← New search

2010 Volkswagen Jetta

Owner reports · Recalls · Investigations

More warning signs than most Jetta years

Owner complaints for the 2010 Volkswagen Jetta are substantially higher than the model-year median of 68.

About this comparison →

When problems were reported

Mileage at the reported incident

779 reports with mileage · 73 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Diesel. Review the 166 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports5 fire reports10 injury reports

Electrical System complaints

233 reports
Clear category filter
65,000 miles · May 20, 2014
Electrical SystemEquipment

WELL OVER A 100 PEOPLE HAVE COMPLAINED ABOUT THE SAME EXACT ISSUE WITH THEIR 2010 VW TOUCH SCREEN RADIO DYING OUT OF NO WHERE. THE WEBSITE WITH ALL KNOWN COMPLAINTS IS AT: HTTP://WWW.CARGURUS.COM/CARS/DISCUSSION-T36009_DS552583. VW REFUSES TO BE ACCOUNTABLE FOR THEIR MERCHANDISE. WEAR AND TEAR ON ENGINE PARTS, COMPLETELY…

Read full complaint

WELL OVER A 100 PEOPLE HAVE COMPLAINED ABOUT THE SAME EXACT ISSUE WITH THEIR 2010 VW TOUCH SCREEN RADIO DYING OUT OF NO WHERE. THE WEBSITE WITH ALL KNOWN COMPLAINTS IS AT: HTTP://WWW.CARGURUS.COM/CARS/DISCUSSION-T36009_DS552583. VW REFUSES TO BE ACCOUNTABLE FOR THEIR MERCHANDISE. WEAR AND TEAR ON ENGINE PARTS, COMPLETELY UNDERSTANDABLE. A $1000 CRASHING OUT ON MULTIPLE 2010 VWS IS A TREND AND SHOULD BE HANDLED ACCORDINGLY BY A RESPONSIBLE ORGANIZATION. HOWEVER, THIS IS NOT THE CASE. VW CONSIDERS A RADIO A LUXURY ITEM AND WILL NOT REPAIR THE RADIO. *TR

NHTSA ODI #10592832

61,000 miles · May 20, 2014
Electrical System

SINCE 2010 I HAVE OWNED A VOLKSWAGEN JETTA TDI AND HAVE BEEN SATISFIED WITH ITS PERFORMANCE DESPITE A FEW MINOR ISSUES; HOWEVER, I HAVE SUDDENLY EXPERIENCED SERIOUS AND COSTLY ISSUES WITH MY TOUCH SCREEN RADIO THAT HAS FORCED ME TO TAKE ACTION. THE DEVICE SUDDENLY AND WITH NO WARING FAILED TO OPERATE IN ANY CAPACITY. I HAVE CONS…

Read full complaint

SINCE 2010 I HAVE OWNED A VOLKSWAGEN JETTA TDI AND HAVE BEEN SATISFIED WITH ITS PERFORMANCE DESPITE A FEW MINOR ISSUES; HOWEVER, I HAVE SUDDENLY EXPERIENCED SERIOUS AND COSTLY ISSUES WITH MY TOUCH SCREEN RADIO THAT HAS FORCED ME TO TAKE ACTION. THE DEVICE SUDDENLY AND WITH NO WARING FAILED TO OPERATE IN ANY CAPACITY. I HAVE CONSULTED WITH THE VW DEALERSHIP WHERE I HAVE MY VEHICLE MAINTENANCE AND IT WAS SUGGESTED THAT I REPLACE THE RADIO WITH THE SAME MODEL I CURRENTLY HAVE INSTALLED AT A COST TO ME OF $795. AFTER EXTENSIVE RESEARCH OF MANY HOURS AS WELL AS SPEAKING WITH OTHER VOLKSWAGEN ENTHUSIAST I HAVE COME TO THE FRIGHTENING CONCLUSION THAT THIS IS NOT AN ISOLATED INCIDENT OF PRODUCT MALFUNCTION. CONSIDERING VW RESPONSE TO WHAT APPEARS TO BE A WELL KNOWN AND DOCUMENTED PRODUCT DEFECT, MY NEXT STEPS ARE TO MAKE THE GENERAL PUBLIC AWARE OF VOLKSWAGENS GROSS NEGLIGENCE AND POOR CONSUMER RELATIONS IN THIS MATTER. I LOOK FORWARD TO A RESOLUTION TO THIS PROBLEM PLEASE CONTACT ME AT MY EMAIL ADDRESS OR BY PHONE AT [XXX] SINCERELY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #10592816

