NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
228 reportsClear category filterMileage unknown · May 19, 2024
Electrical SystemFuel/propulsion SystemService Brakes
While driving my vehicle it shifts into “park”, not sure if it is an electrical issue, transmission, or breaking issue. I have taken to the dealership for repairs they worked on the driver seat sensors, was at the dealership for 10 days. Three days after repairs the same issue occurred, took back to the dealership and they inf…
Read full complaint
While driving my vehicle it shifts into “park”, not sure if it is an electrical issue, transmission, or breaking issue. I have taken to the dealership for repairs they worked on the driver seat sensors, was at the dealership for 10 days. Three days after repairs the same issue occurred, took back to the dealership and they informed me that they could not recreate the issue(possible electrical issue), the service advisor suggested that I should not move around in the seat while driving to correct the issue. Again about three days later the same issue occurred again, this time in heavy traffic and it was difficult to get into “drive”, I have returned the car back to the dealership. At this time, I asked the service manager to take a ride with me, he seemed very surprised when the issue occurred with him in the drivers seat, he also had a hard time getting the car into drive. This seems like a big safety concern for a vehicle to rear end my car.
NHTSA ODI #11589546
Mileage unknown · May 9, 2024
Electrical System
The infotayment system goes completely dark while driving and reboots by itself after a few minutes. This has happened while I'm driving on the highway at 65MPH and on the roads at 40MPH, happens at any speeds. It happens randomly without a warning. Everything simply shuts down. I have videos of two different occasions that it h…
Read full complaint
The infotayment system goes completely dark while driving and reboots by itself after a few minutes. This has happened while I'm driving on the highway at 65MPH and on the roads at 40MPH, happens at any speeds. It happens randomly without a warning. Everything simply shuts down. I have videos of two different occasions that it happened. The dealership ran a diagnostic and said nothing came up. It happened again and same thing - diagnostic and nothing comes up. It happened again, I called VW NA and sent videos but they said it has been resolved. It happened again. Not sure what to do next.
NHTSA ODI #11587954
Mileage unknown · May 9, 2024
Electrical SystemSeatsInjury
The front seats go back and recline to an almost flat position randomly. This has hurt my kids' knees while they've been seating in the back seat. It is also very scary and they yell and scream in pain and panic. There is no pattern to the moving, it happens while stationary. Dealers have refused to look at it because they canno…
Read full complaint
The front seats go back and recline to an almost flat position randomly. This has hurt my kids' knees while they've been seating in the back seat. It is also very scary and they yell and scream in pain and panic. There is no pattern to the moving, it happens while stationary. Dealers have refused to look at it because they cannot replicate it at the time of the service call. I have pictures and videos of some instances but they are random. No warning or alerts pop up. This has been happening randomly since I bought the car one year ago.
NHTSA ODI #11587950
Mileage unknown · May 9, 2024
Electrical System
The horn stopped working without notice; only found out when I was in a near-miss accident and it did not honk. Never got alert or any other notice about horn not working. A car cut me off and I pushed the horn and no noise. I had the car towed to the VW dealership and they ended up replacing the horn because it did not work. I …
Read full complaint
The horn stopped working without notice; only found out when I was in a near-miss accident and it did not honk. Never got alert or any other notice about horn not working. A car cut me off and I pushed the horn and no noise. I had the car towed to the VW dealership and they ended up replacing the horn because it did not work. I do not know when it stopped working.
NHTSA ODI #11587946
Mileage unknown · May 3, 2024
Electrical System
VW/Audi have known this is an issue for years but do not seem to prioritize a fix. The front passenger window often goes down first when trying to close it. I am pleading with the NHTSA to view this is a safety concern and issue a recall to force the manufacturer into what should be a simple software fix. If I deem someone appr…
Read full complaint
VW/Audi have known this is an issue for years but do not seem to prioritize a fix. The front passenger window often goes down first when trying to close it. I am pleading with the NHTSA to view this is a safety concern and issue a recall to force the manufacturer into what should be a simple software fix. If I deem someone approaching my open passenger window and I attempt to close my window only for it to open more, that welcomes a lot of potentially unsafe situations. Here are two examples. The individual could take something off the passenger seat and get away before the driver has a chance to react safely. Or worse, they could possibly open the door if they view this as an invitation to get in. Every other car manufacturer has power windows that work correctly. This isn't hard and is laziness by VW Auto Group to fix it until their hand is forced, especially given that the other 3 windows work just fine.
