IllustrationHEATED SEAT (DRIVER SIDE) OVERHEATED TO THE POINT WHERE IT BURNED THROUGH THE SEAT MATERIAL, AND BURNED THE DRIVER OF THE VEHICLE. SMALL HOLE VISIBLE IN MATERIAL OF SEAT WHERE IT BURNED THROUGH, AND SMOKE COULD BE SMELLED. THIS OCCURED WITHIN 10 MINUTES OF THE SEAT BEING TURNED ON.*AK
2003 Volkswagen Jetta
Owner reports · Recalls · Investigations
More warning signs than most Jetta years
Owner complaints for the 2003 Volkswagen Jetta are substantially higher than the model-year median of 68.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jetta years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
790–25K
9225–50K
7650–75K
4875–100K
46100–150K
33150K+
374 reports with mileage · 81 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Seats. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 97 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports70 fire reports76 injury reports
Seats complaints
100 reports1- TURNED ON THE DRIVER'S SIDE SEAT HEATER 2- FELT HOT SPOT, AND SAW SMOKE COMING FROM LEFT SIDE OF SEAT. A SMALL HOLE WAS BURNED IN LEATHER, AND PADDING INSIDE SEAT WAS BLACK. NO FIRE, JUST SMOKE.*AK 3- TURN OFF SEAT HEATER, PUT WATER ON SMOKING HOLE IN LEATHER SEAT.
WHILE DRIVING WITH THE SEAT HEATER ENGAGED, THE CONSUMER SMELLED A BURNING ODOR ALONG WITH REAR END GETTING EXCESSIVELY HOT. CONSUMER PULLED THE VEHICLE OVER, AND NOTICED THE LEATHER SEAT HAD BURN HOLES. BOTH THE MANUFACTURER AND DEALERSHIP WERE CONTACTED.*AK
DRIVER SEAT HEATER OVERHEATED AND CAUSED DAMAGE TO SEAT. *JB
I OWN A VOLKSWAGEN 2003 JETTA WAGON. THE DRIVERS SIDE SEAT WARMER BURNED A HOLE THROUGH THE SEAT COVER. WHEN BROUGHT IN FOR SERVICE I ASKED THEM TO CHECK THE PASSENGER SIDE FOR THE DEFECTIVE PART AND THEY SAID THERE WAS NO PROBLEM. ONE MONTH LATER I STARTED SMELLING THE SAME SYNTHETIC BURNING SMELL, AND NOTICED A DISCOLORATIO…
Read full complaint
I OWN A VOLKSWAGEN 2003 JETTA WAGON. THE DRIVERS SIDE SEAT WARMER BURNED A HOLE THROUGH THE SEAT COVER. WHEN BROUGHT IN FOR SERVICE I ASKED THEM TO CHECK THE PASSENGER SIDE FOR THE DEFECTIVE PART AND THEY SAID THERE WAS NO PROBLEM. ONE MONTH LATER I STARTED SMELLING THE SAME SYNTHETIC BURNING SMELL, AND NOTICED A DISCOLORATION ON THE SEAT WHERE THE HOT SECTION IS. *AK
DRIVERS HEATED SEAT BURNED A HOLE IN THE SEAT AND BURNED THE DRIVER.*AK
2003 VW JETTA 1.8T GLS W/ LEATHER HAS HEATED SEATS. SEATS MALFUNCTIONED AND BURNT A HOLE THROUGH THE LEATHER. IF I HAD BEEN DRIVING I WOULD HAVE BEEN SCORCHED, LUCKILY I WAS STILL IN MY DRIVEWAY. SEE HERE FOR SIMILAR INCIDENTS. *AK HTTP://FORUMS.VWVORTEX.COM/ZEROTHREAD?ID=1113071&PAGE=1
WE OWN A 2002 JETTA TDI WAGON AND THE DRIVER SEAT HEATING DEVICE BURNED A HOLE IN THE SEAT AND STRAIGHT THROUGH MY OVERCOAT. THIS ALL HAPPENED WITHIN 1 MILE OF DRIVING THE VEHICLE. IF I DID NOT HAVE A THICK JACKET ON, I CERTAINLY WOULD HAVE BEEN BURNED AND IF I DID NOT CATCH IT IN TIME, A FIRE COULD HAVE STARTED. *AK
DRIVER'S SIDE HEATED SEAT BECAME EXTREMELY HOT, BURNING THE LEATHER, AND BURNING THROUGH THE CONSUMERS PANTS, SLIGHTLY BURNING CONSUMER'S LEG. DEALER AND THE MANUFACTURER HAVE BEEN NOTIFIED.*AK *PH *NLM