Mileage unknown · May 19, 2014
Electrical System

THE RADIO JUST SHUT OFF, CHECKED ALL FUSES, EVERYTHING OK. TOOK TO MECHANIC AND SAID RADIO NEEDS TO BE REPLACED. LOOKED ON THE INTERNET AND THERE HAVE BEEN MULTIPLE COMPLAINTS ABOUT THE ELECTRICAL RADIO SYSTEM FOR THE RADIO DISPLAY TOUCH SCREEN RADIO. THREE YEAR OLD CAR SHOULD NOT HAVE RADIO FAILURE. *JS

NHTSA ODI #10592441

27,000 miles · Apr 30, 2014
Electrical SystemEngine

FIRST INCIDENT: OCCURRED IN FALL 2012, EXACT DATE UNKNOWN. SLOWING TO TURN RIGHT, VEHICLE STALLED WITHOUT WARNING. POWER STEERING WAS NOT RESPONDING. IT WAS TAKEN TO DEALERSHIP THE NEXT DAY. VEHICLE WAS EVALUATED, NOTHING WAS FOUND. WE WERE TOLD THAT THEY COULD SEE SOME SORT OF POWER INTERRUPTION, BUT COULD FIND NOTHING WRONG …

Read full complaint

FIRST INCIDENT: OCCURRED IN FALL 2012, EXACT DATE UNKNOWN. SLOWING TO TURN RIGHT, VEHICLE STALLED WITHOUT WARNING. POWER STEERING WAS NOT RESPONDING. IT WAS TAKEN TO DEALERSHIP THE NEXT DAY. VEHICLE WAS EVALUATED, NOTHING WAS FOUND. WE WERE TOLD THAT THEY COULD SEE SOME SORT OF POWER INTERRUPTION, BUT COULD FIND NOTHING WRONG WITH ANY OF THE SYSTEMS INVOLVED. SECOND INCIDENT: OCCURRED ABOUT 1 MONTHS AFTER FIRST INCIDENT. WHILE SLOWING TO A STOP, INTENDING TO MAKE A LEFT TURN OUT OF PARKING LOT, AGAIN VEHICLE STALLED WITHOUT WARNING. DID NOT TAKE CAR TO DEALERSHIP, AS IT HAD JUST RECENTLY BEEN EVALUATED. GAS WAS < 1/8 TANK FILLED, AND PARKING LOT EXIT WAS ON A SLIGHT DECLINE, SUSPECTED MAYBE IT WAS RELATED TO LOW FUEL, AND WE TRIED TO KEEP THE CAR ABOVE 1/4 TANK FULL AT ALL TIMES THEREAFTER. THIRD INCIDENT: OCCURRED 4/29/14. SLOWING TO PULL INTO A PARKING SPACE, AGAIN ENGINE STALLED WITHOUT WARNING. I NOTED THAT THE BATTERY INDICATOR LIGHT ON THE DASHBOARD LIT UP SLIGHTLY BEFORE OR AS CAR WAS STALLING. POWER STEERING FAILED AS WELL WHEN CAR STALLED. RADIO / HEATER / OTHER ELECTRONICS SEEMED UNAFFECTED AFTER A BRIEF FLICKER. FOURTH INCIDENT: OCCURRED ABOUT 20 MINUTES LATER ON 4/29/14. SLOWING FOR A STOP LIGHT, VEHICLE STALLED UNEXPECTEDLY. CAR IS DUE FOR INSPECTION, APPOINTMENT IN 2 DAYS. DEALERSHIP ASKED TO INVESTIGATE STALLING AS WELL. *JS

