NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
74 reportsClear category filter1,000 miles · Oct 25, 2018
Service BrakesUnknown Or Other
WHEN VEHICLE TRAVEL DOWN AN INCLINE LIKE A DRIVEWAY, THE EMERGENCY BREAKING FEATURE WILL UNEXPECTEDLY ENGAGED, CAUSING THE VEHICLE TO COME TO A COMPLETE AND SUDDEN STOP. WHEN THIS OCCURS, I HAVE NO CONTROL OVER THE CONTINUED MOVEMENT OF THE VEHICLE. I AM REQUIRED TO CHANGE GEARS AND/OR RESTART THE VEHICLE IN ORDER TO MOVE THE VE…
Read full complaint
WHEN VEHICLE TRAVEL DOWN AN INCLINE LIKE A DRIVEWAY, THE EMERGENCY BREAKING FEATURE WILL UNEXPECTEDLY ENGAGED, CAUSING THE VEHICLE TO COME TO A COMPLETE AND SUDDEN STOP. WHEN THIS OCCURS, I HAVE NO CONTROL OVER THE CONTINUED MOVEMENT OF THE VEHICLE. I AM REQUIRED TO CHANGE GEARS AND/OR RESTART THE VEHICLE IN ORDER TO MOVE THE VEHICLE AGAIN. THIS POSES A EXTREME SAFETY ISSUE AS THE VEHICLE WILL SHUT DOWN WHEN YOU ARE ATTEMPTING TO PULL OUT OF A PRIVATE DRIVE AND ON TO A ACTIVE ROADWAY, INCREASING THE RISK OF A SIDE ON VEHICLE COLLISION. ISSUE WAS REPORTED TO VW SERVICE DEPARTMENT. SERVICE MANAGER WAS ABLE TO DUPLICATE THE ISSUE. SERVICE MANAGER ALSO TESTED ANOTHER VW ATLAS ON THE SALE LOT WITH THE SAME FEATURE. SERVICE MANAGER REPORTED THAT THE SAME ISSUE OCCURRED WITH THE OTHER ATLAS AS WELL. SERVICE DEPARTMENT WAS UNABLE TO CORRECT THE ISSUE, REPORTING THE VEHICLE IS "OPERATING AS DESIGNED." THIS ISSUE POSES A MAJOR SAFETY ISSUE NO ONLY TO THE DRIVER AND OCCUPANTS OF THE VEHICLE, BUT TO OTHER MOTORISTS ON THE ROAD. VOLKSWAGEN HAS BEEN GIVEN NOTICE OF THE ISSUE AND REFUSES TO ACKNOWLEDGE OF TAKE ACTION.
NHTSA ODI #11142549
1,000 miles · Sep 6, 2018
Electrical SystemService BrakesVehicle Speed Control
I HAVE HAD THIS CAR TWO MONTHS AND IT HAS NOW BEEN IN SERVICE TWICE. AS OF TODAY THEY HAVE HAD IT FOR TWO WEEKS. THE AUTONOMOUS BREAK SYSTEM IS WAY TOO SENSITIVE AND THE CAR STOPS GOING DOWN STEEP INCLINES OR GOING OVER POT HOLES WHILE IN MOTION. THE CAR HAS STOPPED IN THE MIDDLE OF DRIVING AT LEAST 7 TIMES. I TAKE IT TO SER…
Read full complaint
