IllustrationMY AIRBAG WAS DISABLED BY A FAULTY CLOCK SPRING IN THE STEERING WHEEL. THIS IS THE SAME ISSUE THAT CAUSED VOLKSWAGEN TO RECALL 420K CARS, INCLUDING NON-HYBRID JETTAS. FOR REASON UNKNOWN TO ME THE HYBRID JETTA WAS NOT INCLUDED IN THE RECALL, BUT IT SEEMS THAT HAVE THE EXACT SAME ISSUE AS OTHER JETTAS.
2013 Volkswagen Jetta Hybrid
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jetta Hybrid years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
110–25K
925–50K
1350–75K
1875–100K
17100–150K
1150K+
69 reports with mileage · 10 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports0 fire reports0 injury reports
What owners actually said
79 reportsJETTA HYBRIDS -SEVEN-SPEED DUAL-CLUTCH TRANSMISSION THAT RESULTED IN A LOSS OF DRIVE. THIS IS WHAT I WAS TOLD BY THE DEALERSHIP AND WHAT APPEARS ON THE RECALL. THE ENGINE SHUTS DOWN AND A COAST AFTER APPROXIMATELY 30 SECONDS. I WAS FORCED TO GET A TOW TO THE DEALERSHIP WHICH I HAD TO PAY FOR. I AM SERIOUSLY WONDERING WHY MY JE…
Read full complaint
JETTA HYBRIDS -SEVEN-SPEED DUAL-CLUTCH TRANSMISSION THAT RESULTED IN A LOSS OF DRIVE. THIS IS WHAT I WAS TOLD BY THE DEALERSHIP AND WHAT APPEARS ON THE RECALL. THE ENGINE SHUTS DOWN AND A COAST AFTER APPROXIMATELY 30 SECONDS. I WAS FORCED TO GET A TOW TO THE DEALERSHIP WHICH I HAD TO PAY FOR. I AM SERIOUSLY WONDERING WHY MY JETTA IS NOT "INCLUDED" IN THE 2013 VW JETTA HYBRID RECALL??? I HAVE BEEN TO THE ANTWERPEN VW DEALERSHIP IN GLEN BURNIE, MD ON 2 OCCASIONS AND THEY CONTEND MY CAR IS NOT PART OF THE RECALL. EVEN THOUGH WHEN I CALLED, I WAS TOLD THE PROBLEM WAS EXACTLY THE SAME AS WHAT IS LISTED IN THE RECALL INFORMATION. I WAS TOLD THAT THE PART HAS TO BE ORDERED FROM GERMANY AND IT WOULD TAKE A WEEK TO ARRIVE AND THEN THEY COULD DO THE WORK. IT HAS BEEN OVER A WEEK AND CAN' T GET ANYONE TO CONTACT ME. NOT ONLY THAT, I HAVE NOT BEEN ABLE TO MEET WITH THE SERVICE MANAGER(HE WAS IN AN IMPORTANT MEETING) BUT HE HAS NOT RETURNED MY CALLS. I WAS ALSO NOT PERMITTED TO GET A LOANER CAR FROM THE DEALERSHIP FOR SOMETHING THAT IS BEYOND MY CONTROL. *TR
TL* THE CONTACT OWNS 2013 VOLKSWAGEN JETTA HYBRID. THE CONTACT STATED THAT WHILE ACCELERATING FROM A COMPLETE STOP, THE VEHICLE STALLED AND RESTARTED SHORTLY AFTER. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER. HOWEVER, THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE O…
Read full complaint
TL* THE CONTACT OWNS 2013 VOLKSWAGEN JETTA HYBRID. THE CONTACT STATED THAT WHILE ACCELERATING FROM A COMPLETE STOP, THE VEHICLE STALLED AND RESTARTED SHORTLY AFTER. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER. HOWEVER, THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN RECALL NHTSA CAMPAIGN NUMBER: 13V568000 (POWER TRAIN). THE APPROXIMATE FAILURE MILEAGE WAS 4,000. UPDATED 01/09/15*LJ UPDATED 01/21/15*CN THE CONSUMER STATED THE INCIDENT ALSO HAPPENED FROM 0-30 MPH. UPDATED 01/26/15 UPDATED 10/5/2015*JS
TL* THE CONTACT OWNS A 2013 VOLKSWAGEN JETTA HYBRID PREMIUM. THE CONTACT STATED THAT THE ELECTRONIC CONTROL WARNING LIGHT ILLUMINATED AS THE VEHICLE ACCELERATED INDEPENDENTLY. THE CONTACT WAS AT A COMPLETE STOP WHEN THE VEHICLE THEN INDEPENDENTLY ACCELERATED TO 5 MPH BUT THE CONTACT WAS UNABLE TO ACCELERATE ANY HIGHER THAN 5 MPH…
Read full complaint
TL* THE CONTACT OWNS A 2013 VOLKSWAGEN JETTA HYBRID PREMIUM. THE CONTACT STATED THAT THE ELECTRONIC CONTROL WARNING LIGHT ILLUMINATED AS THE VEHICLE ACCELERATED INDEPENDENTLY. THE CONTACT WAS AT A COMPLETE STOP WHEN THE VEHICLE THEN INDEPENDENTLY ACCELERATED TO 5 MPH BUT THE CONTACT WAS UNABLE TO ACCELERATE ANY HIGHER THAN 5 MPH. THE CONTACT SHUT THE VEHICLE OFF AND ONCE RESTARTED, THE VEHICLE RESUMED NORMAL OPERATION. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO A DEALER. HOWEVER, THE FAILURE WAS UNABLE TO BE DUPLICATED OR REPAIRED. THE MANUFACTURER WAS ALSO MADE AWARE OF THE ISSUE BUT PROVIDED NO ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 32,000.
