IllustrationRIGHT REAR PASSENGER WINDOW MADE A GRINDING NOISE AND WINDOW BECAME INOPERABLE. VW ACKNOWLEDGES THAT THIS IS A KNOWN PROBLEM, BUT NOT A RECALL. REPAIR IS $1200 FOR ONE WINDOW REGULATOR.
2004 Volkswagen Beetle
Owner reports · Recalls · Investigations
More warning signs than most Beetle years
Owner complaints for the 2004 Volkswagen Beetle are substantially higher than the model-year median of 49.
About this comparison →How this year compares
Owner complaints by model year
Compare all Beetle years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
270–25K
6225–50K
11150–75K
7675–100K
31100–150K
5150K+
312 reports with mileage · 37 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 157 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 73 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports13 fire reports2 injury reports
Visibility complaints
62 reportsI HAVE A 2004 VW BEETLE CONVERTIBLE. THE DRIVER'S SIDE WINDOW DOES NOT DROP DOWN IN ORDER TO CLEAR THE CANVAS TOP. I WAS TOLD THIS WAS A REGULATOR ISSUE. NOW MY BACK PASSENGER WINDOW IS FROZEN IN HALF DOWN POSITION. IT CAN NOT BE PULLED UP OR PUSHED DOWN. THERE HAVE BEEN NUMEROUS COMPLAINTS REGARDING THE WINDOW ON THESE MODELS. …
Read full complaint
I HAVE A 2004 VW BEETLE CONVERTIBLE. THE DRIVER'S SIDE WINDOW DOES NOT DROP DOWN IN ORDER TO CLEAR THE CANVAS TOP. I WAS TOLD THIS WAS A REGULATOR ISSUE. NOW MY BACK PASSENGER WINDOW IS FROZEN IN HALF DOWN POSITION. IT CAN NOT BE PULLED UP OR PUSHED DOWN. THERE HAVE BEEN NUMEROUS COMPLAINTS REGARDING THE WINDOW ON THESE MODELS. I HAVE ALSO HAD THE GLASS IN THE CANVAS TOP TO BECOME DETACHED. MY INSURANCE WILL NOT COVER THIS AS DURING THEIR INVESTIGATION THEY FOUND THAT IT IS SO COMMON WITH THIS MODEL OF VEHICLE THAT THEY CAN DEEM IT "NORMAL WEAR AND TEAR." THIS IS NOT RIGHT! MY CAR IS GARAGE KEPT AND SHOULD NOT BE HAVING THESE PROBLEMS! I AM NOT ABLE TO REPLACE ANY PARTS AT THIS TIME BECAUSE OF INCOME. THE CONSUMER IS MADE TO PAY THE BILL FOR VW'S FAULTY MANUFACTORING. *TR
WELL IT HAS BEEN NOTHING BUT TROUBLE. FIRST THING, THE TRANSMISSION WENT BAD AND THEN RIGHT AFTER THAT THERE WAS NO BRAKE LIGHTS. THE TOP WILL NOT COME DOWN BY IT SELF. THE DASH LIGHTS COME ON ( AIR BAG, BRAKES, CHECK ENGINE, EMISSIONS). SOUNDS LIKE THERE ARE HOLES IN THE MUFFLER. LAST BUT NOT LEAST THE RIGHT REAR WINDOW FELL DO…
Read full complaint
WELL IT HAS BEEN NOTHING BUT TROUBLE. FIRST THING, THE TRANSMISSION WENT BAD AND THEN RIGHT AFTER THAT THERE WAS NO BRAKE LIGHTS. THE TOP WILL NOT COME DOWN BY IT SELF. THE DASH LIGHTS COME ON ( AIR BAG, BRAKES, CHECK ENGINE, EMISSIONS). SOUNDS LIKE THERE ARE HOLES IN THE MUFFLER. LAST BUT NOT LEAST THE RIGHT REAR WINDOW FELL DOWN AND THEY WON'T 800 TO FIX, THERE ARE SEVERAL COMPLAINTS ABOUT THIS AND NOTHING IS BEING DONE. *TR
DRIVER SIDE WINDOW FAILED IN THE DOWN POSITION ON MY 2004 NEW BEETLE CONVERTIBLE. THE REGULATOR HAS FAILED ON MANY NEW BEETLES. THE WINDOW REGULATOR HAS BEEN COVERED FOR 2003 - 2005 NEW BEETLE SEDANS BUT NOT CONVERTIBLES. I WANT TO DOCUMENT THAT THE PROBLEM EXISTS ON THE CONVERTIBLES AS WELL. *TR
WINDOW REGULATOR ON OUR 2004 VOLKSWAGEN BEETLE CONVERTIBLE FAILED ON THE SECOND REAR WINDOW ON DECEMBER 18, 2010. THE FIRST OCCURRED ON SEPTEMBER 22, 2010. ACCORDING TO OUR REPAIRMAN, THIS WINDOW REGULATOR IS A VERY POOR DESIGN AND HAPPENS ON MANY BEETLES, EVEN NEW 2010 VERSIONS. VOLKSWAGEN OF AMERICA REFUSES TO ISSUE A RECALL…
Read full complaint
WINDOW REGULATOR ON OUR 2004 VOLKSWAGEN BEETLE CONVERTIBLE FAILED ON THE SECOND REAR WINDOW ON DECEMBER 18, 2010. THE FIRST OCCURRED ON SEPTEMBER 22, 2010. ACCORDING TO OUR REPAIRMAN, THIS WINDOW REGULATOR IS A VERY POOR DESIGN AND HAPPENS ON MANY BEETLES, EVEN NEW 2010 VERSIONS. VOLKSWAGEN OF AMERICA REFUSES TO ISSUE A RECALL OR WARRANTY COVERAGE FOR ITS DESIGN PROBLEM. OUR COST TO REPAIR WILL BE $850 TO $1,000. *TR
TL*THE CONTACT OWNS 2004 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE REAR WINDOW REGULATOR WAS BROKEN ON THE REAR WINDOWS TWICE. THE CONTACT ORIGINALLY HAD TO REPLACE THE PARTS IN JULY OF 2010. THE DEALER DID NOT GIVE A REASON FOR THE FAILURE. THE CONTACT STATED THAT THIS WAS A DEFECT. THE FAILURE MILEAGE WAS 60000 AND THE C…
Read full complaint
TL*THE CONTACT OWNS 2004 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE REAR WINDOW REGULATOR WAS BROKEN ON THE REAR WINDOWS TWICE. THE CONTACT ORIGINALLY HAD TO REPLACE THE PARTS IN JULY OF 2010. THE DEALER DID NOT GIVE A REASON FOR THE FAILURE. THE CONTACT STATED THAT THIS WAS A DEFECT. THE FAILURE MILEAGE WAS 60000 AND THE CURRENT MILEAGE WAS 65000.
THE WINDOW REGULATORS ON THE 2004 NBC ARE DEFECTIVE. BOTH OF MY REAR WINDOWS HAVE BROKEN. ACCORDING TO VW, THERE WAS A CLASS ACTION LAWSUIT WHERE THEY EXTENDED THE WARRANTY ON THESE PARTS FOR 7 YEARS. WHEN I CALLED TO SEE ABOUT MINE THEY SAID THE CONVERTIBLES WERE NOT COVERED, EVEN THOUGH THE SAME PARTS WERE USED. THE WINDOW…
Read full complaint
THE WINDOW REGULATORS ON THE 2004 NBC ARE DEFECTIVE. BOTH OF MY REAR WINDOWS HAVE BROKEN. ACCORDING TO VW, THERE WAS A CLASS ACTION LAWSUIT WHERE THEY EXTENDED THE WARRANTY ON THESE PARTS FOR 7 YEARS. WHEN I CALLED TO SEE ABOUT MINE THEY SAID THE CONVERTIBLES WERE NOT COVERED, EVEN THOUGH THE SAME PARTS WERE USED. THE WINDOWS BROKE WHEN I ROLLED THEM DOWN TO GET THE MORNING CONDENSATION OFF OF THEM. AN OUTSIDE MECHANIC WILL CHARGE ME $260 PER WINDOW VERSUS THE $500 PER WINDOW QUOTED BY VW. *TR
DRIVER SIDE REAR WINDOW FAILED 9-22-10. I PUT THE WINDOWS DOWN. I TRIED TO PUT THE WINDOWS BACK UP AS IT WAS STARTING TO RAIN. THE DRIVER SIDE REAR WINDOW WILL ONLY GO HALF WAY UP AND THEN STOPS AND GOES BACK DOWN. *TR
I HAVE A 2004 VW BEETLE CONVERTIBLE 2.0L GLS AND BOTH FRONT WINDOW REGULATORS ARE BROKEN AT THE SAME TIME. I PULLED ONE OF THE DOORS APART TO SEE WHAT WAS BROKEN AND IT IS A PLASTIC PIECE THAT HOLDS THE MOTOR TO THE REGULATOR. THERE IS NO REASON FOR THIS PART TO BREAK AND ESPECIALLY FOR BOTH SIDES TO BREAK ABOUT THE SAME TIME. T…
Read full complaint
I HAVE A 2004 VW BEETLE CONVERTIBLE 2.0L GLS AND BOTH FRONT WINDOW REGULATORS ARE BROKEN AT THE SAME TIME. I PULLED ONE OF THE DOORS APART TO SEE WHAT WAS BROKEN AND IT IS A PLASTIC PIECE THAT HOLDS THE MOTOR TO THE REGULATOR. THERE IS NO REASON FOR THIS PART TO BREAK AND ESPECIALLY FOR BOTH SIDES TO BREAK ABOUT THE SAME TIME. THE PLASTIC PART THAT IS NEEDED IS NOT SOLD SEPARATE, THE WHOLE WINDOW REGULATOR ASSEMBLY HAS TO BE PURCHASED, SO TO FIX THE WINDOWS WILL COST A LOT OF MONEY. *TR
POWER WINDOW REGULATORS FAIL ON 2004 VW BEETLE CONERTIBLE REAR WINDOWS. I HAVE REPLACED 2 OF TM SO FAR IN 50,000 MILES. THE FIRST ONE WAS $375 FOR THE PARTS ONLY AND NOW THEY HAVE DECIDED TO INCREASE THAT PRICE TO $672! IT IS ABSOLUTELY RIDICULOUS THAT THEY CHARGE THAT MUCH FOR A FAULTY PART AND THE NEW ONES ARE NO BETTER. IF I …
Read full complaint
POWER WINDOW REGULATORS FAIL ON 2004 VW BEETLE CONERTIBLE REAR WINDOWS. I HAVE REPLACED 2 OF TM SO FAR IN 50,000 MILES. THE FIRST ONE WAS $375 FOR THE PARTS ONLY AND NOW THEY HAVE DECIDED TO INCREASE THAT PRICE TO $672! IT IS ABSOLUTELY RIDICULOUS THAT THEY CHARGE THAT MUCH FOR A FAULTY PART AND THE NEW ONES ARE NO BETTER. IF I PAY THE DEALERSHIP TO INSTALL IT, IT IS AT LEAST $1,200. SOMETHING NEEDS TO BE DONE! *TR
Official recalls
308V178000 · Air Bags:frontal:sensor/control MODULE-INACTIVE
Apr 17, 2008
VOLKSWAGEN IS RECALLING 76,900 MY 2004-2005 NEW BEETLE AND MY 2003-2005 NEW BEETLE CONVERTIBLES EQUIPPED WITH AN ADVANCED (DUAL-STAGE) AIR BAG SYSTEM. THIS SYSTEM MAY HAVE AIR BAG FRONTAL CRASH SENSORS THAT CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAIN HIGH TEMPERATURE CONDITIONS. IF THIS OCCURS, THE AIR BAG INDICATOR LIGHT WILL ILLUMINATE AND THE FALLBACK ALGORITHM WILL ENSURE THAT THE FRONT AIR BAGS ALWAYS DEPLOY IN A FRONTAL CRASH IN WHICH THE VEHICLE'S DECELERATION IS HIGH ENOUGH TO ACTIVATE THE FRONTAL AIR BAGS.
Consequence & remedy
Consequence: IN LOW-SEVERITY FRONTAL IMPACTS, THE FRONT AIR BAGS MAY DEPLOY MORE FORCEFULLY THAN DESIGNED, INCREASING THE POSSIBILITY OF INJURY TO OUT-OF-POSITION FRONT SEAT OCCUPANTS.
Remedy: DEALERS WILL INSPECT EACH VEHICLE TO DETERMINE THAT THE SPECIFIC DEFECT CRASH SENSOR IS PRESENT ON ONE OR BOTH SIDES OF THE VEHICLE. ALL OF THE DEFECT CRASH SENSORS WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE JULY 31, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
07V063000 · Exterior Lighting:brake Lights:switch
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
04V586000 · Fuel System, Diesel
Dec 15, 2004
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
Remedy: DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08012 · Front Air Bag Crash Sensor Failure
Opened Feb 15, 2008 · Closed Apr 24, 2008
Status: closed (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CERTAIN SUBJECT VEHICLES, MODEL YEAR (MY) 2003 CONVERTIBLE AND MY 2004 SEDAN AND CONVERTIBLE VEHICLES ARE EQUIPPED WITH AN ADVANCED DUAL-STAGE AIR BAG SYSTEM.THE AIR BAG CRASH SENSORS (#1F0 909 606) CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAIN HIGH TEMPERATURE CONDITIONS.IF THIS OCCURS, THE AIR BAG INDICATOR LIGHT WILL ILLUMINATE AND THE CONTROL MODULE WILL ENABLE A FALLBACK ALGORITHM THAT WILL ENSURE THAT THE FRONT AIR BAG ALWAYS DEPLOYS IN A FRONTAL CRASH IN WHICH THE VEHICLE'S DECELERATION IS HIGH ENOUGH TO ACTIVATE THE FRONTAL AIR BAGS.HOWEVER, IN LOW-SEVERITY FRONTAL IMPACTS, THE FRONT AIR BAGS MAY DEPLOY MORE FORCEFULLY THAN DESIGNED, INCREASING THE POSSIBILITY OF INJURY TO OUT-OF-POSITION FRONT SEAT OCCUPANTS.VOLKSWAGEN WILL INSPECT FOR THE DEFECTIVE CRASH SENSOR AND REPLACE WITH AN UPDATED DESIGN.IN ADDITION, 16,177 EARLY-MY 2005 NEW BEETLE SEDAN AND CONVERTIBLE VEHICLES (BUILT THROUGH OCT 31, 2004) ARE ALSO INCLUDED IN THE RECALL CAMPAIGN.THIS PRELIMINARY EVALUATION IS CLOSED (SEE RECALL 08V-178)