Air BagsService Brakes, AirVehicle Speed ControlCrashInjury
WHILE DRIVING ON A HIGHWAY AT 65 MILES PER HOUR, I ATTEMPTED TO TURN THE CRUISE CONTROL OFF. IT DID NOT GO OFF. THEN I APPLIED THE BRAKES AND THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR WITH NO TENSION. THERE WAS NO BRAKING ACTION AT ALL. I DROVE ALONG SOME GRASSY AREAS ON THE SIDE OF THE HIGHWAY TO SLOW THE CAR, TURNED OF…
Read full complaint
WHILE DRIVING ON A HIGHWAY AT 65 MILES PER HOUR, I ATTEMPTED TO TURN THE CRUISE CONTROL OFF. IT DID NOT GO OFF. THEN I APPLIED THE BRAKES AND THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR WITH NO TENSION. THERE WAS NO BRAKING ACTION AT ALL. I DROVE ALONG SOME GRASSY AREAS ON THE SIDE OF THE HIGHWAY TO SLOW THE CAR, TURNED OFF THE IGNITION BECAUSE THE CAR WAS NO DECELERATING, AND HIT A TREE AT ABOUT 50 MPH. THE AIRBAGS DID NOT GO OFF. THE CAR WAS TOTALLED. THE CAR WAS SOLD TO A JUNK YARD BECAUSE THE REPAIR COSTS WERE TOO HIGH AND BECAUSE THE REPAIR FACILITY SAID THEY COULD NOT DETERMINE WHY THE CRUISE CONTROL AND BRAKES FAILED.
NHTSA ODI #10193906
30,000 miles · Apr 16, 2007
Air Bags
AIRBAG SYSTEM DEFECTIVE, REQUIRING REPAIRS AND REPLACEMENTS, INCLUDING AIRBAG REPLACEMENTS, 11 DIFFERENT TIMES. SINCE SYSTEM DOES NOT WORK AND AIRBAGS DO NOT DEPLOY WHEN SENSORS ARE ON, THIS IS CLEARLY A SAFETY ISSUE. *AK
NHTSA ODI #10187992
20,013 miles · Mar 15, 2007
Air Bags
I AM THE ORIGINAL OWNER OF THIS 2000 VOLKSWAGEN BEETLE. ON JULY 30, 2001 (MILEAGE 20013) I COMPLAINED TO MY DEALERSHIP THAT THE AIR BAG LIGHT WAS ON ALL THE TIME WHILE DRIVING. THEY RECONNECTED THE WIRE UNDER THE DRIVERS SEAT STATING IT WAS LOOSE, POOR FIT. ON NOVEMBER 15, 2002 (MILEAGE 33164) I COMPLAINED AGAIN THAT THE AIR BAG…
Read full complaint
I AM THE ORIGINAL OWNER OF THIS 2000 VOLKSWAGEN BEETLE. ON JULY 30, 2001 (MILEAGE 20013) I COMPLAINED TO MY DEALERSHIP THAT THE AIR BAG LIGHT WAS ON ALL THE TIME WHILE DRIVING. THEY RECONNECTED THE WIRE UNDER THE DRIVERS SEAT STATING IT WAS LOOSE, POOR FIT. ON NOVEMBER 15, 2002 (MILEAGE 33164) I COMPLAINED AGAIN THAT THE AIR BAG LIGHT WAS ON ALL THE TIME. THEY INSPECTED AND FOUND TWO MISC. CODES RESET AND TESTED, SAID ALL IS OK AT THIS TIME. ON SEPTEMBER 3, 2003 (MILEAGE 41463)I COMPLAINED THAT THE AIR BAG LIGHT WAS ON ALL THE TIME, AGAIN. DEALERSHIP TESTED AND SAID I NEEDED D/D AIR BAG, HARNESS AND SEAT BELT REPLACED AT A COST OF $675.00. I DECLINED REPAIR AND CALLED VOLKSWAGEN. ON NOVEMBER 5, 2003 VW SAID THEY WOULD REPAIR THIS PROBLEM FREE OF CHARGE FOR CUSTOMER "GOODWILL". ON JULY 19, 2005 (MILEAGE 61130) I COMPLAINED THAT THE AIR BAG LIGHT WAS ONCE AGAIN ON ALL THE TIME. DEALERSHIP REPOSITIONED CONNECTOR FOR DRIVERS SIDE AIR BAG AND STATED IF IT COMES ON AGAIN WILL NEED NEW AIR BAG. ON NOVEMBER 20, 2006 (MILEAGE 73661) ONCE AGAIN I COMPLAINED THAT THE AIR BAG LIGHT WAS ON ALL THE TIME WHILE DRIVING. I WAS TOLD I NEEDED A NEW DRIVERS SEAT AIR BAG, HARNESS WITH REWIRE TO CONTROL AT A COST OF $1040. ONCE AGAIN I CALLED VOLKSWAGEN AND THIS TIME I WAS TOLD SORRY, THERE IS NOTHING THEY CAN DO TO HELP ME. THIS HAS BEEN AN ON GOING PROBLEM WITH MY VEHICLE AND SPECIFICALLY A HUGE SAFETY ISSUE. PLEASE ADVISE IF THERE IS ANY HELP YOU ARE ABLE TO OFFER. *JB
NHTSA ODI #10185216
Mileage unknown · Feb 13, 2007
Air Bags
THE AIRBAG LIGHT CAME ON IN 2005. THE DEALER SAID THE DRIVER'S AIRBAG HAD TO BE REPLACED. APPROXIMATELY 1 YEAR LATER, THE LIGHT CAME ON AGAIN. THIS TIME THE DEALER SAID THEY "FIXED" IT. I DON'T KNOW WHAT THEY DID. IN JANUARY 2007, THE AIRBAG LIGHT CAME ON AGAIN. I DON'T KNOW WHAT TO DO NOW. I'M WORRIED THAT MY AIRBAGS WON'…
Read full complaint
THE AIRBAG LIGHT CAME ON IN 2005. THE DEALER SAID THE DRIVER'S AIRBAG HAD TO BE REPLACED. APPROXIMATELY 1 YEAR LATER, THE LIGHT CAME ON AGAIN. THIS TIME THE DEALER SAID THEY "FIXED" IT. I DON'T KNOW WHAT THEY DID. IN JANUARY 2007, THE AIRBAG LIGHT CAME ON AGAIN. I DON'T KNOW WHAT TO DO NOW. I'M WORRIED THAT MY AIRBAGS WON'T WORK IN A COLLISION BECAUSE I DON'T KNOW WHAT THE DEALER IS DOING AND THEY CAN'T TELL ME WHAT THE CONTINUING PROBLEM IS. *JB
NHTSA ODI #10182459
54,241 miles · Dec 7, 2006
Air Bags
DT*: THE CONTACT STATED THE AIR BAG LIGHT ON THE DASHBOARD ILLUMINATED. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO DETERMINED THAT THE AIR BAG DRIVER INFLATOR MODULE FAILED.
NHTSA ODI #10175471
Mileage unknown · Dec 1, 2006
Air BagsElectrical SystemEngine And Engine Cooling
AIRBAG SHORT TO GROUND COOLANT SYSTEM SHORT TO GROUND. *JB
NHTSA ODI #10174943
35,500 miles · Nov 6, 2006
Air Bags
AIR BAG DASHBOARD LIGHT LIT AT 24,635 MILES. REPAIR MADE BY DEALER 2/9/05 FOR $308 LABOR AND $44.76 PART (SMALL CABLE UNDER DRIVER'S SEAT). TEXT ON DEALER WORK ORDER: "FOUND THE D/S AIRBAG ASSM. TO HAVE A FAULT IN THE CONNECTOR OF HARNESS. REMOVED SEAT ASSM AND REPLACED HARNESS. SEAT AIRBAG CODES. T/DRIVE TO CONFIRM REPAIR." …
Read full complaint
AIR BAG DASHBOARD LIGHT LIT AT 24,635 MILES. REPAIR MADE BY DEALER 2/9/05 FOR $308 LABOR AND $44.76 PART (SMALL CABLE UNDER DRIVER'S SEAT). TEXT ON DEALER WORK ORDER: "FOUND THE D/S AIRBAG ASSM. TO HAVE A FAULT IN THE CONNECTOR OF HARNESS. REMOVED SEAT ASSM AND REPLACED HARNESS. SEAT AIRBAG CODES. T/DRIVE TO CONFIRM REPAIR." AT 35,500 AIR BAG DASHBOARD LIGHT HAS LIT AGAIN. *NM
NHTSA ODI #10172787
31,000 miles · Apr 12, 2006
Air Bags
WHY WOULD I HAVE SO MUCH TROUBLE TRYING TO GET MY VOLKSWAGEN AIRBAG LIGHT FOR SAFER DRIVING. CANNOT ORDER THE CORRECT PARTS. *NM
NHTSA ODI #10155229
Mileage unknown · Jan 3, 2006
Air Bags
2000 VW BEETLE AIRBAG LIGHT. MY WIFE'S 2000 BEETLE'S AIR BAG LIGHT KEEPS COMING ON. IT HAS BEEN BACK TO VW SERVICE FOUR TIMES TO CORRECT THE PROBLEM. IT STARTED WELL BEFORE THE WARRANTY RAN OUT. EACH TIME THEY REPLACE EITHER THE DRIVER SEAT WIRING HARNESS OR DRIVER SEAT AIRBAG OR BOTH. ONE TIME THEY REPLACED THE CONTROLLER. IT H…
Read full complaint
2000 VW BEETLE AIRBAG LIGHT. MY WIFE'S 2000 BEETLE'S AIR BAG LIGHT KEEPS COMING ON. IT HAS BEEN BACK TO VW SERVICE FOUR TIMES TO CORRECT THE PROBLEM. IT STARTED WELL BEFORE THE WARRANTY RAN OUT. EACH TIME THEY REPLACE EITHER THE DRIVER SEAT WIRING HARNESS OR DRIVER SEAT AIRBAG OR BOTH. ONE TIME THEY REPLACED THE CONTROLLER. IT HAS HAPPENED AGAIN AND AGAIN AND MOST RECENTLY THEY REPLACED THE AIRBAG AND WIRING HARNESS FOR THE FOURTH TIME. THIS TOOK CARE OF THE PROBLEM FOR A WEEK AND THEN AGAIN THE LIGHT COMES ON. VW HAS BEEN GOOD TO COVER THESE REPAIRS EVEN THOUGH THE CAR IS NOW OUT OF WARRANTY BUT AS WE SEE IT, THE PROBLEM HAS NEVER REALLY BEEN FIXED CORRECTLY IN THE FIRST PLACE SO IT'S ONLY RIGHT THAT THEY KEEP SPENDING THEIR DOLLAR TO GET IT RIGHT. IT HAS BEEN EXPLAINED TO US BY VW SERVICE THAT IF THE LIGHT IS ON, THE AIRBAGS SYSTEM WILL NOT FUNCTION IN A CRASH AND THIS CAUSES US GREAT CONCERN. THE VW SERVICE MANAGER CONTACTED VWOA TECH SUPPORT AND THEY SUGGESTED BYPASSING A WIRING CONNECTOR BY RUNNING A WIRE FROM THE CONTROLLER TO THE AIRBAG. (SOUNDS LIKE THEY ARE GRASPING AT STRAWS). PROBLEM IS THEY WANT US TO PAY THE $550 TO PERFORM THIS. VWOA HAS REFUSED TO PAY FOR THIS PROCEDURE. WWW.NEWBEETLE.ORG IS LITTERED WITH AIR BAG PROBLEMS SO IT IS NOT JUST OUR CAR THAT THIS AFFECTS. PLEASE LOOK INTO THESE PROBLEMS AND MAKE VW ACCOUNTABLE FOR THEIR AIR BAG SYSTEMS. SOONER OR LATER SOMEONE IS GOING TO BE KILLED BY THEIR AIRBAG FAILING TO INFLATE. THANK YOU. *NM
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Exterior Lighting:brake Lights
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
THE BRAKE LIGHT SWITCH USED IN NEW BEETLE IS ALSO SPECIFIED IN GOLF AND JETTA MODELS.ONE TYPE OF SWITCH IS USED ON CRUISE EQUIPPED MODELS, A SECOND TYPE IS USED ON NON-CRUISE MODELS.VW REPORTS 86 CONSUMER COMPLAINTS AND 2575 WARRANTY CLAIMS OF INOPERATIVE BRAKE LIGHTS, THE MAJORITY OF WHICH ARE RELATED TO THE BRAKE SWITCH.TWO OF THE VW COMPLAINTS INVOLVE FAILURES THAT WERE ALSO REPORTED TO ODI.ADDITIONALLY, OVER 100,000 BRAKE SWITCH SERVICE COMPONENTS HAVE BEEN SOLD UNDER 4 DIFFERENT PART NUMBERS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN NEW BEETLE IS ALSO SPECIFIED IN GOLF AND JETTA MODELS.ONE TYPE OF SWITCH IS USED ON CRUISE EQUIPPED MODELS, A SECOND TYPE IS USED ON NON-CRUISE MODELS.VW REPORTS 86 CONSUMER COMPLAINTS AND 2575 WARRANTY CLAIMS OF INOPERATIVE BRAKE LIGHTS, THE MAJORITY OF WHICH ARE RELATED TO THE BRAKE SWITCH.TWO OF THE VW COMPLAINTS INVOLVE FAILURES THAT WERE ALSO REPORTED TO ODI.ADDITIONALLY, OVER 100,000 BRAKE SWITCH SERVICE COMPONENTS HAVE BEEN SOLD UNDER 4 DIFFERENT PART NUMBERS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
Exterior Lighting
THE BRAKE LIGHT SWITCH USED IN NEW BEETLE IS ALSO SPECIFIED IN GOLF AND JETTA MODELS.ONE TYPE OF SWITCH IS USED ON CRUISE EQUIPPED MODELS, A SECOND TYPE IS USED ON NON-CRUISE MODELS.VW REPORTS 86 CONSUMER COMPLAINTS AND 2575 WARRANTY CLAIMS OF INOPERATIVE BRAKE LIGHTS, THE MAJORITY OF WHICH ARE RELATED TO THE BRAKE SWITCH.TWO OF THE VW COMPLAINTS INVOLVE FAILURES THAT WERE ALSO REPORTED TO ODI.ADDITIONALLY, OVER 100,000 BRAKE SWITCH SERVICE COMPONENTS HAVE BEEN SOLD UNDER 4 DIFFERENT PART NUMBERS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
2000 Volkswagen Beetle Problems, Complaints & Recalls | Skip That Year
Illustration