← New search

2010 Volkswagen Jetta

Owner reports · Recalls · Investigations

More warning signs than most Jetta years

Owner complaints for the 2010 Volkswagen Jetta are substantially higher than the model-year median of 68.

About this comparison →

When problems were reported

Mileage at the reported incident

779 reports with mileage · 73 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Diesel. Review the 166 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports5 fire reports10 injury reports

Engine complaints

117 reports
Clear category filter
40,000 miles · Feb 13, 2013
EnginePower TrainSteering

WHEN AN ENGINE STALL OCCURS, THIS CAR REQUIRES A FULL RESET BEFORE A RESTART CAN BE PERFORMED. THIS IS VERY DANGEROUS WHEN SAID RESET HAPPENS WHILE THE CAR IS MOVING. MEANING ' A FULL RESET MEANS THE IGNITION KEY MUST FIRST BE FULLY TURNED OFF. WHEN THE CAR IS IN MOTION AND THE KEY IS FULLY TURNED OFF, AT THAT TIME THE LOCKIN…

Read full complaint

WHEN AN ENGINE STALL OCCURS, THIS CAR REQUIRES A FULL RESET BEFORE A RESTART CAN BE PERFORMED. THIS IS VERY DANGEROUS WHEN SAID RESET HAPPENS WHILE THE CAR IS MOVING. MEANING ' A FULL RESET MEANS THE IGNITION KEY MUST FIRST BE FULLY TURNED OFF. WHEN THE CAR IS IN MOTION AND THE KEY IS FULLY TURNED OFF, AT THAT TIME THE LOCKING GEAR IN THE IGNITION SWITCH ENGAGES AND LOCKS THE STEERING WHEEL... WHILE THE CAR IS IN MOTION!!! THIS IS A COMMON OCCURRENCE IN THE MANUAL SHIFT TRANSMISSION MODELS. *TR

NHTSA ODI #10498017

34,511 miles · Jan 14, 2013
EngineFuel System, DieselFuel/propulsion System

THE VEHICLE WAS VALET PARKED. THE VALET ATTENDANT REPORTED THAT THE VEHICLE SHUT DOWN AS SHE WAS DRIVING IT UP THE RAMP OUT OF THE PARKING GARAGE. SHE ALSO REPORTED A KNOCKING SOUND AND THAT THE "CHECK ENGINE" LIGHT WAS ON. UPON ENTERING THE VEHICLE, I WAS UNABLE TO START IT. I HAD THE VEHICLE TOWED TO THE VW DEALERSHIP. THEY…

Read full complaint

THE VEHICLE WAS VALET PARKED. THE VALET ATTENDANT REPORTED THAT THE VEHICLE SHUT DOWN AS SHE WAS DRIVING IT UP THE RAMP OUT OF THE PARKING GARAGE. SHE ALSO REPORTED A KNOCKING SOUND AND THAT THE "CHECK ENGINE" LIGHT WAS ON. UPON ENTERING THE VEHICLE, I WAS UNABLE TO START IT. I HAD THE VEHICLE TOWED TO THE VW DEALERSHIP. THEY TOLD ME THAT THE HIGH PRESSURE FUEL PUMP HAD FAILED AND THAT THEY HAD SEEN OTHER CARS COMING IN WITH THIS SAME PROBLEM. SERVICE DEPARTMENT PAPERWORK STATES: "DEFECTIVE HIGH PRESSURE PUMP-METAL IN SYSTEM" AND "FOUND FAULT P0191." VEHICLE SPEED AT TIME OF INCIDENT IS ESTIMATED BASED ON VALET ATTENDANT'S DESCRIPTION. *TR

NHTSA ODI #10492963

60,050 miles · Jan 14, 2013
EngineFuel/propulsion System

ON FRIDAY JAN. 11, 2013, THE VEHICLE (2010 VW JETTA TDI) IN QUESTION WAS TRAVELING ON AN EXPRESSWAY AT A SPEED OF APPROXIMATELY 50 MPH WHEN SUDDENLY THE GLOW PLUG LIGHT AND CHECK ENGINE WARNINGS TURNED ON THE VEHICLE DISPLAY AND SHORTLY AFTERWARDS THE ENGINE STALLED. THE VEHICLE STALLED IN THE MIDDLE OF THE ROAD BUT NO ACCIDENT …

