NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
668 reportsMileage unknown · Nov 6, 2004
Structure
FRONT BUMPER OF VEHICLE HAS BEEN PULLED OFF 10 TIMES DUE TO WHEN YOU PUT THE CAR IN REVERSE THE BOTTOM OF THE FRONT BUMPER GETS STUCK ON ANY PARKING BLOCK WHICH RESULTS IN THE BUMPER BEING PULLED AWAY FROM THE CAR AND HAVING TO BE REPLACED OR REATTACHED. WE HAVE SPOKE TO OTHER JETTA TDI OWNERS AND HAVE FOUND THAT THEY HAVE EXPER…
Read full complaint
FRONT BUMPER OF VEHICLE HAS BEEN PULLED OFF 10 TIMES DUE TO WHEN YOU PUT THE CAR IN REVERSE THE BOTTOM OF THE FRONT BUMPER GETS STUCK ON ANY PARKING BLOCK WHICH RESULTS IN THE BUMPER BEING PULLED AWAY FROM THE CAR AND HAVING TO BE REPLACED OR REATTACHED. WE HAVE SPOKE TO OTHER JETTA TDI OWNERS AND HAVE FOUND THAT THEY HAVE EXPERIENCED THE SAME PROBLEM. THE DEALERS WE HAVE SPOKE TO ARE ALSO AWARE THAT THIS IS A PROBLEM WITH THIS TYPE OF VEHICLE BUT BECAUSE THERE HAS NOT BEEN A RECALL NOTHING THEY WILL NOT DO ANYTHING AND WE CONTINUALLY HAVE TO PAY TO HAVE IT FIXED. 8JB
NHTSA ODI #10098361
Mileage unknown · Nov 5, 2004
Engine And Engine Cooling
THE VEHICLE MASS AIR FLOW SENSOR FAILED WHICH CAUSED THE VEHICLE TO PERFORM POORLY. *NM THE CONSUMER WAS REIMBURSED FOR THE COST OF THE REPAIR. *TC *JB
NHTSA ODI #10101200
55,000 miles · Nov 5, 2004
Engine And Engine Cooling
ENGINE COIL PACK MALFUNCTIONED. *AK
NHTSA ODI #10099483
33,075 miles · Nov 5, 2004
Exterior Lighting
THE TURN SIGNALS, ONCE ACTIVATED, WOULD STOP WORKING EVEN THOUGH THEY WERE IN THE ACTIVE MODE. I TOOK IT IN TO THE DEALERSHIP ON NOVEMBER 5, 2004 AND ONE OF THE MECHANICS IN THE SERVICE BAY SAID IT SOUNDED LIKE THE HAZARD SWITCH RELAY AND THAT A LOT OF PEOPLE HAVE HAD A PROBLEM WITH THAT. THEY WANTED TO CHARGE OVER $100 TO REPLA…
Read full complaint
THE TURN SIGNALS, ONCE ACTIVATED, WOULD STOP WORKING EVEN THOUGH THEY WERE IN THE ACTIVE MODE. I TOOK IT IN TO THE DEALERSHIP ON NOVEMBER 5, 2004 AND ONE OF THE MECHANICS IN THE SERVICE BAY SAID IT SOUNDED LIKE THE HAZARD SWITCH RELAY AND THAT A LOT OF PEOPLE HAVE HAD A PROBLEM WITH THAT. THEY WANTED TO CHARGE OVER $100 TO REPLACE-- BECAUSE THEY SAID IT WAS NOT UNDER WARRANTY. I ONLY HAVE JUST OVER 33,000 MILES ON THE CAR. I LOOKED ONLINE AND IT APPEARS THAT MANY PEOPLE HAVE EXPERIENCED THE SAME ISSUE. FURTHERMORE, THE PART WILL COST ME $19 AT A LOCAL AUTO PART STORE AND IS APPARENTLY VERY EASY TO REPLACE. *AK
NHTSA ODI #10098344
23,000 miles · Oct 26, 2004
Service Brakes, Hydraulic
THE BRAKES STARTED GRINDING. AFTER DEALER INSPECTED THE BRAKES THE ROTORS AND CALIPERS WERE REPLACED. *AK
NHTSA ODI #10097791
50,000 miles · Oct 25, 2004
Service Brakes, Hydraulic
I AM THE ORIGINAL OWNER OF A 2001, VW JETTA TDI. I TOOK MY CAR TO WEST BROAD VOLKSWAGEN, RICHMOND VA, TO HAVE THE BRAKES CHECKED BECAUSE I HEARD A SQUEALING NOISE (JUST ONCE). THE DEALER TOLD ME THAT MY REAR BRAKES NEED TO BE CHANGED VERY SOON AND THE COST WOULD BE $427.00! I ASKED, HOW COULD IT JUST BE THE REAR BRAKES? …
