Vehicle started to show intermittent coolant gauge fluctuation with simultaneous loss of cruise control function. The coolant gauge would show cold, then hot. After visiting a dealer, a coolant leak was identified from a crack in the Thermostat/Water Pump housing along with corrosion in the coolant bottle. In addition, the trunk…
Read full complaint
Vehicle started to show intermittent coolant gauge fluctuation with simultaneous loss of cruise control function. The coolant gauge would show cold, then hot. After visiting a dealer, a coolant leak was identified from a crack in the Thermostat/Water Pump housing along with corrosion in the coolant bottle. In addition, the trunk latch failed, likely from a faulty windshield washer fluid valve leaking onto the electrical equipment. All parts were replaced. Within another 3 months the fuel pump failed and needed to be replaced. All parts were repaired at a Volkswagen Dealer. The overheating of the engine and failure of the fuel pump could have caused engine failure and the car to lose immediate power, causing a fire or crash. The faulty rear door latch could have caused the door to open while driving. All of these issues occurred without warning. Check engine light, EPC and disabled cruise control lights came on at the time of the problem. The vehicle also restricted the speed of the car and maximum RPMs allowed.
NHTSA ODI #11483589
Mileage unknown · Nov 8, 2021
EnginePower Train
Plastic Thermostat Housing Failure-- Cracks and leaking coolant. While getting an oil change done at a local Volkswagen dealership, the mechanic pointed out that there is a coolant leak and showed me where the leak is coming from (Thermostat housing/water pump) The coolant is slowly seep out of the crack on the underside of th…
Read full complaint
Plastic Thermostat Housing Failure-- Cracks and leaking coolant. While getting an oil change done at a local Volkswagen dealership, the mechanic pointed out that there is a coolant leak and showed me where the leak is coming from (Thermostat housing/water pump) The coolant is slowly seep out of the crack on the underside of the thermostat housing, I have been adding coolant every other week. As the loss of coolant often trips the low coolant warning if the level isn't maintained. I feel like I'm not the only one with this issue, after reading online Volkswagen community. Many 2015-2020 GTI owners are also having the same problem. The car overheated couple times when stuck in New York traffic, I would like Volkswagen manufacture to address this issue and give all the GTI owners an explanation to why their part fails less than a few years of ownership.
NHTSA ODI #11439765
57,000 miles · Sep 26, 2020
Power Train
I HAD MY THERMOSTAT HOUSING REPLACED TO DUE LEAKAGE. I WANTED TO FILE A COMPLAINT BECAUSE I BELIEVE THIS IS A REOCCURRING ISSUE THAT CAN LEAD TO ENGINE DAMAGE. THIS HAS HAPPENED GRADUALLY OVER TIME AND NOT DUE TO ANY INCIDENT WITH ANOTHER VEHICLE. THIS WAS DISCOVERED FROM A VW SERVICE WHEN I WAS AT APPROXIMATELY 57000 MILES.
NHTSA ODI #11361264
85,000 miles · Aug 21, 2020
EnginePower Train
I HAVE A 2015 GTI THAT HAS ONLY 80,000 MILES ON IT. I HAD A REPAIR DONE TO REPLACE VALVES, COIL SPRINGS, SPARK PLUGS AND IGNITION COILS LAST YEAR DUE TO FAILURE OF THE ENGINE. THEY CLAIMED TO FIX THIS PROBLEM AND A YEAR LATER THE SAME EXACT FAILURE HAPPENED. THE FIRST TIME IT COST 3,500 TO FIX WITH A CUSTOMER LOYALTY DISCOUNT. T…
Read full complaint
I HAVE A 2015 GTI THAT HAS ONLY 80,000 MILES ON IT. I HAD A REPAIR DONE TO REPLACE VALVES, COIL SPRINGS, SPARK PLUGS AND IGNITION COILS LAST YEAR DUE TO FAILURE OF THE ENGINE. THEY CLAIMED TO FIX THIS PROBLEM AND A YEAR LATER THE SAME EXACT FAILURE HAPPENED. THE FIRST TIME IT COST 3,500 TO FIX WITH A CUSTOMER LOYALTY DISCOUNT. THIS TIME THEY SUGGEST REPLACING THE ENGINE AT A 14,000 PRICE TAG. THERE IS CLEARLY SOME DESIGN FLAW THAT IS CAUSING THIS REPEATED FAILURE IN SUCH A NEW CAR. VOLKSWAGEN DOESN'T BACK UP THE PREVIOUS REPAIR. WITH THE FREQUENCY OF THIS ISSUE I'M SURE THERE ARE OTHER PEOPLE WITH THIS SAME ISSUE.
NHTSA ODI #11350665
62,000 miles · Jul 7, 2020
Power Train
FAILED WATER PUMP FIXTURE AND GASKETS AT 62000 MILES. LEAKING COOLANT CONSTANTLY AND WARNING LIGHT GOING OFF WHILE DRIVING
NHTSA ODI #11338043
Mileage unknown · Jan 10, 2020
Power Train
VEHICLE IS LEAKING COOLANT. NEEDING TO REPLACE THERMOSTAT HOUSING/WATER PUMP ON VEHICLE. OUT OF WARRANTY. VERY COMMON ISSUE WITH 2015+ VW GTI VEHICLES.
NHTSA ODI #11298340
65,250 miles · Nov 7, 2019
EnginePower Train
WHILE DRIVING TO WORK, MY VEHICLE WOULD LOSE ACCELERATION AS I PRESS ON THE GAS AND WOULD NOT ACCELERATE RIGHT AWAY. ALSO AS I'M IN PARK OR IDLING IN TRAFFIC, THE CAR WOULD SHUT OFF BUT THE VEHICLE LIGHTS WOULD STILL FUNCTION.
NHTSA ODI #11278780
Mileage unknown · Jan 6, 2019
EnginePower TrainCrash
MY CAR STARTS TO FEEL LIKE IT'S GOING TO DIE OUT. THERE IS A TICKING COMING FROM THE ENGINE THAT COMES AND GOES WHEN IDLED. I'VE INFORMED THE DEALERSHIP BUT THEY CAN'T SEEM TO FIND WHAT THE TICKING NOISE IS.
NHTSA ODI #11165476
23,000 miles · May 15, 2018
EnginePower Train
FIRST ISSUE I HAD WAS ABOUT TWO YEARS AFTER PURCHASING MY VEHICLE WAS WITH MY GEAR BOX. I HAVE AN AUTOMATIC "DSG" TRANSMISSION WHICH BEGAN GIVING AN ERROR LIGHT TELLING ME TO TAKE MY CAR TO SERVICE IMMEDIATELY. I TOOK IT TO MY LOCAL VOLKSWAGEN DEALER WHICH ENDED UP REPLACING THE WHOLE BOX UNIT DO TO AN ELECTRICAL SENSOR NOT READ…
Read full complaint
FIRST ISSUE I HAD WAS ABOUT TWO YEARS AFTER PURCHASING MY VEHICLE WAS WITH MY GEAR BOX. I HAVE AN AUTOMATIC "DSG" TRANSMISSION WHICH BEGAN GIVING AN ERROR LIGHT TELLING ME TO TAKE MY CAR TO SERVICE IMMEDIATELY. I TOOK IT TO MY LOCAL VOLKSWAGEN DEALER WHICH ENDED UP REPLACING THE WHOLE BOX UNIT DO TO AN ELECTRICAL SENSOR NOT READING WHEN I'D ENGAGE INTO DRIVE. I WAS UNDER WARRANTY SO IT WAS COST FREE BUT ANOTHER YEAR LATER THE SAME ERROR IS COMING OUT AND WAS TOLD IT WOULD HAVE TO BE REPLACED AGAIN BUT I'M NO LONGER UNDER WARRANTY SO I'D HAVE TO PAY. I FEEL THAT'S PRETTY UNFAIR AND UNACCEPTABLE KNOWING ITS HAPPEN ONCE AND WAS REPLACED BY PROFESSIONALS YET I'M STUCK WITH THE SAME SITUATION. I FEEL THIS PART SHOULD HAVE CAME WITH SOME SORT OF GUARANTEE AFTER BEING REPLACED. I GOT THIS CAR IN NOVEMBER OF 2015 AND IT'S PRETTY SAD THAT IN UNDER 4 YEARS I'M EXPERIENCING THIS SCENARIO. NOW I FEAR OF DRIVING KNOWING THAT ERROR WILL COME ON AT SOME POINT OR WORSE SOMETHING HAPPEN WITH MY GEARS AND THE CAR BE PUT IN ANOTHER GEAR AT RANDOM. AND NOW I'M BEING PLACED IN ANOTHER SITUATION IN WHICH MY WATERPUMP IS LEAKING COOLANT WHICH I FIND VERY UPSETTING KNOWING VOLKSWAGEN HAD THIS SAME ISSUE WITH THE 201-2014 GTI MK6 AND HAD A RECALL YET IT SEEMS THE PROBLEM CONTINUES WITH THE FOLLOWING GENERATION. AND IT'S SAD TO SAY BUT I'M AT THE POINT OF CALLING CORPORATE AND SEEING WHAT THEY CAN DO BECAUSE I HAVEN'T EVEN HIT 50,000 MILES AND THIS IS HAPPENING. AND BOTH OF THIS PARTS ARE PRETTY PRICEY WHEN IT COMES TO LABOR. AT THIS POINT I CAN ONLY HOLD OFF AND SAVE TO HOPEFULLY GET THE WATER PUMP REPLACED BUT AS FAR AS FOR THE TRANSMISSON ISSUE I'LL WAIT TO SEE WHAT CAN BE DONE BECAUSE I FEEL THAT SHOULD BE RESOLVED BY VOLKSWAGEN.
NHTSA ODI #11094059
18,600 miles · Aug 2, 2016
EnginePower Train
THE CLUTCH OPERATION IN MY 2015 VOLKSWAGE GTI (6 SPEED MANUAL TRANSMISSION) IS MALFUNCTIONING TO SUCH A DEGREE THAT I WAS ALMOST IN AN ACCIDENT AND NOW FEAR FOR MY SAFETY. CLUTCH OPERATION IN THE VEHICLE HAS BECOME UNPREDICTABLE, WHEN DEPRESSED THE CLUTCH PEDAL WILL REMAIN ON THE FLOOR AFTER THE PEDAL IS RELEASED, THUS PREVENTIN…
Read full complaint
THE CLUTCH OPERATION IN MY 2015 VOLKSWAGE GTI (6 SPEED MANUAL TRANSMISSION) IS MALFUNCTIONING TO SUCH A DEGREE THAT I WAS ALMOST IN AN ACCIDENT AND NOW FEAR FOR MY SAFETY. CLUTCH OPERATION IN THE VEHICLE HAS BECOME UNPREDICTABLE, WHEN DEPRESSED THE CLUTCH PEDAL WILL REMAIN ON THE FLOOR AFTER THE PEDAL IS RELEASED, THUS PREVENTING THE VEHICLE FROM ACCELERATING. THIS HAS HAPPENED MULTIPLE TIMES WHILE STATIONARY IN TRAFFIC, WHILE IN MOTION AND WHILE ACCELERATING. MOST RECENTLY WHILE ATTEMPTING TO MERGE ONTO A BUSY HIGHWAY THE CLUTCH PEDAL STUCK TO THE FLOOR, THIS NEARLY FORCED ME TO TAKE EVASIVE STEPS INTO A CONSTRUCTION ZONE. AFTER THIS INCIDENT I BROUGHT THE VEHICLE TO THE VOLKSWAGEN DEALERSHIP FOR DIAGNOSIS AND SERVICE. I HAVE HEARD OF SEVERAL ALARMINGLY SIMILAR REPORTS FROM OTHER 2015 GTI OWNERS WHERE THE CAUSE OF THE ISSUE WAS A FAILED ENGINE BEARING THAT RESULTS IN SIDE-TO-SIDE CRANKSHAFT MOVEMENT IN THE ENGINE.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence & remedy
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Additional source detail variants (2)
Fuel System, Gasoline
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Engine And Engine Cooling:exhaust System:emission Control
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015 Volkswagen Golf, and GTI manufactured on February 17, 2014, to May 22, 2014, and Audi A3 manufactured on February 16, 2013, to April 23, 2014. Improper nickel plating of components within the fuel pump may result in the fuel pump failing.
Consequence & remedy
Consequence: If the fuel pump fails, the vehicle will not start, or if the engine is running, it will stop and the vehicle will stall, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the vehicles and replace any affected fuel pumps, free of charge. The recall began on June 16, 2015. Owners may contact Volkswagen at 1-800-893-5298 or Audi at 1-800-253-2834.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2014-2015 Jetta vehicles manufactured March 28, 2014, to November 24, 2014, 2014-2015 Passat vehicles manufactured April 7, 2014, to November 18, 2014, 2015 Golf and GTI vehicles manufactured July 1, 2014, to November 20, 2014, and 2014-2015 Beetle and Beetle Convertible vehicles manufactured March 31, 2014, to November 27, 2014. A sealing cap at the fuel rail may fail, allowing fuel to leak into the engine compartment.
Consequence & remedy
Consequence: A fuel leak, in the presence of an ignition source, can result in a vehicle fire.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel rails with new parts, free of charge. The recall began February 6, 2015. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 24BL. Note: This recall expands and supersedes recall 14V-809 (Volkswagen recall number 24Bi) and only affects vehicles not previously repaired under that campaign.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015 Golf and GTI vehicles manufactured January 27, 2014, to May 12, 2014. In the affected vehicles, the stabilizer link fasteners may come loose and possibly interfere with the steering of the vehicle.
Consequence & remedy
Consequence: A loose stabilizer link may interfere with the vehicle's steering, requiring additional effort to control the vehicle, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the front stabilizer links, free of charge. The recall began in July 2014. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 40K9/1W.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2015 Volkswagen Gti Problems, Complaints & Recalls | Skip That Year
Illustration