Read full complaint

ON FRIDAY JAN. 11, 2013, THE VEHICLE (2010 VW JETTA TDI) IN QUESTION WAS TRAVELING ON AN EXPRESSWAY AT A SPEED OF APPROXIMATELY 50 MPH WHEN SUDDENLY THE GLOW PLUG LIGHT AND CHECK ENGINE WARNINGS TURNED ON THE VEHICLE DISPLAY AND SHORTLY AFTERWARDS THE ENGINE STALLED. THE VEHICLE STALLED IN THE MIDDLE OF THE ROAD BUT NO ACCIDENT OCCURRED BECAUSE THERE WAS NO OTHER TRAFFIC AT THE TIME OF FAILURE. ATTEMPTS TO START THE ENGINE FAILED.VEHICLE HAD TO BE PUSHED TO THE SIDE OF THE ROAD. VEHICLE WAS TOWED TO SERVICE LOCATION TO BE DIAGNOSED AND RESULTS WERE INDICATIVE THAT THE FUEL PUMP FAILED CATASTROPHICALLY RENDERING THE VEHICLE INOPERABLE. EXCESSIVE METAL SHARDS WERE EVIDENT ON THE FUEL FILTER. VEHICLE HAS NOT YET BEEN REPAIRED PENDING A RESPONSE FROM THE MANUFACTURER. SAME VEHICLE STALLED IN TRAFFIC AFTER BOUGHT NEW AT APPROXIMATELY 8000 MILES ON THE ODOMETER IN 2010 BUT ENGINE WAS ABLE TO BE RESTARTED. VOLKSWAGEN DEALERSHIP SERVICE DEPARTMENT PERFORMED DIAGNOSTIC FOR THE 1ST STALLING INCIDENT AND SAID THERE WAS NOTHING WRONG. NO SERVICE WAS PERFORMED TO CHECK FUEL SYSTEM AT THAT TIME. *TR

NHTSA ODI #10492418

55,000 miles · Dec 18, 2012
EngineVehicle Speed Control

THE CAR ABRUPTLY DECELERATED FROM 65 TO 35 MPH ON A MAJOR INTERSTATE AS THE ENGINE WENT INTO 'LIMP MODE'. THE SUDDEN DECELERATION CAUSED SWERVING AND I HAD TO PULL OVER TO THE CURB IN ORDER TO AVOID AN ACCIDENT. THE COIL/CHECK ENGINE LIGHT TURNED ON AND CAR HESITATED AS IT DROVE. THIS IS THE THIRD INCIDENT THAT THIS CAR HAS HAD …

Read full complaint

THE CAR ABRUPTLY DECELERATED FROM 65 TO 35 MPH ON A MAJOR INTERSTATE AS THE ENGINE WENT INTO 'LIMP MODE'. THE SUDDEN DECELERATION CAUSED SWERVING AND I HAD TO PULL OVER TO THE CURB IN ORDER TO AVOID AN ACCIDENT. THE COIL/CHECK ENGINE LIGHT TURNED ON AND CAR HESITATED AS IT DROVE. THIS IS THE THIRD INCIDENT THAT THIS CAR HAS HAD WITH THE EXHAUST PROBLEM CAUSING ENGINE TO FORCE DECELERATION AND ABRUPT STOPPING EVEN STALLING. THE SYSTEM THIS TIME DIAGNOSED A DEFECTIVE EXHAUST CONTROL MODULE/FLAP. THE PREVIOUS EMISSIONS ISSUE WHILE THE CAR WAS UNDER WARRANTY INVOLVED DEFECTIVE EGR VALVES. PROBLEM SEEMS TO SHOW UP EVERY 10-15K MILES ON THIS DIESEL MODEL. *TR

NHTSA ODI #10489093

41,000 miles · Dec 4, 2012
EngineFuel System, DieselFuel/propulsion System

HAPPENED LAST NIGHT, WITH MY 6 YR OLD DAUGHTER IN THE CAR, AND WIFE DRIVING ON THE FREEWAY! CHECK ENGINE LIGHT, AND FUEL INJECTOR/GLOW PLUG LIGHT BLINKING, CAR SHUTDOWN, BUT FORTUNATELY WAS ABLE TO PULL OFF TO THE SIDE BUT STILL NEXT TO FREEWAY ON/OFF RAMP. CAR WOULD CRANK OVER BUT NOT START. CALLED AAA TOW TO VW DEALER WHERE T…

