NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
60 reportsClear category filterMileage unknown · Oct 18, 2002
Electrical System
NO ENGINE LIGHT CAME ON AND I LOST POWER UP HILL ALL OF A SUDDEN AND WAS ALMOST HIT BY A CAR AND A SEMI IN BACK OF ME. I TOOK IT TO DICK HANNA IN VANC. WA AND THEY LOOKED AT IT. THEY THOUGHT IT WAS THE MASS AIR SENSOR . I CALLED VOLKSWAGON AND THEY ONLY WOULD OFFER TO PAY 50/50 ON THE JOB. BUT THIS IS AFTER I JUST PAID 1300.00 …
Read full complaint
NO ENGINE LIGHT CAME ON AND I LOST POWER UP HILL ALL OF A SUDDEN AND WAS ALMOST HIT BY A CAR AND A SEMI IN BACK OF ME. I TOOK IT TO DICK HANNA IN VANC. WA AND THEY LOOKED AT IT. THEY THOUGHT IT WAS THE MASS AIR SENSOR . I CALLED VOLKSWAGON AND THEY ONLY WOULD OFFER TO PAY 50/50 ON THE JOB. BUT THIS IS AFTER I JUST PAID 1300.00 FOR TH E 40,000 MILE CHECK UP. THEN I REFUSED I SAID I WANTED TO GO TO ANOTHER DEALER AND HAVE IT LOOKED AT. VOLKSWAGON THEN SAID THAT THEY MIGHT NOT PAY ANYTHING ON IT IF I DID GO TO ARMSTRONG,(WHERE I ORIGINALLY BOUGHT THE CAR) WHEN I ASKED THEM WHY THEY ARE WILLING TO PAY 100% TO OTHERS WITH THIS PROBLEM THEY SAID THEY REVIEW THESE CASES (CASE BY CASE). WHEN ASKED WHY WOULD THEY NOT OFFER 50/50 IF I WENT TO ARMSTRONG THEY GOT REALLY NASTY ON THE PHONE. I THINK THAT VOLKSWAGON NEEDS TO BE INVESTIGATED, THERE SOUNDS LIKE THERE IS SOMETHING ILLEGAL GOING ON. DT
NHTSA ODI #768604
Mileage unknown · Jul 31, 2002
Electrical System
THE VEHICLE FAILED TO START ON SEVERAL OCCASIONS DUE TO IMMOBILIZER BEING ACTIVATED. THE DEALER REPAIRED THE VEHICLE A NUMBER OF TIMES FOR THE SAME PROBLEM, BUT WAS UNABLE TO CORRECT THE PROBLEM. *YH
NHTSA ODI #786400
Mileage unknown · Jul 12, 2002
Electrical SystemFuel System, GasolineService Brakes, Hydraulic
MY CAR IS NIGHTMARE OF FAILURES. CRUISE CONTROL LIGHT (DEALER CLAIMS THE CAR DOESNT HAVE ONE - BUT YOU CAN SEE IT IF YOU USE A FLASHLIGHT AT AN OBLIQUE ANGLE) FAILURE, ABS MODULE SWITCH FAILURE (ACCORDING TO DEALER) CAUSING CRUISE CONTROL TO UNEXPECTEDLY DISENGAGE. I ALSO LEARNED FROM OTHER MOTORISTS THAT THE SAME SWITCH CONTROL…
Read full complaint
MY CAR IS NIGHTMARE OF FAILURES. CRUISE CONTROL LIGHT (DEALER CLAIMS THE CAR DOESNT HAVE ONE - BUT YOU CAN SEE IT IF YOU USE A FLASHLIGHT AT AN OBLIQUE ANGLE) FAILURE, ABS MODULE SWITCH FAILURE (ACCORDING TO DEALER) CAUSING CRUISE CONTROL TO UNEXPECTEDLY DISENGAGE. I ALSO LEARNED FROM OTHER MOTORISTS THAT THE SAME SWITCH CONTROLS BRAKE LIGHT ILLUMINATION (ALL BULBS AND OTHER SIGNAL LIGHTS WORK). FUEL INJECTION MODULE OVER INJECTED GAS CAUSING EXCESSIVE PRESSURE. RELIEF VALVE FAILED TO OPEN CAUSING TURBO OVERPRESSURE TO +120PSI. FAILURE CAUSED HOSES TO BLOW SENDING HOSE CLAMPS AS PROJECTILES. THIS WEEK, THE FRONT PASSENGER SIDE WINDOW UNEXPECTEDLY DROPPED INTO THE DOOR. DEALER HAS LITERALLY TAPED THE WINDOW UP UNTIL A PART ARRIVES. DEALER ADMITS TO MFG DESIGN DEFECT - NO VOLUNTARY RECALL. NO DEALERS WILL VOLUNTARILY REPLACE CLIPS UNTIL THEY FAIL. VOLKSWAGEN POSITION IS THAT THEY KNOW THERE IS A DESIGN FLAW, BUT WONT REPLACE KNOWN BAD CLIPS UNTIL THERE IS A FAILURE. WINDOW FAILURE COULD CAUSE OBJECTS (STONES KICKED UP BY TIRES OF OTHER CARS) TO HIT PASSENGERS. INFANT / CHILD SAFETY RISK. WINDOW INTEGRITY QUESTIONABLE IN AN ACCIDENT IF IT FAILS WHEN DRIVING 15MPH. HELP!*AK