I HAVE HAD THIS CAR TWO MONTHS AND IT HAS NOW BEEN IN SERVICE TWICE. AS OF TODAY THEY HAVE HAD IT FOR TWO WEEKS. THE AUTONOMOUS BREAK SYSTEM IS WAY TOO SENSITIVE AND THE CAR STOPS GOING DOWN STEEP INCLINES OR GOING OVER POT HOLES WHILE IN MOTION. THE CAR HAS STOPPED IN THE MIDDLE OF DRIVING AT LEAST 7 TIMES. I TAKE IT TO SERVICE, THEY SAY THERE IS NO RECORD IN THE CARS COMPUTER OF THE INCIDENT. THE FRONT SENSORS ARE ALWAYS BEEPING. I PULL UP TO A STOP SIGN, THE SENSORS GO OFF. I DO A U-TURN AND THE SENSORS GO OFF. SOME DAYS WAY TOO EXCESSIVELY, SOME DAYS NOT AT ALL. IT SCARES ME TO DEATH AND I SLAM ON MY BRAKES BECAUSE I AM AFRAID I AM GOING TO HIT SOMETHING. I TAKE IT TO SERVICE, THEY SAY THERE IS NO RECORD OF IT IN THE CARS COMPUTER. FRONT END COLLISION ALERT, I WAS DRIVING DOWN THE ROAD AND WAS THE ONLY ONE ON THE ROAD AND THE FRONT END COLLISION ALERT WENT OFF. I OF COURSE SLAM ON THE BRAKES IN THE MIDDLE OF THE ROAD WITH NO TRAFFIC, THANK GOD NO ONE WAS BEHIND ME. I TAKE IT TO SERVICE, THEY SAY THERE IS NO RECORD IN THE CARS COMPUTER OF IT. SERVICE HAS BEEN ABLE TO RECREATE THE ISSUE WITH THE FRONT SENSORS, BUT SAYS THERE IS NO FIX. THE CUSTOMER CARE REP FOR VW STATED TODAY ON THE PHONE THAT THEY RECOGNIZE THERE IS AN ISSUE WITH THE SENSITIVITY OF THE AUTONOMOUS BREAKING BUT HAS NO FIX FOR IT SO I WILL HAVE TO DEAL WITH IT. I LIVE IN HOUSTON, I WILL DIE IF I HIT A POT HOLE AND STOP. IT'S UNACCEPTABLE AND A HUGE SAFETY HAZARD. I AM READING ALL OVER THE INTERNET ABOUT THIS ISSUE WITH THE AUTONOMOUS BRAKING PROBLEMS. IT SHOULD NOT BE ALLOWED TO CONTINUE. SOMEONE IS GOING TO DIE. I WAS ABLE TO VIDEO THE ISSUE WITH THE SENSORS AND VW HAS THE VIDEO AND RECOGNIZES A PROBLEM BUT STATES THAT'S JUST THE WAY THE CAR IS GOING TO WORK. STATES THEY SEE THE ISSUE THERE TOO, BUT THERE IS NO FIX.
NHTSA ODI #11127895
6,000 miles · Aug 27, 2018
Service BrakesVehicle Speed Control
WHEN DESCENDING AN INCLINE AT SLOW SPEED TO TURN ONTO A ROADWAY THE SENSOR PERCEIVES THE ROAD AS AN OBSTACLE WHICH CAUSES THE CAR TO AUTO-STOP PARTIALLY IN THE ROAD. I THEN HAVE TO DISENGAGE THE EMERGENCY BRAKE AND BEGIN AGAIN. THIS IS TOTALLY UNSAFE. IT HAS HAPPENED 10 TIMES WHEN LEAVING MY OWN DRIVEWAY.
