IllustrationMy car started to loose coolant around 50K. This is a common problem for MK7 Golf which is usually caused by failure of the waterpump housing. VW is aware of this issue since 2016 but never addressed this problem. I request a formal investigation of this issue and demand VW to recall the vehicles.
2017 Volkswagen Golf
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Golf years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
160–25K
1025–50K
250–75K
375–100K
1100–150K
0150K+
32 reports with mileage · 84 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports0 fire reports5 injury reports
What owners actually said
116 reportsIn December 2021, my fuel gauge read empty, so I stopped at a gas station near the Honolulu Airport and VW Honolulu dealership. As I was pumping the gasoline, it began overflowing from the top of the tank, although I had just started pumping. I immediately removed the pump which is when gas began leaking out of the bottom of the…
Read full complaint
In December 2021, my fuel gauge read empty, so I stopped at a gas station near the Honolulu Airport and VW Honolulu dealership. As I was pumping the gasoline, it began overflowing from the top of the tank, although I had just started pumping. I immediately removed the pump which is when gas began leaking out of the bottom of the tank, like a faucet. Luckily, I was right by the dealership, and was able to make it there without anything dangerous happening. After assessing my vehicle, the VW technicians said there was an internal issue with a faulty fuel tank. They said this issue was not something that I caused. Attached are the invoices and notes provided by the technicians.
Fuel leaking out of rear passenger side bumper close to exhaust. VW Dealer believes related to suction pump failure located in the fuel tank. Same issue as detailed in Safety Recall Code: 20Y6 for 2015 and 2016 VW GTI models, but no recall issued for 2017. Component has not been removed from car and can be inspected when needed.…
Read full complaint
Fuel leaking out of rear passenger side bumper close to exhaust. VW Dealer believes related to suction pump failure located in the fuel tank. Same issue as detailed in Safety Recall Code: 20Y6 for 2015 and 2016 VW GTI models, but no recall issued for 2017. Component has not been removed from car and can be inspected when needed. Fuel leaking out of vehicle near exhaust components while driving - fire risk. Was notified by another motorist while at stop light of rapid fuel leak onto road surface. Dealer has confirmed issue. Vehicle inspected by Dealer, but component in question (suction pump from earlier recall) is internal to the fuel tank and requires disassembly. Waiting on feedback from VW corporate. No warning lights
Faulty clock spring causing passenger airbag warning and loss of steering wheel controls, ie: horn, volume, cruise…
On 10/23/2021 in the process of refueling the vehicle in question the gas pump shut off after only pumping less than a gallon of gas. Repeated attempts yielded the same results. Additionally gas would back up and flow down the over flow tube onto the ground. I tried other pumps on subsequent dates with same result. I was able to…
Read full complaint
On 10/23/2021 in the process of refueling the vehicle in question the gas pump shut off after only pumping less than a gallon of gas. Repeated attempts yielded the same results. Additionally gas would back up and flow down the over flow tube onto the ground. I tried other pumps on subsequent dates with same result. I was able to get enough gas into the tank, less than a gallon at a time, to drive the vehicle from 10/23/2021 to 11/2/2021 when the vehicle began to buck or act like it would shut off. I was able to drive home and stopped driving the vehicle on 11/2/2021. I contacted the local VW dealer and made an appointment to have the vehicle looked at on 11/16/2021. This problem isn't unique to my vehicle. There have been a lot of VW/AUDI vehicles that experienced the same or similar problems. On 11/16/2021 the dealer verified the problem I described. Dealer could not get flap to open in tank. Dealer removed EVAP canister and fuel sprayed out. Dealer replaced fuel tank, EVAP canister and other related parts. Repairs were completed and $3896.69 later vehicle runs fine. There were no warning lights to warn me of a problem. Of course, when gasoline and gasoline vapors are present there is always the possibility of damage, injury, or death. Consumer stated recall for vins were issued prior to consumer's vehicle but not his.
