NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
702 reports72,501 miles · May 19, 2008
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
I PURCHASED THE 2002 VOLKSWAGEN JETTA IN AUGUST OF 2006. THE FIRST SET OF REPAIRS WAS ON 3/2007 AT 64,332 MI CHECK ENGINE LIGHT MULITPLE MISFIRES: P0300, P0301, P0302, P0303, P0304 REPLACED IGNITION COILS COST: $200.11 SECOND REPAIR TOOK PLACE IN APRIL OF 2007 TOOK CAR IN FOR RECALL - REPLACEMENT OF BRAKE LIGHT SWITCH…
Read full complaint
I PURCHASED THE 2002 VOLKSWAGEN JETTA IN AUGUST OF 2006. THE FIRST SET OF REPAIRS WAS ON 3/2007 AT 64,332 MI CHECK ENGINE LIGHT MULITPLE MISFIRES: P0300, P0301, P0302, P0303, P0304 REPLACED IGNITION COILS COST: $200.11 SECOND REPAIR TOOK PLACE IN APRIL OF 2007 TOOK CAR IN FOR RECALL - REPLACEMENT OF BRAKE LIGHT SWITCH CHECK ENGLINE LIGHT WAS BACK ON - REPLACED TEMP. SENSOR COST: $199.33 CAR WAS JERKING INTO GEAR, DOWNSHIFTING HARD AND SLUGGISH. BROUGHT CAR INTO DEALSERHSIP IN APRIL 2008 WORN STRUT BRUSHINGS NEEDS REAR PADS NEEDS ROTORS CHECK ENGLINE LIGHT ON AGAIN NEEDS NEW COILS AGAIN SPARK PLUGS TEMP SENSOR AGAIN NEW T-STAT FANS NOT WORKING HOSES UNDER INTAKE BROKEN NEEDS NEW TRANSMISSION DIAGNOSIS COST: $149.21 ESTIMATED COST OF REPAIR: $6,500.00. *TR
NHTSA ODI #10228140
35,000 miles · May 15, 2008
Power Train
RELATED TO HTSA 10024548. 2002 JETTA STALLS AND HAS TRANSMISSION ISSUES BETWEEN 2ND AND 3RD GEARS WHICH MAKES CONTROLLING THE CAR DIFFICULT WHEN TRYING TO ACCELERATE FROM A STOPPED POSITION. TOOK THIS ISSUE TO DEALER BUT THEY RECOMMENDED OTHER SERVICE WHICH IS NOT NEEDED. THE SUDDEN LOSS OF POWER AND THEN THE FAST GEAR SHIFT …
Read full complaint
RELATED TO HTSA 10024548. 2002 JETTA STALLS AND HAS TRANSMISSION ISSUES BETWEEN 2ND AND 3RD GEARS WHICH MAKES CONTROLLING THE CAR DIFFICULT WHEN TRYING TO ACCELERATE FROM A STOPPED POSITION. TOOK THIS ISSUE TO DEALER BUT THEY RECOMMENDED OTHER SERVICE WHICH IS NOT NEEDED. THE SUDDEN LOSS OF POWER AND THEN THE FAST GEAR SHIFT FROM 2ND TO 3RD CAN BE A REAL ISSUE IN STOP AND GO TRAFFIC AS IT IS HARD TO CONTROL THE CAR. LUCKY NO ACCIDENTS BUT A FEW CLOSE CALLS INCLUDING MERGING INTO HIGHWAY TRAFFIC. HAVE TO USE VERY LOW SPEEDS TO AVOID THIS HARD SHIFTING ISSUE. *TR
NHTSA ODI #10227947
96,000 miles · May 1, 2008
Service Brakes, Hydraulic