NHTSA ODI #764145
Mileage unknown · Apr 17, 2002
Electrical System
WHEN OPERATING DRIVER POWER WINDOW IT WENT DOWN 2 INCHES THEN FELL IN THE DOOR. THE SAME HAPPENED TO THE PASSENGER FRONT WINDOW ON 16 APRIL 2002. DEALER REPLACED THE REGULATOR IN BOTH WINDOWS. NLM
NHTSA ODI #8007852
Mileage unknown · Mar 1, 2002
Electrical SystemEngine And Engine Cooling
FOR A NEWER CAR THIS VOLKSWAGEN HAS BEEN VERY PROBLEMATIC. ON THREE OCCASIONS AFTER STARTING THE CAR THE ENGINE WOULD MAKE A NOTICEABLE SPUTTERING NOICE AND SHAKING LIKE IT WAS STRUGGLING TO KEEP RUNNING. THE CHECK ENGINE LIGHT WOULD COME ON ACCOMPANIED BY A SULFUROUS SMELL AND BLUISH EXHAUST. UPON ATTEMPTING TO PUT THE CAR IN D…
Read full complaint
FOR A NEWER CAR THIS VOLKSWAGEN HAS BEEN VERY PROBLEMATIC. ON THREE OCCASIONS AFTER STARTING THE CAR THE ENGINE WOULD MAKE A NOTICEABLE SPUTTERING NOICE AND SHAKING LIKE IT WAS STRUGGLING TO KEEP RUNNING. THE CHECK ENGINE LIGHT WOULD COME ON ACCOMPANIED BY A SULFUROUS SMELL AND BLUISH EXHAUST. UPON ATTEMPTING TO PUT THE CAR IN DRIVE, AFTER IDLING FOR A WHILE, THE CAR WOULD STALL AND NOT RESTART. USUALLY WITHIN AN HOUR TO A DAY LATER IT WOULD START AGAIN ONLY AFTER REVING THE ENGINE TO HIGH RPMS FOR ABOUT 5 MINUTES. I CONTACTED THE DEALER THE FIRST TIME IT OCCURED (TOO BUSY TO SEE MY CAR) THEY THOUGHT IT MIGHT BE MOISTURE IN THE ENGINE. THE PROBLEM SEEMS TO OCCUR AFTER OR AROUND RAINY/SNOWY WEATHER. I HAD A TUNE UP RECENTLY AND THE CAR STILL FEELS LIKE IT MAY STALL WHEN IT IS IDLING AT A STOP LIGHT OR IN THE DRIVEWAY. THIS IS UNACCEPABLE FOR SUCH A NEW CAR. AMONG OTHER PROBLEMS I HAD THE INDASH CD PLAYER REPLACED TWICE BECAUSE OF DEFECT AND THE FUSES THAT ILLUMINATE THE TEMP/RADIO CONTROLS REPLACE TWICE ALL WITHIN THE FIRST MONTH OF OWNERSHIP DUE TO MALFUNCTION.*AK
NHTSA ODI #758805
Mileage unknown · Aug 16, 2001
Electrical SystemExterior Lighting
MY FRUSTRATION AND FEAR AT THE FACT THAT MY BRAKE SWITCH HAS FAILED TWICE, MY BATTERY HAS DIED 3 TIMES WHILE WITH THE DEALER, AND MY BRAKES SEIZED WHILE DRIVING ON A MAJOR ROAD AND MY ALARM GOES OFF CONSTANTLY, IS ONLY COMPOUNDED BY THE FACT THAT VW HAS NOT ONE EXPLAINATION FOR WHY ANY OF THIS IS HAPPENING. TO TELL ME EVERYTHIN…
Read full complaint
MY FRUSTRATION AND FEAR AT THE FACT THAT MY BRAKE SWITCH HAS FAILED TWICE, MY BATTERY HAS DIED 3 TIMES WHILE WITH THE DEALER, AND MY BRAKES SEIZED WHILE DRIVING ON A MAJOR ROAD AND MY ALARM GOES OFF CONSTANTLY, IS ONLY COMPOUNDED BY THE FACT THAT VW HAS NOT ONE EXPLAINATION FOR WHY ANY OF THIS IS HAPPENING. TO TELL ME EVERYTHING IS "TESTING" FINE CERTAINLY ADDS TO THIS FRUSTRATION BECAUSE THERE'S NOTHING THEY CAN FIX WHEN NOTHING IS "WRONG." TO THAT I SAY, O.K. THEN, GIVE THIS CAR TO YOUR LOVED ONE TO DRIVE AND WE'LL SEE HOW SAFE YOU FEEL. ABSURD -- WILL IS TAKE DEATHS FOR SOMEONE TO DO SOMETHING?