NHTSA ODI #11122872
7,500 miles · Aug 24, 2018
Service Brakes
THE AUTONOMOUS BREAKING SYSTEM AND PEDIATRIAN WARNING SENSORS ARE MALFUNCTIONING MAKING MY CAR UNSAFE TO DRIVE. SINCE IT'S PURCHASE IN JANUARY 2018, THE BRAKES HAVE LOCKED UP AT LEAST 10 TIMES UNDER NORMAL DRIVING CONDITIONS. I CAN RE-CREATE THE PROBLEM WHEN I AM MOVING SLOWLY ON AN UNEVEN ROAD SURFACE. IN ADDITION, AS I …
Read full complaint
THE AUTONOMOUS BREAKING SYSTEM AND PEDIATRIAN WARNING SENSORS ARE MALFUNCTIONING MAKING MY CAR UNSAFE TO DRIVE. SINCE IT'S PURCHASE IN JANUARY 2018, THE BRAKES HAVE LOCKED UP AT LEAST 10 TIMES UNDER NORMAL DRIVING CONDITIONS. I CAN RE-CREATE THE PROBLEM WHEN I AM MOVING SLOWLY ON AN UNEVEN ROAD SURFACE. IN ADDITION, AS I SLOW DOWN TO APPROACH A STOP SIGN OR A RED LIGHT, THE ALARMS GO OFF SUGGESTING THAT THERE IS SOMETHING IN THE ROADWAY AT LEAST HALF OF THE TIME. I HAVE BEEN TOLD BY MY LOCAL VW SERVICE STATION THAT THERE ARE NO ERRORS BEING RECORDED BY THE CAR'S SYSTEM THAT CAN BE CORRECTED AND AT THIS TIME ALL ATLAS CARS THAT THEY HAVE TESTED ON THE LOT ARE HAVING DOING THE SAME THING. THEY WERE ABLE TO RECREATE THE AUTO-BRAKING ON A HILL ON THEIR LOT, BUT HAVE NO WAY TO STOP IT FROM HAPPENING. ON SATURDAY, 8/18/2019 WHILE I WAS SLOWLY PULLING OUT OF A LOCAL SHOPPING CENTER, MAKING A LEFT HAND TURN DOWN AN INCLINE THE CAR BRAKES LOCKED UP AFTER I ENTERED THE ACTIVE ROADWAY- AS A RESULT I WAS NEARLY T-BONED BY A CAR THAT HAD JUST MAKE A RIGHT HAND TURN ONTO THE SAME ROADWAY. BY THE GRACE OF GOD, THAT DRIVER WAS MOVING SLOW ENOUGHT TO STOP. I IMMEDIATELY CALLED VW CAR NET, I WAS CONNECTED TO MY DEALER, AND THEY TOOK THE CAR IN FOR INSPECTION. AS I MENTIONED ABOVE, AFTER 5 DAYS THEY WERE NOT ABLE TO RESOLVE THE PROBLEM. I HAVE INITIATED A COMPLAINT WITH VW OF AMERICA AND AM WRITING TO TELL YOU THAT I DO NOT FEEL SAFE DRIVING A CAR THAT WILL STOP ME IN THE MIDDLE OF A ROAD WAY. I DO NOT WANT MY FAMILY TO BE THE VICTIMS OF A PREVENTABLE ACCIDENT AND WANT THIS PROBLEM FIXED BEFORE THERE IS A CATASTROPHE FOR ME OR ANOTHER ATLAS OWNER. PLEASE ME KNOW HAVE OTHER INFORMATION I CAN GIVE YOU SO THAT YOU CAN PROPERLY INVESTIGATE THIS PROBLEM.
NHTSA ODI #11122194
2,000 miles · Aug 8, 2018
Service Brakes
I BOUGHT A VW ATLAS 2018 EXPECTING THE FRONT ASSIST FEATURE, WHEREBY IF THE SUV DETECTS AN OBSTACLE IN ITS PATH, IT WILL ENGAGE THE BRAKES TO STOP THE VEHICLE AND AVOID A COLLISION. UNFORTUNATELY I AM EXPERIENCING A SITUATION WHERE THE FEATURE COULD CAUSE A COLLISION. FROM CONVERSATIONS WITH VM SERVICE, THE SENSOR THAT DETECT…
Read full complaint
