesel

JETTA TDI DIESEL ENGINE STALL PRECEDED BY GLOW PLUG ALARM AND SUBSEQUENT CHECK ENGINE LIGHT DISPLAY. THE CAR COULD BE RESTARTED AFTER SEVERAL TRIES AND DRIVEN VERY SLOWLY AS THE ENGINE WAS EXTREMELY SLUGGISH. THIS WAS THE SECOND TIME THIS FAILURE OCCURRED, THE LAST BEING IN NOVEMBER 2010. THE FIRST FAILURE WAS CORRECTED BY A S…

Read full complaint

JETTA TDI DIESEL ENGINE STALL PRECEDED BY GLOW PLUG ALARM AND SUBSEQUENT CHECK ENGINE LIGHT DISPLAY. THE CAR COULD BE RESTARTED AFTER SEVERAL TRIES AND DRIVEN VERY SLOWLY AS THE ENGINE WAS EXTREMELY SLUGGISH. THIS WAS THE SECOND TIME THIS FAILURE OCCURRED, THE LAST BEING IN NOVEMBER 2010. THE FIRST FAILURE WAS CORRECTED BY A SOFTWARE UPDATE. IN THIS SECOND FAILURE, THE DEALER SAID THEY FOUND METAL FILINGS IN THE FUEL SYSTEM AND THEY WILL REPLACE ALL COMPONENTS IN THE FUEL SYSTEM AND SEND THE PARTS INCLUDING THE REMAINING FUEL TO GERMANY FOR ANALYSIS. GAS WAS SUSPECTED IN THE FUEL, BUT RULED OUT BY TESTING AT THE DEALERSHIP. THE DEALER SAYS VW DOES NOT KNOW WHAT THE PROBLEM CAUSE IS AND THEY HAVE HAD SIMILAR FAILURES IN OTHER JETTA TDI'S. *TR

NHTSA ODI #10395792

Official recalls

4

16V913000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Dec 20, 2016

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence & remedy

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional source detail variants (2)

Electronic Stability Control (esc)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

11V490000 · Fuel System, Diesel

Oct 3, 2011

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence & remedy

Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

10V621000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 10, 2010

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

Consequence & remedy

Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

09V333000 · Power Train:automatic Transmission

Aug 20, 2009

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.

Consequence & remedy

Consequence: THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: VOLKSWAGEN WILL REPROGRAM THE TRANSMISSION CONTROL MODULE WITH UPDATED SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA18003 · Air Bag Clockspring Failure

Opened Apr 18, 2018 · No close date supplied

Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Additional source detail variants (3)

Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags:frontal

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

PE11023 · Diesel Fuel Injector Line Leakage

Opened Aug 2, 2011 · Closed Dec 2, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.

EA11003 · High-Pressure Fuel Pump Failure

Opened Feb 7, 2011 · Closed Mar 27, 2015

Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Additional source detail variants (2)

Fuel System, Diesel

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

PE10034 · High Pressure Fuel Pump Failure (hpfp)

Opened Aug 26, 2010 · Closed Feb 8, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

The Office of Defects Investigation (ODI) and Volkswagen (VW) have received a total of 160 complaints and field reports alleging incidents of engine stall and/or loss of power that appear to be related to high pressure fuel pump (HPFP) failures in certain model year (MY) 2009 through 2010 Volkswagen Jetta and MY 2010 Volkswagen Golf and Audi A3 vehicles equipped with TDI clean diesel engines.Approximately half of the reports indicate that the failure resulted in an engine stall incident, with many of these alleging stall incidents at highway speeds in traffic with no restart.There has been one minor crash alleged to have resulted from HPFP failure in the subject vehicles.In response to ODI's information request for PE10-034, VW indicated that it had found no defect related to motor vehicle safety with relation to the TDI Clean Diesel fuel system at issue in this investigation and attributed problems with HPFP failure to operation with gasoline contaminated diesel fuel.Volkswagen stated that even a small amount of gasoline in the diesel fuel may disrupt the necessary lubrication required and may cause the HPFP to fail.In response to concerns that fuel contamination was the major cause of HPFP and related fuel system failures, VW issued a Technical Service Bulletin in May 2010 (VW TB V011011 2023624 and Audi TB A011008 2023360-1), with instructions to inspect the diesel fuel for vehicles requiring fuel system service that have symptoms associated with HPFP failure.The bulletin states that fuel system damage incurred by use of fuel not complying to ASTM-D-975 Grade 2 S15 (B5 or less biodiesel content) standards will not be covered under warranty. Volkswagen also provided information about 121 mis-fueling incidents reportedly acknowledged by consumers or dealers and test results for about 50 diesel fuel samples taken from complaint vehicles in late-August through early-October 2010.The mis-fueling incidents include about 20 reports involving incorrect fueling by dealer sales or service personnel and generally report symptoms such as rough running, stalling and/or no start within a few miles of refueling the vehicle with gasoline.Volkswagen indicated that the testing of fuel samples from complaint vehicles found that nearly 90 percent contained high amounts of gasoline.Volkswagen implemented design changes for the HPFP in May 2008, September 2009 and November 2010 to improve the robustness of the pump when used with poor quality fuel.ODI analysis of HPFP failures identified from all sources shows failure rates of 0.53% for MY 2009 vehicles and 0.11% for MY 2010 vehicles.This investigation has been upgraded to an Engineering Analysis (EA11-003) to continue to investigate the issues with mis-fueling and HPFP design identified during the Preliminary Evaluation.