NHTSA ODI #10585627

40,000 miles · Apr 25, 2014
Electrical SystemPower Train

CAR WOULD NOT MOVE FORWARD OR BACKWARD. HAD TO TURN OFF IGNITION, THEN CAR WAS FINE. APRIL 25TH PUT CAR IN DRIVE TO ENTER STREET FROM MY DRIVEWAY AND CAR SHOT BACKWARDS. TRIED THREE TIMES AND THE SAME THING OCCURRED. HUSBAND TURNED OFF IGNITION AND RESTARTED CAR. THIS TOOK CARE OF THE PROBLEM. WE HAVE AN APPOINTMENT WITH THE DEA…

Read full complaint

CAR WOULD NOT MOVE FORWARD OR BACKWARD. HAD TO TURN OFF IGNITION, THEN CAR WAS FINE. APRIL 25TH PUT CAR IN DRIVE TO ENTER STREET FROM MY DRIVEWAY AND CAR SHOT BACKWARDS. TRIED THREE TIMES AND THE SAME THING OCCURRED. HUSBAND TURNED OFF IGNITION AND RESTARTED CAR. THIS TOOK CARE OF THE PROBLEM. WE HAVE AN APPOINTMENT WITH THE DEALERSHIP ON MONDAY, APRIL 28TH CASE #[XXX]. FRANKLY, I DON'T THINK I WILL EVER AGAIN BE COMFORTABLE DRIVING THIS CAR. I WAS VERY LUCKY THIS HAPPENED IN MY DRIVEWAY AND NO ONE WAS BEHIND ME. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #10584891

53,500 miles · Jan 31, 2014
Electrical SystemEquipmentExterior Lighting

I BOUGHT MY 2010 JETTA USED IN JUNE 2013. A MONTH AFTER I PURCHASED IT, I NOTICED THE A/C WAS NOT WORKING. I RETURNED IT TO THE DEALER AND THEY CONFIRMED THAT THE A/C COMPRESSOR WASN'T WORKING. THEY INSTALLED A NEW ONE AND I DIDN'T HAVE A PROBLEM UNTIL 8/7/13. I WENT OUT TO START MY CAR AND NOTICED I HAD A LIGHT ON MY DASHBOARD.…

Read full complaint

I BOUGHT MY 2010 JETTA USED IN JUNE 2013. A MONTH AFTER I PURCHASED IT, I NOTICED THE A/C WAS NOT WORKING. I RETURNED IT TO THE DEALER AND THEY CONFIRMED THAT THE A/C COMPRESSOR WASN'T WORKING. THEY INSTALLED A NEW ONE AND I DIDN'T HAVE A PROBLEM UNTIL 8/7/13. I WENT OUT TO START MY CAR AND NOTICED I HAD A LIGHT ON MY DASHBOARD. I GOT OUT OF THE CAR AND NOTICED MY RIGHT FRONT PASSENGER SIDE HEADLIGHT OUT. I WALKED AROUND AND NOTICED THE DRIVERS SIDE REAR TAIL LIGHT WAS ALSO OUT. I GOT HOME AND WHEN I SHUT THE CAR OFF AND TURNED IT BACK ON, THE LIGHT ON THE DASH WAS OUT, AND ALL MY EXTERIOR LIGHTS WERE WORKING. IT WAS AROUND THIS TIME I NOTICED A BURNING SMELL WHENEVER I EXITED THE CAR, BUT I COULDN'T' PINPOINT WHERE IT WAS COMING FROM. I DIDN'T HAVE ANOTHER ISSUE UNTIL 10/25/14 WHEN I WAS VISITING FRIENDS 30 MILES AWAY. I WENT TO LEAVE, AND WHEN I STARTED MY CAR I ONCE AGAIN HAD THE LIGHT ON THE DASH, SO I GOT OUT AND NOTICED THE SAME LIGHTS WERE ONCE AGAIN OUT. I HAD TO DRIVE ON THE HIGHWAY LIKE THIS, BUT THANKFULLY WHILE I WAS DRIVING THEY ALL CAME BACK ON. THE CAR WAS FINE UNTIL 12/14/13 WHEN I WENT OUT TO START MY CAR IN THE MORNING AND ONCE AGAIN THE SAME LIGHTS WERE OUT. THE LAST TIME I HAD AN ISSUE WITH THIS WAS 1/7/14, IN THE MIDDLE OF A BLIZZARD. I GOT OUT OF WORK AND STARTED MY CAR TO CLEAR SNOW OFF IT, AND EVERYTHING WAS FINE. IT WASN'T UNTIL I TURNED THE HEADLIGHTS ON THAT I NOTICED THE LIGHT ON THE DASH WAS ON INDICATING I HAD A LIGHT OUT SOMEWHERE. I GOT OUT AND NOTICED THAT IN ADDITION TO THE SAME HEADLIGHT AND TAIL LIGHT BEING OUT, THE LICENSE PLATE LIGHTS WERE ALSO OUT. BY THE TIME I COULD GET IN THE CAR THEY WERE ALL WORKING AGAIN. I TOOK IT TO THE DEALERSHIP AND THEY CONFIRMED THE 30 AMP FUSE HAD OVERHEATED AND CAUSED THE FUSEBOX TO MELT (HENCE THE BURNING SMELL). $500 LATER MY CAR IS HOPEFULLY FIXED. THANKFULLY THE CAR DIDN'T BURN TO THE GROUND. *TR

NHTSA ODI #10562328

18,458 miles · Jan 28, 2014
Electrical SystemLatches/locks/linkagesStructure

WE HAVE OWNED THIS 2010 JETTA SPORTWAGEN TDI SINCE BRAND NEW. TODAY 1/28/14 IS THE FOURTH TIME WE HAVE HAD TO REPLACE THE LOCK MECHANISM ON ONE OF THE DOORS. PART NUMBERS 3B4-839-016-AP (LEFT REAR), 3B1-837-016-CG (RIGHT FRONT) AND 3B4-839-015-AP (RIGHT REAR) HAVE ALL BEEN REPLACED AT LEAST ONCE. RIGHT REAR LATCH HAS BEEN REPLAC…

Read full complaint

WE HAVE OWNED THIS 2010 JETTA SPORTWAGEN TDI SINCE BRAND NEW. TODAY 1/28/14 IS THE FOURTH TIME WE HAVE HAD TO REPLACE THE LOCK MECHANISM ON ONE OF THE DOORS. PART NUMBERS 3B4-839-016-AP (LEFT REAR), 3B1-837-016-CG (RIGHT FRONT) AND 3B4-839-015-AP (RIGHT REAR) HAVE ALL BEEN REPLACED AT LEAST ONCE. RIGHT REAR LATCH HAS BEEN REPLACED TWICE - ONLY ONCE UNDER WARRANTY. IN LOOKING ON NHTSA WEB SITE THERE ARE 8 OTHER REPORTS OF PROBLEMS WITH LATCHES IN THE 2010 JETTA. THIS IS A SERIOUS SAFETY CONCERN BECAUSE MOST OF THE REPORTS (INCLUDING MINE) WERE FOR DOORS THAT WOULD NOT UNLOCK AND DOORS THAT WOULD NOT OPEN NO MATTER WHAT THE REPORTING PARTY TRIED. CAN YOU IMAGINE IF THESE LATCHES FAILED IN AN ACCIDENT AND CHILDREN SITTING IN THE REAR SEATS WERE TRAPPED? *TR

NHTSA ODI #10561940

47,700 miles · Dec 13, 2013
Electrical SystemEngineFuel System, Gasoline

WHEN MAKING A LEFT HAND TURN CAR STALLS. DASH PANEL LIGHTS GO OUT AND BATTERY WARNING LIGHT FLASHES AND CAR SHUTS OFF. CAR HAS TO BE COMPLETELY STOPPED,IGNITION TURNED TO THE OFF POSITION AND PUT INTO PARK, BEFORE IT CAN RESTART. VERY DANGEROUS WHEN DRIVING IN HIGH TRAFFIC AREAS. YOU DON'T HAVE TIME TO PULL OVER. THE CAR JUS…