I was driving to work today play in my steering wheel made a funky crinkling sound and then I had a warning about my airbag and no horn working now after and I didn't hit anything nor was I hit
On 8/22/21, the aluminum/plastic trim around the gear shifter boot gave me a deep cut on my pinky finger as I removed my phone from the USB adapter. The bleeding did not stop for several hours even after applying pressure and I'm very lucky that I didn't need stitches!!! That aluminum/plastic trim is RAZOR SHARP!!! This is an ex…
Read full complaint
On 8/22/21, the aluminum/plastic trim around the gear shifter boot gave me a deep cut on my pinky finger as I removed my phone from the USB adapter. The bleeding did not stop for several hours even after applying pressure and I'm very lucky that I didn't need stitches!!! That aluminum/plastic trim is RAZOR SHARP!!! This is an extreme safety hazard for drivers and passengers and not to mention children!!! Why Volkswagen has not issued a recall on this dangerously sharp part is appalling!!! I take excellent care of my vehicle and normal wear and tear does not equal a razor sharp edge on a gear shifter boot. This is shoddy craftsmanship and UNSAFE for ALL drivers and passengers. I contacted Volkswagen customer care and they asked me to send pictures of the faulty part and asked me to take it to the nearest dealership so they could assess. The VW dealership assessed the issue and advised they would need to order the part to replace. Volkswagen care agreed to a "goodwill gesture" to have the trim replaced free of charge to me. Fast forward to the dealer replacing the part and I receive the car back...THE TRIM IS STILL RAZOR SHARP!!!! What was the point of that exercise? Volkswagen offered zero help when I advised them of this and closed my case. THIS PART NEEDS TO BE RECALLED SO NO CHILDREN (or ANYONE) GET CUT!!! I am extremely disappointed at how Volkswagen handled this and how they have not done THE RIGHT THING and done a recall for this part. There is precedent for this happening on Volkswagen forums all over the internet!!! I at least want to document this complaint to NHTSA and to point out Volkswagen's bad business practice with this.
Safety: Had a charcoal canister saturated with gasoline resulting in a fuel leak; gasoline was dripping down the rear right side of the car via the charcoal filter and soaking the rear fender. Raw fuel was also being pumped into the air intake of the engine (where air is supposed to go). Fuel tank was bulging due to the high pre…
Read full complaint
Safety: Had a charcoal canister saturated with gasoline resulting in a fuel leak; gasoline was dripping down the rear right side of the car via the charcoal filter and soaking the rear fender. Raw fuel was also being pumped into the air intake of the engine (where air is supposed to go). Fuel tank was bulging due to the high pressure and could have cracked. Other symptoms: Had fuel spillback while refueling, and also could not fill the tank because the handle kept clicking. Car was riding rough and jerking randomly. Failed component: Dealer determined a faulty suction pump was causing liquid fuel to fill the charcoal canister while the car is running. This is the same part that was previously recalled in earlier 2015-2016 Golfs (NHTSA Safety Recall Code: 20Y6, published December 2016). My 2017 Golf (16k miles) was manufactured April 2017 and sold to me in October 2017. On the 2017 Golf, the suction pump is now molded inside the fuel tank in an inaccessible location and cannot be serviced; the entire fuel tank must be replaced. Reproduction: The dealer disconnected the vent lines from the fuel tank and proved that liquid fuel was venting out of the fuel tank and into the charcoal canister via the suction pump (see attached invoice). Inspection: The car was not inspected by the manufacturer, only the dealer. Warnings: There were no warnings or lights. When I first noticed my car jerking, I ran my OBD-II scanner and found a code "P0461 Fuel Level Sensor Circuit Range/Performance" but the car did not report this to the driver (see attached image). Rectifications: The fuel tank should be recalled, and Volkswagen should release a software update to make the P0461 code trigger a Check Engine Light.
My 2017 golf is 21,000 miles now. A gasoline leak occurred. It seems to be the same symptom as 2016 golf recall according to the report as attached. why 2017 golf is not covered for recall? In fact, gasoline leaked onto the street, which was a very dangerous situation. We can provide a video on this matter.
My 2017 VW Golf has been leaking oil and coolant. It was taken to a VW dealership where the problem was diagnosed as a leaking auxiliary bracket gasket behind the thermostat housing. The service advisor told me that the car could randomly undergo a catastrophic loss of power if the component were to totally fail. He advised me n…
Read full complaint
My 2017 VW Golf has been leaking oil and coolant. It was taken to a VW dealership where the problem was diagnosed as a leaking auxiliary bracket gasket behind the thermostat housing. The service advisor told me that the car could randomly undergo a catastrophic loss of power if the component were to totally fail. He advised me not to drive the vehicle due to this possibility and the safety issues involved with abrupt loss of power, especially at highway speeds. I requested that this component be repaired under the VW Powertrain Warranty which is still in force for my vehicle but this coverage has been denied by VW Customer Care. The car continues to leak but has not yet lost power. I am concerned that this is a major safety issue for my car. The car is available for inspection upon request.
Official recalls
524V110000 · Fuel System, Gasoline
Feb 14, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
21V321000 · Unknown Or Other
May 5, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Touareg GP, Tiguan, Golf A6, E-Golf GP, CCF, 2016-2017 Passat GP, 2018-2019 Golf R GP, and 2018 Atlas vehicles. These internal-use vehicles were sold without confirmation that they were built to all applicable regulatory requirements and may have been modified prior to sale. As such, these vehicles may fail to comply with the requirements of various Federal Motor Vehicle Safety Standards.