ON THE EVENING OF OCTOBER 30, MY 2003 VOLKSWAGEN JETTA VEHICLE DRIVER SEAT AND MY COAT CAUGHT ON FIRE, BEGINNING TO MELT MY PANTS TO MY SKIN. ONCE I REALIZED THE PROBLEM, I MOVED THROUGH TRAFFIC TO FIND A SAFE PLACE TO PARK MY CAR. I TURNED OFF THE SEAT HEATER AND ENGINE HEATER, AND WAITED SOME TIME TO REENTER THE CAR. ON FRID…
Read full complaint
ON THE EVENING OF OCTOBER 30, MY 2003 VOLKSWAGEN JETTA VEHICLE DRIVER SEAT AND MY COAT CAUGHT ON FIRE, BEGINNING TO MELT MY PANTS TO MY SKIN. ONCE I REALIZED THE PROBLEM, I MOVED THROUGH TRAFFIC TO FIND A SAFE PLACE TO PARK MY CAR. I TURNED OFF THE SEAT HEATER AND ENGINE HEATER, AND WAITED SOME TIME TO REENTER THE CAR. ON FRIDAY MORNING, I SHOWED A MECHANIC THE PROBLEM AND HE SAID I MUST TAKE THE CAR INTO THE DEALERHSIP IMMEDIATELY. AFTER SEVERAL CALLS TO DICK HANNAH VOLKSWAGEN (DHVW) DEALERSHIP AND VOLKSWAGEN USA, DHVW FIXED THE SEAT HEATER DEFECT AND PROVIDED A CONTACT TO VOLKSWAGEN USA. DHVW PROVIDED MEDIOCORE CUSTOMER SERVICE, LACKED WILLINGNESS TO FULLY DISCUSS THE PROBLEM WITHOUT REPEATED PROMPTS, HAD NO IDEA WHETHER THIS DEFECT HAS BEEN FOUND IN OTHER VOLKSWAGEN VEHICLES AND WOULD NOT PROVIDE ANY COMPENSATION. ULTIMATELY, I AM A VERY UNHAPPY DICK HANNAH VOLKSWAGEN CUSTOMER, WITH A CAR THAT MAKES AFRAID TO DRIVE WITH THE SEAT HEATER FEATURE, NO COMPENSATION FOR MY WINTER COAT AND PANTS, TIME FROM WORK AND STRESS. *LA
Official recalls
218V406000 · Air Bags:frontal:driver Side:inflator Module
Jun 13, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator, free of charge. The recall began May 2, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69X3.
07V063000 · Exterior Lighting:brake Lights:switch
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA04010 · Driver Side Front Seat Overheats
Opened Mar 30, 2004 · Closed Oct 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THIS INVESTIGATION CONCERNS THE ELECTRIC SEAT HEATER INSTALLED IN SOME MY 2002-2003 VOLKSWAGEN (VW) JETTA VEHICLES.CONSUMERS ALLEGE THAT THE SEAT HEATER MAY OVERHEAT, RESULTING IN BURN DAMAGE TO THE SEAT COVER AND TO THE DRIVER'S CLOTHING AND/OR SKIN.THIS EA ADDRESSES WHETHER SUCH FAILURES MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ODI CONCLUDES THAT THE DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE, (I.E., DRIVER INGRESS AND EGRESS FROM THE VEHICLE).THE INVESTIGATION DISCLOSED THAT SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND.THEREFORE, THIS EA HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ATTACHED SUMMARY REPORT PROVIDES FURTHER DETAIL CONCERNING THIS EA.
PE03052 · Driver Seat Overheats/burns
Opened Nov 19, 2003 · Closed Mar 30, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL ELECTRICALLY HEATED DRIVER AND FRONT PASSENGER SEATS.INFORMATION RECEIVED DURING PE03-052 DISCLOSED A SIGNIFICANT NUMBER OF INCIDENTS OF MALFUNCTIONING/OVERHEATING OF THE DRIVER SEAT HEATER IN THE SUBJECT VEHICLES.ADDITIONAL INCIDENTS MAY OCCUR DURING THE FINAL MONTHS OF THE WINTER SEASON.THIS MATTER IS ALSO CURRENTLY BEING INVESTIGATED BY TRANSPORT CANADA.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-010)IN ORDER TO FULLY INVESTIGATE THESE OCCURRENCES AND THEIR SAFETY IMPLICATIONS.