Read full complaint

WHEN MAKING A LEFT HAND TURN CAR STALLS. DASH PANEL LIGHTS GO OUT AND BATTERY WARNING LIGHT FLASHES AND CAR SHUTS OFF. CAR HAS TO BE COMPLETELY STOPPED,IGNITION TURNED TO THE OFF POSITION AND PUT INTO PARK, BEFORE IT CAN RESTART. VERY DANGEROUS WHEN DRIVING IN HIGH TRAFFIC AREAS. YOU DON'T HAVE TIME TO PULL OVER. THE CAR JUST DIES! *TR

NHTSA ODI #10555950

100 miles · Dec 4, 2013
Electrical SystemLatches/locks/linkages

REMOTE CONTROL DOOR LOCKS. SINCE I PURCHASED MY 2010 VW JETTA TDI AS A NEW VEHICLE, THE REMOTE CONTROL KEY HAS RANDOMLY NOT FUNCTIONED PROPERLY TO UNLOCK THE DOORS OR TRUNK. THE PROBLEM IS NOT DUE TO RFI. IT CAN ALWAYS BE IMMEDIATELY CORRECTED BY USING THE MANUAL KEY TO UNLOCK THE VEHICLE, WHICH SEEMS TO RESET THE LOCKING SYSTE…

Read full complaint

REMOTE CONTROL DOOR LOCKS. SINCE I PURCHASED MY 2010 VW JETTA TDI AS A NEW VEHICLE, THE REMOTE CONTROL KEY HAS RANDOMLY NOT FUNCTIONED PROPERLY TO UNLOCK THE DOORS OR TRUNK. THE PROBLEM IS NOT DUE TO RFI. IT CAN ALWAYS BE IMMEDIATELY CORRECTED BY USING THE MANUAL KEY TO UNLOCK THE VEHICLE, WHICH SEEMS TO RESET THE LOCKING SYSTEM AND ALLOWS THE REMOTE KEY TO UNLOCK THE DOORS OR TRUNK REMOTELY. I HAVE BROUGHT THIS TO THE ATTENTION OF THE DEALER AT EVERY VISIT. THE DEALER HAS LOOKED INTO IT, BEEN UNABLE TO REPLICATE THE PROBLEM, HAS REPROGRAMMED THE LOCKS. IT CONTINUES TO BE A RANDOM PROBLEM THAT I MYSELF CAN'T PREDICT OR REPLICATE ON DEMAND, BUT WANT OTHERS TO KNOW ABOUT THIS ANNOYANCE. *TR

NHTSA ODI #10554830

92,368 miles · Nov 15, 2013
Electrical SystemExterior Lighting

WHILE STARTING MY CAR AND GETTING READY FOR WORK I NOTICED I HAD A HEADLAMP OUT. I THOUGHT I COULD DRIVE TO WORK SAFELY SO, I STARTED MY COMMUTE. HOWEVER, ON STOPPING TO GET COFFEE I NOTICED I HAD TAILLIGHTS OUT AND UPON FURTHER TESTING BRAKE LIGHTS WERE FAILING TO. I STOPPED AT A AUTOPARTS STORE TO REPLACE THE TAIL LIGHTS AN…

Read full complaint

WHILE STARTING MY CAR AND GETTING READY FOR WORK I NOTICED I HAD A HEADLAMP OUT. I THOUGHT I COULD DRIVE TO WORK SAFELY SO, I STARTED MY COMMUTE. HOWEVER, ON STOPPING TO GET COFFEE I NOTICED I HAD TAILLIGHTS OUT AND UPON FURTHER TESTING BRAKE LIGHTS WERE FAILING TO. I STOPPED AT A AUTOPARTS STORE TO REPLACE THE TAIL LIGHTS AND NOTICED THAT I HAD LOST THE OTHER HEADLAMP AND BACKUP LIGHTS. I DECIDED TO PARK THE CAR AND CALL THE DEALERSHIP FOR ADVICE. I HAD THE CAR TOWED (TO DANGEROUS TO DRIVE) TO THE DEALERSHIP AND AT THAT TIME IT WAS DIAGNOSED OF HAVING A BURNED FUSE PANEL BOX. IT WAS REPLACED FOR A TOTAL OF $533.11 DOLLARS. THE REASON I AM REPORTING THIS IS I READ AN ARTICLE IN MY LOCAL NEWSPAPER (ZANESVILLE TIMES RECORDER)ABOUT THE SAME THING HAPPENING IN VW TIGUANS. I WANTED TO BRING TO LIGHT THAT IT IS HAPPENING IN VW JETTA'S ALSO. MY CAR IS A 2010 VW JETTA DIESEL. THE HIGH MILEAGE IS DUE TO A 110 MILE ROUND TRIP DAILY COMMUTE. I HAVE THE BURNED FUSE BOX PANEL IN MY POSSESSION IF YOU WOULD LIKE IT FOR INSPECTION. *TR

NHTSA ODI #10552456

Official recalls

4

16V913000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Dec 20, 2016

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence & remedy

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional source detail variants (2)

Electronic Stability Control (esc)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

11V490000 · Fuel System, Diesel

Oct 3, 2011

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence & remedy

Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

10V621000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 10, 2010

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

Consequence & remedy

Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

09V333000 · Power Train:automatic Transmission

Aug 20, 2009

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.

Consequence & remedy

Consequence: THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: VOLKSWAGEN WILL REPROGRAM THE TRANSMISSION CONTROL MODULE WITH UPDATED SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA18003 · Air Bag Clockspring Failure

Opened Apr 18, 2018 · No close date supplied

Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Additional source detail variants (3)

Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags:frontal

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

PE11023 · Diesel Fuel Injector Line Leakage

Opened Aug 2, 2011 · Closed Dec 2, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.

EA11003 · High-Pressure Fuel Pump Failure

Opened Feb 7, 2011 · Closed Mar 27, 2015

Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Additional source detail variants (2)

Fuel System, Diesel

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

PE10034 · High Pressure Fuel Pump Failure (hpfp)

Opened Aug 26, 2010 · Closed Feb 8, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

The Office of Defects Investigation (ODI) and Volkswagen (VW) have received a total of 160 complaints and field reports alleging incidents of engine stall and/or loss of power that appear to be related to high pressure fuel pump (HPFP) failures in certain model year (MY) 2009 through 2010 Volkswagen Jetta and MY 2010 Volkswagen Golf and Audi A3 vehicles equipped with TDI clean diesel engines.Approximately half of the reports indicate that the failure resulted in an engine stall incident, with many of these alleging stall incidents at highway speeds in traffic with no restart.There has been one minor crash alleged to have resulted from HPFP failure in the subject vehicles.In response to ODI's information request for PE10-034, VW indicated that it had found no defect related to motor vehicle safety with relation to the TDI Clean Diesel fuel system at issue in this investigation and attributed problems with HPFP failure to operation with gasoline contaminated diesel fuel.Volkswagen stated that even a small amount of gasoline in the diesel fuel may disrupt the necessary lubrication required and may cause the HPFP to fail.In response to concerns that fuel contamination was the major cause of HPFP and related fuel system failures, VW issued a Technical Service Bulletin in May 2010 (VW TB V011011 2023624 and Audi TB A011008 2023360-1), with instructions to inspect the diesel fuel for vehicles requiring fuel system service that have symptoms associated with HPFP failure.The bulletin states that fuel system damage incurred by use of fuel not complying to ASTM-D-975 Grade 2 S15 (B5 or less biodiesel content) standards will not be covered under warranty. Volkswagen also provided information about 121 mis-fueling incidents reportedly acknowledged by consumers or dealers and test results for about 50 diesel fuel samples taken from complaint vehicles in late-August through early-October 2010.The mis-fueling incidents include about 20 reports involving incorrect fueling by dealer sales or service personnel and generally report symptoms such as rough running, stalling and/or no start within a few miles of refueling the vehicle with gasoline.Volkswagen indicated that the testing of fuel samples from complaint vehicles found that nearly 90 percent contained high amounts of gasoline.Volkswagen implemented design changes for the HPFP in May 2008, September 2009 and November 2010 to improve the robustness of the pump when used with poor quality fuel.ODI analysis of HPFP failures identified from all sources shows failure rates of 0.53% for MY 2009 vehicles and 0.11% for MY 2010 vehicles.This investigation has been upgraded to an Engineering Analysis (EA11-003) to continue to investigate the issues with mis-fueling and HPFP design identified during the Preliminary Evaluation.