Read full complaint

HAPPENED LAST NIGHT, WITH MY 6 YR OLD DAUGHTER IN THE CAR, AND WIFE DRIVING ON THE FREEWAY! CHECK ENGINE LIGHT, AND FUEL INJECTOR/GLOW PLUG LIGHT BLINKING, CAR SHUTDOWN, BUT FORTUNATELY WAS ABLE TO PULL OFF TO THE SIDE BUT STILL NEXT TO FREEWAY ON/OFF RAMP. CAR WOULD CRANK OVER BUT NOT START. CALLED AAA TOW TO VW DEALER WHERE THE CAR WAS PURCHASED. I DROVE THE CAR EARLIER THAT MORNING ON A FAIRLY LONG TRIP (OVER 100 MILES), AND STARTED NOTICING THE FUEL ECONOMY WASN'T AS GOOD AS I NORMALLY WOULD GET (40 MPG), BUT IT WAS RAINING HEAVY THAT MORNING SO THAT'S WHAT I ATTRIBUTED IT TO, BUT ONLY SEEING 30 MPG AFTER ALL FREEWAY DRIVING WAS SUSPICIOUS TO ME. VW DEALER SAID THE HIGH PRESSURE FUEL PUMP FAILED AND CONTAMINATED THE ENTIRE DIESEL FUEL SYSTEM AND ALL THE PARTS WILL NEED TO BE REPLACED AND FUEL SYSTEM CLEANED OUT. *TR

NHTSA ODI #10487273

72,010 miles · Nov 15, 2012
EngineFuel/propulsion SystemPower Train

MY 2010 VW JETTA SPORTWAGEN GOT THE GLOW PLUG LIGHT INTERMITTENT FLASH STARTING ON 72K MILES. IN THE COLD MORNING I COULD DRIVE 10-15 MINUTES WITHOUT ISSUE. HOWEVER, ONCE THE GLOW PLUG IS ON, IT COULD NOT EXCEED 40MPH. HERE'S THE DIAGNOSTIC FROM THE DEALERSHIP: 72017 CONFIRM MILE ON, GLOW PLUG LIGHT INTERMITTENT FLASH. PERFO…

Read full complaint

MY 2010 VW JETTA SPORTWAGEN GOT THE GLOW PLUG LIGHT INTERMITTENT FLASH STARTING ON 72K MILES. IN THE COLD MORNING I COULD DRIVE 10-15 MINUTES WITHOUT ISSUE. HOWEVER, ONCE THE GLOW PLUG IS ON, IT COULD NOT EXCEED 40MPH. HERE'S THE DIAGNOSTIC FROM THE DEALERSHIP: 72017 CONFIRM MILE ON, GLOW PLUG LIGHT INTERMITTENT FLASH. PERFORM GUIDED FAULT FINDING, FAULTS TORED P00AF. TURBOCHARGER BOOST PERFORMANCE VISUAL INSPECTION FOUND VACUUM HOSES GOOD. FOLLOWING TEST PLAN, CHECK N75 SOLENOID GOOD. CHECK WIRING TO G581 REF VOLT GOOD. PERFORM GFF FUNCTION TEST VACUUM DIAPHRAM GOOD. FUNCTION TEST N75 GOOD. VACUUM AT 9PSI. CHECK INTERNAL RESISTANCE AT BOOST ACTUATOR POSITION SENSOR OUT OF SPEC. REC REPLACE G581 CHARGE PRESSURE ACTUATOR POSITION SENSOR (WITHIN TURBO ASSEMBLY)... PARTS WILL NEED TO BE SPECIAL ORDERED $1,444.41 + TAX... *TR

NHTSA ODI #10484861

26,770 miles · Nov 8, 2012
EngineFuel System, Gasoline

GLOW PLUG LIGHT CAME LIT ON DASH AND SAID "SERVICE ENGINE IMMEDIATELY." ENGINE THEN LOST POWER ON INTERSTATE (DANGEROUS). WHEN RE-CRANKED, ENGINE WAS SLUGGISH AND WOULD NOT ACCELERATE ABOVE 40MPH. VW SERVICE SAID IT WAS DUE TO A FAULTY FUEL PUMP. *TR

