Illustration2017 VOLKSWAGEN GOLF. CONSUMER WRITES WITH CONCERNS REGARDS SUNROOF EXPLOSION. *AS THE CONSUMER STATED THE MANUFACTURER REFUSES TO REPAIR THE VEHICLE UNDER WARRANTY CLAIMING THERE MUST HAVE BEEN AN IMPACT FROM OUTSIDE. *JS
2017 Volkswagen Golf
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Golf years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
160–25K
1025–50K
250–75K
375–100K
1100–150K
0150K+
32 reports with mileage · 84 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports0 fire reports5 injury reports
What owners actually said
116 reportsTL* THE CONTACT OWNS A 2017 VOLKSWAGEN GOLF. THE CONTACT STATED THAT THE FRONT ASSIST WARNING INDICATOR ILLUMINATED AND THE "FRONT ASSIST NOT AVAILABLE" MESSAGE WAS DISPLAYED. THE VEHICLE WAS TAKEN TO LIBERTY VOLKSWAGEN (920 S MILWAUKEE AVE, LIBERTYVILLE, IL 60048, (847) 680-8000) WHERE IT WAS DIAGNOSED THAT THE VEHICLE FAILED T…
Read full complaint
TL* THE CONTACT OWNS A 2017 VOLKSWAGEN GOLF. THE CONTACT STATED THAT THE FRONT ASSIST WARNING INDICATOR ILLUMINATED AND THE "FRONT ASSIST NOT AVAILABLE" MESSAGE WAS DISPLAYED. THE VEHICLE WAS TAKEN TO LIBERTY VOLKSWAGEN (920 S MILWAUKEE AVE, LIBERTYVILLE, IL 60048, (847) 680-8000) WHERE IT WAS DIAGNOSED THAT THE VEHICLE FAILED TO CONNECT TO THE SERVER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 7,200. THE VIN WAS NOT AVAILABLE.
SHATTERED SUNROOF FOR 2017 VW GOLF GTI. SUNROOF SHATTERED FOLLOWING A LOUD NOISE WITH NO OBVIOUS DIRECT CAUSE. THERE WERE NO VEHICLES AHEAD AND NO OVERHEADS OR BRIDGES IN THE AREA. EVENT TOOK PLACE ON AUGUST 16TH, 2018 ON A SUNNY MORNING (75-80F), AT 45-55MPH. THE ENTIRE SUNROOF CRACKED FOLLOWING THE LOUD NOISE AND SMALL PIECE…
Read full complaint
SHATTERED SUNROOF FOR 2017 VW GOLF GTI. SUNROOF SHATTERED FOLLOWING A LOUD NOISE WITH NO OBVIOUS DIRECT CAUSE. THERE WERE NO VEHICLES AHEAD AND NO OVERHEADS OR BRIDGES IN THE AREA. EVENT TOOK PLACE ON AUGUST 16TH, 2018 ON A SUNNY MORNING (75-80F), AT 45-55MPH. THE ENTIRE SUNROOF CRACKED FOLLOWING THE LOUD NOISE AND SMALL PIECES BEGAN TO SLOWLY FALL ON TOP OF THE SEE-THROUGH FABRIC SUNROOF SHADE THAT WAS CLOSED AT THE TIME OF THE INCIDENT. LARGER PORTIONS OF THE SUNROOF FELL AS THE VEHICLE RETURNED TO A SAFE LOCATION TO REMOVE THE REMAINING GLASS. SHATTERING GLASS POSES A SAFETY CONCERN TO DRIVERS AND PASSENGERS OF THE AFFECTED VEHICLES, IN ADDITION TO NEARBY MOTORISTS THAT COULD GET IMPACTED BY THE GLASS DEBRIS AT HIGHER SPEEDS. THE USE OF LAMINATED GLASS COULD PREVENT THIS SAFETY CONCERN TO MOTORISTS.
BRAKES SEIZED.