Read full complaint
I AM THE ORIGINAL OWNER OF A 2001, VW JETTA TDI. I TOOK MY CAR TO WEST BROAD VOLKSWAGEN, RICHMOND VA, TO HAVE THE BRAKES CHECKED BECAUSE I HEARD A SQUEALING NOISE (JUST ONCE). THE DEALER TOLD ME THAT MY REAR BRAKES NEED TO BE CHANGED VERY SOON AND THE COST WOULD BE $427.00! I ASKED, HOW COULD IT JUST BE THE REAR BRAKES? THE SERVICE ADVISER COULD NOT EXPLAIN. I STATED TO HIM THAT EVERY CAR I HAVE EVER OWNED WAS FRONT WHEEL DRIVE AND IN ALL MY YEARS, IT WAS ALWAYS THE FRONT WHEELS TO GO FIRST! I ASKED HIM DIDNT HE THINK IT STRANGE THAT JUST ONE SET OF BRAKES HAVE GONE BAD?&AGAIN, NO ANSWER. BASED ON WHAT I HAVE READ, IT IS MY BELIEF THAT THE BRAKE PADS ARE DEFECTIVE AND IT APPEARS THAT THIS DEALERSHIP IS PRICE GOUGING!*AK
NHTSA ODI #10096380
45,000 miles · Oct 25, 2004
Fuel System, Diesel
I OWN A 2001 VW JETTA TDI (DIESEL). I TOOK MY CAR TO THE WEST BROAD VOLKSWAGEN, RICHMOND, VA ON 10/22/04, CONCERNING THE FACT THAT MY CAR WOULD NOT START AND THAT IT FELT LIKE THE CAR WAS NOT RECEIVING ANY FUEL. ADDITIONALLY, THE CAR IS STEADILY LOOSING ITS ABILITY TO ACCELERATE INTO TRAFFIC. NOT ONLY WAS I CHARGED $69.95 FOR…
Read full complaint
I OWN A 2001 VW JETTA TDI (DIESEL). I TOOK MY CAR TO THE WEST BROAD VOLKSWAGEN, RICHMOND, VA ON 10/22/04, CONCERNING THE FACT THAT MY CAR WOULD NOT START AND THAT IT FELT LIKE THE CAR WAS NOT RECEIVING ANY FUEL. ADDITIONALLY, THE CAR IS STEADILY LOOSING ITS ABILITY TO ACCELERATE INTO TRAFFIC. NOT ONLY WAS I CHARGED $69.95 FOR A DIAGNOSTIC, BUT I WAS THEN TOLD THE INTAKE WAS FULL OF CARBON AND THAT IT WOULD COST $978.00 TO FIX THE PROBLEM! ADDITIONALLY, THE CAR DIED DURING THE SUMMER MONTHS AS I WAS TRYING TO GET ON TO THE HIGHWAY. AS THE STEERING WHEEL BECAME STIFF, I VEERED OFF OF THE ROAD TO KEEP FROM BEING KILLED! WHEN I TRIED TO RESTART THE CAR, IT FELT LIKE THE CAR WASN'T GETTING FUEL. I WAS TOWED TO THE NEAREST DEALERSHIP, BROWNS VOLKSWAGEN, MIDLOTHIAN VA. THEY KEPT MY CAR FOR 2 DAYS, TOLD ME IT WAS FIXED AND WHEN I GOT THERE THE CAR STILL WOULD NOT START. WHILE I WAS IN THE DEALERSHIP LOOSING MY MIND, THEY DID SOMETHING TO MY CAR AND IT MYSTERIOUSLY STARTED. I NEVER RECEIVED AN EXPLANATION FOR WHAT WAS WRONG WITH MY CAR, NOR DID I GET A RECEIPT DOCUMENTING WHAT HAPPENED. I DIDNT KNOW IT AT THE TIME, BUT THIS PROBLEM WAS ALREADY IN THE MAKING...THANK GOD FOR ROADSIDE ASSISTANCE!*AK
NHTSA ODI #10096377
1,000 miles · Oct 19, 2004
Service Brakes, Hydraulic
MY BRAKES WOULD SLOW THE CAR DOWN ON A STOP AND GO TRAFFIC, WHERE I WILL BE DRIVING SLOWLY (WITHOUT ME STEPPING ON THE BRAKES), MY CAR WOULD EVENTUALLY STOP AND WILL REQUIRE HEAVY ON THE GAS PEDAL TO ALLOW THE CAR TO MOVE. (WHILE THE CAR CAR IS IN THIS STAGE:ON A SMALL SLOPE THE CAR PLACED ON NETURAL WOULD NOT MOVE) THIS WOULD B…
Read full complaint