NHTSA ODI #10483784

32,000 miles · Oct 26, 2012
EngineFuel/propulsion System

WHILE DRIVING 65 MPH ON THE FREEWAY IN OAKLAND, CA, THE ENGINE MALFUNCTION LIGHT CAME ON, MY CAR BEGAN TO SLOW DOWN, AND AS SOON AS I EXITED THE FREEWAY THE CAR STALLED AND STOPPED ALTOGETHER, AND WOULD NOT RESTART. I WAS TOWED TO THE OAKLAND VW DEALERSHIP. THEY INFORMED ME THAT THE FUEL PUMP HAD FAILED, AND HAD TO REPLACE THE…

Read full complaint

WHILE DRIVING 65 MPH ON THE FREEWAY IN OAKLAND, CA, THE ENGINE MALFUNCTION LIGHT CAME ON, MY CAR BEGAN TO SLOW DOWN, AND AS SOON AS I EXITED THE FREEWAY THE CAR STALLED AND STOPPED ALTOGETHER, AND WOULD NOT RESTART. I WAS TOWED TO THE OAKLAND VW DEALERSHIP. THEY INFORMED ME THAT THE FUEL PUMP HAD FAILED, AND HAD TO REPLACE THE FUEL PUMP, FILTER, FUEL LINES, ETC. THE DEALER SAID THAT THERE WERE SHARDS OF METAL THROUGHOUT THE FUEL LINES. THIS APPEARS RELATED TO NHTSA ENGINEERING ANALYSIS EA11-003. *TR

NHTSA ODI #10482361

43,000 miles · Oct 15, 2012
EnginePower Train

WHILE DRIVING ON THE HIGHWAY WITH CRUISE CONTROL ENGAGED AT/AROUND SPEED LIMIT, I NOTICED THE RPMS JUMPING AND COULD FEEL THE CAR JERKING, AS IF SOME KIND OF ACCELERATION/DECELERATION WAS HAPPENING. I ALSO NOTICE RPMS JUMP 50 UP/DOWN WHILE IDLING. THIS SEEMS TO HAPPEN WHEN DRIVING DOWN HILLS ON CRUISE CONTROL, MORE PREVALENT I…

Read full complaint

WHILE DRIVING ON THE HIGHWAY WITH CRUISE CONTROL ENGAGED AT/AROUND SPEED LIMIT, I NOTICED THE RPMS JUMPING AND COULD FEEL THE CAR JERKING, AS IF SOME KIND OF ACCELERATION/DECELERATION WAS HAPPENING. I ALSO NOTICE RPMS JUMP 50 UP/DOWN WHILE IDLING. THIS SEEMS TO HAPPEN WHEN DRIVING DOWN HILLS ON CRUISE CONTROL, MORE PREVALENT IN COLDER WEATHER. NO LOSS OF CONTROL HAS OCCURRED, BUT APPEARS TO BE ISSUE THAT IS SLOWLY WORSENING. *TR

NHTSA ODI #10480624

30,632 miles · Sep 3, 2012
EngineFuel System, DieselPower Train

HIGH PRESSURE FUEL PUMP FAILED TRAVELING 60MPH, CAR BEGINS TO STUMBLE (MORE OFTEN THEN EVERY HUNDRED MILES-NOW LESS THAN EVERY 5 MILES), ENGINE ALMOST DIES OUT MULTIPLE TIMES, RPM DROPS TO NEAR ZERO, CHECK ENGINE LIGHT TURNS ON, HUNDREDS OF MINI METAL FLAKES FOUND IN FUEL SYSTEM/FUEL CANISTER . CAR DRIVEN TO DEALER (SHOWED P…

Read full complaint

HIGH PRESSURE FUEL PUMP FAILED TRAVELING 60MPH, CAR BEGINS TO STUMBLE (MORE OFTEN THEN EVERY HUNDRED MILES-NOW LESS THAN EVERY 5 MILES), ENGINE ALMOST DIES OUT MULTIPLE TIMES, RPM DROPS TO NEAR ZERO, CHECK ENGINE LIGHT TURNS ON, HUNDREDS OF MINI METAL FLAKES FOUND IN FUEL SYSTEM/FUEL CANISTER . CAR DRIVEN TO DEALER (SHOWED PICTURE OF METAL IN FUEL CANISTER). HAMILTON IMPORTS (VW DEALER) HAD INITIAL TECH ON 081412 DIAGNOSIS PROBLEM AS "NORMAL FOR DIESEL FUEL." CALLED 081512 TO SERVICE MANAGER JOHN, LEFT MESSAGE, HE REPLIED STATING METAL IN FUEL IS "NORMAL." ON 081612 EMAIL VW OF AMERICA, IN REGARDS TO THE PROBLEM, CALL FROM SERVICE ADVISER ON 081712 AND ARE LOOKING FURTHER INTO THE PROBLEM. LATER THAT DAY, CALLED SERVICE ADVISER, THEY ORDERED A COMPLETE FUEL SYSTEM AND APOLOGIZED FOR THE INITIAL DELAY AND NOT FIXING THE CAR CORRECTLY. RECEIVED A CALL FROM THE DEALER, 082812, THE CAR IS READY FOR PICKUP. A COMPLETE NEW FUEL SYSTEM WAS INSTALLED (INJECTORS, HIGH PRESSURE FUEL PUMP(FAILED), FUEL RAIL, ELECTRIC FUEL PUMP IN TANK, ALL PIPING). *TR

