Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 11 of 29 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel/propulsion System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports2 injury reports
What owners actually said
29 reports
Mileage unknown · Aug 13, 2023
Fuel/propulsion System
During refueling after low fuel indicator, fuel tank was not able to accept any fuel. During a second attempt, vehicle accepted 0.25 gallons but all of this fuel came gushing out of the tank from the inlet and from the passenger side rear wheel well. Fuel kept leaking for another 20miles until vehicle was taken to the Rochester …
Read full complaint
During refueling after low fuel indicator, fuel tank was not able to accept any fuel. During a second attempt, vehicle accepted 0.25 gallons but all of this fuel came gushing out of the tank from the inlet and from the passenger side rear wheel well. Fuel kept leaking for another 20miles until vehicle was taken to the Rochester Hills, MI VW dealership. The vehicle continued to leak fuel at the dealership and I was requested to park outside due to the risk of a fire. During this 20mile trip, engine was very hesitant and spluttered and almost stalled. No warning lights on dash. My personal safety was at risk since any ignition source would cause a fire due to this fuel leak, vehicle did not show any warning lights besides low fuel. VW dealership information was that the fuel tank suction jet pump needs replacement. No information was shared if the component will be sent to the manufacturer for inspection. No information how this new pump will not cause a repeat event.
NHTSA ODI #11538196
Mileage unknown · Jul 6, 2023
Electrical SystemFuel/propulsion System
I have owned the 2018 VW GTI since new. With 105,000 miles, following a 30 minute highway drive, the EPC light came on and the vehicle entered limp mode. After turning car off, letting it sit 5 minutes, and restarting, EPC light went off and no limp mode. Drove car daily for another week with no observed issues until appointm…
Read full complaint
I have owned the 2018 VW GTI since new. With 105,000 miles, following a 30 minute highway drive, the EPC light came on and the vehicle entered limp mode. After turning car off, letting it sit 5 minutes, and restarting, EPC light went off and no limp mode. Drove car daily for another week with no observed issues until appointment. Brought car to dealer. They identified the fuel injector wiring harness was faulty and needed to be replaced, and fuel injector #3 was dirty and needed to be replaced, at total cost of $1,756. Online search turned up VWP-23-03, a FUEL INJECTOR WIRING HARNESS LIMITED WARRANTY EXTENSION up to 10 years or 120,000 miles for similar VW cars: 2018-2019 Tiguan 2018-2019 Beetle 2018-2020 Passat So the same exact part, on thousands of other VW models produced at the same time, is covered by a warranty extension. The dealer declined to cover this repair. VW Customer Care declined to cover this repair or offer partial coverage. The car has been repaired by dealer (harness was shorted). I am not asking for special treatment. I am looking for fairness. If VW has identified a given component as defective on three different models, and the same component fails on my GTI, then VW should also cover the GTI under the Warranty Extension.
NHTSA ODI #11530629
Mileage unknown · Jan 7, 2023
Exterior Lighting
Headlights don't turn on immediately upon ignition start. Error message appears on infotainment and dashboard. The temporary fix, Turned off the vehicle and locked the car, and tried again and it worked just fine. I took the car for regular service when I had mentioned to them that my headlights were acting up. they told me th…
Read full complaint
Headlights don't turn on immediately upon ignition start. Error message appears on infotainment and dashboard. The temporary fix, Turned off the vehicle and locked the car, and tried again and it worked just fine. I took the car for regular service when I had mentioned to them that my headlights were acting up. they told me they found no fault codes and could not do anything about it. I spoke to a manager and they told me to take pictures if it happens again, so I did. (The picture in the dark) The headlights would not turn on once again in evening in the Auto setting and I had to cycle the car off and on to get them working properly again. Once turned on the driver-side headlight is now a yellow color similar to a halogen light. (The picture in the daytime) Last week I went to warm up the car for 3-5 minutes and when I returned to the vehicle I noticed the driver-side headlight DRL was not Illuminated. I went into the vehicle and saw that there was an error message on the infotainment screen regarding the headlights. I cycled the car on and off and the vehicle went back to "normal" These issues happen on both headlights but is more persistent on the driver side headlight on my vehicle.I mentioned this on a Facebook group to ask if anyone has experienced this and many people are/did, unfortunately, experience this issue, even as far back as the 2015 Model years. Many people mentioned that they went to the dealership(s) and they would not cover the headlight under warranty as according to them it's impossible to have both headlights inoperable at the same time. I am lucky to have a good dealership to where to they actually are replacing the entire headlight assembly on the driverside. But i am worried even with a new headlight assembly, in a few years it will happen again. If this would have happened while driving at nighttime I would’ve not had any visibility whatsoever. Please recall the LED headlights in these vehicles
NHTSA ODI #11500614
Mileage unknown · Oct 24, 2022
Power Train
Received a low coolant warning and then checked the coolant level. Coolant was low and was topped off. One week later the issue recurred as the coolant level and dropped below minimum levels again. Thermostat housing had a slow leak which was discovered by the dealer. This seems to be a flaw in the design of the thermostat housi…
Read full complaint
Received a low coolant warning and then checked the coolant level. Coolant was low and was topped off. One week later the issue recurred as the coolant level and dropped below minimum levels again. Thermostat housing had a slow leak which was discovered by the dealer. This seems to be a flaw in the design of the thermostat housing as multiple owners are reporting the same issue with the same flaw in the thermostat housing.
