IllustrationVEHICLE EXPERIENCING FUEL LEAKAGES FROM THE FUEL LINE FIXING. REPAIRS WERE DONE BY A DEALER AT CONSUMER'S COST. PROBLEM IS REOCCURRING, MANUFACTURER NOTIFIED, AND INFORMED CONSUMER THAT THIS VEHICLE WAS NOT COVERED UNDER RECALL 00V039000 DUE TO VIN. *AK
1993 Volkswagen Eurovan
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Eurovan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 82 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports9 fire reports0 injury reports
Fuel System, Gasoline complaints
43 reportsFUEL LINE LEAKS. VW DENIED ANY RECALL DURING SEVERAL TELEPHONE CALLS. *AK
LEAK AT RETURN LINE AND FUEL MANIFOLD. FUEL DRIPPED ON DISTRIBUTOR LOCADED DIRECTLY BELOW. USED HALON FIRE EXTINGUISHER TO PREVENT FIRE.*AK
THE FUEL LINE LEAKED AS I STARTED THE CAR. I SMELLED GAS, TURNED IT OFF AND INVESTIGATED. FUEL WAS DRIPPING FROM THE FITTING. THE FITTING IS RIGHT ABOVE THE DISTRIBUTOR AND CLOSE TO THE EXHAUST MANIFOLD. A FIRE WAS LIKELY IF I HAD DRIVEN THE VAN. I REPLACED THE LINE, PAID OUT OF POCKET SINCE VW DOES NOT SEE THIS AS A MANUFA…
Read full complaint
THE FUEL LINE LEAKED AS I STARTED THE CAR. I SMELLED GAS, TURNED IT OFF AND INVESTIGATED. FUEL WAS DRIPPING FROM THE FITTING. THE FITTING IS RIGHT ABOVE THE DISTRIBUTOR AND CLOSE TO THE EXHAUST MANIFOLD. A FIRE WAS LIKELY IF I HAD DRIVEN THE VAN. I REPLACED THE LINE, PAID OUT OF POCKET SINCE VW DOES NOT SEE THIS AS A MANUFACTURING DEFECT. I HAVE REPLACED LINE BUT A GAS SMELL PERSISTS AND IS PROBABLY LINKED TO A BAD VAPOR RECOVERY SYSTEM. THIS VEHICLE HAS PROBLEMS WITH FUEL LINES, AS OTHER OWNERS CAN TESTIFY. THERE HAVE ONLY BEEN 10 000 SOLD IN THE US AND A REPORTED 3 HAVE CAUGHT ON FIRE AND I KNOW OF SEVERAL IN CANADA. *AK
THIS IS AN ADDENDUM TO THE EARLIER VOQ I POSTED ON 9/10/99. EUROVANS WERE RECALLED IN CANADA FOR THE VERY SAME FUEL LEAK PROBLEM - CANADIAN RECALL # 1994072. THE RECALL IS IN 1994, THEREFORE VW WOULD NOT HAVE HAD ANY NOTICE OF THE PROBLEM UNTIL 1994, AFTER THE 1993 MODEL YEAR PRODUCTION HAD ENDED. THE FUEL SYSTEMS BETWEEN 1992 C…
Read full complaint
THIS IS AN ADDENDUM TO THE EARLIER VOQ I POSTED ON 9/10/99. EUROVANS WERE RECALLED IN CANADA FOR THE VERY SAME FUEL LEAK PROBLEM - CANADIAN RECALL # 1994072. THE RECALL IS IN 1994, THEREFORE VW WOULD NOT HAVE HAD ANY NOTICE OF THE PROBLEM UNTIL 1994, AFTER THE 1993 MODEL YEAR PRODUCTION HAD ENDED. THE FUEL SYSTEMS BETWEEN 1992 CANADIAN AND 1993 US EUROVANS ARE IDENTICAL, THEREFORE THE PROBLEM IS COMMON TO BOTH. *AK
FUEL LINE FITTINGS OVER ENGINE LEAK GASOLINE, TYPICALLY AS WEATHER TURNS COLDER. ONE THREE PORT FITTING AND TWO CONNECTIONS TO LINES RUNNING TO THE GAS TANK ARE INVOLVED. TRANSPORT CANADA ISSUED RECALL # 1994072 FOR 1992 EUROVANS WHICH HAD IDENTICAL COMPONENTS. THIS ISSUE IS COMMON TO 5 CYL VW EUROVANS AS REPORTED TO THE INTER…
Read full complaint
FUEL LINE FITTINGS OVER ENGINE LEAK GASOLINE, TYPICALLY AS WEATHER TURNS COLDER. ONE THREE PORT FITTING AND TWO CONNECTIONS TO LINES RUNNING TO THE GAS TANK ARE INVOLVED. TRANSPORT CANADA ISSUED RECALL # 1994072 FOR 1992 EUROVANS WHICH HAD IDENTICAL COMPONENTS. THIS ISSUE IS COMMON TO 5 CYL VW EUROVANS AS REPORTED TO THE INTERNET EUROVAN LIST. *AK
I BELIEVE IT WAS FUEL LINE RELATED AS THE MAJORITY OF THE FIRE DAMAGE WAS CENTERED AROUND THE CLUSTER OF FUEL LINES ON THE DRIVER'S SIDE OF THE ENGINE, ABOVE THE DISTRIBTOR.
THERE IS A GAS LEAK COMING FROM A GAS LINE THAT GOES TO FUEL INJECTION DUE TO A FACTORY MACHINE PRESSURE CLAMP, POTENTIAL FIRE HAZARD. CLAMP CANNOT BE TIGHTENED, AND THE PARTS NEEDED TO REPAIR ARE UNAVAILABLE. *AK
STARTED UP VEHICLE IN THE DRIVEWAY AND SMELLED GAS. OPENED THE HOOD, AND NOTICED FUEL LEAKAGE. CONTACTED DEALER. DEALER WAS NOT AWARE OF A RECALL FOR THIS PROBLEM. *AK
THE LEAKING CRIMP IS DIRECTLY ABOVE THE DISTRIBUTOR - HENCE A HUGE FIRE HAZARD. *AK
Official recalls
300V039000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Feb 15, 2000
VEHICLE DESCRIPTION: MINI VANS. THE CONNECTING ENDS OF THE FUEL FEED AND RETURN HOSES IN THE ENGINE COMPARTMENT CAN "SETTLE" OVER TIME WHICH COULD CAUSE THE FASTENING CLAMPS TO LOSE THEIR TIGHT FIT AND PERMIT FUEL TO SEEP OUT AT THE HOSE CONNECTION.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL FEED AND RETURN HOSES.
94V058000 · Steering: Steering Wheel/handle Bar
Apr 4, 1994
THESE STEERING WHEELS AND INCLUDE A UNIVERSAL JOINT WHICH IS ATTACHED TO STEERING SHAFTS AND SECURED BY LOCKING BOLTS. THE UNIVERSAL JOINT'S UPPER LOCKING BOLT WAS NOT SUFFICIENTLY TORQUED DURING MANUFACTURE, AND CAN EVENTUALLY LOOSEN.
Consequence & remedy
Consequence: IF THE UPPER LOCKING BOLT HOLDING THE STEERING ASSEMBLY'S UNIVERSAL JOINT LOOSENS, IT CAN RENDER THE STEERING SYSTEM INOPERATIVE AND CAUSE AN ACCIDENT.
Remedy: DEALERS WILL REMOVE THE PRESENT UNIVERSAL UPPER LOCKING BOLT, INSTALL A NEW ONE, AND TORQUE IT TO SPECIFICATIONS.
93V138000 · Parking Brake:conventional:mechanical
Sep 3, 1993
THE HANDLE OF THE EMERGENCY BRAKE CONTAINS A TORSION SPRING WHICH IS DESIGNED TO ENSURE THAT THE LOCKING MECHANISM REMAINS FIRMLY ENGAGED UPON APPLICATION OF THE EMERGENCY BRAKE. SOME OF THESE SPRINGS MAY HAVE BEEN IMPROPERLY INSTALLED.
Consequence & remedy
Consequence: AN IMPROPERLY INSTALLED SPRING CAN CAUSE THE EMERGENCYBRAKE TO RELEASE. IF THE VEHICLE IS NOT PROPERLY SECURED, IT COULD SET ITSELFIN MOTION AND CAUSE AN ACCIDENT.
Remedy: DEALERS WILL INSTALL A LONGER TENSION SPRING TO PROVIDE SUFFICIENT TENSION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1SQ99023 · Fuel Line Leak In Engine Compartment
Opened Oct 7, 1999 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available