NHTSA ODI #10473663

Official recalls

4

16V913000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Dec 20, 2016

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence & remedy

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional source detail variants (2)

Electronic Stability Control (esc)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

11V490000 · Fuel System, Diesel

Oct 3, 2011

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence & remedy

Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

10V621000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 10, 2010

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

Consequence & remedy

Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

09V333000 · Power Train:automatic Transmission

Aug 20, 2009

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.

Consequence & remedy

Consequence: THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: VOLKSWAGEN WILL REPROGRAM THE TRANSMISSION CONTROL MODULE WITH UPDATED SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA18003 · Air Bag Clockspring Failure

Opened Apr 18, 2018 · No close date supplied

Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Additional source detail variants (3)

Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags:frontal

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

PE11023 · Diesel Fuel Injector Line Leakage

Opened Aug 2, 2011 · Closed Dec 2, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.

EA11003 · High-Pressure Fuel Pump Failure

Opened Feb 7, 2011 · Closed Mar 27, 2015

Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Additional source detail variants (2)

Fuel System, Diesel

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

PE10034 · High Pressure Fuel Pump Failure (hpfp)

Opened Aug 26, 2010 · Closed Feb 8, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

The Office of Defects Investigation (ODI) and Volkswagen (VW) have received a total of 160 complaints and field reports alleging incidents of engine stall and/or loss of power that appear to be related to high pressure fuel pump (HPFP) failures in certain model year (MY) 2009 through 2010 Volkswagen Jetta and MY 2010 Volkswagen Golf and Audi A3 vehicles equipped with TDI clean diesel engines.Approximately half of the reports indicate that the failure resulted in an engine stall incident, with many of these alleging stall incidents at highway speeds in traffic with no restart.There has been one minor crash alleged to have resulted from HPFP failure in the subject vehicles.In response to ODI's information request for PE10-034, VW indicated that it had found no defect related to motor vehicle safety with relation to the TDI Clean Diesel fuel system at issue in this investigation and attributed problems with HPFP failure to operation with gasoline contaminated diesel fuel.Volkswagen stated that even a small amount of gasoline in the diesel fuel may disrupt the necessary lubrication required and may cause the HPFP to fail.In response to concerns that fuel contamination was the major cause of HPFP and related fuel system failures, VW issued a Technical Service Bulletin in May 2010 (VW TB V011011 2023624 and Audi TB A011008 2023360-1), with instructions to inspect the diesel fuel for vehicles requiring fuel system service that have symptoms associated with HPFP failure.The bulletin states that fuel system damage incurred by use of fuel not complying to ASTM-D-975 Grade 2 S15 (B5 or less biodiesel content) standards will not be covered under warranty. Volkswagen also provided information about 121 mis-fueling incidents reportedly acknowledged by consumers or dealers and test results for about 50 diesel fuel samples taken from complaint vehicles in late-August through early-October 2010.The mis-fueling incidents include about 20 reports involving incorrect fueling by dealer sales or service personnel and generally report symptoms such as rough running, stalling and/or no start within a few miles of refueling the vehicle with gasoline.Volkswagen indicated that the testing of fuel samples from complaint vehicles found that nearly 90 percent contained high amounts of gasoline.Volkswagen implemented design changes for the HPFP in May 2008, September 2009 and November 2010 to improve the robustness of the pump when used with poor quality fuel.ODI analysis of HPFP failures identified from all sources shows failure rates of 0.53% for MY 2009 vehicles and 0.11% for MY 2010 vehicles.This investigation has been upgraded to an Engineering Analysis (EA11-003) to continue to investigate the issues with mis-fueling and HPFP design identified during the Preliminary Evaluation.