I OWN A 2002 VW JETTA 1.8T. OVER THE WINTER MY ABS SYSTEM DID NOT FUNCTION PROPERLY AT ALL! SOMETIMES IT WOULD WORK AND SOMETIMES IT WOULDN'T. NOW THAT IT IS WARMER OUT IT DOES NOT WORK AT ALL! ABS LIGHT, TRACTION LIGHT, AND BLINKING BRAKE LIGHT NOW ILLUMINATE MY DASHBOARD. I HAVE READ THAT THIS IS A FAULTY ABS CONTROL UNIT WHIC…
Read full complaint
I OWN A 2002 VW JETTA 1.8T. OVER THE WINTER MY ABS SYSTEM DID NOT FUNCTION PROPERLY AT ALL! SOMETIMES IT WOULD WORK AND SOMETIMES IT WOULDN'T. NOW THAT IT IS WARMER OUT IT DOES NOT WORK AT ALL! ABS LIGHT, TRACTION LIGHT, AND BLINKING BRAKE LIGHT NOW ILLUMINATE MY DASHBOARD. I HAVE READ THAT THIS IS A FAULTY ABS CONTROL UNIT WHICH MANY PEOPLE HAVE HAD PROBLEMS WITH. I SIMPLY DON'T HAVE 1,500 DOLLARS TO FIX SOMETHING LIKE THIS BUT IT WOULD BE NICE TO BE IN CONTROL OF MY CAR ON SNOWY WISCONSIN ROADS. *TR
NHTSA ODI #10226350
100,000 miles · Apr 20, 2008
Electrical System
IN REGARDS TO INVESTIGATION DP05004, I ALSO EXPERIENCED THIS SAME PROBLEM ABOUT 2 1/2 YEARS AGO. MY 2002 VOLKSWAGEN JETTA ENGINE LOST POWER, AND STALLED. WHEN THE DEALER CHECKED MY CAR THEY SAID IT WAS MY IGNITION COIL AND DIDN'T INFORM ME THAT THERE WAS AN INVESTIGATION. I WAS TOLD I HAD TO PAY FOR THE COILS, WHICH I DID. I…
Read full complaint
IN REGARDS TO INVESTIGATION DP05004, I ALSO EXPERIENCED THIS SAME PROBLEM ABOUT 2 1/2 YEARS AGO. MY 2002 VOLKSWAGEN JETTA ENGINE LOST POWER, AND STALLED. WHEN THE DEALER CHECKED MY CAR THEY SAID IT WAS MY IGNITION COIL AND DIDN'T INFORM ME THAT THERE WAS AN INVESTIGATION. I WAS TOLD I HAD TO PAY FOR THE COILS, WHICH I DID. I HAVE A COPY OF MY PAPERWORK FOR THE REPAIRS. IS THERE ANYTHING I CAN DO? *TR
NHTSA ODI #10225198
Mileage unknown · Apr 15, 2008
Air Bags
WAS DRIVING DOWN THE STREET AND MY SIDE AIR BAGS DEPLOY FOR NO REASON. I DID NOT HIT ANYTHING THERE IS NO DAMAGE DONE TO MY CAR NOR BEEN IN A ACCIDENT. WENT TO VW SOUTHERN STATES AND WAS TOLD THAT MY CAR ONLY HAS A 50,000 MILE WARRANTY AND THAT I HAVE TO PAY FOR THE CAR TO GET FIXED. ABOUT 3,000 DOLLARS HE SAID..... *TR
NHTSA ODI #10224638
102,681 miles · Mar 27, 2008
SeatsFire
ON MY 2002 VOLKSWAGEN JETTA TDI, THE DRIVER SIDE SEAT HEATER HAS BURNED A HOLE THROUGH THE SEAT PADDING, SEAT COVER AND THE JACKET I WAS WEARING. I HAVE SEEN REPORTS OF SIMILAR ISSUES WITH THE JETTAS ON VARIOUS WEBSITE FORUMS. *TR
NHTSA ODI #10222478
90,700 miles · Mar 10, 2008
Air BagsSeat BeltsUnknown Or Other
I INADVERTENTLY HIT A POT HOLE. THE POT HOLE WAS PROBABLY A LITTLE DEEPER THAN MOST. THE DRIVER'S SIDE-CURTAIN AIRBAG, THE SEAT SIDE AIRBAG AND THE SEATBELT TENSIONER WERE DEPLOYED. THERE WAS NO DAMAGE TO THE CAR. THERE WAS NO IMMEDIATE DANGER TO ME. I DID NOT LOSE CONTROL OF THE CAR EVEN WITH THE STARTLING DEPLOYMENT OF THE SAF…
Read full complaint
I INADVERTENTLY HIT A POT HOLE. THE POT HOLE WAS PROBABLY A LITTLE DEEPER THAN MOST. THE DRIVER'S SIDE-CURTAIN AIRBAG, THE SEAT SIDE AIRBAG AND THE SEATBELT TENSIONER WERE DEPLOYED. THERE WAS NO DAMAGE TO THE CAR. THERE WAS NO IMMEDIATE DANGER TO ME. I DID NOT LOSE CONTROL OF THE CAR EVEN WITH THE STARTLING DEPLOYMENT OF THE SAFETY SYSTEMS. I WAS TOLD BY THE GUY IN ONE OF THE BODY SHOPS THAT I WENT TO TO GET ESTIMATES THAT VWS AND BMWS ARE KNOWN FOR THEIR "TOUCHY" AIRBAG SYSTEMS. I DO NOT THINK THAT IT IS REASONABLE TO HAVE A $2700 REPAIR BILL, THE INCONVENIENCE OF ALL OF THE LEGWORK TO GET MY CAR FIXED OR THE TEMPORARY NON-FUNCTIONING OF MY CAR'S SAFETY SYSTEM JUST FROM HITTING A POT HOLE! I AM WORKING ON A CLAIM AND HAVE NOT YET HAD THE CAR REPAIRED. PARTS LISTED AS BEING NECESSARY TO REPLACE ARE: SIDE CURTAIN AIRBAG, SEAT SIDE AIRBAG, SEAT BELT/TENSIONER ASSEMBLY, SEAT COVER, A-PILLAR TRIM, HEADLINER, SAIL PANEL TRIM, AIRBAG SENSOR AND AIRBAG CONTROL MODULE. ALSO, THE CAR WILL NEED TO BE PLUGGED INTO A COMPUTER ANALYZER IN ORDER THAT THE AIRBAG CODES BE RESET. *TR
NHTSA ODI #10220682
79,000 miles · Mar 3, 2008
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. WHILE DRIVING 45 MPH, THE CONTACT HEARD A NOISE COMING FROM THE REAR OF THE VEHICLE NEAR THE EXHAUST PIPE. THE MECHANIC STATED THAT THE FAILURE WAS ELECTRICAL AND CAUSED THE CATALYTIC CONVERTER TO MALFUNCTION. THE MANUFACTURER STATED THAT IT WAS THE CONTACT'S RESPONSIBILITY TO REPA…
Read full complaint
TL*THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. WHILE DRIVING 45 MPH, THE CONTACT HEARD A NOISE COMING FROM THE REAR OF THE VEHICLE NEAR THE EXHAUST PIPE. THE MECHANIC STATED THAT THE FAILURE WAS ELECTRICAL AND CAUSED THE CATALYTIC CONVERTER TO MALFUNCTION. THE MANUFACTURER STATED THAT IT WAS THE CONTACT'S RESPONSIBILITY TO REPAIR THE VEHICLE. THE CURRENT MILEAGE WAS 80,260 AND FAILURE MILEAGE WAS 79,000.
