← New search

2010 Volkswagen Jetta

Owner reports · Recalls · Investigations

More warning signs than most Jetta years

Owner complaints for the 2010 Volkswagen Jetta are substantially higher than the model-year median of 68.

About this comparison →

When problems were reported

Mileage at the reported incident

779 reports with mileage · 73 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Diesel. Review the 166 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports5 fire reports10 injury reports

Electrical System complaints

233 reports
Clear category filter
60,000 miles · Feb 8, 2013
Electrical System

VW JETTA TDI PURCHASED IN DECEMBER 2009 IN SAVANNAH, GA. THE REAR PASSENGER DOOR HAS HAD INTERMITTENT PROBLEMS WITH THE WINDOW BUMPING OFF THE TOP WHEN WE ATTEMPT TO CLOSE IT. IT THEN RETRACTS TO FULLY OPEN. THE MAIN PROBLEM CURRENTLY IS THE DOOR LOCK ON THE SAME DOOR. IT WILL NOT LOCK UNDER ANY TYPE OF ATTEMPT. I HAVE TRIE…

Read full complaint

VW JETTA TDI PURCHASED IN DECEMBER 2009 IN SAVANNAH, GA. THE REAR PASSENGER DOOR HAS HAD INTERMITTENT PROBLEMS WITH THE WINDOW BUMPING OFF THE TOP WHEN WE ATTEMPT TO CLOSE IT. IT THEN RETRACTS TO FULLY OPEN. THE MAIN PROBLEM CURRENTLY IS THE DOOR LOCK ON THE SAME DOOR. IT WILL NOT LOCK UNDER ANY TYPE OF ATTEMPT. I HAVE TRIED THE FOB, THE INTERIOR DOOR LOCK ON THE DRIVER DOOR, AND THE LOCK ON THE DOOR ITSELF. I TOOK IT TO THE DEALER WHO DETERMINED THAT I NEED A NEW LOCK ASSEMBLY AT THE COST OF $600. THEY LATER OFFERED A REDUCED PRICE OF $491. FORTUNATELY, I PURCHASED A WARRANTY WHEN I BOUGHT THE CAR AND I ONLY WILL BE CHARGED THE $100 DEDUCTIBLE. THANK GOODNESS. THE CAR HAS 60,000 MILES ON IT AND IT SEEMS A SHAME THAT THE CAR IS NOT SAFE AT THAT MINIMAL AMOUNT OF MILES. *TR

NHTSA ODI #10496871

59,500 miles · Jan 23, 2013
Electrical System

I WAS TRAVELING UP A MOUNTAIN ROAD WHEN MY CAR DECIDED TO TURN OFF. I HAD TO COAST ACROSS INCOMING TRAFFIC TO THE TURNOUT. I WAITED HERE UNTIL I WAS ABLE TO GET MY CAR STARTED AND WAS ABLE TO DRIVE HOME. I MADE AN APPOINTMENT FOR THE FOLLOWING DAY TO HAVE IT CHECKED OUT. I WAS TOLD IT WAS THE ENGINE SPEED SENSOR. THE EPC AN…

Read full complaint

I WAS TRAVELING UP A MOUNTAIN ROAD WHEN MY CAR DECIDED TO TURN OFF. I HAD TO COAST ACROSS INCOMING TRAFFIC TO THE TURNOUT. I WAITED HERE UNTIL I WAS ABLE TO GET MY CAR STARTED AND WAS ABLE TO DRIVE HOME. I MADE AN APPOINTMENT FOR THE FOLLOWING DAY TO HAVE IT CHECKED OUT. I WAS TOLD IT WAS THE ENGINE SPEED SENSOR. THE EPC AND ENGINE LIGHT WERE GOING ON INTERMITTENTLY. THERE WAS NO REASON THAT MY CAR SHOULD HAVE THESE PROBLEMS NOT COVERED BY WARRANTY WHEN IT IS ONLY ABOUT 2 YEARS OLD WITH LESS THAN 60,000 MILES ON IT. *TR

NHTSA ODI #10494495

60,000 miles · Dec 13, 2012
Electrical SystemVehicle Speed Control

I WAS DRIVING ON THE HIGHWAY DOING ABOUT 55 MILES AN HOUR WITH FULL TRAFFIC AND MY JETTA SPUTTERED AND BEGAN TO LOSE SPEED-QUICKLY, I TRIED TO ACCELERATE BY PRESSING GAS PEDAL BUT NOTHING HAPPENED AND I LUCKILY COASTED INTO STORE PARKING LOT. I TRIED TO RESTART IT BUT IT WOULD NOT RESTART. I HAD IT TOWED TO VW DEALERSHIP AND THE…

