NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
51 reportsMileage unknown · Nov 16, 2022
Power Train
In late summer (August 2022) I started seeing a warning but it would disappear so fast. Now it's popping up more: Yellow triangle appears. Engine is giving code# B116229 - "Selector lever park position lock switch Implausible signal" (mileage 104814 km). I originally received a recall notice like this and brought the car into…
Read full complaint
In late summer (August 2022) I started seeing a warning but it would disappear so fast. Now it's popping up more: Yellow triangle appears. Engine is giving code# B116229 - "Selector lever park position lock switch Implausible signal" (mileage 104814 km). I originally received a recall notice like this and brought the car into the dealer. He said there was a VIN "Mix up" - something about the last two digits being reversed with another customer. Reading off my dash, this is my VIN [XXX] This sounds a lot like the "Shift Lever Micro Switch" recall which is a safety issue. Thank you INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA ODI #11493741
86,400 miles · Jul 29, 2022
Engine And Engine CoolingFuel System, Gasoline
The contact owns a 2016 Volkswagen Golf Sportwagen. The contact stated that there was an odor of gasoline in the vehicle. Additionally, the vehicle was stalling while driving. The contact stated she stopped at a gas station and attempted to add gasoline; however, the tank was already full. The contact was able to drive home safe…
Read full complaint
The contact owns a 2016 Volkswagen Golf Sportwagen. The contact stated that there was an odor of gasoline in the vehicle. Additionally, the vehicle was stalling while driving. The contact stated she stopped at a gas station and attempted to add gasoline; however, the tank was already full. The contact was able to drive home safely. After the vehicle was parked, the contact noticed that gasoline was leaking underneath the vehicle. The dealer was contacted and informed that the vehicle had experienced the failure listed in NHTSA Campaign Number: 16V647000 (Fuel System, Gasoline, Engine And Engine Cooling) however, the vehicle was previously repaired under the recall. The contact was informed that the repair would be an out-of-pocket expense. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 86,400.
NHTSA ODI #11476587
Mileage unknown · Jul 11, 2022
Engine
Dealer maintained 2016 VW Golf Sportwagen - coolant level kept getting low. Recent dealer visit indicated a leak in the thermostat housing. This seems to be a common issue with many such VWs, and in some cases other owners have reported multiple repeated failures of this housing. My car only has 66K miles and i haven't had any o…
Read full complaint
Dealer maintained 2016 VW Golf Sportwagen - coolant level kept getting low. Recent dealer visit indicated a leak in the thermostat housing. This seems to be a common issue with many such VWs, and in some cases other owners have reported multiple repeated failures of this housing. My car only has 66K miles and i haven't had any of my other cars have this issue over 25years of various car ownership.
NHTSA ODI #11473452
Mileage unknown · Jul 23, 2021
Suspension
The passenger side rear coil spring snapped without any warning and with in normal highway and city street use with only 46,244 miles and 5 years of age. The was manufactured in August of 2015, was delivered in November of 2015, and the spring failed in the last week of June 2021. The vehicle is used on road and has had all main…
Read full complaint
The passenger side rear coil spring snapped without any warning and with in normal highway and city street use with only 46,244 miles and 5 years of age. The was manufactured in August of 2015, was delivered in November of 2015, and the spring failed in the last week of June 2021. The vehicle is used on road and has had all maintenance done on time or early. I drove the vehicle on June 25th and when I was about 2 miles from home I slowed for an intersection and heard a clank sound from the rear of the vehicle, the remainder of the drive was uneventful. The next day when exiting our garage my wife and I heard a loud clanking sound. I test drove the car around the block and every turn, deceleration, and bump resulted in a clank from the back rear wheel area. The VW dealer confirmed the rear spring had snapped and also noted they had had a number of occurrences on MQB platform VWs and had a Tiguan (same chassis/platform) of similar age in the shop for the same reason. I drove slowly and on low roads to the dealer but it was clear the handling was compromised as it was not predictable in terms of both motions over bumps or when turning or reaction to steering inputs. I spoke with VW corporate and they confirmed an earlier recall on rear coil springs on VW Golf Sportwagens but that recall impacted the 2015. They were unable to assist with the repair but suggested I contact NHTSA. It is fortunate that the failure occurred when it did and not at highway speeds or severe weather. It is also fortunate no fragments of the spring impacted the tire or break components. I have owned many cars with significantly higher miles and managed armored and police vehicle fleets but have never had a car with so few miles have a spring snap.