NHTSA ODI #11490647
Mileage unknown · Sep 14, 2022
EnginePower Train
Vehicle intermittently stalls when coming to a stop in traffic while in gear. Has occurred on multiple separate occasions, but cannot be easily re-produced. When vehicle stalls it can be difficult to restart while in traffic and occurs without warning creating safety hazard. Usually there are no codes stored by the computer w…
Read full complaint
Vehicle intermittently stalls when coming to a stop in traffic while in gear. Has occurred on multiple separate occasions, but cannot be easily re-produced. When vehicle stalls it can be difficult to restart while in traffic and occurs without warning creating safety hazard. Usually there are no codes stored by the computer when this occurs, but check engine light has been noticed. Vehicle has been brought to dealership 3 different times for same issue. Upon first visit starter was replaced. Upon 2nd visit an oxygen sensor was replaced. Upon 3rd visit no further action was taken and I was told by dealer vehicle tested normal with no further repairs being authorized.
NHTSA ODI #11484494
Mileage unknown · Jul 29, 2022
Fuel/propulsion System
Fuel leaking from charcoal canister next to exhaust can lead to fire. Fuel leaking on to ground by passenger side rear wheel. Strong smell of gasoline outside and inside car. Caused dizziness while driving can harm children. No warning or any lights other then strong odour of gasoline from inside/outside of vehicle Similar to …
Read full complaint
Fuel leaking from charcoal canister next to exhaust can lead to fire. Fuel leaking on to ground by passenger side rear wheel. Strong smell of gasoline outside and inside car. Caused dizziness while driving can harm children. No warning or any lights other then strong odour of gasoline from inside/outside of vehicle Similar to safety recall 20Y6 Parts requested for repair by dealer -EVAP can system -Fuel Tank
NHTSA ODI #11476551
Mileage unknown · Nov 10, 2021
Tires
UNKNOWN We have Hankook Ventus S1 Noble 2 225/40R18 tires on our 2018 VW GTI that came OEM, and are the same on the car as when we took possession of the car from the dealer in 2018. The front right tire, has two substantial cracks and one section where a more open gap occurred in the exterior sidewall. In this latter section…
Read full complaint
UNKNOWN We have Hankook Ventus S1 Noble 2 225/40R18 tires on our 2018 VW GTI that came OEM, and are the same on the car as when we took possession of the car from the dealer in 2018. The front right tire, has two substantial cracks and one section where a more open gap occurred in the exterior sidewall. In this latter section, it is very near the tire's tread. We have less than 14,000 miles on this vehicle, as we are retired and did not drive much to begin with, but even less after the Pandemic occurred. Additional Details (below) - I first saw the tire issues on 11/10/2021, but the tire has not yet failed. Per Hankook's earlier recall, I am concerned that the cracks/opening are precursors to failure while in use.
NHTSA ODI #11440068
34,000 miles · Apr 23, 2021
Unknown Or OtherInjury
TRIM ON CENTER CONSOLE ABOVE SHIFTER AND BELOW CENTER CUBBY IS RAZOR SHARP AND HAS CUT MY HAND DEEPLY TWICE WHILE PARKED AND CLEANING INTERIOR SINCE PURCHASING THE CAR.
NHTSA ODI #11413606
6,000 miles · Jan 29, 2021
Fuel/propulsion System
RIGHT FRONT (PASSENGER) SIDE HAS A VERY LOUD CONSISTENT RATTLING NOISE AT AROUND 2000-3500 ENGINE RPM RANGE. READING ALONE AND CONFIRMING WITH OTHER OWNERS OF THE SAME VEHICLE, IT IS A LOOSE FUEL LINE GOING UNDER THE FRONT PASSENGER SIDE RATTLING AGAINST THE CHASSIS. COULD BE A HIGH RISK, NOT SURE, CHECK AND ADVISE.
