2005 Volkswagen Jetta

THE AIRBAG LIGHT HAS COME ON 4 TIMES IN MY 2005 NEW JETTA 2.5 THE SEAT BELT SENSORS IN FRONT HAVE BEEN REPLACED ONCE AT DEALERSHIP, THIS STARTED WHEN THE CAR HAD ONLY 22000 MILES AND KEPT COMING ON AROUND EVERY 10000 MILES, THEY HAD TO ALSO REPLACE THE AIRBAG(S) NOT SURE WHICH ONES WERE REPLACED, THE SEATBEALTS DON'T WIND BACK UP PROPERLY SOMETIMES AS WELL. AT AROUND 25000 MILES THE BRAKES HAD TO BE REPLACED, WE HEARD A CLICKING ONE DAY IN THE REAR WHEEL WELL, WE TOOK IT TO THE DEALERSHIP THEY HAD REPLACED THE BRAKES, ROTORS ETC. I HAVE DOCUMENTATION OF THESE REPAIRS. *TR

I WAS DRIVING DOWN THE ROAD AT ABOUT 30 MPH WHEN MY CAR STALLED IN THE MIDDLE OF THE ROAD AND MY DRIVER SIDE AIRBAGS HAD BEEN DEPLOYED. MY SEATBELT RESTRICTED SO HARD, I COULD HARDLY BREATHE ANYMORE. NOTHING HAD HIT MY CAR AND I HAD NOT GONE OVER ANY POTHOLES OR BUMPS. VW SAID THAT IT IS NOT THEIR RESPONSIBILITY TO REPAIR MY AIRBAGS OR THE DAMAGE DONE TO MY HEADLINER AND DRIVER SEAT. I NO LONGER HAVE A FUNCTIONING SEATBELT EITHER. THIS IS A HUGE SAFETY ISSUE FOR AMERICA. NOT ONLY DID THE AIRBAGS DEPLOY WITH NO ACCIDENT, I NO LONGER FEEL SAFE DRIVING IN MY OWN VEHICLE. WHAT IF I GET INTO AN ACCIDENT TONIGHT WITHOUT THE PROPER PROTECTION A CAR IS GUARANTEED TO HAVE? IF I WAS KILLED OR MY KIDS WERE KILLED, WOULD VW DO SOMETHING THEN? *TR

THE VOLKSWAGEN TDI 1.9L ENGINE WHEN COUPLED TO THE DSG( DIRECT SHIFT GEAR) TRANSMISSION HAS AN EXTREMELY HIGH FAILURE RATE OF THE DMF (DUAL MASS FLYWHEEL). FAILURES HAVE OCCURRED BETWEEN 10K AND 100K MILES. THE INTERNAL CONSTRUCTION OF THE FLYWHEEL IS IMPROPER AND WILL SEPARATE LEADING TO THE TOTAL FAILURE OF THE UNIT. WHEN THE UNIT FAILS IT CAUSES A VERY SPECIFIC AND POTENTIALLY DEADLY SET OF CIRCUMSTANCES. THE DMF CAN SEPARATE AND THEN FRACTURE INTO LARGE SHRAPNEL TYPE PIECES. THIS SHRAPNEL WILL THE CAUSE THE TRANSMISSION AND POSSIBLY THE ENGINE TO SEIZE. WHEN THE SEIZURE OCCURS IS CAUSES THE FRONT TIRES TO LOCK AND SUBSEQUENT LOSS OF CONTROL OF THE VEHICLE RESULTING IN POSSIBLE INJURY OR DEATH. THE SHRAPNEL CAN ALSO CAUSE THE FAILURE OF THE TRANSMISSION CASE RESULTING IT THE LOSS OF PRESSURIZED TRANSMISSION FLUID. THIS FLUID CAN CONTACT THE TURBOCHARGER AND RESULT IN AN UNDER HOOD FIRE. CATASTROPHIC ENGINE FAILURE IS COMMON AS WELL. VWA(VOLKSWAGEN OF AMERICA) IS AWARE OF THIS PROBLEM AND HAS REDESIGNED THE DMF. THE NEW DESIGN HAS NOT FAILED. THE DMF HAS BEEN RECALLED IN THE EUROPEAN UNION AND AUSTRALIA AS A SAFETY CONCERN . VWA HAS BEEN SUCCESSFUL IN NOT COVERING THIS REPAIR UNDER EVEN IT'S STANDARD WARRANTY. NO VOLUNTARY RECALL HAS BEEN ISSUED. I CURRENTLY HAVE AN EXAMPLE OF THE FAILED PART AVAILABLE. THIS MODEL HAS THE POTENTIAL TO CAUSE INJURY OR DEATH ON A LARGE SCALE IF NOT ADDRESSED. *TR

MY DAUGHTER HIT THE BACK OF A VOLVO SUV WITH HER 2005 VW JETTA AND NOT 1 AIR BAG DEPLOYED LEAVING HER IN THE HOSPITAL FOR A MONTH'S STAY WITH MAJOR BRAIN TRAUMA AND $100,000 + DOLLARS IN MEDICAL BILLS INSTEAD OF A MINOR TRIP TO THE EMERGENCY ROOM FOR AIR BAG DEPLOYMENT. HER ENTIRE FRONT END IS IN THE WINDSHIELD. (WE HAVE PHOTOS).BECAUSE SHE HIT THE VOLVO AT THE WRONG ANGLE, WAS THE DETERMINED REASONING AS TO WHY THE AIR BAGS DIDN'T DEPLOY. ARE YOU KIDDING ME. LET'S TAKE A CLOSER LOOK INTO VW'S ADVERTISEMENTS FOR SAFETY. MY DAUGHTER WAS FOOLED BY THIS NONSENSE AND THE REST OF THE COUNTRY IS BEING FOOLED ALSO. I WILL PURSUE THIS FOR CORRECTION FOR AS LONG AS NEED BE.LET'S HOPE THE BOARD GETS ON BOARD WITH THIS UNSAFE ISSUE! "AIRBAGS ONLY DEPLOY IF YOU HIT THE FRONT END AT A CERTAIN ANGLE? AGAIN< ARE YOU KIDDING ME? I'M SURE JOHN.Q. PUBLIC WILL BE VERY INTERESTED TO SEE THESE PIX ONLINE. *TR

ON FEBRUARY 16TH WHILE RUNNING ERRANDS I PULLED THROUGH A DRIVE THROUGH FOR LUNCH, CAR WAS RUNNING AND SOUNDED JUST FINE, AFTER PULLING AWAY I HEARD A LOUD "SHRIEKING" NOISE AND THEN A CLUNK, THE CAR LOST POWER AND MADE A GRINDING NOISE, I IMMEDIATELY PULLED INTO THE ADJACENT PARKING LOT AND SHUT THE CAR OFF, I WAITED A FEW MINUTES THEN RESTARTED THE CAR IT STARTED JUST FINE BUT SEEMED TO BE IDLING A LITTLE ROUGH, I SHIFTED CAR INTO DRIVE AND LIGHTLY PRESSED THE ACCELERATOR THE GRINDING NOISE WAS PRESENT SO I PUT THE CAR BACK IN PARK AND SHUT OFF THE ENGINE, CALLED AAA AND HAD THE CAR TOWED TO THE DEALERSHIP. THE DEALERSHIP THEN CALLED ME LATER THAT AFTERNOON AND INFORMED ME THAT THE DUAL MASS FLYWHEEL HAD SEPARATED AND WOULD NEED TO BE REPLACED, THEY QUOTED ME $1800 FOR THE REPAIR. I WAS INFORMED THAT THEY HAD THE PART IN STOCK AND I APPROVED THE REPAIR. THE CAR JUST HAD 64,381 MILES AND I THOUGH IT WAS ODD THAT THIS FAILURE OCCURRED, I DID SOME RESEARCH ON THE INTERNET AND DISCOVERED THAT THIS IS A "KNOWN" FAILURE. SINCE THE WARRANTY "JUST" EXPIRED I HAD TO PAY FOR THE REPAIR. I CONTACTED VW0FA AND THEY TOOK THE INFORMATION BUT DID STATE THE WARRANTY EXPIRED, I UNDERSTAND THAT BUT IT APPEARS THAT THIS ISSUE HAS BEEN REPORTED NUMEROUS TIMES AND THIS NEEDS TO BE INVESTIGATED! I HAD JUST EXITED THE INTERSTATE BEFORE THIS HAPPENED, WHAT WOULD HAVE BEEN THE OUTCOME IF I STAYED ON THE FREEWAY AT 60MPH AND THIS COMPONENT FAILED?*TR