AFTER FIRST STARTING THE VEHICLE AND DRIVING APPROXIMATELY 5 MINUTES OR LESS, WHEN THE VEHICLE IS AT A FULL STOP, ATTEMPTING TO ACCELERATE THE VEHICLE HESITATES FOR A LEAST 3 TO 5 SECONDS MULTIPLE TIMES BEFORE THE ENGINE ENGAGES AND THE VEHICLE STARTS TO MOVE FORWARD. THIS HAS HAPPENED ON AT LEAST 7 DIFFERENT OCCASIONS AND THE …
Read full complaint
AFTER FIRST STARTING THE VEHICLE AND DRIVING APPROXIMATELY 5 MINUTES OR LESS, WHEN THE VEHICLE IS AT A FULL STOP, ATTEMPTING TO ACCELERATE THE VEHICLE HESITATES FOR A LEAST 3 TO 5 SECONDS MULTIPLE TIMES BEFORE THE ENGINE ENGAGES AND THE VEHICLE STARTS TO MOVE FORWARD. THIS HAS HAPPENED ON AT LEAST 7 DIFFERENT OCCASIONS AND THE DEALER HAS INDICATED THAT THEY CANNOT REPLICATE THE PROBLEM ALTHOUGH MULTIPLE INCIDENTS HAVE BEEN REPORTED WITH THE SAME DSG TRANSMISSION ON 2014 VW JETTA DIESEL MODELS. IT FELT LIKE A CHOPPY STUTTER. IT WAS WORSE WHEN THE CAR WAS COLD BUT ALWAYS HAPPENED WHEN I WAS APPLYING JUST A SMALL AMOUNT OF PRESSURE ON THE THROTTLE. I ALSO HAVE A SIMILAR ISSUE WHEN LAUNCHING THE CAR, WHEN PUTTING THE PEDAL DOWN HARD WHEN ENTERING FAST TRAFFIC FROM A DEAD STOP. I'D HIT THE GAS AND THE WHOLE CAR WOULD HEDGE AS POWER WOULD DISAPPEAR FOR A TERRIFYING FEW SECONDS. IT WAS SOMETHING QUITE DIFFERENT THAN TURBO LAG. I HAVE A COMPLAINT INTO VW AND THEY ARE SUPPOSED TO BE WORKING WITH THE DEALER TO RESOLVE. AS OF 4/9/14, I HAVE NOT BEEN ABLE TO OBTAIN AN APPOINTMENT. *TR
I HAVE NOTICED THAT THERE IS A MYSTERY LEAK COMING FROM SOMEWHERE IN THE VEHICLE THAT THE SERVICE DEPARTMENT HAS BEEN UNABLE TO LOCATE. THE RESEARCH THAT I HAVE BEEN ABLE TO FIND HAS SAID THAT IT COULD BE A POSSIBLE LEAK IN THE SUNROOF DRAIN, FRONT WINDSHIELD DRAIN, OR AC CONDENSER DRAIN THAT IS SOMEHOW MANAGING TO LEAK INTO TH…
Read full complaint
I HAVE NOTICED THAT THERE IS A MYSTERY LEAK COMING FROM SOMEWHERE IN THE VEHICLE THAT THE SERVICE DEPARTMENT HAS BEEN UNABLE TO LOCATE. THE RESEARCH THAT I HAVE BEEN ABLE TO FIND HAS SAID THAT IT COULD BE A POSSIBLE LEAK IN THE SUNROOF DRAIN, FRONT WINDSHIELD DRAIN, OR AC CONDENSER DRAIN THAT IS SOMEHOW MANAGING TO LEAK INTO THE CABIN OF THE VEHICLE. THIS CAN CAUSE SEVERE WATER DAMAGE AND MOLD ISSUES THAT COULD IN TURN CAUSE A HEALTH HAZARD FOR THOSE ALLERGIC OR HAVE ISSUES WITH MOLD. *TR
ACCORDING TO THIS RECALL: SAFETY RECALL 34F6/4V 7-SPEED DSG AUTO TRANSMISSION W/TIPTRONIC (DQ-200 DIRECT-SHIFT GEARBOX) 2013-2014 MODEL YEAR VOLKSWAGEN JETTA HYBRID MY VEHICLE IS AFFECTED, BUT WHEN I CONTACTED MY VW DEALERSHIP AND VW CUSTOMER CARE, I WAS TOLD THAT THERE IS NO RECALL ON MY VEHICLE. THIS IS A VERY SERIOUS RECA…
Read full complaint
ACCORDING TO THIS RECALL: SAFETY RECALL 34F6/4V 7-SPEED DSG AUTO TRANSMISSION W/TIPTRONIC (DQ-200 DIRECT-SHIFT GEARBOX) 2013-2014 MODEL YEAR VOLKSWAGEN JETTA HYBRID MY VEHICLE IS AFFECTED, BUT WHEN I CONTACTED MY VW DEALERSHIP AND VW CUSTOMER CARE, I WAS TOLD THAT THERE IS NO RECALL ON MY VEHICLE. THIS IS A VERY SERIOUS RECALL, BUT NO ONE AT VW WILL ACKNOWLEDGE THERE IS A PROBLEM. *TR
ON THE FREEWAY, I SLAMMED ON THE BRAKES, AS THERE WAS AN ACCIDENT IN FRONT OF ME, AND THE REGENERATIVE BRAKES DID NOT ACTIVATE WHEN SLAMMING ON THE BRAKES. THE STANDARD ABS DISK BRAKES, WITHOUT REGENERATIVE BRAKING, ARE NOT SUFFICIENT ENOUGH TO STOP THE VEHICLE IN AN EMERGENCY INSTANCE SUCH AS THIS. THIS IS EITHER AN ISSUE WITH …
Read full complaint
ON THE FREEWAY, I SLAMMED ON THE BRAKES, AS THERE WAS AN ACCIDENT IN FRONT OF ME, AND THE REGENERATIVE BRAKES DID NOT ACTIVATE WHEN SLAMMING ON THE BRAKES. THE STANDARD ABS DISK BRAKES, WITHOUT REGENERATIVE BRAKING, ARE NOT SUFFICIENT ENOUGH TO STOP THE VEHICLE IN AN EMERGENCY INSTANCE SUCH AS THIS. THIS IS EITHER AN ISSUE WITH THE REGENERATIVE BRAKES INITIALIZING WHEN THEY ARE NEEDED (WHICH IS A KNOWN ISSUE WITH THE HYBRID MODEL OF THE 2013 VOLKSWAGEN JETTA), OR THE STANDARD ANTI-LOCK DISK BRAKES NOT BEING SUFFICIENT ENOUGH TO STOP THE CAR ACCORDING TO THE FEDERAL MOTOR VEHICLE SAFETY STANDARDS AND REGULATIONS BY THE US DEPARTMENT OF TRANSPORTATION. THE STANDARD THAT THIS VEHICLE FAILS IS: "STANDARD NO. 105 - HYDRAULIC AND ELECTRIC BRAKE SYSTEMS - PASSENGER CARS (EFFECTIVE 1-1-68) THIS STANDARD SPECIFIES REQUIREMENTS FOR VEHICLES EQUIPPED WITH HYDRAULIC AND ELECTRIC SERVICE BRAKE SYSTEMS AND ASSOCIATED PARKING BRAKE SYSTEMS TO ENSURE SAFE BRAKING PERFORMANCE UNDER NORMAL CONDITIONS AND EMERGENCY CONDITIONS" (HTTP://WWW.NHTSA.GOV/CARS/RULES/IMPORT/FMVSS/). THIS FAILURE OF THE BRAKING SYSTEM RESULTED IN ME BEING UNABLE TO STOP THE CAR WITHIN A REASONABLE DISTANCE FOR MY SPEED, AND I REAR ENDED THE CAR IN FRONT OF ME.
HELLO, THE BRAKES ON THE NEW 2013 JETTA HYBRID ARE VERY DIFFICULT TO CONTROL. WHEN I TOLD MY DEALER, I WAS TOLD THAT THE BRAKES BEHAVED AS INTENDED. A GOOGLE SEARCH FOR "JETTA HYBRID BRAKES FEEL WEIRD" SHOWED MULTIPLE REPORTS ON STRANGE BEHAVING BRAKES. I THINK THIS IS A SAFETY ISSUE. I CANNOT COME TO A SMOOTH, STEADY STOP. EITH…
Read full complaint
HELLO, THE BRAKES ON THE NEW 2013 JETTA HYBRID ARE VERY DIFFICULT TO CONTROL. WHEN I TOLD MY DEALER, I WAS TOLD THAT THE BRAKES BEHAVED AS INTENDED. A GOOGLE SEARCH FOR "JETTA HYBRID BRAKES FEEL WEIRD" SHOWED MULTIPLE REPORTS ON STRANGE BEHAVING BRAKES. I THINK THIS IS A SAFETY ISSUE. I CANNOT COME TO A SMOOTH, STEADY STOP. EITHER IT IS TOO FAST OR TOO SLOW AND I HAVE TO SLAM ON THE BRAKES AT THE END. I THINK VW SHOULD BE REQUIRED TO MAKE THE BRAKES ON THE JETTA HYBRID SAFER AND RETROFIT VEHICLES ALREADY ON THE ROAD. THANK YOU FOR YOUR CONSIDERATION. *TR
Official recalls
319V866000 · Power Train:automatic Transmission; Power Train:clutch Assembly
Dec 6, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2015 Jetta Hybrid vehicles equipped with a DQ200 7-Speed DSG Automatic Transmission. Hairline cracks can develop within the transmission electronic gearbox (mechatronic unit), causing an internal transmission oil leak and a decrease in oil pressure.
Consequence & remedy
Consequence: A decrease in transmission oil pressure can cause the clutch to fail to engage, resulting in a sudden loss of drive power, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will install a repair kit and, as necessary, replace affected parts, free of charge. Owner notification letters were mailed June 25, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 34J6.
Additional source detail variants (2)
Power Train:automatic Transmission
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2015 Jetta Hybrid vehicles equipped with a DQ200 7-Speed DSG Automatic Transmission. Hairline cracks can develop within the transmission electronic gearbox (mechatronic unit), causing an internal transmission oil leak and a decrease in oil pressure.
Consequence: A decrease in transmission oil pressure can cause the clutch to fail to engage, resulting in a sudden loss of drive power, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will install a repair kit and, as necessary, replace affected parts, free of charge. Owner notification letters were mailed June 25, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 34J6.
Power Train:clutch Assembly
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2015 Jetta Hybrid vehicles equipped with a DQ200 7-Speed DSG Automatic Transmission. Hairline cracks can develop within the transmission electronic gearbox (mechatronic unit), causing an internal transmission oil leak and a decrease in oil pressure.
Consequence: A decrease in transmission oil pressure can cause the clutch to fail to engage, resulting in a sudden loss of drive power, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will install a repair kit and, as necessary, replace affected parts, free of charge. Owner notification letters were mailed June 25, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 34J6.
19V679000 · Unknown Or Other
Sep 25, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015 Golf Sportwagen, 2013 Golf, 2008-2010 and 2012-2013 Beetle and Beetle Convertible, 2008-2010 Beetle, and Beetle Convertible vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
Consequence & remedy
Consequence: If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Remedy: Volkswagen will notify owners and repurchase the affected vehicles. The recall began November 6, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01D7. Note: This recall is an expansion of NHTSA recall number 18V-329.
13V568000 · Power Train
Nov 14, 2013
Volkswagen Group of America, Inc (Volkswagen) is recalling certain model year 2013-2014 Jetta Hybrid vehicles manufactured October 2012 through October 2013 and equipped with a DQ-200 direct-shift gearbox. Due to gearbox fluid additives, the control module within the gearbox may corrode. The deposits from this corrosion may cause an electrical short and result in a stall-like condition.
Consequence & remedy
Consequence: This sudden loss of power while driving increases the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the gearbox oil with a non-corrosive version, free of charge. The recall began on December 6, 2013. Owners may contact Volkswagen at 1-800-893-5298. Volkswagen's recall number is 34F6/4V.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
EA18003 · Air Bag Clockspring Failure
Opened Apr 18, 2018 · No close date supplied
Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Additional source detail variants (3)
Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Air Bags:frontal
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Air Bags
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
PE15010 · Air Bag Clockspring Failure
Opened Mar 24, 2015 · Closed Sep 28, 2015
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Electrical System
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
Additional source detail variants (3)
Air Bags:frontal
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
Air Bags
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
Electrical System
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.