← New search

2010 Volkswagen Jetta

Owner reports · Recalls · Investigations

More warning signs than most Jetta years

Owner complaints for the 2010 Volkswagen Jetta are substantially higher than the model-year median of 68.

About this comparison →

When problems were reported

Mileage at the reported incident

779 reports with mileage · 73 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Diesel. Review the 166 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports5 fire reports10 injury reports

Fuel/propulsion System complaints

122 reports
Clear category filter
32,000 miles · Aug 31, 2012
Fuel/propulsion System

I WAS TRAVELING APPROXIMATELY 45 MPH IN MY 2010 JETTA TDI WHEN THE CAR SUDDENLY STALLED WITHOUT ANY WARNING. I WAS UNABLE TO NAVIGATE THE CAR TO A SAFE PLACE AND WAS STUCK IN THE MIDDLE TWO LANES. I WAS UNABLE TO RESTART THE CAR AND HAD TO WAIT 40MIN FOR A TOW TRUCK TO ARRIVE. THE DEALERSHIP INDICATED THAT THE FUEL PUMP FAILE…

Read full complaint

I WAS TRAVELING APPROXIMATELY 45 MPH IN MY 2010 JETTA TDI WHEN THE CAR SUDDENLY STALLED WITHOUT ANY WARNING. I WAS UNABLE TO NAVIGATE THE CAR TO A SAFE PLACE AND WAS STUCK IN THE MIDDLE TWO LANES. I WAS UNABLE TO RESTART THE CAR AND HAD TO WAIT 40MIN FOR A TOW TRUCK TO ARRIVE. THE DEALERSHIP INDICATED THAT THE FUEL PUMP FAILED. THEY ARE ALSO HAVING TO REPLACE THE FUEL DISTRIBUTOR AND FILTER. *TR

NHTSA ODI #10473199

47,000 miles · Aug 23, 2012
Fuel/propulsion SystemPower Train

WHILE EXITING A PARKING AT A STOP SIGN, WHEN ACCELERATING OUT PAST THE STOP SIGN AT APPROXIMATELY 10 MPH THE CAR'S ENGINE SUDDENLY LOST POWER AND DIED. AFTER THE VEHICLE ONCE AGAIN RETURNED TO A COMPLETE STOP, I WAS ABLE TO RESTART THE ENGINE AFTER PUTTING THE CAR INTO PARK. TAKEN INTO DEALERSHIP 10 DAYS LATER FOR SCHEDULE S…

Read full complaint

WHILE EXITING A PARKING AT A STOP SIGN, WHEN ACCELERATING OUT PAST THE STOP SIGN AT APPROXIMATELY 10 MPH THE CAR'S ENGINE SUDDENLY LOST POWER AND DIED. AFTER THE VEHICLE ONCE AGAIN RETURNED TO A COMPLETE STOP, I WAS ABLE TO RESTART THE ENGINE AFTER PUTTING THE CAR INTO PARK. TAKEN INTO DEALERSHIP 10 DAYS LATER FOR SCHEDULE SERVICE AND MAINTENANCE; NOTHING OUT OF THE ORDINARY WAS FOUND. *TR

NHTSA ODI #10471965

119,000 miles · Aug 21, 2012
Fuel/propulsion System

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 60 MPH THE VEHICLE STALLED. HE WAS ABLE TO RESTART THE VEHICLE SHORTLY THEREAFTER. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE DEALER STATED THAT THE FUEL SYSTEM NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AN…

Read full complaint

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 60 MPH THE VEHICLE STALLED. HE WAS ABLE TO RESTART THE VEHICLE SHORTLY THEREAFTER. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE DEALER STATED THAT THE FUEL SYSTEM NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND THE CURRENT MILEAGE WAS 119,000.

NHTSA ODI #10471795

54,000 miles · Jul 19, 2012
Fuel/propulsion System

FIRST INCIDENCE: DRIVING 45 MPH, GLOW PLUG LIGHT STARTS FLASHING, CAR GOES INTO LIMP MODE. DRIVE SLOWLY HOME. CALL DEALERSHIP, TOLD TO RECYCLE (TURN OFF/ON). IF LIGHT GOES AWAY SHOULD BE OKAY THEY SAID. TOOK TO DEALER TO CHECK OUT TO BE SURE. THEY FOUND NOTHING. A WEEK LATER WAS ON THE HIGHWAY AND NEEDED TO ACCELERATE AND F…

Read full complaint

FIRST INCIDENCE: DRIVING 45 MPH, GLOW PLUG LIGHT STARTS FLASHING, CAR GOES INTO LIMP MODE. DRIVE SLOWLY HOME. CALL DEALERSHIP, TOLD TO RECYCLE (TURN OFF/ON). IF LIGHT GOES AWAY SHOULD BE OKAY THEY SAID. TOOK TO DEALER TO CHECK OUT TO BE SURE. THEY FOUND NOTHING. A WEEK LATER WAS ON THE HIGHWAY AND NEEDED TO ACCELERATE AND FLASHING LIGHT AND LIMP MODE AGAIN. PULLED OVER, TURNED OFF AND ON. DROVE SLOW TO THE DEALER, CAR VERY SLUGGISH. IT IS AT THE DEALER NOW AND THEY ARE GOING TO REPLACE THE HIGH PRESSURE FUEL PUMP (HPFP). *TR

NHTSA ODI #10466589

28,000 miles · Jul 5, 2012
Fuel System, DieselFuel/propulsion System

MY 2010 JETTA TDI BROKE DOWN ON ME WHILE I WAS THREE HOURS AWAY FROM MY HOME. THE SERVICE REP. SAID HE HAS HAD A FEW CARS COME IN WITH THE SAME PROBLEM. HE STATED IT WAS DUE TO BAD FUEL OR WATER IN THE FUEL LINE. I KNOW I HAD PUT DIESEL IN WHEN I FILLED UP THAT MORNING. HE STATED WE HAD PROBABLY RECEIVED BAD FUEL WHEN WE HAD FIL…

Read full complaint

MY 2010 JETTA TDI BROKE DOWN ON ME WHILE I WAS THREE HOURS AWAY FROM MY HOME. THE SERVICE REP. SAID HE HAS HAD A FEW CARS COME IN WITH THE SAME PROBLEM. HE STATED IT WAS DUE TO BAD FUEL OR WATER IN THE FUEL LINE. I KNOW I HAD PUT DIESEL IN WHEN I FILLED UP THAT MORNING. HE STATED WE HAD PROBABLY RECEIVED BAD FUEL WHEN WE HAD FILLED UP. WE WERE ON A ROAD TRIP (8HRS ONE WAY) AND I HAD DRIVEN ABOUT 5 HOURS BEFORE IT DIED!!! WE WERE TRAVELING AT APPROX. 65 MPH WHEN THE FLASHING GLOW PLUG LIGHT INDICATOR BEGAN TO FLASH. THE CAR THEN STARTED TO LOSE ACCELERATION AND WE PULLED OVER WHERE THE ENGINE FINALLY SHUT DOWN AND IT WOULD NOT RESTART. I HAD TO HAVE THE CAR TOWED TO THE CLOSEST VW DEALER. THEY ARE REPLACING THE ENTIRE FUEL SYSTEM. HOW AM I SUPPOSED TO KNOW WHAT FUEL STATION HAS GOOD DIESEL? I KNOW THE FAULT WAS NOT MINE. I CAN'T AFFORD TO BE WITHOUT MY CAR AGAIN FOR 2 TO 3 WEEKS. AS SOON AS I GET MY CAR BACK I WILL BE TRADING IT IN EVEN THOUGH I AM UPSIDE DOWN ON MY LOAN. I LOVED MY TDI BUT WITH THIS ISSUE ALWAYS BEING A THREAT I WILL NOT BE ABLE TO RECOMMEND THIS CAR TO ANYONE. VW NEEDS TO FIX THIS ISSUE. *TR

NHTSA ODI #10464327

20,426 miles · Jul 3, 2012
Fuel/propulsion System

CHECK ENGINE LIGHT CAME ON WHILE DRIVING JETTA TDI TO/FROM WORK. TOOK IT TO DEALER AND THEY REPORTED IT WAS THE HIGH PRESSURE FUEL SENSOR (VEHICLE STORING FAULT P0191). THEY REPLACED THE SENSOR (THINKING IT FAULTY), BUT THE FOLLOWING DAY THE CHECK ENGINE LIGHT CAME ON AGAIN. RETURNED THE VEHICLE TO THE DEALER AND THEY REPORTED T…

Read full complaint

CHECK ENGINE LIGHT CAME ON WHILE DRIVING JETTA TDI TO/FROM WORK. TOOK IT TO DEALER AND THEY REPORTED IT WAS THE HIGH PRESSURE FUEL SENSOR (VEHICLE STORING FAULT P0191). THEY REPLACED THE SENSOR (THINKING IT FAULTY), BUT THE FOLLOWING DAY THE CHECK ENGINE LIGHT CAME ON AGAIN. RETURNED THE VEHICLE TO THE DEALER AND THEY REPORTED THE SAME FAULT. DEALER KEPT VEHICLE FOR INVESTIGATION. THEIR INVESTIGATION REVEALED METAL SHAVINGS IN THE FUEL SYSTEM. THE VEHICLE REMAINED WITH THE DEALER BETWEEN 03/23-03/27 WHEREIN THEY REPLACED THE ENTIRE FUEL SYSTEM. ON THE MORNING OF 06/29 WENT TO START CAR AND COULD NOT GET IT TO START. VEHICLE WAS TOWED TO DEALER AND THE REPLACEMENT HIGH PRESSURE FUEL PUMP WAS DETERMINED FAULTY. *JS

NHTSA ODI #10464156

28,192 miles · Jun 27, 2012
EngineFuel/propulsion System

WHEN I STARTED MY CAR, A 2010 JETTA SEDAN TDI, IT STARTED MAKING A STRANGE NOISE, BUT STILL RAN. I TRIED TO DRIVE IT OVER TO THE VOLKSWAGEN DEALER WHICH WAS APPROXIMATELY 2 MILES AWAY. I PULLED OUT ONTO THE HIGHWAY AND ACHIEVED A SPEED OF APPROXIMATELY 30MPH. THE CAR CONTINUED TO MAKE THE NOISE AND BEGAN TO LOSE POWER WITHIN A …

Read full complaint

WHEN I STARTED MY CAR, A 2010 JETTA SEDAN TDI, IT STARTED MAKING A STRANGE NOISE, BUT STILL RAN. I TRIED TO DRIVE IT OVER TO THE VOLKSWAGEN DEALER WHICH WAS APPROXIMATELY 2 MILES AWAY. I PULLED OUT ONTO THE HIGHWAY AND ACHIEVED A SPEED OF APPROXIMATELY 30MPH. THE CAR CONTINUED TO MAKE THE NOISE AND BEGAN TO LOSE POWER WITHIN A HALF MILE. I PULLED INTO THE PARKING LOT OF A SHOPPING CENTER AT WHICH TIME THE ENGINE DIED AND WOULD NOT RESTART. THE CAR HAD TO BE TOWED TO THE VOLKSWAGEN DEALER, WALLACE IMPORTS OF JOHNSON CITY, TN. IT TOOK THEM APPROXIMATELY 1 1/2 WEEKS TO GET THE PARTS IN AND REPAIR THE VEHICLE. THE SERVICE REPRESENTATIVE EXPLAINED TO MY HUSBAND THAT THERE WAS A CATASTROPHIC FAILURE OF THE HIGH PRESSURE FUEL PUMP, WHICH RESULTED IN METAL FRAGMENTS CONTAMINATING THE ENTIRE FUEL SYSTEM. AS A RESULT, HE WAS TOLD THAT EVERY PART WHICH CAME IN CONTACT WITH THE FUEL HAD TO BE REPLACED, INCLUDING THE FUEL TANK, FUEL LINES, FILTERS, FUEL INJECTORS, AND MANY OTHERS. THERE WAS A TWO PAGE LIST OF THE PARTS USED TO FIX MY CAR. MY CONCERN IS THAT THIS COULD HAPPEN AGAIN RESULTING IN AN UNSAFE SITUATION. FURTHER, WE ALSO HAVE 2010 JETTA TDI SPORTSWAGEN AND HAVE CONCERNS OF THE SAME PROBLEM OCCURRING AT HIGHWAY SPEEDS SINCE MY HUSBAND ROUTINELY MAKE ROUND TRIPS OF 230 MILES AT LEAST TWICE A WEEK TRAVELING MAINLY ON THE INTERSTATE. *TR

NHTSA ODI #10463362

120 miles · Jun 21, 2012
Electronic Stability Control (esc)EngineFuel/propulsion System

I PURCHASED MY BRAND NEW VW JETTA FROM THE DEALERSHIP LOT. LESS THAN 4 WEEKS LATER WHEN THE CAR WAS IN THE DRIVEWAY I STARTED IT, AND AS I PRESSED THE GAS DOWN THE CAR BEGAN TO MOVE (IN A SPUTTERING/JERKING TYPE OF MOVEMEN)T BUT IT WAS NOT ABLE TO GO MORE THAN 7 FEET BEFORE IT STALLED OUT,, AND THE RPM'S WERE HIGH AND THE CAR JU…