Consequence & remedy
Consequence: Vehicles that do not meet all regulatory requirements may have an increased risk of injury, crash, or fire.
Remedy: Volkswagen will repurchase the vehicles. Owner notification letters were mailed May 20, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01F1.
19V188000 · Suspension:rear:springs:coil Springs
Mar 6, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Golf Sportwagen, 2019 Jetta, 2015-2019 Golf, and 2018-2019 Tiguan vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the rear axle coil springs, free of charge. The recall began April 12, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J5.
18V464000 · Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module; Steering:column LOCKING:ANTI-THEFT Device
Jul 11, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Additional source detail variants (2)
Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
16V955000 · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module; Air Bags:side/window; Seat Belts:pretensioner
Dec 29, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2017 Audi A7, A4, A6, Volkswagen Golf and Tiguan vehicles and 2016 Volkswagen e-Golf vehicles for driver frontal air bags, passenger frontal air bags or head air bags that may not deploy properly. Additionally, certain 2017 Audi Q7, A4 Sedan, A4 Allroad, and 2018 Audi Q5 vehicles are being recalled because the seat belt pretensioners may not activate properly.
Consequence & remedy
Consequence: In the event of a crash, if the air bags and/or the seat belt pretensioners do not inflate or function properly, the vehicle occupants have an increased risk of injury.
Remedy: Volkswagen and Audi will notify owners, and dealers will replace the affected air bags and seat belt pretensioners, free of charge. The recall began April 2017. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834.
Additional source detail variants (4)
Air Bags:side/window
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2017 Audi A7, A4, A6, Volkswagen Golf and Tiguan vehicles and 2016 Volkswagen e-Golf vehicles for driver frontal air bags, passenger frontal air bags or head air bags that may not deploy properly. Additionally, certain 2017 Audi Q7, A4 Sedan, A4 Allroad, and 2018 Audi Q5 vehicles are being recalled because the seat belt pretensioners may not activate properly.
Consequence: In the event of a crash, if the air bags and/or the seat belt pretensioners do not inflate or function properly, the vehicle occupants have an increased risk of injury.
Remedy: Volkswagen and Audi will notify owners, and dealers will replace the affected air bags and seat belt pretensioners, free of charge. The recall began April 2017. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834.
Air Bags:frontal:driver Side:inflator Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2017 Audi A7, A4, A6, Volkswagen Golf and Tiguan vehicles and 2016 Volkswagen e-Golf vehicles for driver frontal air bags, passenger frontal air bags or head air bags that may not deploy properly. Additionally, certain 2017 Audi Q7, A4 Sedan, A4 Allroad, and 2018 Audi Q5 vehicles are being recalled because the seat belt pretensioners may not activate properly.
Consequence: In the event of a crash, if the air bags and/or the seat belt pretensioners do not inflate or function properly, the vehicle occupants have an increased risk of injury.
Remedy: Volkswagen and Audi will notify owners, and dealers will replace the affected air bags and seat belt pretensioners, free of charge. The recall began April 2017. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834.
Seat Belts:pretensioner
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2017 Audi A7, A4, A6, Volkswagen Golf and Tiguan vehicles and 2016 Volkswagen e-Golf vehicles for driver frontal air bags, passenger frontal air bags or head air bags that may not deploy properly. Additionally, certain 2017 Audi Q7, A4 Sedan, A4 Allroad, and 2018 Audi Q5 vehicles are being recalled because the seat belt pretensioners may not activate properly.
Consequence: In the event of a crash, if the air bags and/or the seat belt pretensioners do not inflate or function properly, the vehicle occupants have an increased risk of injury.
Remedy: Volkswagen and Audi will notify owners, and dealers will replace the affected air bags and seat belt pretensioners, free of charge. The recall began April 2017. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834.
Air Bags:frontal:passenger Side:inflator Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2017 Audi A7, A4, A6, Volkswagen Golf and Tiguan vehicles and 2016 Volkswagen e-Golf vehicles for driver frontal air bags, passenger frontal air bags or head air bags that may not deploy properly. Additionally, certain 2017 Audi Q7, A4 Sedan, A4 Allroad, and 2018 Audi Q5 vehicles are being recalled because the seat belt pretensioners may not activate properly.
Consequence: In the event of a crash, if the air bags and/or the seat belt pretensioners do not inflate or function properly, the vehicle occupants have an increased risk of injury.
Remedy: Volkswagen and Audi will notify owners, and dealers will replace the affected air bags and seat belt pretensioners, free of charge. The recall began April 2017. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
Opened Dec 12, 2023 · Closed Jul 1, 2024
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage:evaporative Emissions:canister; Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Fuel System, Gasoline:storage:evaporative Emissions:canister
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.