TL*THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. IN APRIL OF 2007, THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V063000 (EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH). THE VEHICLE WAS REPAIRED AT THAT TIME. APPROXIMATELY A YEAR AND A HALF LATER, THE BRAKE LIGHT SWITCH BEGAN TO FAIL AGAIN. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE BRAKE LIGHT SWITCH WOULD NOT STOP ILLUMINATING ON THE INSTRUMENT PANEL AND THE VEHICLE WOULD NOT SHIFT GEARS. THE VEHICLE WAS TURNED OFF APPROXIMATELY THREE TIMES AND, FINALLY, THE BRAKE LIGHT DIMMED AND THE VEHICLE BECAME MOBILE. THE FAILURE OCCURRED INTERMITTENTLY FOR ONE MONTH AND THE CONTACT CALLED THE DEALER. SHE WAS INFORMED THAT THE BRAKE LIGHT SWITCH WAS DEFECTIVE. THE MANUFACTURER STATED THAT SINCE THE FAILURE OCCURRED MORE THAN TWELVE MONTHS LATER, THEY WERE NOT LIABLE FOR THE REPAIRS. THE CURRENT MILEAGE WAS 71,707 AND FAILURE MILEAGE WAS 71,207. UPDATED 03-09-09 *BF THE SHIFTER WOULD NOT COME OUT OF PARK. THE FUEL PUMP WAS NOISEY AND WHICH WAS REPLACED BY THE DEALER. UPDATED 03/12/09.*JB

2005 VW JETTA CLUTCH FAILURE AT 26K MILES. THERE IS NO WEAR AND TEAR ON THE VEHICLE, BUT MY CLUTCH WENT OUT WHILE DRIVING DOWN HIGHWAY. WITH CAR DISABLED, THIS CAN CAUSE AN ACCIDENT. VW WON'T COVER THIS UNDER WARRANTY BECAUSE THEY DEEM THE CLUTCH AS A NORMAL WEAR AND TEAR ITEM. I HAVE READ NUMEROUS DISCUSSION BOARDS WHERE PEOPLE HAVE HAD THE SAME ISSUE. IT'S TIME FOR A RECALL OF THESE DEFECTIVE CLUTCHES. THEY ARE NOT GOING OUT BECAUSE OF NORMAL WEAR AND TEAR. DEFECTIVE CLUTCHES WERE MADE AND PUT IN THESE CARS AND VW IS MAKING CUSTOMERS PAY FOR THEIR MISTAKES. IF I HAD BEEN IN A REMOTE LOCATION, I COULD'VE BEEN STRANDED ON THE SIDE OF THE ROAD FOR HOURS AND COULD'VE BEEN STRUCK BY ANOTHER VEHICLE. ALSO, WITH THE CLUTCH NOT WORKING, IF I HAD BEEN DRIVING FAST, WHEN I APPLIED THE BREAKS, IT COULD'VE JERKED TO A HALT AND I COULD'VE LOST CONTROL OF VEHICLE. THIS IS NOT ACCEPTABLE. *TR

ON THE NIGHT OF 25 DEC 2008 MY VEHICLE STALLED IN THE MIDDLE OF AN INTERSECTION. THE VEHICLE WOULD NOT START BACK UP, THE IGNITION WAS CYCLED SEVERAL TIMES AND ASSISTANCE WAS REQUIRED TO GET THE VEHICLE OUT OF THE INTERSECTION TO A SAFE LOCATION. THE NEXT MORNING THE VEHICLE STARTED WITH NO ISSUES. IT WAS ADVISED THAT THE FUEL FILTER BE REPLACED AND THAT WAS DONE IMMEDIATELY ON THE MORNING ON 26 DEC 2008. THE SAME EVENING THE VEHICLE STALLED ONCE MORE IN THE MIDDLE OF A MAIN ROAD. IT IS FORTUNATE THAT THE VEHICLE WAS ON A DECLINE AND TRAFFIC WAS MOVING RATHER SLOW WHICH ALLOWED THE VEHICLE TO COAST TO A SAFE TURN-OFF POINT. THREE HOURS LATER THE VEHICLE WAS ABLE TO START ONCE MORE AND MADE IT TO A SAFE LOCATION WHERE THE FUEL PUMP (AKA IN TANK LIFT PUMP) COULD THEN BE REPLACED. A NEW FUEL PUMP WAS ORDERED AND REPLACED ON 29 DEC 2008 AND THE OLD PUMP WAS TESTED AND DEEMED TO HAVE FAILED. THERE WERE NO WARNING SIGNS OF FAILURE, NO ERROR CODES PRODUCED BY THE VEHICLE AND NO MEANS OF SAFELY BEING ABLE TO MOVE THE VEHICLE AFTER IT STALLED. THE VEHICLE HAS BEEN OPERATING WITH THE NEW FUEL PUMP WITHOUT INCIDENT. *TR