NHTSA ODI #11390636
500 miles · Dec 26, 2020
Lane DeparturePower TrainSuspension
SO WHAT HAPPEN WAS EVER SINCE I GOT MY 2018 GOLF GTI AUTOBAHN DSG, I'VE EXPERIENCED ISSUES WITH THE TRANSMISSION, IT JERKS WHEN SLOWING DOWN FROM 2ND GEAR TO FIRST AND SOMETIMES FROM 4TH THROUGH 1ST. I TOOK IN THE CAR TO THE DEALERSHIP AND THEY SAID NOTHING WAS WRONG I TOOK IT TO THEM MULTIPLE TIMES AND THEY STILL SAID NOTHING I…
Read full complaint
SO WHAT HAPPEN WAS EVER SINCE I GOT MY 2018 GOLF GTI AUTOBAHN DSG, I'VE EXPERIENCED ISSUES WITH THE TRANSMISSION, IT JERKS WHEN SLOWING DOWN FROM 2ND GEAR TO FIRST AND SOMETIMES FROM 4TH THROUGH 1ST. I TOOK IN THE CAR TO THE DEALERSHIP AND THEY SAID NOTHING WAS WRONG I TOOK IT TO THEM MULTIPLE TIMES AND THEY STILL SAID NOTHING IS WRONG HOWEVER I HAVE SHOWED THEM PROOF THAT THERE IS SOMETHING WRONG WITH THE CAR, I HAVE A SCANNER TOOL AND IT SHOWS THAT I HAVE MULTIPLE CODES FOR TRANSMISSION AND OTHER STUFF AS WELL. THE CAR HAS 7600 MILES WHICH IS BASICALLY BRAND NEW CONSIDERING ITS 2YRS OLD. ALSO WHEN REVERSING THE TRANSMISSION MAY DISENGAGE REPEATEDLY, THIS HAPPENS MOSTLY WHEN REVERSING ON AN INCLINE, HOWEVER THE INCLINE IS AS LITTLE AS 1.5-2%.THE LANE DEPARTURE KEEP FEATURE IS DANGEROUS, LET ME EXPLAIN WHY. WHEN DRIVING ON A ROAD THAT DOESN'T HAVE VISIBLE LINES THE SYSTEM MAY JERK THE STEERING WHEEL HARD TO ONE SIDE DEPENDING ON ROAD CONDITIONS, IF A DRIVER DOESN'T HAVE A GOOD GRIP OF THE STEERING WHEEL, THERE IS A HIGH RISK OF A CRASH. THE SUSPENSION IN THIS CAR IS AMAZING BUT WHEN IT WAS NEW, NOW IT FEELS LIKE THE CAR HAS NO STABILITY AND DOES NOT ABSORB BUMPS IN THE ROAD.MY 2013 TOYOTA COROLLA LE DOES A BETTER JOB AT ABSORBING BUMPS THAN MY 2018 GTI WITH ADAPTIVE DAMPENING. MY CAR USED TO FEEL LIKE A SUPER EXPENSIVE MERCEDES-BENZ OR BMW WHEN IT CAME TO SUSPENSION COMFORT BUT NOW ITS JUST NOT THE SAME AT ALL.SO THE OTHER DAY THIS CRAZY DRIVER SLAMMED ON HIS/HERS BRAKES AND THE AUTOMATIC BRAKING SYSTEM ENGAGED WHICH IS GOOD CAUSE NO ACCIDENTS HAPPENED, HOWEVER THE CAR HAD A HARD TIME ACCELERATING AFTER, IT FELT LIKE THE FRONT BRAKES WERE STILL ENGAGED, BUT AFTER 1 LONG MINUTE THE CAR STARTED MOVING AGAIN NORMALLY UNTIL YOU TRY TO REVERSE AND THEN IT STARTED JERKING REPEATEDLY WHILE GOING IN REVERSE.THIS CAR NEEDS TO BE RECALLED ESPECIALLY THE 6 SPEED DSG TRANSMISSION
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
Volkswagen Group of America, Inc. (Volkswagen) is recalling two 2018 Golf GTI vehicles. The VIN printed on the Federal Certification label may not match the actual VIN on the vehicle. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Consequence & remedy
Consequence: If the stamped vehicle identification number (VIN) does not match the VIN on the Vehicle Certification Label, owners may be unable to tell if their vehicle is under an important safety recall, possibly exposing them to an increased risk of a crash, fire or injury.
Remedy: Volkswagen will notify owners, and dealers will install a correct certification label, free of charge. This recall began July 9, 2020. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01E7.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Golf Sportwagen, 2019 Jetta, 2015-2019 Golf, and 2018-2019 Tiguan vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the rear axle coil springs, free of charge. The recall began April 12, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J5.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas, Passat, Beetle, Beetle Convertible, Golf, Golf SportWagen and GTI and Audi Q5 and SQ5 vehicles. The brake caliper pistons on these vehicles may have insufficient coating, potentially reducing the brake performance.
Consequence & remedy
Consequence: A reduction of braking performance can increase the risk of a crash.
Remedy: Volkswagen and Audi will notify their owners. Audi dealers will bleed the rear brakes. Volkswagen dealers will bleed the front and rear brake calipers. Note: Owners are advised not to drive their vehicles until the brake system has been checked. The recall began June 29, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298 and Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 47N8, 47N9, and 47N6.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2018 Volkswagen Golf Problems, Complaints & Recalls | Skip That Year
Illustration