NHTSA ODI #10219974
32,400 miles · Feb 11, 2008
Engine And Engine Cooling
THE COOLANT TEMPERATURE SENSOR WARNING LIGHT COMES ON DURING COOL AND COLD WEATHER AND STAYS ON TILL THE ENGINE IS WARMED UP. AT WHICH TIME, IF THE ENGINE IS TURNED OFF AND THEN RESTARTED, THE WARNING LIGHT WILL REMAIN OUT. THERE ARE NO CODES LISTED IN THE ECU. THIS ISSUE HAS OCCURRED CONTINUOUSLY SINCE THE CAR WAS PURCHASED IN…
Read full complaint
THE COOLANT TEMPERATURE SENSOR WARNING LIGHT COMES ON DURING COOL AND COLD WEATHER AND STAYS ON TILL THE ENGINE IS WARMED UP. AT WHICH TIME, IF THE ENGINE IS TURNED OFF AND THEN RESTARTED, THE WARNING LIGHT WILL REMAIN OUT. THERE ARE NO CODES LISTED IN THE ECU. THIS ISSUE HAS OCCURRED CONTINUOUSLY SINCE THE CAR WAS PURCHASED IN JUNE 2005. *TR
NHTSA ODI #10217763
71,000 miles · Feb 6, 2008
Engine And Engine Cooling
2002 TDI VW JETTA . HAD FOR 1.5 YEARS ENGINE BLEW AT 70K ON IT .. TOOK TO SEACOAST VW IN NH FIRST SAID MIGHT BE SLUDGE LATER SAID WAS A CHAIN THAT SLIPPED CAUSED ENGINE TO BLOW AND METAL PIECES TO BE THROUGHOUT. CALLED VW FIRST SAID I WOULD HAVE TO PAY FOR IT AND THEN SEND THEM RECEIPTS. WHEN NOT ABLE TO AFFORD THE THOUSANDS IT …
Read full complaint
2002 TDI VW JETTA . HAD FOR 1.5 YEARS ENGINE BLEW AT 70K ON IT .. TOOK TO SEACOAST VW IN NH FIRST SAID MIGHT BE SLUDGE LATER SAID WAS A CHAIN THAT SLIPPED CAUSED ENGINE TO BLOW AND METAL PIECES TO BE THROUGHOUT. CALLED VW FIRST SAID I WOULD HAVE TO PAY FOR IT AND THEN SEND THEM RECEIPTS. WHEN NOT ABLE TO AFFORD THE THOUSANDS IT WOULD COST TALKED TO THEM AGAIN SPOKE TO ALICIA AT VW AND SHE CALLED SEACOAST VW IN NH THEN CALLED AND STATE IT WOULD BE COVERED. WENT ABOUT HAVING IT TOWED TO VW DEALERSHIP TO GET FIXED. WHEN CALLED AGAIN WAS TOLD WOULDN'T COVER IT BUT WOULD GIVE ME 1000 DOLLARS OFF THE PRICE OF THE REPAIR VALID FOR 30 DAYS .. ENGINE STILL BLOWN CAR STILL SITTING IN GARAGE BEEN TRYING TO GET FIXED SINCE APRIL OF 2007 .SEEMS TO BE A COMMON THING WITH VW THAT HAVE MAJOR ENGINE PROBLEMS WITHOUT LOTS OF MILEAGE. *TR
NHTSA ODI #10217112
Official recalls
5Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Dec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Jan 31, 2002
ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).
Consequence & remedy
Consequence: THIS CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
EA04010 · Driver Side Front Seat Overheats
Opened Mar 30, 2004 · Closed Oct 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THIS INVESTIGATION CONCERNS THE ELECTRIC SEAT HEATER INSTALLED IN SOME MY 2002-2003 VOLKSWAGEN (VW) JETTA VEHICLES.CONSUMERS ALLEGE THAT THE SEAT HEATER MAY OVERHEAT, RESULTING IN BURN DAMAGE TO THE SEAT COVER AND TO THE DRIVER'S CLOTHING AND/OR SKIN.THIS EA ADDRESSES WHETHER SUCH FAILURES MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ODI CONCLUDES THAT THE DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE, (I.E., DRIVER INGRESS AND EGRESS FROM THE VEHICLE).THE INVESTIGATION DISCLOSED THAT SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND.THEREFORE, THIS EA HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ATTACHED SUMMARY REPORT PROVIDES FURTHER DETAIL CONCERNING THIS EA.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
PE03052 · Driver Seat Overheats/burns
Opened Nov 19, 2003 · Closed Mar 30, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL ELECTRICALLY HEATED DRIVER AND FRONT PASSENGER SEATS.INFORMATION RECEIVED DURING PE03-052 DISCLOSED A SIGNIFICANT NUMBER OF INCIDENTS OF MALFUNCTIONING/OVERHEATING OF THE DRIVER SEAT HEATER IN THE SUBJECT VEHICLES.ADDITIONAL INCIDENTS MAY OCCUR DURING THE FINAL MONTHS OF THE WINTER SEASON.THIS MATTER IS ALSO CURRENTLY BEING INVESTIGATED BY TRANSPORT CANADA.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-010)IN ORDER TO FULLY INVESTIGATE THESE OCCURRENCES AND THEIR SAFETY IMPLICATIONS.
Illustration