I BOUGHT A VW ATLAS 2018 EXPECTING THE FRONT ASSIST FEATURE, WHEREBY IF THE SUV DETECTS AN OBSTACLE IN ITS PATH, IT WILL ENGAGE THE BRAKES TO STOP THE VEHICLE AND AVOID A COLLISION. UNFORTUNATELY I AM EXPERIENCING A SITUATION WHERE THE FEATURE COULD CAUSE A COLLISION. FROM CONVERSATIONS WITH VM SERVICE, THE SENSOR THAT DETECTS OBSTACLES POINTS FROM THE GRILL, DIRECTLY OUT, AND PARALLEL TO THE ROAD. WHEN DRIVING ON A DOWN SLOPE THAT LEVELS OUT, THE SENSOR WILL DETECT THE ROAD, AND, ASSUMING IT IS AN OBSTACLE, ENGAGE THE BRAKES TO STOP THE VEHICLE TO AVOID COLLISION. AT SPEEDS >10MPH, THERE IS NO DETECTION. BUT, I DISCOVERED (MULTIPLE TIMES) THAT ENTERING TRAFFIC FROM A CAR PARK CREATES THE DOWN ANGLE, AND (BECAUSE ITS IS ESSENTIAL TO DRIVE SLOWLY EXITING A CAR PARK TO FULLY OBSERVE THE ONCOMING TRAFFIC) THE SPEED WHEREBY THE FEATURE ENGAGES AND STOPS THE SUV. IN MULTIPLE OCCASIONS THIS HAS STOPS US IN INCOMING TRAFFIC, WITH THE REAL POSSIBILITY OF A DRIVERS SIDE COLLISION. I HAD STARTED TO DISABLE THE FRONT ASSIST FEATURE BUT DISCOVERED THIS MUST BE DONE ON EVERY TRIP, AND OF COURSE (A) SOMETIMES THIS IS FORGOTTEN AND (B) OTHERS DRIVING THE SUV MAY NOT REMEMBER OR EVEN KNOW. I FEEL THAT THIS FEATURE (ACKNOWLEDGEDLY A GREAT SAFETY FEATURE WHEN DRIVING ON A LEVEL ROAD), IS ACTUALLY A POTENTIAL COLLISION HAZARD WHEN DRIVING IN THE CONDITIONS DESCRIBED ABOVE.
NHTSA ODI #11118557
4,100 miles · Aug 6, 2018
Power TrainService BrakesStructureCrash
THE VEHICLE FAILED TO STOP ON A CITY STREET AFTER FULL APPLICATION OF BRAKES CAUSING COLLISION AND DAMAGE TO FRONT BUMPER . I HAVE NOT RECEIVED ANY NOTIFICATION FROM WALKS WAGON THAT CERAMIC COATING ON THE BRAKES NEEDS TO BE FIXED AND WAS NOT AWARE OF ANY BRAKE ISSUES PRIOR TO THE COLLISION .THE VEHICLE HAS APPROXIMATELY 4100 M…
Read full complaint
THE VEHICLE FAILED TO STOP ON A CITY STREET AFTER FULL APPLICATION OF BRAKES CAUSING COLLISION AND DAMAGE TO FRONT BUMPER . I HAVE NOT RECEIVED ANY NOTIFICATION FROM WALKS WAGON THAT CERAMIC COATING ON THE BRAKES NEEDS TO BE FIXED AND WAS NOT AWARE OF ANY BRAKE ISSUES PRIOR TO THE COLLISION .THE VEHICLE HAS APPROXIMATELY 4100 MILES AND CURRENTLY AT THE COLLISION CENTRE .
NHTSA ODI #11118107
500 miles · Jul 23, 2018
Service BrakesUnknown Or Other
I?M CONTACTING YOU WITH AN ISSUE THAT NEEDS IMMEDIATE ATTENTION. THERE IS A SERIOUS DEFECT WITH THE VW ATLAS WE LEASED 2 MONTHS AGO. THE AUTOMATIC BRAKING SYSTEM DEPLOYS AT UNEXPECTED AND INAPPROPRIATE TIMES PRODUCING A LIFE THREATENING SITUATION. THE AUTOMATIC BRAKING SYSTEM HAS ACTIVATED, DANGEROUSLY AND INAPPROPRIATELY, …
Read full complaint
I?M CONTACTING YOU WITH AN ISSUE THAT NEEDS IMMEDIATE ATTENTION. THERE IS A SERIOUS DEFECT WITH THE VW ATLAS WE LEASED 2 MONTHS AGO. THE AUTOMATIC BRAKING SYSTEM DEPLOYS AT UNEXPECTED AND INAPPROPRIATE TIMES PRODUCING A LIFE THREATENING SITUATION. THE AUTOMATIC BRAKING SYSTEM HAS ACTIVATED, DANGEROUSLY AND INAPPROPRIATELY, SEVERAL TIMES, USUALLY WHEN PULLING OUT OF A DRIVEWAY AND ATTEMPTING TO ENTER A LANE. ALTHOUGH THERE IS NO OBSTRUCTION OR RISK OF COLLISION, THE CAR SENSES THE INSIGNIFICANT CHANGE IN SLOPE FROM DRIVEWAY TO ROAD AND SLAMS ON THE BRAKES CAUSING THE DRIVER TO LOSE ALL CONTROL. THE CAR IS THEN STALLED IN THE MIDDLE OF ONCOMING TRAFFIC. RECENTLY, MY WIFE AND TWO CHILDREN PULLED OUT OF THE DRIVEWAY OF OUR LOCAL SUPERMARKET AND MADE A LEFT TURN. THE AUTOMATIC BREAKING SYSTEM WAS ACTIVATED AND SHE WAS LEFT STALLED IN THE MIDDLE OF ONCOMING TRAFFIC. ANOTHER DRIVER BARELY AVOIDED COLLIDING INTO OUR REAR SIDE DOOR WHERE OUR 3 YEAR OLD SON?S CAR SEAT IS LOCATED. WE HAVE TAKEN THIS ISSUE TO OUR LOCAL DEALERSHIP, AND THEY CHECKED THE SYSTEM, AND TOLD US ?IT IS PERFORMING AS THE MANUFACTURE INTENDED IT TO?. THIS IS A SERIOUS DESIGN ISSUE AND ITS ONLY A MATTER OF TIME BEFORE IT RESULTS IN A MAJOR ACCIDENT AND I CAN ONLY PRAY THAT MY YOUNG CHILDREN ARENA?T MAIMED OR KILLED. THE VW SERVICE PEOPLE HAVE SHOWN US A COMPLICATED WAY TO TURN OFF THE AUTOMATIC BRAKING SYSTEM IN THE CAR, HOWEVER THIS NEEDS TO BE DONE EVERY TIME YOU START THE CAR. I FEEL ITS INEVITABLE THAT A BUSY MOTHER DOING CHORES WITH TWO TODDLERS WILL FORGET TO TURN OFF THE SYSTEM AT SOME POINT. THIS MATTER NEEDS TO BE RESOLVED BEFORE DISABILITY OR LOSS OF LIFE OCCURS. THERE NEEDS TO BE A WAY TO FIX THE SYSTEM OR PERMANENTLY DISABLE IT. WE ASKED VW TO PERMANENTLY DISABLE THE SYSTEM BUT THEY DECLINED. WE LOOK FORWARD TO YOUR PROMPT REPLY THANK YOU. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *PM
NHTSA ODI #11113195
7,000 miles · Jul 12, 2018
Service BrakesVehicle Speed Control
THE AUTO BRAKING AND WARNING SENSORS GO OFF WHEN YOU ARE DRIVING FROM AN INCLINED DRIVEWAY TO A ROADWAY. THIS HAS HAPPENED TO US MULTIPLE TIMES, THE MOST RECENT WAS ON 7-2-2018, AND IT BRINGS THE VEHICLE TO A COMPLETE STOP. THIS IS SUPPOSED TO BE A SAFETY FEATURE THAT WAS AN EXTRA COST, BUT THIS IS GOING TO CAUSE A CRASH IF NOT …
Read full complaint
THE AUTO BRAKING AND WARNING SENSORS GO OFF WHEN YOU ARE DRIVING FROM AN INCLINED DRIVEWAY TO A ROADWAY. THIS HAS HAPPENED TO US MULTIPLE TIMES, THE MOST RECENT WAS ON 7-2-2018, AND IT BRINGS THE VEHICLE TO A COMPLETE STOP. THIS IS SUPPOSED TO BE A SAFETY FEATURE THAT WAS AN EXTRA COST, BUT THIS IS GOING TO CAUSE A CRASH IF NOT RECTIFIED. I HAVE TAKEN THE VEHICLE IN FOR THIS ISSUE, AND MULTIPLE OTHER ISSUES AND ALL I GET BACK IS ' SYSTEM IS PERFORMING AS DESIGNED.' IF THE SYSTEM IS PERFORMING AS DESIGNED, THE SYSTEM NEEDS TO BE CHANGED. THIS IS WITHOUT A DOUBT A SAFETY ISSUE IN ITSELF. THERE ARE MULTIPLE OTHER OWNERS ON MESSAGE BOARDS THAT ARE HAVING THE SAME ISSUES AND HAVING THE SAME ANSWERS FROM THE DEALERSHIPS. ON ONE OF THE MESSAGE BOARDS, THERE IS ACTUALLY A VIDEO OF THE VEHICLE COMING TO A COMPLETE STOP DRIVING FROM A BANK PARKING LOT TO A MAIN ROAD.