Read full complaint

I WAS DRIVING ON THE HIGHWAY DOING ABOUT 55 MILES AN HOUR WITH FULL TRAFFIC AND MY JETTA SPUTTERED AND BEGAN TO LOSE SPEED-QUICKLY, I TRIED TO ACCELERATE BY PRESSING GAS PEDAL BUT NOTHING HAPPENED AND I LUCKILY COASTED INTO STORE PARKING LOT. I TRIED TO RESTART IT BUT IT WOULD NOT RESTART. I HAD IT TOWED TO VW DEALERSHIP AND THEY CALLED ME THE NEXT DAY TO SAY IT WAS THE INTERCOOLANT SYSTEM AND IT WOULD BE 1300.00. VERY VERY LUCKY I WAS NOT HIT. *TR

NHTSA ODI #10488717

78,000 miles · Dec 3, 2012
Electrical SystemPower TrainFire

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE TRANSMISSION OVERHEAT WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT MOVED OFF THE ROADWAY AND RESTARTED THE VEHICLE, AS IT RESUMED PROPERLY. THE VEHICLE WAS TAKEN TO A DEALER FOR INSPECTION WHERE THEY ADVISED THE CON…

Read full complaint

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE TRANSMISSION OVERHEAT WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT MOVED OFF THE ROADWAY AND RESTARTED THE VEHICLE, AS IT RESUMED PROPERLY. THE VEHICLE WAS TAKEN TO A DEALER FOR INSPECTION WHERE THEY ADVISED THE CONTACT THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE DEALER ALSO STATED THAT WHILE PERFORMING AN INSPECTION OF THE VEHICLE, HE NOTICED THAT THE WIRES THAT WERE CONNECTED TO THE ALTERNATOR WERE BURNED AND THE FUSE BLOCK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 78,000.

NHTSA ODI #10487153

49,800 miles · Nov 23, 2012
Electrical SystemExterior Lighting

ON MONDAY, 11-19, AFTER WORK I NOTICED THAT THE BULB INDICATOR LIGHT WAS IN ON THE DASHBOARD. I GOT OUT AND WALKED AROUND THE CAR TO SEE WHAT WENT OUT AND COULD NOT FIND ANYTHING. AFTER GETTING BACK IN I SAW THAT THE LIGHT WAS OFF. THE NEXT DAY WHEN MY HUSBAND GOT IN THE CAR THE SAME INCIDENT HAPPENED. LATER THAT SAME DAY I DROV…

Read full complaint

ON MONDAY, 11-19, AFTER WORK I NOTICED THAT THE BULB INDICATOR LIGHT WAS IN ON THE DASHBOARD. I GOT OUT AND WALKED AROUND THE CAR TO SEE WHAT WENT OUT AND COULD NOT FIND ANYTHING. AFTER GETTING BACK IN I SAW THAT THE LIGHT WAS OFF. THE NEXT DAY WHEN MY HUSBAND GOT IN THE CAR THE SAME INCIDENT HAPPENED. LATER THAT SAME DAY I DROVE THE CAR AND THE LIGHT CAME ON. AS I TURNED INTO A FUEL STATION THE TURN SIGNAL BEGAN TO FLASH QUICKLY (INDICATING THE TURN SIGNAL WAS OUT). AFTER I REFUEL THE LIGHTS ALL CAME BACK ON. NO PROBLEMS WERE NOTICED UNTIL THURSDAY, 11-22, WHEN MY HUSBAND STARTED THE CAR AND THE INDICATOR LIGHT WAS ON AND HE GOT OUT TO CHECK AND THE PASSENGER TURN SIGNALS WAS OUT, ALONG WITH THE PASSENGER HEADLIGHT, AND THE WHOLE DRIVER SIDE TAIL LIGHT ASSEMBLY IS OUT. *TR

NHTSA ODI #10485818

56,000 miles · Sep 29, 2012
Air BagsElectrical SystemStructure

THE SEAL BETWEEN THE CONNECTORS AND THE DRAIN HOSE FOR THE SUNROOF DRAINS LEAK (THREE OF FOUR CONNECTORS), ALLOWING WATER TO RUN DOWN THE BOTH DRIVER AND PASSENGER SIDE A-PILLARS. THIS RESULTED IN THE AIRBAG AND ITS ASSOCIATED MOUNTS/WIRING AND HARNESS GETTING SOAKED. THE WATER CONTINUED DOWN THE A PILLARS TO COLLECT IN THE FR…