NHTSA ODI #750612
Mileage unknown · Jul 18, 2001
Electrical SystemEngine And Engine Cooling
DEALERS OPENLY ACKNOWLEGE PROBLEMS WITH THEIR MAP SENSORS ON GAS AND DIESEL ENGINES, BUT VOLKSWAGEN OF AMERICA INTERNALLY REFUSES TO RECALL THIS ITEM. THE SAME COMPLAINTS ARE MADE ABOUT THE VERY COMMON RELAY 109 FUSE FAILURES, WHICH VOLKSWAGENW IS LIKEWISE PUTTING OFF. PLEASE FORCE THEM TO RECALL THESE TWO ITEMS THAT HAVE COST…
Read full complaint
DEALERS OPENLY ACKNOWLEGE PROBLEMS WITH THEIR MAP SENSORS ON GAS AND DIESEL ENGINES, BUT VOLKSWAGEN OF AMERICA INTERNALLY REFUSES TO RECALL THIS ITEM. THE SAME COMPLAINTS ARE MADE ABOUT THE VERY COMMON RELAY 109 FUSE FAILURES, WHICH VOLKSWAGENW IS LIKEWISE PUTTING OFF. PLEASE FORCE THEM TO RECALL THESE TWO ITEMS THAT HAVE COST ME PLENTY OF OUT OF POCKET MONEY, EVEN THOUGH MY CAR IS UNDER WARRANTY. THIS IS A RIP-OFF OF ALL CONSUMERS BY VW OF AMERICA AND THEY NEED TO BE HELD ACCOUNTABLE FOR THEIR IGNORANCE OF THESE OBVIOUS PROBLEMS! *AK
NHTSA ODI #748695
Mileage unknown · Jul 2, 2001
Electrical SystemVehicle Speed Control
NUMEROUS ELECTRICAL COMPNENTS HAVE FAILED AND BEEN REPLACED. THE MISFIRING ON ACCELERATION CAUSES CAR TO THRUST FORWARD AFTER APPLYING THE THROTTLE. I CONSIDER THIS TO BE A SAFETY HAZARD, AS I WAS ALMOST STRUCK BY ON-COMING TRAFIC IN AN INTERSECTION.
NHTSA ODI #747683
Mileage unknown · Jan 29, 2001
Air BagsElectrical SystemEngine And Engine Cooling
AIR BAG WAS REPAIRED 5 TIMES AND SPIRAL SPRING REPLACED - LIGHT STILL INDICATES MALFUNCTIONING SYSTEM. *AK CONSUMER STATES THAT BRAKE LIGHT WAS INOPERATIVE AND THE ELECTRICAL CONNECTORS WERE REPLACED, INSTALLED FRONT HEATED OXYGEN SENSOR, INSTALL 6 DISC CD CHANGER, BATTERY WAS REPLACED AND WIRING HARNESS WAR REPLACED. OWNER IS…
Read full complaint
AIR BAG WAS REPAIRED 5 TIMES AND SPIRAL SPRING REPLACED - LIGHT STILL INDICATES MALFUNCTIONING SYSTEM. *AK CONSUMER STATES THAT BRAKE LIGHT WAS INOPERATIVE AND THE ELECTRICAL CONNECTORS WERE REPLACED, INSTALLED FRONT HEATED OXYGEN SENSOR, INSTALL 6 DISC CD CHANGER, BATTERY WAS REPLACED AND WIRING HARNESS WAR REPLACED. OWNER IS NO LONGER IN POSSESSION OF THE VEHICLE *YD
NHTSA ODI #740118
Mileage unknown · Aug 13, 2000
Electrical System
THE RED LIGHTING FOR THE CLIMATE CONTROL KNOBS INTERMITTENTLY FAIL
NHTSA ODI #727731
Official recalls
4May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Dec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Sep 12, 2002
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." CHILD SEAT ANCHORAGES INSTALLED IN THE VEHICLE'S REAR SEATS MUST BE IDENTIFIED BY MARKINGS, AND THEIR LOCATION AND USE BE DESCRIBED IN THE OWNER'S MANUAL.
Consequence & remedy
Consequence: THESE VEHICLES WERE NOT MARKED OR DESCRIBED AS REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THE OWNER'S MANUAL AND ALSO ONE SET OF FOUR GUIDANCE FIXTURES INTENDED TO USE IN CONJUNCTION WITH CHILD SEATS EQUIPPED WITH RIGID OR SEMI-RIGID LOWER ANCHORAGE ATTACHMENTS. ALSO ENCLOSED WILL BE FOUR DECALS TOGETHER WITH INSTALLATION INSTRUCTIONS AND A TEMPLATE FOR ATTACHING THE DECALS TO THE LOWER SEAT BACKS. OWNER NOTIFICATION IS EXPECTED TO BEGIN SEPTEMBER 15, 2002. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
Illustration