NHTSA ODI #11110898
4,446 miles · Jul 11, 2018
Electronic Stability Control (esc)Service BrakesVehicle Speed Control
AUTOMATIC BRAKING SYSTEM IS FAULTY. WHEN I PULL OUT OF DRIVEWAYS OR PARKING LOTS THE SENSORS ARE ACTIVATING AND THE MANEUVER BRAKING IS APPLIED AND THE CAR COMES TO AN ABRUBT STOP IN THE MIDDLE OF THE ROAD. EVERYTIME THIS HAS OCCURED THERE HAS NOT BEEN AN OBJECT OR CAR PRESENT. THIS SYSTEM IS FAULTY AND DANGEROUS. I HAVE 3 CHILD…
Read full complaint
AUTOMATIC BRAKING SYSTEM IS FAULTY. WHEN I PULL OUT OF DRIVEWAYS OR PARKING LOTS THE SENSORS ARE ACTIVATING AND THE MANEUVER BRAKING IS APPLIED AND THE CAR COMES TO AN ABRUBT STOP IN THE MIDDLE OF THE ROAD. EVERYTIME THIS HAS OCCURED THERE HAS NOT BEEN AN OBJECT OR CAR PRESENT. THIS SYSTEM IS FAULTY AND DANGEROUS. I HAVE 3 CHILDREN IN THE BACK SEAT AND THIS MAKES ME VERY CONCERNED FOR THEIR SAFETY WHEN I DRIVE THIS VEHICLE. VW SERVICE IS LOOKING INTO THE ISSUE AND HAS GIVEN ME A LOANER ATLAS THAT IS DOING THE EXACT SAME THING. I HAVE A VIDEO OF THE ISSUE OCCURING.
NHTSA ODI #11110813
Mileage unknown · Jun 28, 2018
Service Brakes
NOTIFIED ON 06/15/18 THAT MY VEHICLES BRAKE CALIPERS WERE MANUFACTURED WITH INSUFFICIENT CHROME COATING WHICH COULD LEAD TO THE FORMATION OF GAS BUBBLES AND CREATE A SOFT BRAKE POSSIBLY RESULTING IN A CRASH. THERE WAS A STOP SALE ASSOCIATED WITH MY VIN ON 05/25/18 BUT I WAS NOT INFORMED UNTIL 06/15/18. ON 06/15/18 I WAS TOLD TO …
Read full complaint
NOTIFIED ON 06/15/18 THAT MY VEHICLES BRAKE CALIPERS WERE MANUFACTURED WITH INSUFFICIENT CHROME COATING WHICH COULD LEAD TO THE FORMATION OF GAS BUBBLES AND CREATE A SOFT BRAKE POSSIBLY RESULTING IN A CRASH. THERE WAS A STOP SALE ASSOCIATED WITH MY VIN ON 05/25/18 BUT I WAS NOT INFORMED UNTIL 06/15/18. ON 06/15/18 I WAS TOLD TO STOP DRIVING THE VEHICLE AND HAVE IT TOWED TO THE DEALERSHIP IMMEDIATELY. THERE IS STILL NO ETA ON WHEN PARTS WILL BE AVAILABLE OR WHEN MY VEHICLE WILL BE RETURNED TO ME.
NHTSA ODI #11104612
Official recalls
17Sep 11, 2026
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan, 2018-2019 Atlas, and 2019-2021 Audi Q3 vehicles. One of the bolts that attaches the steering rack to the subframe may corrode and break. If this happens, the steering rack housing can break.
Consequence & remedy
Consequence: A broken steering rack housing can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the right-side steering rack mounting bolt, free of charge. Owner notification letters are expected to be mailed November 10, 2026. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 48LG and 48VT. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 16, 2026.