Read full complaint

THE SEAL BETWEEN THE CONNECTORS AND THE DRAIN HOSE FOR THE SUNROOF DRAINS LEAK (THREE OF FOUR CONNECTORS), ALLOWING WATER TO RUN DOWN THE BOTH DRIVER AND PASSENGER SIDE A-PILLARS. THIS RESULTED IN THE AIRBAG AND ITS ASSOCIATED MOUNTS/WIRING AND HARNESS GETTING SOAKED. THE WATER CONTINUED DOWN THE A PILLARS TO COLLECT IN THE FRONT WHEEL WELLS. THE PATH OF THE WATER WAS OVER/THROUGH THE DRIVERS SIDE INTERIOR JUNCTION/FUZE BLOCK. THE REAR DRAINS ALSO LEAK, CAUSING INTERMITTENT ELECTRICAL MALFUNCTIONS. NOTE THAT THIS LEAK IS NOT DUE TO THE DRAINS BEING BLOCKED. RATHER THE SEALS BETWEEN THE WHITE PLASTIC THAT CONNECTS TO THE DRAIN AND THE BROWN DRAIN HOSE IS NOT COMPLETE. THIS ALLOWS WATER TO DRIP DOWN ONTO THE FRAME. AS MUCH AS 2-3 GALLONS OF WATER COULD ENTER DURING A MILD RAIN STORM. *TR

NHTSA ODI #10477473

54,000 miles · Aug 20, 2012
Electrical SystemPower Train

CAR HAS HAD ISSUES 4K ON. CAR WOULD ACCELERATE ON ITS OWN FROM 70 MPH TO 75 LIKE WIDE OPEN THROTTLE. CAR WILL QUIT AT HIGHWAY SPEEDS 70 MPH (NO POWER STEERING, NO BRAKES, JUST THE SERVICE ENGINE NOW AND GLOWPLUG LIGHT ARE ON FLASHING,(50K ON) THIS HAS HAPPENED 4 TIMES, CAR WILL QUIT MAKING A RIGHT HAND TURN HITTING POTHOLE (50…

Read full complaint

CAR HAS HAD ISSUES 4K ON. CAR WOULD ACCELERATE ON ITS OWN FROM 70 MPH TO 75 LIKE WIDE OPEN THROTTLE. CAR WILL QUIT AT HIGHWAY SPEEDS 70 MPH (NO POWER STEERING, NO BRAKES, JUST THE SERVICE ENGINE NOW AND GLOWPLUG LIGHT ARE ON FLASHING,(50K ON) THIS HAS HAPPENED 4 TIMES, CAR WILL QUIT MAKING A RIGHT HAND TURN HITTING POTHOLE (50K ON). TOTAL DPF SYSTEM HAS BEEN CHANGED OUT TWO TIMES FROM TWO DEALERS , 3 TOTAL WITH ORIGINAL. ERRATIC EGR SIGNAL WAS ALWAYS TRIPPING CHECK ENGINE LIGHT, SOME FAULTS BUT NOT ALL ARE EXHAUST GAS RECIRC FLOW INSUFFICIENT DETECTED SPORADIC, CYLINDER 2 INJECTOR N31 OPEN CIRCUIT SPORADIC, EXHAUST AFTERTREATMENT FUEL SUPPLY CONTROL PERFORMANCE SPORADIC, THROTTLE ACTUATOR CONTROL MOTOR CIRCUIT RANGE/PERFORMANCE SPORADIC, NAVIGATION ANTENNA (GPS) SHORT TO EARTH. DEALERS HAVE SPENT OVER 20 THOUSAND DOLLARS PARTS AND LABOR, IN 4 DIFFERENT SHOPS OVER 83 DAYS (OVERNIGHT), OVER 95 INCLUDING READING CODES ONLY. OUT OF WARRANTY EXPENDITURES OVER 1 THOUSAND DOLLARS SO FAR. 69,000 MILES AND THE DEALER TECH HAS NO IDEA HOW TO FIX THIS CAR, HE STARTED OUT SAYING HE HAS NEVER SEEN A CAR HE CAN'T FIX. I HAVE OVER 50 PAGES OF DEALER DOCUMENTED FAULTS AND REPAIRS, REPROGRAMMING ECU, WAS REPLACED THIS YEAR TO SEE IF THAT WOULD FIX PROBLEMS, SOME GONE BUT NOW MAJOR ISSUES LISTED ABOVE ARE HAPPENING. REPLACED DIESEL PARTICULATE FILTER 2 TIMES, REPLACED O2 SENSORS, REPLACED EGR SENSORS AND GASKETS 2 TIMES, REPLACE THROTTLE POSITION SENSOR, REPLACED PRESSURE SENSOR. ONLY ITEM NOT REPLACED IS THE WIRING HARNESS. *TR