THE SUNROOF LEAKS WATER FROM ALL FOUR COUNTERS INTO THE VEHICLE: HEADLINER, SEATS, CARPET AND DASHBOARD. WARNING SIGNALS/ERRORS MESSAGES: AIR BAG, TRACTION, ENGINE LIGHT. 2500 MILES ON VEHICLE PURCHASED 3/18 NEW. THE VEHICLE WAS PARKED IN A DRIVEWAY DURING A MAJOR RAIN STORM.
JUNE 16,2017 , I PUT THE CAR IN REVERSE AND ATTEMPTED TO LEAVE THE PARKING SPACE. ALL WHEEL BRAKES WERE LOCKED/THE CAR STALLED. 2-3 MINUTES LATER, THEY FREED UP. ON FEB.15,2018 WHILE WAITING IN TRAFFIC ON RT.580 IN DUNEDIN, THEY LOCKED UP AGAIN. 2-3 MINUTES LATER, THEY FREED UP AND I SHUT OFF MY EMERGENCY FLASHERS. MARCH 28 ,20…
Read full complaint
JUNE 16,2017 , I PUT THE CAR IN REVERSE AND ATTEMPTED TO LEAVE THE PARKING SPACE. ALL WHEEL BRAKES WERE LOCKED/THE CAR STALLED. 2-3 MINUTES LATER, THEY FREED UP. ON FEB.15,2018 WHILE WAITING IN TRAFFIC ON RT.580 IN DUNEDIN, THEY LOCKED UP AGAIN. 2-3 MINUTES LATER, THEY FREED UP AND I SHUT OFF MY EMERGENCY FLASHERS. MARCH 28 ,2018 , DITTO IN MY DRIVEWAY AFTER JUST BACKING OUT OF THE GARAGE. TWO VW DEALERS ON MAR.22 AND AGAIN ON APRIL 5, THEIR COMPUTERS COULD FIND NO PROBLEMS WITH THE BRAKING SYSTEM. MY SCAN OF THE INTERNET ALL POINTED TO THE MASTER CYLINDER AS THE PROBLEM. *JS *JS
LOW AND HIGH BEAM LAMPS ARE INADEQUATE AND DO NOT SUFFICIENTLY ILLUMINATE THE ROAD. MUCH DIMMER THAN ANY CAR I HAVE EVER DRIVEN. VW NEEDS TO ADDRESS THIS LIGHTING ISSUE.
THE PROBLEM PRESENTS ITSELF AS TICKING/CLICKING/CRACKING NOISE COMING FROM THE TOP OF THE DRIVER'S SIDE B-PILLAR WHEN THE BODY OF THE CAR FLEXES, FOR EXAMPLE WHEN DRIVING OVER UNEVEN ROAD (EVEN AT PARKING LOT SPEED). AFTER THE DEALERSHIP TRIED TO ADDRESS IT BY REPLACING INTERIOR PANELS AND APPLYING FOAM, THEY WERE ADVISED BY T…
Read full complaint
THE PROBLEM PRESENTS ITSELF AS TICKING/CLICKING/CRACKING NOISE COMING FROM THE TOP OF THE DRIVER'S SIDE B-PILLAR WHEN THE BODY OF THE CAR FLEXES, FOR EXAMPLE WHEN DRIVING OVER UNEVEN ROAD (EVEN AT PARKING LOT SPEED). AFTER THE DEALERSHIP TRIED TO ADDRESS IT BY REPLACING INTERIOR PANELS AND APPLYING FOAM, THEY WERE ADVISED BY THE MANUFACTURER THAT THE ISSUE IS RELATED TO A WELD JOINT, AND 'PERFORMED ADJUSTMENT TO PILLAR SEAM' (AS LISTED ON THE SERVICE RECORD). THIS FAILED TO ADDRESS THE ISSUE, SO AFTER A VISIT FROM A VW REPRESENTATIVE THEY TRIED 'PEENIG OVER' THE SEAM, BUT THE NOISE IS STILL PRESENT. MY CONCERN IS THAT ANY ISSUE RELATED TO A STRUCTURAL COMPONENT OF THE CAR, SUCH AS THE B-PILLAR TO ROOF/DOOR FRAME JOINT, POTENTIALLY COMPROMISES THE STRUCTURAL INTEGRITY AND SAFETY OF THE CAR.
TAKATA RECALL HAVING AN ISSUE WITH ACC OR ADAPTIVE CRUISE CONTROL, INFO SCREEN SAYS ACC NOT AVAILABLE, THIS IS SECOND TIME HAPPENING, FIRST TIME DEALER SAID IT JUST NEEDS CALIBRATION, IT JUST HAPPENED AGAIN. THE CAR IS STILL UNDER WARRANTY, ONCE IT EXPIRES AND IT HAPPENED AGAIN, IT WILL BE OUT OF POCKET EXPENSE. PLEASE TAKE ACTI…
Read full complaint
TAKATA RECALL HAVING AN ISSUE WITH ACC OR ADAPTIVE CRUISE CONTROL, INFO SCREEN SAYS ACC NOT AVAILABLE, THIS IS SECOND TIME HAPPENING, FIRST TIME DEALER SAID IT JUST NEEDS CALIBRATION, IT JUST HAPPENED AGAIN. THE CAR IS STILL UNDER WARRANTY, ONCE IT EXPIRES AND IT HAPPENED AGAIN, IT WILL BE OUT OF POCKET EXPENSE. PLEASE TAKE ACTION TO THIS MATTER, MULTIPLE PEOPLE BEEN HAVING SAME ISSUE.
VEHICLE HAD 300 MILES ON ENGINE WHEN LOW OIL PRESSURE INDICATOR REGISTERED. CAUSE WAS METAL SHAVINGS IN OIL, ACCORDING TO MANUFACTURER AS TOLD TO DEALER. MANUFACTURER INSTRUCTED DEALER TO REPLACE ENGINE AND ALL ASSOCIATED PARTS LUBRICATED BY ENGINE OIL AND SEND NON-FUNCTIONING ENGINE TO MANUFACTURER'S RESEARCH AND DEVELOPMENT …
Read full complaint
VEHICLE HAD 300 MILES ON ENGINE WHEN LOW OIL PRESSURE INDICATOR REGISTERED. CAUSE WAS METAL SHAVINGS IN OIL, ACCORDING TO MANUFACTURER AS TOLD TO DEALER. MANUFACTURER INSTRUCTED DEALER TO REPLACE ENGINE AND ALL ASSOCIATED PARTS LUBRICATED BY ENGINE OIL AND SEND NON-FUNCTIONING ENGINE TO MANUFACTURER'S RESEARCH AND DEVELOPMENT FACILITY; STATED THAT PROBLEM HAS HAPPENED, ALBEIT INFREQUENTLY, TO OTHER LIKE ENGINES. WARRANTY COVERED ALL COSTS. I HAVE INVOICES FOR AUTO PURCHASE AND REPAIR.
Official recalls
524V110000 · Fuel System, Gasoline
Feb 14, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
21V321000 · Unknown Or Other
May 5, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Touareg GP, Tiguan, Golf A6, E-Golf GP, CCF, 2016-2017 Passat GP, 2018-2019 Golf R GP, and 2018 Atlas vehicles. These internal-use vehicles were sold without confirmation that they were built to all applicable regulatory requirements and may have been modified prior to sale. As such, these vehicles may fail to comply with the requirements of various Federal Motor Vehicle Safety Standards.
Consequence & remedy
Consequence: Vehicles that do not meet all regulatory requirements may have an increased risk of injury, crash, or fire.
Remedy: Volkswagen will repurchase the vehicles. Owner notification letters were mailed May 20, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01F1.
19V188000 · Suspension:rear:springs:coil Springs
Mar 6, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Golf Sportwagen, 2019 Jetta, 2015-2019 Golf, and 2018-2019 Tiguan vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the rear axle coil springs, free of charge. The recall began April 12, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J5.
18V464000 · Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module; Steering:column LOCKING:ANTI-THEFT Device
Jul 11, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Additional source detail variants (2)
Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
16V955000 · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module; Air Bags:side/window; Seat Belts:pretensioner
Dec 29, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2017 Audi A7, A4, A6, Volkswagen Golf and Tiguan vehicles and 2016 Volkswagen e-Golf vehicles for driver frontal air bags, passenger frontal air bags or head air bags that may not deploy properly. Additionally, certain 2017 Audi Q7, A4 Sedan, A4 Allroad, and 2018 Audi Q5 vehicles are being recalled because the seat belt pretensioners may not activate properly.
Consequence & remedy
Consequence: In the event of a crash, if the air bags and/or the seat belt pretensioners do not inflate or function properly, the vehicle occupants have an increased risk of injury.
Remedy: Volkswagen and Audi will notify owners, and dealers will replace the affected air bags and seat belt pretensioners, free of charge. The recall began April 2017. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834.
Additional source detail variants (4)
Air Bags:side/window
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2017 Audi A7, A4, A6, Volkswagen Golf and Tiguan vehicles and 2016 Volkswagen e-Golf vehicles for driver frontal air bags, passenger frontal air bags or head air bags that may not deploy properly. Additionally, certain 2017 Audi Q7, A4 Sedan, A4 Allroad, and 2018 Audi Q5 vehicles are being recalled because the seat belt pretensioners may not activate properly.
Consequence: In the event of a crash, if the air bags and/or the seat belt pretensioners do not inflate or function properly, the vehicle occupants have an increased risk of injury.
Remedy: Volkswagen and Audi will notify owners, and dealers will replace the affected air bags and seat belt pretensioners, free of charge. The recall began April 2017. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834.
Air Bags:frontal:driver Side:inflator Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2017 Audi A7, A4, A6, Volkswagen Golf and Tiguan vehicles and 2016 Volkswagen e-Golf vehicles for driver frontal air bags, passenger frontal air bags or head air bags that may not deploy properly. Additionally, certain 2017 Audi Q7, A4 Sedan, A4 Allroad, and 2018 Audi Q5 vehicles are being recalled because the seat belt pretensioners may not activate properly.
Consequence: In the event of a crash, if the air bags and/or the seat belt pretensioners do not inflate or function properly, the vehicle occupants have an increased risk of injury.
Remedy: Volkswagen and Audi will notify owners, and dealers will replace the affected air bags and seat belt pretensioners, free of charge. The recall began April 2017. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834.
Seat Belts:pretensioner
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2017 Audi A7, A4, A6, Volkswagen Golf and Tiguan vehicles and 2016 Volkswagen e-Golf vehicles for driver frontal air bags, passenger frontal air bags or head air bags that may not deploy properly. Additionally, certain 2017 Audi Q7, A4 Sedan, A4 Allroad, and 2018 Audi Q5 vehicles are being recalled because the seat belt pretensioners may not activate properly.
Consequence: In the event of a crash, if the air bags and/or the seat belt pretensioners do not inflate or function properly, the vehicle occupants have an increased risk of injury.
Remedy: Volkswagen and Audi will notify owners, and dealers will replace the affected air bags and seat belt pretensioners, free of charge. The recall began April 2017. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834.
Air Bags:frontal:passenger Side:inflator Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2017 Audi A7, A4, A6, Volkswagen Golf and Tiguan vehicles and 2016 Volkswagen e-Golf vehicles for driver frontal air bags, passenger frontal air bags or head air bags that may not deploy properly. Additionally, certain 2017 Audi Q7, A4 Sedan, A4 Allroad, and 2018 Audi Q5 vehicles are being recalled because the seat belt pretensioners may not activate properly.
Consequence: In the event of a crash, if the air bags and/or the seat belt pretensioners do not inflate or function properly, the vehicle occupants have an increased risk of injury.
Remedy: Volkswagen and Audi will notify owners, and dealers will replace the affected air bags and seat belt pretensioners, free of charge. The recall began April 2017. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
Opened Dec 12, 2023 · Closed Jul 1, 2024
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage:evaporative Emissions:canister; Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Fuel System, Gasoline:storage:evaporative Emissions:canister
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.