NHTSA ODI #11586695
Mileage unknown · Apr 27, 2024
Electrical System
VEHICLE INSTRUMENT CLUSTER AND INFOTAINMENT DISPLAYS POWER OFF WHILE VEHICLE IS IN MOTION. NO INFORMATION REGARDING VEHICLE SPEED OR CONTROLS IS DISPLAYED ON THE SCREEN FOR SEVERAL MINUTES WHILE THE VEHICLE SYSTEM RESTARTS. AFTER 5-7 MINUTES, THE INSTRUMENT CLUSTER AND INFOTAINMENT DISPLAY WILL POWER BACK ON. THIS HAS OCCURRED M…
Read full complaint
VEHICLE INSTRUMENT CLUSTER AND INFOTAINMENT DISPLAYS POWER OFF WHILE VEHICLE IS IN MOTION. NO INFORMATION REGARDING VEHICLE SPEED OR CONTROLS IS DISPLAYED ON THE SCREEN FOR SEVERAL MINUTES WHILE THE VEHICLE SYSTEM RESTARTS. AFTER 5-7 MINUTES, THE INSTRUMENT CLUSTER AND INFOTAINMENT DISPLAY WILL POWER BACK ON. THIS HAS OCCURRED MULTIPLE TIMES WITHOUT A SPECIFIC CAUSE OR INDICATION LEADING UP TO THE PROBLEM.
NHTSA ODI #11585636
Mileage unknown · Apr 27, 2024
Electrical SystemExterior Lighting
I was driving down a highway traveling 59 mph around 5:20AM when my infotainment system and lights inside all went dark. The speedometer stayed lit up but changed to an alternate color while I was traveling. I slowed down to make sure I could brake and that all was working. Within about 20-30 seconds the whole system restarted a…
Read full complaint
I was driving down a highway traveling 59 mph around 5:20AM when my infotainment system and lights inside all went dark. The speedometer stayed lit up but changed to an alternate color while I was traveling. I slowed down to make sure I could brake and that all was working. Within about 20-30 seconds the whole system restarted and came back online. This was not necessarily a safety hazard, however the sheer shock of it made cause for my safety because I reacted to it in a somewhat panic sort of way by braking rapidly. I found this forum where others have reported the exact same thing. There were no warning lamps messages or any notice of the occurrence. It all started back up as if nothing happened. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11585604
Mileage unknown · Apr 25, 2024
Electrical SystemStructure
2023 VW ID.4 - While driving the passenger door latch started making a clicking noise and door became ajar triggering a door ajar light on dash information center. Passenger held door from completely opening until it was safe to pull over. Door latch continued to make clicking noises and continued to open itself. A google sea…
Read full complaint
2023 VW ID.4 - While driving the passenger door latch started making a clicking noise and door became ajar triggering a door ajar light on dash information center. Passenger held door from completely opening until it was safe to pull over. Door latch continued to make clicking noises and continued to open itself. A google search revealed recall campaign "Door handle recall 57J5 [NHTSA 23V312] for MY21 and MY22" It was raining out when this happened. Volkswagen clearly hasn't fixed this issue for MY23.
NHTSA ODI #11585341
Mileage unknown · Apr 8, 2024
Electrical SystemStructureUnknown Or Other
I submitted a previous report regarding my passenger front door attempting to open while the vehicle was in motion. Yesterday the door fully opened under motion with my wife as a passenger. It sounds like the latch kept cycling until the door opened. My wife just prior to departure decided to start video recording while driving …
Read full complaint
I submitted a previous report regarding my passenger front door attempting to open while the vehicle was in motion. Yesterday the door fully opened under motion with my wife as a passenger. It sounds like the latch kept cycling until the door opened. My wife just prior to departure decided to start video recording while driving as we both believed the dealer may not be able to replicate the incidents. We have recording of this we can email. The door does attempt to open several times on some days, some days it doesn't. My vehicle according to the dealer is not a part of the affected vin's for the recall. It has not been back to the dealer for evaluation and repair yet. This has become an extremely dangerous situation as an owner or passenger.
NHTSA ODI #11581690
Mileage unknown · Feb 27, 2024
Electrical SystemLane DepartureUnknown Or Other
Center console spontaneously shuts down while driving. After about 3 min, the system reboots, but temporarily the driver console also disappears and the speedometer cannot be seen. A warning that lane assist is not available is shown. The backup rear view cannot be used during the downtime. In this car, this happened three times…
Read full complaint
Center console spontaneously shuts down while driving. After about 3 min, the system reboots, but temporarily the driver console also disappears and the speedometer cannot be seen. A warning that lane assist is not available is shown. The backup rear view cannot be used during the downtime. In this car, this happened three times over a 4 month period with about 2000 total miles driven. In a previous instance in a different ID4, braking was also impacted and additional error messages appeared temporarily.
NHTSA ODI #11574245
Official recalls
13Jan 21, 2026
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2023-2024 ID.4 vehicles. The high voltage (HV) battery cell modules may contain misaligned electrodes that can result in a battery fire.
Consequence & remedy
Consequence: A vehicle fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside immediately after charging and not leave their vehicles charging indoors overnight until the recall repair is complete. Also, owners are advised not to use Level 3 DC chargers and to limit the maximum charge of the battery to 80% until the remedy has been completed. Dealers will replace the high voltage battery cell modules as necessary, free of charge. Owner notification letters were mailed March 18, 2026. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 93EW. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 23, 2026.
Jan 21, 2026
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2023-2025 ID.4 vehicles. The high-voltage battery may overheat.
Consequence & remedy
Consequence: A high-voltage battery that overheats increases the risk of a fire.
Remedy: Dealers will update the high-voltage battery software, and replace the high-voltage battery, as necessary, free of charge. Owner notification letters were mailed March 18, 2026. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 93EA. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 23, 2026.
Dec 3, 2025
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2023-2024 ID.4 vehicles. The high voltage (HV) battery cell modules may contain misaligned electrodes that can result in a battery fire.
Consequence & remedy
Consequence: A vehicle fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside immediately after charging and not leave their vehicles charging indoors overnight until the recall repair is complete. Also, owners are advised not to use Level 3 DC chargers and to limit the maximum charge of the battery to 80% until the remedy has been completed. Dealers will replace the high voltage battery cell modules as necessary, free of charge. Owner notification letters were mailed February 11, 2026. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 93EV. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 5, 2025.
Jun 30, 2025
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2023-2025 Atlas, Atlas Cross Sport and 2023-2024 ID.4 vehicles. Certain bolts on the chassis, brake system and/or suspension (such as bolts for certain cross member, engine mount, control arm, subframe, rear brake carrier, etc.) of affected vehicles may not have been correctly tightened during the manufacturing process.
Consequence & remedy
Consequence: A loss of vehicle control increases the risk of a crash.
Remedy: Dealers will replace the bolts as necessary, free of charge. Owner notification letters were mailed July 25, 2025. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 42HX.
Additional source detail variants (2)
Suspension
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2023-2025 Atlas, Atlas Cross Sport and 2023-2024 ID.4 vehicles. Certain bolts on the chassis, brake system and/or suspension (such as bolts for certain cross member, engine mount, control arm, subframe, rear brake carrier, etc.) of affected vehicles may not have been correctly tightened during the manufacturing process.
Consequence: A loss of vehicle control increases the risk of a crash.
Remedy: Dealers will replace the bolts as necessary, free of charge. Owner notification letters were mailed July 25, 2025. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 42HX.
Service Brakes
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2023-2025 Atlas, Atlas Cross Sport and 2023-2024 ID.4 vehicles. Certain bolts on the chassis, brake system and/or suspension (such as bolts for certain cross member, engine mount, control arm, subframe, rear brake carrier, etc.) of affected vehicles may not have been correctly tightened during the manufacturing process.
Consequence: A loss of vehicle control increases the risk of a crash.
Remedy: Dealers will replace the bolts as necessary, free of charge. Owner notification letters were mailed July 25, 2025. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 42HX.
Feb 27, 2025
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021-2023 ID.4, 2022-2023 Audi Q4 e-Tron, and Q4 e-Tron Sportback vehicles. The instrument panel may not properly display the transmission gear lever indicator. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect."
Consequence & remedy
Consequence: Failure to display the gear position may result in a vehicle rollaway if the parking brake is not engaged, increasing the risk of a crash.
Remedy: Dealers will update the brake control unit software, free of charge. Owner notification letters were mailed March 14, 2025. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 97H3. Audi's number for this recall is 454R.
Additional source detail variants (2)
Power Train:automatic Transmission:gear Position Indication (prndl)
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021-2023 ID.4, 2022-2023 Audi Q4 e-Tron, and Q4 e-Tron Sportback vehicles. The instrument panel may not properly display the transmission gear lever indicator. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect."