Mar 29, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2021 Atlas and 2020 Atlas Cross Sport vehicles. The passenger occupant detection system (PODS) may experience a fault in the wiring and deactivate the front passenger air bag when the seat is occupied.
Consequence & remedy
Consequence: A deactivated passenger air bag increases the risk of injury during a crash.
Remedy: Dealers will replace the PODS sensor mat and wiring harness, free of charge. Owner notification letters were mailed on March 22, 2024. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 69FB.
Feb 16, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2021 Atlas and 2020-2021 Atlas Cross Sport vehicles equipped with accessory side steps. The reduced Gross Vehicle Weight Rating (GVWR) label, reflecting the additional weight of the side steps, was not installed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Without the reduced GVWR label, the vehicle could be overloaded, leading to a loss of control and increasing the risk of a crash.
Remedy: Dealers will install the reduced GVWR label, free of charge. Owner notification letters were mailed March 31, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 09D9.
May 5, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Touareg GP, Tiguan, Golf A6, E-Golf GP, CCF, 2016-2017 Passat GP, 2018-2019 Golf R GP, and 2018 Atlas vehicles. These internal-use vehicles were sold without confirmation that they were built to all applicable regulatory requirements and may have been modified prior to sale. As such, these vehicles may fail to comply with the requirements of various Federal Motor Vehicle Safety Standards.
Consequence & remedy
Consequence: Vehicles that do not meet all regulatory requirements may have an increased risk of injury, crash, or fire.
Remedy: Volkswagen will repurchase the vehicles. Owner notification letters were mailed May 20, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01F1.
Mar 5, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Atlas vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 24, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 44R1.
Sep 16, 2020
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Golf R and Atlas, 2017 Golf Alltrack and E-Golf and 2016-2018 Passat vehicles. These internal use vehicles were sold without confirmation that they were built to all applicable regulatory requirements and may have been modified prior to sale. As such, these vehicles may fail to comply with the requirements of various Federal Motor Vehicle Safety Standards.
Consequence & remedy
Consequence: Vehicles that do not meet all regulatory requirements may have an increased risk of a crash or injury to vehicle occupants.
Remedy: Volkswagen will notify owners and will repurchase the vehicles. The recall began October 6, 2020. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01E9.
Jan 31, 2020
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Atlas vehicles. The vehicles may be equipped with an incorrectly manufactured air bag sensor, which can delay or disable air bag deployment when necessary.
Consequence & remedy
Consequence: In the event of a crash necessitating frontal air bag deployment, a delayed or disabled airbag deployment can increase the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will replace the air bag crash sensor, free of charge. The recall began February 21, 2020. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69AL.
May 22, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2020 Volkswagen Passat and 2018-2019 Atlas vehicles. The blocking cap disabling the adjustment of the headlight's horizontal aim may not have been installed. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Without the blocking cap, the headlight aim can be adjusted out of specification, reducing visibility and increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect and, as necessary, block the headlight horizontal adjustment, free of charge. The recall began July 16, 2019. Owners may contact Volkswagen customer service at 1-800-253-2834. Volkswagen's number for this recall is 94L9.
Dec 19, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas, 2015 Volkswagen Golf SportWagen, and 2019 Volkswagen Jetta vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen has notified owners, and dealers will replace the rear axle coil springs, free of charge. The recall began January 31, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J2/42J3.
Nov 26, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas and Tiguan and 2019 Volkswagen Jetta vehicles that do not have keyless entry. The instrument cluster may not provide an audible warning to let the driver know that the key is still in the ignition when the door is open. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the driver is not notified by an audible noise that the key is left in the ignition, it can increase the risk of vehicle theft or crash.
Remedy: Volkswagen will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began December 13, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 90L3 and 90L4.
Aug 20, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas vehicles. During production, the air conditioning system drain tube may have been twisted, causing water to drain into the air bag control module.
Consequence & remedy
Consequence: The wet air bag control module may result in an unintentional deployment of the air bags, increasing the risk of injury or crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the air conditioning drain tube, and if it is twisted, the drain tube and air bag control module will be replaced, free of charge. Some of the affected vehicles have had their drain tube previously replaced but did not receive a new air bag control module; the airbag control module will be replaced in these vehicles. The recall began September 14, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 87F9.