Read full complaint

I PURCHASED MY BRAND NEW VW JETTA FROM THE DEALERSHIP LOT. LESS THAN 4 WEEKS LATER WHEN THE CAR WAS IN THE DRIVEWAY I STARTED IT, AND AS I PRESSED THE GAS DOWN THE CAR BEGAN TO MOVE (IN A SPUTTERING/JERKING TYPE OF MOVEMEN)T BUT IT WAS NOT ABLE TO GO MORE THAN 7 FEET BEFORE IT STALLED OUT,, AND THE RPM'S WERE HIGH AND THE CAR JUST MOVED LIKE IT WAS NOT ABLE TO PROPERLY ACCELERATE, IT STALLED OUT BEFORE THE END OF MY DRIVE WAY. I STARTED IT AGAIN AND IT DROVE PROPERLY, THIS EXACT INCIDENT OCCURRED AT LEAST1- 2 TIMES A WEEK ON A COLD START. I TOOK IT TO DEALERSHIP, NOTHING FOUND ON DIAGNOSTICS.THEN AT LEAST EVERY 1-2 MONTHS I TOOK IT TO DEALERSHIP, NO PROOF ON DIAGNOSTICS .NEXT A RECALL & WORK WAS DONE. SAME PROBLEM OCCURRED AGAIN AND AGAIN. TOOK IT BACK. THEY SAID THEY COULD NOT FIND A SOLUTION BECAUSE ITS NOT REPEATING THE STALLING WHEN ITS AT DEALERSHIP. I AM STILL HAVING THE ISSUE OF MY CAR STALLING OUT WHEN DRIVING, IT IS A SAFETY ISSUE. IT IS DANGEROUS DRIVING A CAR THAT STALLS OUT WHILE YOU ARE ON THE ROAD. SINCE THE COLD START ISSUES I HAVE ALSO HAD IT STALL OUT ON THE ROAD, IN AN INTERSECTION. THIS CAR IS STILL REPEATING THE STALLING. I CANNOT GET ANY ANSWERS ON HOW TO FIX IT DUE TO NO "PROOF" ON DIAGNOSTICS CHECK. I FEEL UNSAFE IN MY CAR. IT STARTS TO ACCELERATE THEN SHUTS OFF. THIS IS NOT ACCEPTABLE AND HASNT EVER BEEN PROPERLY FIXED EVEN THOUGHVW CORPORATE HAS A CASE ON THE ISSUES OF MY CAR. *TT

NHTSA ODI #10462666

24,000 miles · May 24, 2012
Fuel/propulsion System

I HAVE EXPERIENCED REPEATED PROBLEMS WITH MY TDI MANUAL TRANSMISSION JETTA SPORTWAGEN. WITHIN THE FIRST MONTH OF BUYING THIS VEHICLE, I EXPERIENCED A LURCHING SENSATION WHICH WOULD COME AND GO RANDOMLY ESPECIALLY WHEN IN THIRD GEAR. BROUGHT IT TO THE DEALER, BUT THEY COULDN'T REPLICATE. THIS HAS CONTINUED SPORADICALLY FOR OVER …

Read full complaint

I HAVE EXPERIENCED REPEATED PROBLEMS WITH MY TDI MANUAL TRANSMISSION JETTA SPORTWAGEN. WITHIN THE FIRST MONTH OF BUYING THIS VEHICLE, I EXPERIENCED A LURCHING SENSATION WHICH WOULD COME AND GO RANDOMLY ESPECIALLY WHEN IN THIRD GEAR. BROUGHT IT TO THE DEALER, BUT THEY COULDN'T REPLICATE. THIS HAS CONTINUED SPORADICALLY FOR OVER A YEAR AND A HALF. THE VEHICLE ALSO SOMETIMES IDLES VERY ROUGHLY WHEN AT A STOP. MORE RECENTLY, IN MARCH 2012, THE VEHICLE STALLED TWICE WHILE DRIVING AT ABOUT 30 - 40 MPH AND ALSO NOW IN MAY 2012 IT HAS DONE THIS AGAIN. THERE ARE NEVER ANY WARNING LIGHTS THAT GO ON, ONLY THE ENGINE LIGHT ONCE IT HAS ACTUALLY STALLED. BROUGHT IT TO THE DEALER EVERYTIME THIS HAS HAPPENED AND THEY ARE NEVER ABLE TO REPLICATE THE SITUATION, SO THEY SEND ME HOME WITH IT. I WAS VERY UPSET WITH THIS AND CONFRONTED THE DEALERSHIP ABOUT THIS WHEN I REALIZED HOW MANY OTHERS HAVE HAD SIMILAR PROBLEMS. THEY SAID THEY COULDN'T DO ANYTHING BECAUSE THEY COULDN'T FIND ANYTHING TO FIX. THEY SAID THEY WOULD NOTIFY VOLKSWAGEN AND I CALLED THEM AS WELL AND HAVE NOW BEEN GIVEN A CASE NUMBER. THIS IS A SERIOUS ISSUE AND NEEDS TO BE ADDRESSED. THERE IS POTENTIAL FOR MAJOR LIFE THREATENING SITUATIONS IF A CAR STALLS WHILE DRIVING IN THE MIDDLE OF TRAFFIC. I FEEL LIKE I AM DRIVING AROUND IN A TIME BOMB, BECAUSE YOU NEVER KNOW WHEN IT IS GOING TO HAPPEN. *TR

NHTSA ODI #10459568

25,000 miles · May 22, 2012
Fuel/propulsion System

JETTA TDI, CHECK ENGINE LIGHT AND GLOW PLUG WARNING LIGHT FOLLOWED BY REDUCED POWER. VEHICLE RAN FOR SEVERAL MILES BEFORE STALLING. WOULD NOT RESTART. DEALER REPORTED FAILURE OF THE HIGH PRESSURE FUEL PUMP AND METAL IN THE FUEL FILTER. *TT

NHTSA ODI #10459301

Official recalls

4

16V913000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Dec 20, 2016

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence & remedy

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional source detail variants (2)

Electronic Stability Control (esc)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

11V490000 · Fuel System, Diesel

Oct 3, 2011

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence & remedy

Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

10V621000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 10, 2010

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

Consequence & remedy

Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

09V333000 · Power Train:automatic Transmission

Aug 20, 2009

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.

Consequence & remedy

Consequence: THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: VOLKSWAGEN WILL REPROGRAM THE TRANSMISSION CONTROL MODULE WITH UPDATED SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA18003 · Air Bag Clockspring Failure

Opened Apr 18, 2018 · No close date supplied

Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Additional source detail variants (3)

Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags:frontal

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

PE11023 · Diesel Fuel Injector Line Leakage

Opened Aug 2, 2011 · Closed Dec 2, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.

EA11003 · High-Pressure Fuel Pump Failure

Opened Feb 7, 2011 · Closed Mar 27, 2015

Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Additional source detail variants (2)

Fuel System, Diesel

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

PE10034 · High Pressure Fuel Pump Failure (hpfp)

Opened Aug 26, 2010 · Closed Feb 8, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

The Office of Defects Investigation (ODI) and Volkswagen (VW) have received a total of 160 complaints and field reports alleging incidents of engine stall and/or loss of power that appear to be related to high pressure fuel pump (HPFP) failures in certain model year (MY) 2009 through 2010 Volkswagen Jetta and MY 2010 Volkswagen Golf and Audi A3 vehicles equipped with TDI clean diesel engines.Approximately half of the reports indicate that the failure resulted in an engine stall incident, with many of these alleging stall incidents at highway speeds in traffic with no restart.There has been one minor crash alleged to have resulted from HPFP failure in the subject vehicles.In response to ODI's information request for PE10-034, VW indicated that it had found no defect related to motor vehicle safety with relation to the TDI Clean Diesel fuel system at issue in this investigation and attributed problems with HPFP failure to operation with gasoline contaminated diesel fuel.Volkswagen stated that even a small amount of gasoline in the diesel fuel may disrupt the necessary lubrication required and may cause the HPFP to fail.In response to concerns that fuel contamination was the major cause of HPFP and related fuel system failures, VW issued a Technical Service Bulletin in May 2010 (VW TB V011011 2023624 and Audi TB A011008 2023360-1), with instructions to inspect the diesel fuel for vehicles requiring fuel system service that have symptoms associated with HPFP failure.The bulletin states that fuel system damage incurred by use of fuel not complying to ASTM-D-975 Grade 2 S15 (B5 or less biodiesel content) standards will not be covered under warranty. Volkswagen also provided information about 121 mis-fueling incidents reportedly acknowledged by consumers or dealers and test results for about 50 diesel fuel samples taken from complaint vehicles in late-August through early-October 2010.The mis-fueling incidents include about 20 reports involving incorrect fueling by dealer sales or service personnel and generally report symptoms such as rough running, stalling and/or no start within a few miles of refueling the vehicle with gasoline.Volkswagen indicated that the testing of fuel samples from complaint vehicles found that nearly 90 percent contained high amounts of gasoline.Volkswagen implemented design changes for the HPFP in May 2008, September 2009 and November 2010 to improve the robustness of the pump when used with poor quality fuel.ODI analysis of HPFP failures identified from all sources shows failure rates of 0.53% for MY 2009 vehicles and 0.11% for MY 2010 vehicles.This investigation has been upgraded to an Engineering Analysis (EA11-003) to continue to investigate the issues with mis-fueling and HPFP design identified during the Preliminary Evaluation.