Consequence: Failure to display the gear position may result in a vehicle rollaway if the parking brake is not engaged, increasing the risk of a crash.
Remedy: Dealers will update the brake control unit software, free of charge. Owner notification letters were mailed March 14, 2025. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 97H3. Audi's number for this recall is 454R.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021-2023 ID.4, 2022-2023 Audi Q4 e-Tron, and Q4 e-Tron Sportback vehicles. The instrument panel may not properly display the transmission gear lever indicator. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect."
Consequence: Failure to display the gear position may result in a vehicle rollaway if the parking brake is not engaged, increasing the risk of a crash.
Remedy: Dealers will update the brake control unit software, free of charge. Owner notification letters were mailed March 14, 2025. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 97H3. Audi's number for this recall is 454R.
Nov 20, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2023 ID.4 vehicles. The rearview camera image may not display when the vehicle is placed in reverse or when the park function is manually activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A blank rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will replace the peripheral camera control module, free of charge. Owner notification letters were mailed December 26, 2025. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 91B3.
Sep 4, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021-2024 ID.4 vehicles. The door handles may allow water to enter the circuit board assembly, which can cause the doors to open unexpectedly.
Consequence & remedy
Consequence: A vehicle door that opens unexpectedly while driving increases the risk of injury.
Remedy: Volkswagen dealers will inspect and replace the door handles as necessary, and update the vehicle software, free of charge. Owner notification letters were mailed on December 27, 2024. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 57J9. This recall expands previous recall numbers 23V-312 and 23V-213. Vehicles previously repaired under 23V-312 and 23V-213 will need to have the new remedy completed.
Aug 28, 2024
Volkswagen Group of America, Inc. (VW) is recalling certain 2023-2024 ID4 vehicles. The fasteners securing the passenger frontal air bag inflator may be loose.
Consequence & remedy
Consequence: An improperly secured air bag inflator may not deploy as intended, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and replace the air bag as necessary, free of charge. Owner notification letters were mailed October 10, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagens number for this recall is 69E8.
May 15, 2024
Volkswagen Group of America, Inc. (VW) is recalling certain 2021-2023 ID.4 vehicles. Due to a software issue, affected vehicles may experience center displays and instrument panel displays that do not boot, or that sporadically reset. This can result in loss of speedometer information or loss of rearview camera image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays" and 111, "Rear Visibility."
Consequence & remedy
Consequence: Displays that do not show critical information, such as vehicle speed or the rearview camera image, increase the risk of a crash.
Remedy: Dealers will update the vehicle software, free of charge. Owner notification letters were mailed on December 20, 2024. Owners may contact VW customer service at 1-800-893-5298. VW's number for this recall is 919A.
Additional source detail variants (3)
Equipment:electrical:infotainment:software
Volkswagen Group of America, Inc. (VW) is recalling certain 2021-2023 ID.4 vehicles. Due to a software issue, affected vehicles may experience center displays and instrument panel displays that do not boot, or that sporadically reset. This can result in loss of speedometer information or loss of rearview camera image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays" and 111, "Rear Visibility."
Consequence: Displays that do not show critical information, such as vehicle speed or the rearview camera image, increase the risk of a crash.
Remedy: Dealers will update the vehicle software, free of charge. Owner notification letters were mailed on December 20, 2024. Owners may contact VW customer service at 1-800-893-5298. VW's number for this recall is 919A.
Back Over Prevention:software
Volkswagen Group of America, Inc. (VW) is recalling certain 2021-2023 ID.4 vehicles. Due to a software issue, affected vehicles may experience center displays and instrument panel displays that do not boot, or that sporadically reset. This can result in loss of speedometer information or loss of rearview camera image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays" and 111, "Rear Visibility."
Consequence: Displays that do not show critical information, such as vehicle speed or the rearview camera image, increase the risk of a crash.
Remedy: Dealers will update the vehicle software, free of charge. Owner notification letters were mailed on December 20, 2024. Owners may contact VW customer service at 1-800-893-5298. VW's number for this recall is 919A.
Electrical System:instrument Panel:speedometer/odometer
Volkswagen Group of America, Inc. (VW) is recalling certain 2021-2023 ID.4 vehicles. Due to a software issue, affected vehicles may experience center displays and instrument panel displays that do not boot, or that sporadically reset. This can result in loss of speedometer information or loss of rearview camera image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays" and 111, "Rear Visibility."
