2004 Volkswagen Jetta

TL* - THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA GLS. THE CONTACT'S VEHICLE REAR ENDED ANOTHER VEHICLE WHILE TRAVELING 45 MPH. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS DESTROYED. THE CURRENT AND FAILURE MILEAGE WERE 38,000. THE CONTAACT SUSTAINED MINOR INJURIES, AND DID NOT REMEMBER IF HE WAS BELTED. A POLICE REPORT WAS TAKEN. THE CONTACT HAD PICTURES OF THE VEHICLE, AND SUBMITTED PICTURES TO THE MANUFACTURER. THE MANUFACTURER STATED THAT AFTER REVIEWING THE PICTURES THE AIR BAGS PERFORMED PROPERLY.*AK

THERE WAS SOME NOISE COMING FROM THE ENGINE, THEN THE DIRECTION LIGHTS DID NOT WORK, NOR DID THE INTERIOR FAN WORK. THEN I NOTICED SMOKE COMING UP FROM UNDER THE HOOD (ENGINE HOOD). I PULLED OVER AND STOP THE CAR AND TURNED OFF THE ENGINE. SMOKE CONTINUED TO COME OUT FROM THE ENGINE COMPARTMENT. IT WAS AN ELECTRICAL FIRE. THE SMELL WAS AWFUL. THERE WERE NO FLAMES TO BE SEEN. WHEN I OPENED THE HOOD THERE WAS LOTS OF SMOKE. THE DEALERSHIP INFORMED ME TODAY THAT THE IGNITION GOT STUCK IN THE ON MODE AND THIS BURNT OUT THE STARTER. THE FIRE WAS FROM THE STARTER BEING IN THE ON MODE AND BURNING ITSELF OUT. THE DEALERSHIP HAS ORDERED THE PARTS AND WILL REPLACE THEM. THE CAR IS STILL UNDER WARRANTY. *JB

ON 1/25/2007 OUR VEHICLE WAS TAKEN IN TO DEALER SERVICE DEPARTMENT FOR REPAIR OF AN ENGINE VIBRATION. INITIAL DIAGNOSIS WAS THE TIMING BELT AND IT WAS ADJUSTED APPROXIMATELY 4 DEGREES AND PROMISED TO BE READY ON 1/27/07. BELT ADJUSTMENT DID NOT FIX THE PROBLEM AND CAR WAS NOT PICKED UP. ADDITIONAL DIAGNOSIS WAS PERFORMED, INCLUDING COMPRESSION TEST OF ENGINE, AND TECHNICIAN CONTACTED VOLKSWAGEN FOR ASSISTANCE. AFTER WEEKS OF DIAGNOSIS AND TESTING WE WERE TOLD THAT THE IN TANK FUEL PUMP THAT WAS REPLACED AT A DIFFERENT VW DEALERSHIP ON 9/11/06 HAD FAILED. RESEARCHING NHTSA I ALSO FOUND OUT THAT IT WAS A RECALLED PUMP. BECAUSE THE MILEAGE WAS ALMOST 3K OVER THE WARRANTY OF THE PART AND VW ALREADY SATISFIED THE RECALL VW WOULD NOT COVER A REPLACEMENT. THE NEW FUEL PUMP ALSO DID NOT FIX THE VIBRATION PROBLEM. DEALERS DIAGNOSIS WITH VOLKSWAGEN'S ASSISTANCE CONTINUED UNTIL 2/8/07 WHEN WE WERE TOLD THAT A VALVE LIFTER IN THE CAM ASSEMBLY HAD FAILED CAUSING THE VIBRATION. DEALERSHIP RECOMMENDED A COMPLETE "CYLINDER HEAD REPLACEMENT" AT A COST OF ABOUT $4,500. MY HUSBAND ASKED TO SPEAK WITH THE MECHANIC AND DETERMINED THAT THE DAMAGE WAS ONLY TO ONE VALVE LIFTER. MY HUSBAND AND I DECIDED TO FIX WHAT WAS BROKEN AND ONLY FIXED THE DAMAGED LIFTER WHICH WAS ESTIMATED AT ABOUT $500. THE DEALER AGREED TO PERFORM THIS REPAIR, BUT WOULD NOT WARRANTY THE WORK BECAUSE THEY WERE CONCERNED THAT CYLINDER HEAD MIGHT BE FAULTY. OUR VEHICLE WAS FINALLY REPAIRED AND ABLE TO BE PICKED UP ON 2/19/07. COST OF REPAIRS WAS NEGOTIATED WITHIN OUR SATISFACTION, HOWEVER, THE SERVICE WAS NOT TIMELY AND FEEL THAT THE PARTS IN THE VEHICLE ARE BELOW STANDARD. NOW WE HAVE AN ADDITIONAL PROBLEM WE DID NOT HAVE BEFORE TAKING IT IN FOR REPAIR. TWO DAYS AFTER WE RECEIVED THE VEHICLE FROM THE DEALERSHIP WE FIGURED OUT THE FUEL GAUGE IS NO LONGER WORKING PROPERLY AND HAS A FALSE READING OF APPROXIMATELY 1/4 TANK WHEN THE TANK IS EMPTY. *JB

FUEL PUMP LEAK. THE FUEL PUMP WAS FOUND TO BE LEAKING BY THE DEALERSHIP. THE DEALERSHIP COULD NOT EXPLAIN WHERE THE LEAK WAS COMING FROM OTHER THEN SAYING 'THE FUEL PUMP', THEY COULD NOT SAY IF THE PUMP PART WAS COVERED UNDER THE PREVIOUS RECALL IN 2005, THEY COULD NOT SAY IF THE PUMP WAS REPLACED UNDER THAT RECALL OR GIVE ANY INFORMATION ABOUT THE PREVIOUS RECALL. *JB

I PURCHASED MY 2004 VW JETTA GLI 1.8T LAST AUGUST. IT HAD 21,000 MILES WHEN I PURCHASED IT. AT ABOUT 23,000 TO 24,000 MILES I WAS DRIVING ON THE INTERSTATE AND WITH NO PRIOR WARNINGS THE CLUTCH POPPED. THINKING THAT IT WAS THE PREVIOUS OWNER THAT CAUSED THE PROBLEM I HAD THE CAR TOWED TO A NON VOLKSWAGENS DEALER THINKING THAT IT WAS NOT STILL UNDER WARRANTY( WHICH IT WASN'T). THE REPAIR SHOP TOLD ME THAT IT WAS "DRIVER ERROR" THAT CAUSE THE PROBLEM AND I ASSUMED THAT IT WAS THE PREVIOUS OWNER. I PAID THE $1500 FOR THE REPAIRS AND ABOUT 25,000 TO 26,000 MILES LATER IT WENT OUT AGAIN. I ONCE AGAIN HAD IT TOWED TO THE REPAIR SHOP AND WAS ONCE AGAIN TOLD THAT IT WAS "DRIVER ERROR" THAT CAUSE THE PROBLEM. I PAID THE $1500 AGAIN AND KEPT DRIVING. THEN ABOUT 200 OR 300 MILES LATER THE CLUTCH WENT OUT AGAIN. THIS TIME I SENT IT TO A VOLKSWAGEN DEALER AND HAD THEM LOOK AT IT. AFTER ABOUT A WEEK AND A HALF WITHOUT A CAR THEY FINALLY FIXED THE PROBLEM AND ONCE AGAIN BLAMED IT ON "DRIVER ERROR." BY THIS TIME I WAS SURE THAT THERE WAS SOMETHING THAT BOTH DEALERS WERE MISSING SO I CALLED THE FIRST REPAIR SHOP AND THEY SENT THE SERVICE MANAGER TO TALK TO THE SERVICE MANAGER AT THE VW DEALERSHIP. BOTH HAD REPLACED THE EXACT SAME THREE PARTS AND BOTH THINK THAT IT WAS BECAUSE OF "DRIVER ERROR." IF IT WAS DRIVER ERROR THEN WHY IS THE TIME BETWEEN EACH CLUTCH GETTING SHORTER BUT ITS THE SAME PROBLEM EVERY TIME? SO I PAID MY $2000 AND LEFT AND NOW HAVE SPENT $5000 ON A CAR I EXPECTED TO LAST ME OVER 100,000 MILES. THERE IS DEFINITELY SOMETHING WRONG WITH THE VW CLUTCH.

TWO AIR BAGS DEPLOYED (DRIVER'S SIDE, CURTAIN AND SEAT) ON MY 2004 VW JETTA W/35,000KM WHILE DRIVING AT 15KM/H, NO BODY DAMAGE, NO FLAT TIRE. VW WILL NOT COVER THE REPAIRS, SAID TO CALL INSURANCE, NOT A "SENSOR" ISSUE, CRASH DATA RECORDED OF COURSE SINCE THE AIR BAGS DEPLOYED - AND WHAT IS DISTURBING IS THAT THIS COULD EASILY HAPPEN AGAIN IN A POT HOLE, FLAT TIRE, SPEED BUMP AND VW DOES NOT SEEM BE BOTHERED BY THAT FACT... BUT I SHOULD PAY FOR THIS OVER AND OVER AND/OR MAKE CLAIMS WITH MY INSURANCE... TOLD THEM THAT IF THEIR AIR BAGS WERE SO SENSITIVE, THEY SHOULD POST WARNINGS IN THE VEHICLE. VERY DISGUSTED WITH VW AND THE CAR IS STILL AT THE DEALERSHIP AND I AM SURE THEY ARE ANXIOUS TO HAVE IT REMOVED FROM THEIR LOT BECAUSE THEY KEEP CALLING TO SEE IF I CONTACTED MY INSURANCE... *NM

ABOUT 2 YEARS AGO I PURCHASED A 2004 VOLKSWAGEN JETTA 1.8T WITH THE MANUAL TRANSMISSION (4 YEARS/48,000 MILE WARRANTY). A COUPLE OF WEEKS AGO, I NOTICED THAT I HAD LESS AND LESS POWER TO DRIVE THE CAR WHEN IT WAS IN GEAR. ON DECEMBER 7, I BROUGHT THE CAR TO THE ORIGINAL DEALERSHIP WHERE I PURCHASED THE VEHICLE. I WAS TOLD THAT THE CLUTCH HAD WORN OUT AND WAS NOT COVERED UNDER WARRANTY. THUS, THE COST OF THE REPAIR ON THE VEHICLE WAS GOING TO BE $1,800! MY CAR HAS 30,700 MILES ON IT, I AM 34 YEARS OLD AND THERE ARE CERTAIN DAYS WHEN I DRIVE IT LESS THAN 5 MILES A DAY! OF COURSE, I WAS TOLD BY MY CAR-SALESMAN, THE SERVICE MANAGER, THE TELEPHONE OPERATORS AT VOLKSWAGEN AND THE GENERAL MANGER AT THE PLACE WHERE I PURCHASED THE VEHICLE THAT I (THROUGH POOR DRIVING HABITS AND LITTLE EXPERIENCE DRIVING A CLUTCH) WORE IT OUT. I REQUESTED TO PERSONALLY SPEAK TO THE AREA SERVICE REPRESENTATIVE FROM VOLKSWAGEN YET, I WAS NEVER GIVEN HIS/HER CONTACT INFORMATION. IN ADDITION, I GAVE MY CONTACT INFORMATION TO THE DEALERSHIP TO HAVE THEM REACH THE VOLKSWAGEN SERVICE REPRESENTATIVE TO HAVE THEM CONTACT ME. OVERALL, I WAS NEVER ABLE TO SPEAK TO THIS INDIVIDUAL. I HAD 6 YEARS OF DRIVING EXPERIENCE ON A FORD WITH NO CLUTCH PROBLEMS. I ALSO DID SOME RESEARCH AND FOUND AN INTERESTING WEB SITE HTTP://WWW.MYVWLEMON.COM/UBB/FORUM1/HTML/000155.HTML IT WAS INTERESTING TO READ OTHER INDIVIDUALS WITH THE SAME PROBLEM AS MINE (SOME DIFFERENT YEAR DATES THAN MY CAR)! *NM

DT*: THE CONTACT STATED WHILE TRAVELING 35 MPH, THE DRIVER SIDE CURTAIN AIRBAG AND THE REAR LEFT PASSENGER SIDE CURTAIN AIR BAG DEPLOYED WITHOUT WARNING, PUSHING THE CONTACT TO THE RIGHT SIDE OF THE VEHICLE, AND DAMAGING THE SEAT BELT. A POLICE REPORT AND PHOTOS WERE TAKEN OF THE VEHICLE. THE CONTACT SUSTAINED A WELT ON THE LEFT HIP FROM THE AIRBAG. THE VEHICLE WAS DRIVEN TO A RESIDENCE. THE SERVICE DEALER WAS NOTIFIED AND THE VEHICLE WAS TAKEN TO THE DEALER THE NEXT MORNING. THE MANUFACTURER WAS NOTIFIED.