TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHILE ATTEMPTING TO SHIFT GEARS AT 10 MPH, THE CLUTCH PEDAL DROPPED TO THE FLOOR AND THE VEHICLE WOULD NOT SHIFT. THE VEHICLE WAS PUSHED OFF THE ROAD AND TOWED. THIS IS THE SECOND TIME THAT THE CLUTCH HAS FAILED AND THE ASSEMBLY WAS REPLACED. THE CURRENT MILEAGE WAS 17,000 AND FAI…
Read full complaint
TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHILE ATTEMPTING TO SHIFT GEARS AT 10 MPH, THE CLUTCH PEDAL DROPPED TO THE FLOOR AND THE VEHICLE WOULD NOT SHIFT. THE VEHICLE WAS PUSHED OFF THE ROAD AND TOWED. THIS IS THE SECOND TIME THAT THE CLUTCH HAS FAILED AND THE ASSEMBLY WAS REPLACED. THE CURRENT MILEAGE WAS 17,000 AND FAILURE MILEAGE WAS 1,900.
NHTSA ODI #10199706
29,000 miles · Aug 7, 2007
Power Train
DUAL MASS FLYWHEEL LEAKING FROM CENTER HUB CLUTCH FAILURE. *TR
NHTSA ODI #10198790
48,000 miles · Aug 4, 2007
Power Train
ONLY 48,000 MILES ON THE CAR AND THE CLUTCH/FLYWHEEL ARE SHOT. ACCORDING TO AN INDEPENDENT TRANS SHOP THIS IS THE SECOND TIME ITS BEEN REBUILT WITH VW PARTS. *JB
NHTSA ODI #10198480
15,000 miles · Aug 3, 2007
Power Train
FAULTY CLUTCH AND FLYWHEEL. FLYWHEEL BLEW APART AND DESTROYED CLUTCH. THE INCIDENT NEARLY CAUSED AN ACCIDENT WHICH COULD HAVE POSSIBLY KILLED MY ENTIRE FAMILY. *JB
NHTSA ODI #10198466
58,000 miles · Aug 3, 2007
Power Train
FLYWHEEL AND CLUTCH CATASTROPHIC FAILURE. CLUTCH PEDAL WENT COMPLETELY TO FLOOR AND ENGINE SEIZED UP. CLUTCH WOULD NOT DISENGAGE ENGINE AND WAS SEIZED UP. DRIVER WAS OPERATING VEHICLE AT LOW SPEED WHEN FAILURE OCCURRED. IF FAILURE HAD HAPPENED AT HIGHWAY SPEEDS IT LIKELY WOULD HAVE RESULTED IN HIGH-SPEED WRECK. *TR
NHTSA ODI #10198392
1,000 miles · Aug 3, 2007
Power Train
CLUTCH ASSEMBLY IN BOTH MY 2006 VW JETTA'S HAD TO BE REPLACED, BECAUSE OF INCORRECT ASSEMBLY AT PLANT. ONE IS RUNNING WELL, THE OTHER ONE IS STILL NOT RUNNING PROPERLY. *TR
NHTSA ODI #10198388
43,700 miles · Aug 1, 2007
Power Train
CLUTCH IN MY 2006 JETTA TDI (MANUFACTURED 02/06) WENT OUT WHILE DRIVING DOWN THE HIGHWAY AT 70 MPH. I LOST ABILITY TO SHIFT GEARS AND VEHICLE IS CURRENTLY AT THE DEALERSHIP FOR REPAIRS. DEALER SAYS THAT IT IS THE CLUTCH BUT FROM WHAT I HAVE RESEARCHED THESE CARS (MANUFACTURED BEFORE 03/06) HAVE A FAULTY DUAL MASS FLYWHEEL THAT…
Read full complaint
CLUTCH IN MY 2006 JETTA TDI (MANUFACTURED 02/06) WENT OUT WHILE DRIVING DOWN THE HIGHWAY AT 70 MPH. I LOST ABILITY TO SHIFT GEARS AND VEHICLE IS CURRENTLY AT THE DEALERSHIP FOR REPAIRS. DEALER SAYS THAT IT IS THE CLUTCH BUT FROM WHAT I HAVE RESEARCHED THESE CARS (MANUFACTURED BEFORE 03/06) HAVE A FAULTY DUAL MASS FLYWHEEL THAT COMES APART AND THEN TEARS UP THE CLUTCH. *JB
NHTSA ODI #10198215
20,100 miles · Jul 27, 2007
Power Train
I WENT TO STOP AT A LIGHT PUSHED IN MY CLUTCH AND WHEN IT GOT TO THE FLOOR IT CLICKED EVER SO QUIETLY AND WOULDN'T RETURN TO ENGAGED POSITION. I PULLED THE CLUTCH PEDAL BACK UP OFF THE FLOOR AND NOW IT CAN'T BE PUSHED MORE THAN 3/4 OF THE WAY TO THE FLOOR AND IF YOU TRY WHILE THE ENGINE IS RUNNING YOU GET AN AWFUL GRINDING NOISE…
Read full complaint
I WENT TO STOP AT A LIGHT PUSHED IN MY CLUTCH AND WHEN IT GOT TO THE FLOOR IT CLICKED EVER SO QUIETLY AND WOULDN'T RETURN TO ENGAGED POSITION. I PULLED THE CLUTCH PEDAL BACK UP OFF THE FLOOR AND NOW IT CAN'T BE PUSHED MORE THAN 3/4 OF THE WAY TO THE FLOOR AND IF YOU TRY WHILE THE ENGINE IS RUNNING YOU GET AN AWFUL GRINDING NOISE. CLUTCH PLATE FLEW APART. *JB
NHTSA ODI #10197682
41,000 miles · Jul 23, 2007
Power Train
CLUTCH FLYWHEEL PROBLEMS WITH MY 2006 JETTA TDI. LEFT ME STRANDED ON HIGHWAY WITH ONLY 41 K MILES ON IT. THE VEHICLE IS IN THE SHOP AND UNDER REVIEW. I'M CONCERNED OVER THE NUMBER OF CLUTCH FAILURES AT SUCH LOW MILEAGE. I AM VERY GENTLE WITH MY CLUTCH. *TR
NHTSA ODI #10197245
33,400 miles · Jul 7, 2007
Power Train
AT 65 MPH THERE WAS A BRIEF LOCKUP OF THE FRONT WHEELS, STALLING OF THE ENGINE FOLLOWED BY A LOUD MECHANICAL GRINDING NOISE. STOPPED VEHICLE, POPPED HOOD, NOTED ENGINE TO SHAKE VIOLENTLY TO THE EXTENT THAT THE OIL DIPSTICK CAME LOOSE. BROUGHT VEHICLE TO DEALERSHIP. INFORMED BY SERVICE THAT FAILURE IS DUE TO DISINTEGRATION OF THE…
Read full complaint
AT 65 MPH THERE WAS A BRIEF LOCKUP OF THE FRONT WHEELS, STALLING OF THE ENGINE FOLLOWED BY A LOUD MECHANICAL GRINDING NOISE. STOPPED VEHICLE, POPPED HOOD, NOTED ENGINE TO SHAKE VIOLENTLY TO THE EXTENT THAT THE OIL DIPSTICK CAME LOOSE. BROUGHT VEHICLE TO DEALERSHIP. INFORMED BY SERVICE THAT FAILURE IS DUE TO DISINTEGRATION OF THE DUAL MASS FLYWHEEL LOCATED BETWEEN THE ENGINE AND THE AUTOMATIC TRANSMISSION. DEBRIS FROM THE FLYWHEEL LEAD TO DESTRUCTION OF THE TRANSMISSION HOUSING. LATER, WHEN TALKING TO A MECHANIC, FOUND OUT THAT THIS IS THE SECOND JETTA WITH THE DSG AUTOMATIC TRANSMISSION THAT HAD A DMF FAILURE IN ADDITION TO THREE CATASTROPHIC DMF FAILURES ON MANUAL TRANSMISSION JETTAS). AS THIS HAS THE POTENTIAL TO LEAD TO COMPLETE LOCKUP OF THE FRONT WHEELS AT HIGHWAY SPEEDS WITH POTENTIALLY DIRE CONSEQUENCES, I BELIEVE THAT THIS IS A SAFETY RELEVANT ISSUE THAT MIGHT WARRANT BEING ADDRESSED BY NHTSA. *AK
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.
Consequence & remedy
Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
VOLKSWAGEN IS RECALLING 25,594 MY 2006-2009 JETTA 5TH GENERATION EQUIPPED WITH 2.01 ENGINE. THE FASTENING SCREW CONTACT SURFACES ON THE DRIVESHAFT COVER PLATE MAY NOT HAVE BEEN MANUFACTURED TO FACTORY SPECIFICATIONS. SOME SCREWS MAY NOT HAVE BEEN TORQUED PROPERLY DURING ASSEMBLY AND COULD LOOSEN OVER TIME, CAUSING A KNOCKING SOUND WHEN THE VEHICLE IS IN MOTION. THE DRIVESHAFT SCREWS COULD LOOSEN TO THE POINT WHERE THE DRIVESHAFT DETACHES FROM THE GEARBOX.
Consequence & remedy
Consequence: IF THE VEHICLE IS MOVING WHEN THIS HAPPENS, THE DETACHED DRIVESHAFT COULD CAUSE DAMAGE THE GEARBOX HOUSING. A DAMAGE GEARBOX HOUSING COULD LEAK GEARBOX OIL ONTO THE STREET AND CREATE A RISK OF A VEHICLE CRASH FOR BOTH THE DRIVER AND OTHER MOTORISTS.
Remedy: DEALERS WILL INSPECT THE DRIVESHAFT SCREWS AND REPLACE THE SCREWS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 24, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.
Consequence & remedy
Consequence: NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.
CERTAIN VEHICLES EQUIPPED WITH 2.5L GASOLINE ENGINES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST THE UNDERHOOD FUEL SUPPLY LINE.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE CHAFING HAS THE POTENTIAL TO CAUSE A FUEL LEAK OVER TIME. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR AND WILL ALSO INSPECT AND, IF NECESSARY, REPLACE THE UNDERHOOD FUEL SUPPLY LINE. THE RECALL BEGAN ON AUGUST 24, 2007. OWNERS MAY CONTACT VW AT 1-800-893-5298.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2006 Volkswagen Jetta Problems, Complaints & Recalls | Skip That Year
Illustration