Consequence: Displays that do not show critical information, such as vehicle speed or the rearview camera image, increase the risk of a crash.
Remedy: Dealers will update the vehicle software, free of charge. Owner notification letters were mailed on December 20, 2024. Owners may contact VW customer service at 1-800-893-5298. VW's number for this recall is 919A.
Dec 7, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2023-2024 ID.4 vehicles. The interior sunshade for the panoramic glass roof may be insufficiently fire retardant. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 302, "Flammability of Interior Materials."
Consequence & remedy
Consequence: In a fire, fabric that is not fire retardant may further fuel a fire, increasing the risk of injury.
Remedy: Dealers will apply flame retardant to the sunshade fabric, free of charge. Owner notification letters were mailed December 15, 2023. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 60G3.
Dec 29, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2023 ID4 rear-wheel drive vehicles. The 12-Volt battery charging cable may contact the steering column shaft and cause the cable insulation to wear, possibly resulting in a short circuit.
Consequence & remedy
Consequence: A short circuit may cause a loss of drive power, increasing the risk of a crash. A short circuit also increases the risk of a vehicle fire.
Remedy: Owners are advised to park outside and away from structures until the remedy has been completed. Dealers will inspect the 12-Volt battery charging cable and repair or replace it, as necessary, free of charge. Owner notification letters are expected to be mailed February 27, 2023. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 97HA.
Nov 9, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2023 ID4 vehicles. The electric motor sealing ring was improperly assembled, which may allow coolant to leak into the high-voltage system and interfere with the CAN communication and power supply.
Consequence & remedy
Consequence: Coolant that leaks into the high-voltage system may impact safety-critical systems and warning lights, causing a loss of vehicle control or unintended air bag deployment, and increasing the risk of a crash or injury.
Remedy: Dealers will inspect and replace the electric motor, if necessary, free of charge. Owner notification letters are expected to be mailed January 6, 2023. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 19Q9.
Nov 2, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022 Golf R A8, Audi S3, RS3 Sedan, Q4 E-Tron SUV, A3 Sedan, and 2022-2023 Volkswagen Golf GTI, and ID4 vehicles. The rearview camera image may be blank or unresponsive when the vehicle is placed in reverse gear or when the park function is manually activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed to Audi owners February 14, 2023. Volkswagen owners will receive an owner notification letter once remedy parts become available. Owners may contact Volkswagen's customer service at 1-800-893-5298 and Audi's customer service at 1-800-253-2834. Volkswagen's numbers for this recall are (Volkswagen) 91EK and (Audi) 91EL.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ24010 · Inadvertent Door Opening
Opened May 16, 2024 · Closed Nov 4, 2024
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
On May 16, 2024, the Office of Defects Investigations (ODI) opened Recall Query (RQ) RQ24010 to investigate the remedy and scope of recalls 23V-213 and 23V-312. The affected vehicles by these recalls included model years (MY) 2021 through 2023 Volkswagen ID.4 vehicles. ODI received reports of the vehicle’s doors opening while the vehicle was in motion post recall remedy. ODI, also, received similar allegations on vehicles that were outside the scope of the recalls. Volkswagen issued recall 23V-213 on March 29, 2023, and recall 23V-213 on May 03, 2023. These recalls addressed the defect of water ingress into the circuit board assembly of the door handle. Water ingress can cause communication issues between the door handle and the door control until. This malfunction resulted in the vehicle door inadvertently opening while the vehicle was in motion. Over the course of the investigation, ODI received 17 unique VIN VOQ complaints of the vehicle doors opening while the vehicle was in motion occurring either post recall remedy or on a vehicle that was outside the recall scope. Volkswagen submitted 190 unique VIN complaints reporting the same circumstances. On September 4, 2024, Volkswagen submitted recall 24V-651 to address the issue of inadvertent opening of the door while the vehicle is in motion. The scope of this recall expands the affected vehicles to include all MY2021-2024 Volkswagen ID.4 models, including those remedied under the subject recalls. The recall remedy consists of replacement of the door handle assembly on all four doors as well as a software update. The software update is performed to update the door handle parameters. The new door handle will have the membrane relocated to the back of the handle to avoid standing water within the handle. Also, a protective coating will be on the front and back of the circuit board to avoid direct moisture formation. In view of the action being taken by Volkswagen, Recall 24V-651, ODI is closing this Recall Query. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration