Electrical System. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Visibility. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

14 crash reports16 fire reports6 injury reports

Fuel System, Gasoline complaints

5 reports

Clear category filter

50,000 miles · Aug 25, 2007

Electrical SystemEngine And Engine CoolingEquipment

Read full complaint

SINCE I PURCHASED MY BEETLE IN 2001, IT HAS BEEN AN ONGOING MONEY DRAIN. IN 6 YRS. I HAVE REPLACED THE MANUAL TRANSMISSION TWICE, HAD THE BRAKES WORKED ON A NUMBER OF TIMES, BEEN UNABLE TO OPEN THE GAS "DOOR" ON THE CAR W/ THE GAS CAP LATCH, HAD TO REPLACE THE HOOD OPENING LATCH, HAD REPEATED ELECTRICAL FAILURES, PROBLEMS W/ FRONT & REAR LIGHT WIRING, HAD DOOR LOCKS/ALARM FAIL & SUBSEQUENTLY HAD MY LAPTOP STOLEN FROM THE CAR, THE RADIO HAS NOT WORKED FOR 1+ YEAR, & IT'S COVER PANEL IS LOOSE & FALLING BACK INTO THE DASH, THE REAR-VIEW MIRROR SWITCHES HAVE FAILED, THE POWER WINDOW SWITCHES HAVE HAD TO BE REPLACED, THE DRIVERS SIDE DOOR FELL OFF (!) OF ITS TOP HINGE WHEN THE HINGE BROKE WHILE OPENING THE DOOR NORMALLY AT A GAS STATION, THE AIR COMPRESSOR HAS FAILED MANY TIMES, THE A/C IS CURRENTLY NOT WORKING, THE DRIVERS SIDE DOOR LOCK FELL OUT OF THE HANDLE(!!!!), THE CATALYTIC CONVERTER HAS BEEN REPLACED TWICE, & THE LIST GOES ON. CURRENTLY I HAVE NOT BEEN DRIVING THE CAR FOR SEVERAL WKS B/C THOUGH ONLY A WEEK OR TWO OUT OF THE SHOP, AGAIN IT IS HAVING TRANSMISSION PROBLEMS. I AM AT MY WITS END WITH THIS CAR & HAVING RECENTLY GRADUATED FROM COLLEGE, AM NOT IN THE GREATEST POSITION TO HAVE TO BUY A NEW CAR. MOREOVER, I AM SO DISPLEASED W/ THE CAR THAT I WOULD LITERALLY FEEL GUILTY ABOUT TRADING IT IN TO BE SOLD TO SOME OTHER UNSUSPECTING PERSON. VW SHOULD BE SO ASHAMED OF THEMSELVES, & SHOULD BE REIMBURSING OWNERS OF THE 1998 BEETLE IN FULL FOR ALL OF THE STRIFE & TROUBLE THAT THEY HAVE CAUSED. IN FACT, AFTER WRITING THIS & REALIZING HOW MANY PROBLEMS THIS CAR HAS HAD, I MAY TRY TO TAKE LEGAL ACTION - THIS IS TOTALLY UNACCEPTABLE! FINALLY, OUR LOCAL VW DEALER IS TERRIBLE, KEEPING MY CAR FOR WKS. LONGER THAN EXPECTED, ONE TIME LEAVING A CANDY BAR STUCK TO MY PASSENGER SIDE SEAT!!!, AND ACTING LIKE THEY COULD CARE LESS ABOUT THE POOR QUALITY OF THEIR PRODUCTS & LABOR. *TR

NHTSA ODI #10200746

Mileage unknown · Nov 11, 2001

Electrical SystemEquipmentExterior Lighting

LEFT HEADLIGHT WENT OUT FIRST, THEN AGAIN. AIR COMPRESSOR REPLACED 3 TIMES. CAR NOW STALLS. REPLACED FUEL/AIR FILTERS, STILL STALLS. CAR WAS RECALLED FOR THE ELECTRICAL SYSTEM WIRING HARNESS UNDER HOOD, RECALL STATES ALL PROBLEMS I HAVE HAD. I WAS NOT THE OWNER AT TIME OF RECALL. APPARENTLY WAS NOT FIXED AT RECALL. *AK

NHTSA ODI #754379

Mileage unknown · Sep 20, 2001

Electrical SystemExterior LightingFuel System, Gasoline

MANY PROBLEMS/FAILURES BETWEEN 10600 AND 19000 MILES. DASHBOARD LEFT TURN SIGNAL INDICATOR INTERMITTENT FAILURE PERSISTS FOR >1 YEAR AND DEVONHILLS VW REFUSES TO FIX THE PROBLEM BECAUSE IT WOULD BE EXPENSIVE FOR THEM (IN THE MEAN TIME, THE LIGHT IS USELESS SINCE HALF THE TIME IT IS ON, HALF OFF).*AK

NHTSA ODI #752434

Mileage unknown · Sep 13, 2000

Fuel System, Gasoline

I HAVE HAD MY CAR INTO THE DEALER SEVERAL TIMES AND THEY JUST TOLD ME TO KEEP DRIVING UNTIL HTE "DYING" BECAME CLOSER. I TOLD THEM (AND REPORTED IT TO VOLKSWAGEN "CASE # 407289" ) IT WASN'T SAFE FOR ME TO DRIVE THIS CAR I DRIVE 280-320 MILES A DAY. THEY ARE NOW REPLACING THE FUEL INJECTION PUMP (IT SHORTED OUT) THEY ARE CHARGI…

Read full complaint

NHTSA ODI #731356

Mileage unknown · Sep 5, 1999

Fuel System, Gasoline

Read full complaint

ON 9/1/99, I DROVE THE CAR ALL DAY (BOUT 200 MILES) AND DID NOT KNOW THAT THE TOP OF THE GAS TANK WAS LEAKING GAS. (I HAVE NO SENSE OF SMELL!!) UNTIL I GOT HOME AND TOOK A FRIEND TO DINNER AND HE SAID "THIS CAR STINKS LIKE GASOLINE"! WE LOOKED UNDER THE BACK SEAT AND REMOVED THE COVER PLATE AND THE ENTIRE TOP OF THE GAS TANK IN THE AREA OF THE SENDING UNIT RETAINING RING WAS FILLED WITH GAS (ABOUT 1/2 INCH DEEP) . TOOK CAR TO DEALER AND THEY REPLACED THE SEAL ON THE TOP OF THE TANK. TWO DAYS LATER 9/4/99, GAS SMELL RETURNED AND UPON INSPECTION THE SAME THING HAPPENED AGAIN! GAS POURING OUT OF THE CLOSED RETAINING RING!! DUE TO THE HOLIDAY, I HAVE TO WAIT TIL TUES. TO HAVE CAR LOOKED AT. I HAVE ALSO CONTACTED JOE BERTRAN AT VOLKSWAGEN OF AMERICA RE THIS SERIOUS DEFECT.

NHTSA ODI #710951

Official recalls

06V183000 · Exterior Lighting:brake Lights:switch

May 24, 2006

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.

Consequence & remedy

Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.

98V100000 · Electrical System:wiring:front Underhood

May 13, 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ELECTRICAL WIRING LOCATED IN THE ENGINE COMPARTMENT WAS ROUTED TOO CLOSE TO THE ENDGE OF THE VEHICLE'S BATTERY TRAY. THE WIRING CAN BECOME DAMAGED OVER TIME BY CHAFING AND THE AIR-CONDITIONER COMPRESSOR AND/OR THE FUEL PUMP CAN MALFUNCTION.

Consequence & remedy

Consequence: A MALFUNCTION OF THE FUEL PUMP CAN CAUSE THE VEHICLE TO STALL, AND IN SOME INSTANCES, COULD ALSO RESULT IN A WIRING FIRE IN THE ENGINE COMPARTMENT.

Remedy: DEALERS WILL INSTALL A MODIFIED BATTERY TRAY AND INSPECT, PROPERLY ROUTE, AND SECURING THE WIRING IN ACCORDANCE WITH THE RECALL REPAIR INSTRUCTIONS.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ06004 · Brake Light Switch Failure

Opened Feb 28, 2006 · Closed Aug 7, 2006

Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch

BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.

Additional source detail variants (2)

Exterior Lighting:brake Lights:switch

Exterior Lighting:brake Lights

EA03002 · Brake Light Switch

Opened Apr 8, 2003 · Closed Aug 20, 2003

Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch

THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.

Additional source detail variants (2)

Exterior Lighting:brake Lights:switch

Exterior Lighting:brake Lights

PE02084 · Brake Light Switch Operation

Opened Nov 18, 2002 · Closed Apr 8, 2003

Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights:switch

THE BRAKE LIGHT SWITCH USED IN NEW BEETLE IS ALSO SPECIFIED IN GOLF AND JETTA MODELS.ONE TYPE OF SWITCH IS USED ON CRUISE EQUIPPED MODELS, A SECOND TYPE IS USED ON NON-CRUISE MODELS.VW REPORTS 86 CONSUMER COMPLAINTS AND 2575 WARRANTY CLAIMS OF INOPERATIVE BRAKE LIGHTS, THE MAJORITY OF WHICH ARE RELATED TO THE BRAKE SWITCH.TWO OF THE VW COMPLAINTS INVOLVE FAILURES THAT WERE ALSO REPORTED TO ODI.ADDITIONALLY, OVER 100,000 BRAKE SWITCH SERVICE COMPONENTS HAVE BEEN SOLD UNDER 4 DIFFERENT PART NUMBERS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.

Additional source detail variants (2)

Exterior Lighting:brake Lights:switch

Exterior Lighting