NHTSA ODI #11426160
Mileage unknown · May 27, 2021
Air BagsCrash
1. I BELIEVE THE DRIVER'S SIDE AIRBAG MAY HAVE FAILED OR BEEN DISABLED DURING A RECENT COLLISION THAT OCCURRED ON 5/25/21. A DEER STRUCK THE FRONT END OF MY VEHICLE WHILE TRAVELING ON A 55MPH STATE HIGHWAY. THE VEHICLE IS CURRENTLY AT A COLLISION REPAIR SHOP GETTING AN ESTIMATE. THE SHERIFF'S DEPUTY WHO RESPONDED TO THE SCENE GA…
Read full complaint
1. I BELIEVE THE DRIVER'S SIDE AIRBAG MAY HAVE FAILED OR BEEN DISABLED DURING A RECENT COLLISION THAT OCCURRED ON 5/25/21. A DEER STRUCK THE FRONT END OF MY VEHICLE WHILE TRAVELING ON A 55MPH STATE HIGHWAY. THE VEHICLE IS CURRENTLY AT A COLLISION REPAIR SHOP GETTING AN ESTIMATE. THE SHERIFF'S DEPUTY WHO RESPONDED TO THE SCENE GAVE AN INITIAL DAMAGE ESTIMATE OF $9000.00. 2. IMMEDIATELY UPON IMPACT THE AIRBAG ERROR LIGHT ILLUMINATED BUT DID NOT DEPLOY. 3.ON 5/26/21, THE DAY AFTER MY ACCIDENT, I RECEIVED A WARRANTY EXTENSION NOTICE DUE TO A POTENTIAL CLOCK SPRING FAILURE THAT COULD RESULT IN THE DRIVER'S SIDE AIRBAG NOT DEPLOYING. 4. VEHICLE HAS BEEN INSPECTED BY SHERIFF'S DEPT AND IS CURRENTLY BE EVALUATED BY COLLISION SPECIALIST AND INSURANCE ADJUSTER. 5. THE AIRBAG ERROR LIGHT HAD NEVER ILLUMINATED PRIOR TO THE ACCIDENT.
NHTSA ODI #11418740
66,000 miles · Apr 6, 2021
Air BagsElectrical SystemUnknown Or Other
EXISTING NHTSA RECALL 69L2 BUT ON DIFFERENT MODEL YEAR - VW DRIVER SIDE AIRBAG AND HORN/STEERING WHEEL BUTTONS DISABLED. MY AIRBAG WARNING LIGHT CAME ON AND MY HORN AND STEERING WHEEL BUTTONS BECAME DISABLED SIMULTANEOUSLY AS I WAS IN MOTION DRIVING DOWN THE ROAD. NOW MY AIRBAG AND HORN/BUTTONS ARE NOT WORKING INCLUDING CRUI…
Read full complaint
EXISTING NHTSA RECALL 69L2 BUT ON DIFFERENT MODEL YEAR - VW DRIVER SIDE AIRBAG AND HORN/STEERING WHEEL BUTTONS DISABLED. MY AIRBAG WARNING LIGHT CAME ON AND MY HORN AND STEERING WHEEL BUTTONS BECAME DISABLED SIMULTANEOUSLY AS I WAS IN MOTION DRIVING DOWN THE ROAD. NOW MY AIRBAG AND HORN/BUTTONS ARE NOT WORKING INCLUDING CRUISE CONTROL. VW RECALLED EARLIER-MODEL VEHICLES BUT THIS APPEARS TO BE A PROBLEM THAT STILL HASN'T BEEN SOLVED AND AFFECTS MORE THAN JUST THE MODELS LISTED IN THE ORIGINAL RECALL. I CALLED VW CARE TO SEE IF MY VEHICLE WAS COVERED UNDER A CAMPAIGN OR EXTENDED WARRANTY. HOWEVER THE PERSON I SPOKE TO TOLD ME THAT MY CLOCK SPRING WAS NOT COVERED AND I WOULD HAVE TO PAY OUT OF POCKET. THIS IS INFURIATING BECAUSE IT'S A KNOWN ISSUE THAT'S DISABLING MY AIRBAG AND HORN BUT VW IS REFUSING TO TAKE RESPONSIBILITY. JUDGING BY HOW MANY COMPLAINTS I'VE SEEN I AM DEFINITELY NOT ALONE. MY VEHICLE ONLY HAS ~66K MILES. HERE IS A RELATED VW EXTENDED WARRANTY BULLETIN I FOUND POSTED TO YOUR WEBSITE: HTTPS://STATIC.NHTSA.GOV/ODI/TSBS/2018/MC-10149942-9999.PDF INVESTIGATION INTO WHETHER VW DIDN'T RECALL ENOUGH MODELS: HTTPS://WWW.FORBES.COM/SITES/JENSEN/2018/04/21/FEDS-INVESTIGATE-WHETHER-VW-SHOULD-RECALL-MORE-MODELS/?SH=159D58364C60 CUSTOMERS CONTINUING TO HAVE PROBLEMS EVEN AFTER FIXING, SUGGESTING VW HAS NOT FIXED THE ISSUE: HTTPS://WWW.RATCHETANDWRENCH.COM/ARTICLES/6185-VW-CLOCK-SPRING-RECALL-MAY-HAVE-FAILED HTTP://WWW.VWPROBLEMS.COM/CLOCK-SPRING-FAILURE/ MORE COMPLAINTS: HTTPS://WWW.VEHIE.COM/COMPLAINTS/VOLKSWAGEN?VEHIE_MODEL=GOLF+SPORTWAGEN HTTPS://WWW.CARCOMPLAINTS.COM/VOLKSWAGEN/GOLF_SPORTWAGEN/2016/SEAT_BELTS_AIR_BAGS/CLOCK_SPRING_BROKEN.SHTML ARTICLE MENTIONING THAT 15/16 SPORTWAGENS NOTORIOUSLY HAVE CLOCK SPRING ISSUES: HTTPS://WWW.WHEELS.CA/CAR-REVIEWS/BUYING-USED-2015-2019-VOLKSWAGEN-GOLF-SPORTWAGEN/
NHTSA ODI #11406665
63,000 miles · Apr 1, 2021
Structure
I PURCHASED MY 2016 VW GOLF SPORTWAGEN IN 2019. SOON AFTER, THERE WAS A RAINSTORM, AND I REALIZED THE PANORAMIC SUNROOF WAS LEAKING HEAVILY ALONG THE BACK PANEL OF THE CAR. THE DEALERSHIP I PURCHASED THE VEHICLE FROM HAD THE CAR FOR ABOUT A MONTH, AND WAS ABLE TO CORRECT THE PROBLEM, AS WELL AS REPLACE THE HEADLINER. VW ISSUED A…
Read full complaint
I PURCHASED MY 2016 VW GOLF SPORTWAGEN IN 2019. SOON AFTER, THERE WAS A RAINSTORM, AND I REALIZED THE PANORAMIC SUNROOF WAS LEAKING HEAVILY ALONG THE BACK PANEL OF THE CAR. THE DEALERSHIP I PURCHASED THE VEHICLE FROM HAD THE CAR FOR ABOUT A MONTH, AND WAS ABLE TO CORRECT THE PROBLEM, AS WELL AS REPLACE THE HEADLINER. VW ISSUED A RECALL ON THE FRONT SUNROOF DRAINS IN 2020, IN WHICH THEY MODIFIED THE DRAINS. ONCE THIS WAS PERFORMED, THE SUNROOF BEGAN LEAKING AGAIN. I HAVE HAD TO REPLACE THE REAR SENSORS, WHICH WERE DAMAGED DUE TO WATER DAMAGE. THIS REPAIR WAS EXTREMELY COSTLY, BUT I WAS TOLD I COULD DO NOTHING ABOUT IT, BECAUSE VW WON'T COVER COSTS FROM FAULTY PARTS. I AM NOW LOOKING AT ANOTHER COSTLY REPAIR OF THE SUNROOF, AND A SECOND HEADLINER REPLACEMENT, WITHIN 2 YEARS OF OWNING THIS VEHICLE.
NHTSA ODI #11405910
Mileage unknown · Feb 3, 2021
Air BagsSteering
MY STEERING CLOCK SPRING FAILED AT 37K MILES, THERE'S A RECALL BUT VW SAID MY CAR IS NOT AFFECTED, HOWEVER MANY PEOPLE ON THE FORUMS AND CAR GROUPS HAVE HAD THIS ISSUE MORE THAN ONCE, SOME COVERED SOME NOT.
NHTSA ODI #11394513
44,000 miles · Jan 20, 2021
Air Bags
AIRBAG WARNING LIGHT STAYS ON
NHTSA ODI #11389059
41,000 miles · Dec 30, 2020
Air BagsElectrical System
CLOCK SPRING HAS FAILED WITH HORN AND AIRBAG MALFUNCTION.
NHTSA ODI #11385630
Official recalls
3Feb 14, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
Jul 27, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2016 Audi TT Roadster, TT Coupe, S3 Sedan, R8 Coupe, A3 Sedan, A3 Etron, A3 Cabriolet, 2016 Golf Sportwagen, Golf R, Golf GTI, Golf A7, and E Golf vehicles. During air bag deployment, the front passenger air bag may explode or deploy improperly.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking occupants, resulting in serious injury or death. An improper air bag deployment may not properly restrain the occupant, increasing their risk of injury in a crash.
Remedy: Dealers will replace the front-passenger air bag module, free of charge. Owner notification letters were mailed December 16, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298. Audi's customer service at 1-800-253-2834. Volkswagen's number for this recall is 69DY and 61C1.
Jul 11, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Additional source detail variants (2)
Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Steering:column LOCKING:ANTI-THEFT Device
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
Opened Dec 12, 2023 · Closed Jul 1, 2024
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage:evaporative Emissions:canister; Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Fuel System, Gasoline:storage:evaporative Emissions:canister
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration