TRANSMISSION SOMETIMES JUST DOESN'T WANT TO SHIFT PROPERLY I WAS DRIVING ALONG RT 50 AT 60 MPH WHEN THE CAR JERKS REALLY HARD AND LOSS OF POWER ALMOST GOT RAN OVER BY SEMI CALLED VW WHO IS AWARE OF VALVE BODY DEFECT AND THEY TOLD ME THAT IT WAS INDEED MY FAULT FOR DRIVING IT LIKE THAT IT JUST HAPPENED WAITING ON CALL FROM VWOA P…
Read full complaint
TRANSMISSION SOMETIMES JUST DOESN'T WANT TO SHIFT PROPERLY I WAS DRIVING ALONG RT 50 AT 60 MPH WHEN THE CAR JERKS REALLY HARD AND LOSS OF POWER ALMOST GOT RAN OVER BY SEMI CALLED VW WHO IS AWARE OF VALVE BODY DEFECT AND THEY TOLD ME THAT IT WAS INDEED MY FAULT FOR DRIVING IT LIKE THAT IT JUST HAPPENED WAITING ON CALL FROM VWOA PROBABLY WILL LEAD NO WHERE I WANT THIS FIXED ASKED FOR HELP TO GET PARTS OR ECT I KNOW THERE WAS OPEN RECALL ON THIS BUT MY CAR EXCEEDS YEAR AND MILEAGE BUT A SAFETY RECALL IS JUST THAT SO PLEASE RESEARCH AND SEE IF IT WAS PREFORMED ON MY VEHICLE I AM SURE IT WAS NOT ADDRESSED BUT THEY SENT LETTERS OUT FOR THIS MYSTERY RECALL ALSO I CAN LEAD TO OTHER INTERNAL FAILURES OF TRANS OR REPLACEMENT MY SPEEDO ALSO JUMPS 10-15 MILES UP AND DOWN OTHER TIMES IT WILL WORK YOU CAN CONTACT STATE HWY PATROL THEY CAN TELL YOU EVEN MORE ABOUT THESE PROBLEMS.
NHTSA ODI #10807877
Mileage unknown · May 12, 2010
Vehicle Speed Control
2003 VOLKSWAGEN JETTA. CONSUMER STATES VEHICLE CLOCKS SPEEDS MUCH SLOWER THAN THE CAR IS ACTUALLY GOING DURING SUSTAINED HIGHWAY DRIVING CONDITIONS. *TGW THE DEALERSHIP FOUND A BROKEN PLASTIC GEAR AND BEARING WHICH WAS CAUSING THE PROBLEM. *JB
NHTSA ODI #10330657
36,022 miles · Sep 28, 2006
Power TrainVehicle Speed Control
DT*: THE CONTACT STATED WHEN THE SPEEDOMETER READ 70 MPH, THE VEHICLE WAS TRAVELING 97.3 MPH. THE DEALERSHIP DETERMINED THE GEAR BUSHING WAS BAD AND NEEDED TO BE REPLACED. THE PART NUMBER FOR THE GEAR WAS: 01M-409-187. THE PART NUMBER FOR THE BUSHING WAS: 095-409-190. THE DEALERSHIP INFORMED THE CONTACT, THE MANUFACTURER NEE…
Read full complaint
DT*: THE CONTACT STATED WHEN THE SPEEDOMETER READ 70 MPH, THE VEHICLE WAS TRAVELING 97.3 MPH. THE DEALERSHIP DETERMINED THE GEAR BUSHING WAS BAD AND NEEDED TO BE REPLACED. THE PART NUMBER FOR THE GEAR WAS: 01M-409-187. THE PART NUMBER FOR THE BUSHING WAS: 095-409-190. THE DEALERSHIP INFORMED THE CONTACT, THE MANUFACTURER NEEDED TO KEEP THE OLD GEAR AND BUSHING. THE CONTACT DID NOT AGREE AND WANTED THE OLD PARTS. *AK
NHTSA ODI #10169492
Mileage unknown · May 7, 2004
Service Brakes, HydraulicVehicle Speed ControlCrash
WHEN THE BRAKE PEDAL WAS DEPRESSED TO DISENGAGE THE CRUISE CONTROL BRAKES FAILED. THIS RESULTED IN A REAR END COLLISION. THE INSURANCE WAS NOT ABLE TO PROVE THAT THE FAILURE WAS DUE TO A MALFUNCTION IN THE BRAKE MECHANISM. *AK
NHTSA ODI #10072298
Mileage unknown · Mar 5, 2004
Power TrainVehicle Speed Control
MY 2003 VW JETTA CONSTANTLY GETS STUCK IN PARK LONGEST TIME HAS BEEN 45 MINUTES MY CAR HAS BEEN INTO SERVICE 3 TIMES AND IS STILL ROUGH COMING OUT OF PARK ALSO MY CRUISE CONTROL HAS NEVER WORKED I ONLY HAVE 6000 MILES. *JB
NHTSA ODI #10060530
10,000 miles · Jun 30, 2003
Service Brakes, HydraulicVehicle Speed Control
JUNE 24TH, WHILE I WAS DRIVING MY FOUR MONTH OLD 2003 JETTA TDI ON THE THE HIGHWAY AT A 70MPH, THE CRUISE CONTROL FAILED TO ENGAGE. AFTER THE CAR HAD STOPPED AND BEGAN MOVING AGAIN THE CRUISE FUNCTIONED PROPERLY. TWO DAYS LATER ON JUNE 26, 2003, WHILE IN LUNCH HOUR TRAFFIC-WITH A CO-WORKER IN THE CAR THE BRAKES AUTOMATICALLY…
Read full complaint
JUNE 24TH, WHILE I WAS DRIVING MY FOUR MONTH OLD 2003 JETTA TDI ON THE THE HIGHWAY AT A 70MPH, THE CRUISE CONTROL FAILED TO ENGAGE. AFTER THE CAR HAD STOPPED AND BEGAN MOVING AGAIN THE CRUISE FUNCTIONED PROPERLY. TWO DAYS LATER ON JUNE 26, 2003, WHILE IN LUNCH HOUR TRAFFIC-WITH A CO-WORKER IN THE CAR THE BRAKES AUTOMATICALLY ENGAGED BY THEMSELVES AT 40 MPH. WE STOPPED ON A DIME AND WERE ALMOST REAR ENDED. THIS OCCURED OVER 10 TIMES BEFORE WE GOT BACK TO THE OFFICE (WE WERE LESS THAN TWO MILES AWAY). DEALERSHIP IS REPLACING BRAKE BOOSTER AND MASTER CYLINDER AND I HAVE REQUESTED FULL WARRENTY ON NEW BRAKE SYSTEM FROM VOLKSWAGEN OF AMERICA. THIS IS A POTENTIALLY SERIOUS FLAW THAT COULD HAVE EAISLY CAUSED BODILY INJURY. I HAVE YET TO LEARN IF THERE IS A TRACK RECORD OF THE BRAKES FAILING ON THE 2003 DESIGNS BUT WANTED TO BEGIN A DOCUMENTATION RECORD. *AK
NHTSA ODI #10025161
Mileage unknown · Sep 10, 2002
Vehicle Speed Control
WHEN ACTIVATING CRUISE CONTROL VEHICLE WILL STAY ON CRUISE CONTROL AND NOT TURN OFF. CONTACTED DEALER. *AK *YH
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator, free of charge. The recall began May 2, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69X3.
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA04010 · Driver Side Front Seat Overheats
Opened Mar 30, 2004 · Closed Oct 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THIS INVESTIGATION CONCERNS THE ELECTRIC SEAT HEATER INSTALLED IN SOME MY 2002-2003 VOLKSWAGEN (VW) JETTA VEHICLES.CONSUMERS ALLEGE THAT THE SEAT HEATER MAY OVERHEAT, RESULTING IN BURN DAMAGE TO THE SEAT COVER AND TO THE DRIVER'S CLOTHING AND/OR SKIN.THIS EA ADDRESSES WHETHER SUCH FAILURES MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ODI CONCLUDES THAT THE DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE, (I.E., DRIVER INGRESS AND EGRESS FROM THE VEHICLE).THE INVESTIGATION DISCLOSED THAT SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND.THEREFORE, THIS EA HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ATTACHED SUMMARY REPORT PROVIDES FURTHER DETAIL CONCERNING THIS EA.
PE03052 · Driver Seat Overheats/burns
Opened Nov 19, 2003 · Closed Mar 30, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL ELECTRICALLY HEATED DRIVER AND FRONT PASSENGER SEATS.INFORMATION RECEIVED DURING PE03-052 DISCLOSED A SIGNIFICANT NUMBER OF INCIDENTS OF MALFUNCTIONING/OVERHEATING OF THE DRIVER SEAT HEATER IN THE SUBJECT VEHICLES.ADDITIONAL INCIDENTS MAY OCCUR DURING THE FINAL MONTHS OF THE WINTER SEASON.THIS MATTER IS ALSO CURRENTLY BEING INVESTIGATED BY TRANSPORT CANADA.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-010)IN ORDER TO FULLY INVESTIGATE THESE OCCURRENCES AND THEIR SAFETY IMPLICATIONS.
2003 Volkswagen Jetta Problems, Complaints & Recalls | Skip That Year
Illustration