MY BRAKES WOULD SLOW THE CAR DOWN ON A STOP AND GO TRAFFIC, WHERE I WILL BE DRIVING SLOWLY (WITHOUT ME STEPPING ON THE BRAKES), MY CAR WOULD EVENTUALLY STOP AND WILL REQUIRE HEAVY ON THE GAS PEDAL TO ALLOW THE CAR TO MOVE. (WHILE THE CAR CAR IS IN THIS STAGE:ON A SMALL SLOPE THE CAR PLACED ON NETURAL WOULD NOT MOVE) THIS WOULD BRING THE RPM TO A HIGH RATE TO GO AT TWENTY KM PER HOUR (AROUND 3,000 TO 4,000 RPM). MY REAR DISC BRAKES WOUL HAVE HEAVY SMOKE ONCE I HAVE COME TO A FULL STOP. THIS HAS HAPPENED A FEW MONTHS AFTER I PURCHASED MY CAR. I THOUGHT IT WAS DUE TO THE BREAK IN OF THE ENGINE THAT WAS THE CAUSE. I HAVE CHANGED MY REAR BRAKE DISC PADS A COUPLE OF TIMES. THERE IS HEAVY SIGNS OF THE PADS BURNING(SMOKING), PEOPLE WITH SIMLAR CARS HAVE HAD THE SAME PROBLEM AND THEY CHANGED THE BRAKE BOOSTER AND THE PROBLEM WAS GONE.*AK
NHTSA ODI #10096066
50,000 miles · Oct 18, 2004
Air BagsCrashInjury
WHEN T-BONE AT 10 MPH, THE SIDE AIR BAGS DID NOT DEPLOY. THE CONSUMER SUFFERED MINOR INJURIES. THE VEHICLE WAS TOWED. *JB
NHTSA ODI #10097005
Mileage unknown · Oct 16, 2004
Electrical System
WHEN I ACTIVATE THE TURN SIGNAL, RIGHT OR LEFT, THE SIGNAL WILL BLINK AT AN IRREGULAR INTERVAL AND THEN DIE. THIS INTERVAL IS NOT FIXED...ITS RANDOM. SOMETIMES THE LIGHT WILL BLINK FOR A WHILE, SOMETIMES IT WILL BLINK ONCE AND DIE. IT'S THE EMERGENCY FLASHER SWITCH. I HAVE NOT CORRECTED IT YET. I'VE LOOKED AT THE FUSES, ALL A…
Read full complaint
WHEN I ACTIVATE THE TURN SIGNAL, RIGHT OR LEFT, THE SIGNAL WILL BLINK AT AN IRREGULAR INTERVAL AND THEN DIE. THIS INTERVAL IS NOT FIXED...ITS RANDOM. SOMETIMES THE LIGHT WILL BLINK FOR A WHILE, SOMETIMES IT WILL BLINK ONCE AND DIE. IT'S THE EMERGENCY FLASHER SWITCH. I HAVE NOT CORRECTED IT YET. I'VE LOOKED AT THE FUSES, ALL ARE SOCKETED PROPERLY AND NOT BLOWN. I'VE LOOKED AT ALL 6 LIGHTS CLOSELY, AND THEY ARE WORKING AND APPEAR TO BE SHINING WITH THE SAME INTENSITY. *JB
NHTSA ODI #10095879
Official recalls
6Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Dec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Sep 12, 2002
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." CHILD SEAT ANCHORAGES INSTALLED IN THE VEHICLE'S REAR SEATS MUST BE IDENTIFIED BY MARKINGS, AND THEIR LOCATION AND USE BE DESCRIBED IN THE OWNER'S MANUAL.
Consequence & remedy
Consequence: THESE VEHICLES WERE NOT MARKED OR DESCRIBED AS REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THE OWNER'S MANUAL AND ALSO ONE SET OF FOUR GUIDANCE FIXTURES INTENDED TO USE IN CONJUNCTION WITH CHILD SEATS EQUIPPED WITH RIGID OR SEMI-RIGID LOWER ANCHORAGE ATTACHMENTS. ALSO ENCLOSED WILL BE FOUR DECALS TOGETHER WITH INSTALLATION INSTRUCTIONS AND A TEMPLATE FOR ATTACHING THE DECALS TO THE LOWER SEAT BACKS. OWNER NOTIFICATION IS EXPECTED TO BEGIN SEPTEMBER 15, 2002. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987.
Jan 31, 2002
ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).
Consequence & remedy
Consequence: THIS CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
Illustration