NHTSA ODI #10471620

Mileage unknown · Mar 13, 2012
Electrical System

HORN IS EXTREMELY HARD TO PRESS AND ACTIVATE. HORN DOES NOT SOUND WITH NORMAL AND TYPICAL PRESSURE TO THE STEERING WHEEL PAD. HORN DOES NOT ACTIVATE EVEN WITH POUNDING TO THE PRESS PAD. HORN HAS REPEATEDLY FAILED TO ACTIVATE WHEN ATTEMPTING TO WARN. THIS SEEMS TO BE A SERIOUS SAFETY ISSUE, BUT THE DEALERSHIP SERVICE DEPT HAS…

Read full complaint

HORN IS EXTREMELY HARD TO PRESS AND ACTIVATE. HORN DOES NOT SOUND WITH NORMAL AND TYPICAL PRESSURE TO THE STEERING WHEEL PAD. HORN DOES NOT ACTIVATE EVEN WITH POUNDING TO THE PRESS PAD. HORN HAS REPEATEDLY FAILED TO ACTIVATE WHEN ATTEMPTING TO WARN. THIS SEEMS TO BE A SERIOUS SAFETY ISSUE, BUT THE DEALERSHIP SERVICE DEPT HAS ADVISED IT CANNOT BE ADJUSTED OR REPAIRED. *TR

NHTSA ODI #10451358

44,000 miles · Dec 8, 2011
Electrical SystemStructure

WHILE AT THE DEALER FOR FUEL PUMP FAILURE THE CAR WAS FOUND TO HAVE ANOTHER SERIOUS ISSUE. THERE WAS A SEAL GOING IN TO THE COWLING THAT HAD LEAKED AND CAUSED A MAJOR AMOUNT OF WATER TO LEAK IN TO THE CABIN OF THE VEHICLE, RIGHT WHERE THE ELECTRICAL COMPONENTS AND FUSE PANEL ARE. THIS CAUSED MAJOR DAMAGE AND THE CAR TO STALL / N…

Read full complaint

WHILE AT THE DEALER FOR FUEL PUMP FAILURE THE CAR WAS FOUND TO HAVE ANOTHER SERIOUS ISSUE. THERE WAS A SEAL GOING IN TO THE COWLING THAT HAD LEAKED AND CAUSED A MAJOR AMOUNT OF WATER TO LEAK IN TO THE CABIN OF THE VEHICLE, RIGHT WHERE THE ELECTRICAL COMPONENTS AND FUSE PANEL ARE. THIS CAUSED MAJOR DAMAGE AND THE CAR TO STALL / NOT RUN DUE TO THE WATER DAMAGE. LUCKILY THIS WAS FOUND WHILE THE VEHICLE WAS NOT MOVING, OTHERWISE THE CAR WOULD HAVE STOPPED RUNNING DUE TO VOLKSWAGEN'S ERROR OF NOT HAVING A SEALED ACCESS PORT TO THE INTERIOR OF THE VEHICLE. *TR

NHTSA ODI #10439099

44,000 miles · Dec 8, 2011
Electrical SystemFuel System, Diesel

DRIVING IN HEAVY TRAFFIC AT 45 MPH THE CAR DASH DINGED, I LOOKED DOWN AND IMMEDIATELY THE CAR LOST POWER. I WAS ALMOST IN MULTIPLE ACCIDENTS AS THE CAR SLOWED RAPIDLY WITHOUT BRAKE LIGHTS (THE CAR ENGINE STOPPED SO SUDDENLY THAT IT TOOK THREE OR FOUR SECONDS TO COMPREHEND THE SITUATION AND ACTIVATE HAZARD LIGHTS AND TAKE APPROPR…

Read full complaint

DRIVING IN HEAVY TRAFFIC AT 45 MPH THE CAR DASH DINGED, I LOOKED DOWN AND IMMEDIATELY THE CAR LOST POWER. I WAS ALMOST IN MULTIPLE ACCIDENTS AS THE CAR SLOWED RAPIDLY WITHOUT BRAKE LIGHTS (THE CAR ENGINE STOPPED SO SUDDENLY THAT IT TOOK THREE OR FOUR SECONDS TO COMPREHEND THE SITUATION AND ACTIVATE HAZARD LIGHTS AND TAKE APPROPRIATE ACTION) TO WARN OTHER CARS THAT I NO LONGER HAVE POWER. ALSO, TO TRY AND MOVE OUT OF HARMS WAY WAS EXTREMELY DIFFICULT AS THE CAR HAD NO ENGINE POWER. THE CAR WAS EVENTUALLY TOWED TO THE DEALER WHERE THEY DETERMINED THAT METAL FROM THE FUEL PUMP WAS IN THE ENTIRE FUEL SYSTEM. *TR

NHTSA ODI #10439098

Official recalls

4

16V913000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Dec 20, 2016

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence & remedy

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional source detail variants (2)

Electronic Stability Control (esc)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

11V490000 · Fuel System, Diesel

Oct 3, 2011

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence & remedy

Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

10V621000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 10, 2010

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

Consequence & remedy

Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

09V333000 · Power Train:automatic Transmission

Aug 20, 2009

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.

Consequence & remedy

Consequence: THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: VOLKSWAGEN WILL REPROGRAM THE TRANSMISSION CONTROL MODULE WITH UPDATED SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA18003 · Air Bag Clockspring Failure

Opened Apr 18, 2018 · No close date supplied

Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Additional source detail variants (3)

Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags:frontal

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

PE11023 · Diesel Fuel Injector Line Leakage

Opened Aug 2, 2011 · Closed Dec 2, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.

EA11003 · High-Pressure Fuel Pump Failure

Opened Feb 7, 2011 · Closed Mar 27, 2015

Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Additional source detail variants (2)

Fuel System, Diesel

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

PE10034 · High Pressure Fuel Pump Failure (hpfp)

Opened Aug 26, 2010 · Closed Feb 8, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

The Office of Defects Investigation (ODI) and Volkswagen (VW) have received a total of 160 complaints and field reports alleging incidents of engine stall and/or loss of power that appear to be related to high pressure fuel pump (HPFP) failures in certain model year (MY) 2009 through 2010 Volkswagen Jetta and MY 2010 Volkswagen Golf and Audi A3 vehicles equipped with TDI clean diesel engines.Approximately half of the reports indicate that the failure resulted in an engine stall incident, with many of these alleging stall incidents at highway speeds in traffic with no restart.There has been one minor crash alleged to have resulted from HPFP failure in the subject vehicles.In response to ODI's information request for PE10-034, VW indicated that it had found no defect related to motor vehicle safety with relation to the TDI Clean Diesel fuel system at issue in this investigation and attributed problems with HPFP failure to operation with gasoline contaminated diesel fuel.Volkswagen stated that even a small amount of gasoline in the diesel fuel may disrupt the necessary lubrication required and may cause the HPFP to fail.In response to concerns that fuel contamination was the major cause of HPFP and related fuel system failures, VW issued a Technical Service Bulletin in May 2010 (VW TB V011011 2023624 and Audi TB A011008 2023360-1), with instructions to inspect the diesel fuel for vehicles requiring fuel system service that have symptoms associated with HPFP failure.The bulletin states that fuel system damage incurred by use of fuel not complying to ASTM-D-975 Grade 2 S15 (B5 or less biodiesel content) standards will not be covered under warranty. Volkswagen also provided information about 121 mis-fueling incidents reportedly acknowledged by consumers or dealers and test results for about 50 diesel fuel samples taken from complaint vehicles in late-August through early-October 2010.The mis-fueling incidents include about 20 reports involving incorrect fueling by dealer sales or service personnel and generally report symptoms such as rough running, stalling and/or no start within a few miles of refueling the vehicle with gasoline.Volkswagen indicated that the testing of fuel samples from complaint vehicles found that nearly 90 percent contained high amounts of gasoline.Volkswagen implemented design changes for the HPFP in May 2008, September 2009 and November 2010 to improve the robustness of the pump when used with poor quality fuel.ODI analysis of HPFP failures identified from all sources shows failure rates of 0.53% for MY 2009 vehicles and 0.11% for MY 2010 vehicles.This investigation has been upgraded to an Engineering Analysis (EA11-003) to continue to investigate the issues with mis-fueling and HPFP design identified during the Preliminary Evaluation.