Aug 15, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas and 2017-2018 Volkswagen Passat vehicles. The brake caliper bracket mounting bolts on these vehicles may not have been tightened sufficiently.
Consequence & remedy
Consequence: The loose brake bracket bolts can allow the caliper to move, reducing braking ability or causing a loss of vehicle control and increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the brake caliper bracket bolt tightness, replacing and re-torque the bolts as necessary, free of charge. Additionally brake caliper fasteners, bleeder valve, and brake hose bolts will be checked and torqued to the correct specification, if necessary, free of charge. For Passat vehicles, dealers will also inspect the parking brake cable for proper connection, free of charge. The recall began September 14, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 46H6.
Jun 7, 2018
Volkswagen Group of America, Inc. (Volkswaen) is recalling certain 2018 Volkswagen Atlas vehicles. The owner's manuals provided with the affected vehicles do not inform the customers about the child restraint size limitation/restrictions for the second row center seating position. As a result, the center and adjacent outboard seat belt buckles on the second row can become damaged it a child seat base is installed that is wider than 12.6 inches.
Consequence & remedy
Consequence: A damaged seat belt buckle can release unexpectedly, increasing the risk of injury in a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the center and left outboard seat belt buckles, and replace them if necessary, free of charge. Volkswagen will also provide an owner's manual supplement addressing child safety and child restraints. The recall began June 29, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69X1.
Jun 6, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas and Tiguan vehicles. In the event of a crash, the passenger frontal air bag may tear or not properly unfold during deployment.
Consequence & remedy
Consequence: If the air bag were to tear or unfold incorrectly during deployment, it can increase the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will replace the passenger frontal air bag, free of charge. The recall began July 19, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 69W8, and 69W9.
Jun 1, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas, Passat, Beetle, Beetle Convertible, Golf, Golf SportWagen and GTI and Audi Q5 and SQ5 vehicles. The brake caliper pistons on these vehicles may have insufficient coating, potentially reducing the brake performance.
Consequence & remedy
Consequence: A reduction of braking performance can increase the risk of a crash.
Remedy: Volkswagen and Audi will notify their owners. Audi dealers will bleed the rear brakes. Volkswagen dealers will bleed the front and rear brake calipers. Note: Owners are advised not to drive their vehicles until the brake system has been checked. The recall began June 29, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298 and Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 47N8, 47N9, and 47N6.
May 2, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain Volkswagen Atlas vehicles. The fuel tank on these vehicles may leak fuel due to a manufacturing error. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 301, "Fuel System Integrity."
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel tank, free of charge. The recall began June 22, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20AW. Note: This recall is an expansion of recall 17V-766.
Nov 29, 2017
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Atlas vehicles. The fuel tank may have been manufactured with insufficient wall thickness, potentially resulting in the tank leaking fuel. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 301, "Fuel System Integrity."
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel tank, free of charge. The recall began December 10, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20AQ.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23017 · Inadvertent Automatic Emergency Braking
Opened Sep 28, 2023 · Closed Dec 18, 2024
Status: closed (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles.The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 292 reports that may relate to the alleged defect in MY 2018-2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers.The rate of unique incident reports alleging AEB inadvertent activation in MY 2018 Volkswagen Atlas vehicles was comparable to their Volkswagen peers. To date, ODI has received a total of 69 consumer complaints of inadvertent activation of Front Assist in MY 2018-2019 Volkswagen Atlas vehicles. In total, ODI reviewed 264 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include eight reports of incidents involving an alleged injury and two reports involving a crash. PE23017 has been upgraded to an Engineering Analysis (EA24004) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles.The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 292 reports that may relate to the alleged defect in MY 2018-2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers.The rate of unique incident reports alleging AEB inadvertent activation in MY 2018 Volkswagen Atlas vehicles was comparable to their Volkswagen peers. To date, ODI has received a total of 69 consumer complaints of inadvertent activation of Front Assist in MY 2018-2019 Volkswagen Atlas vehicles. In total, ODI reviewed 264 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include eight reports of incidents involving an alleged injury and two reports involving a crash. PE23017 has been upgraded to an Engineering Analysis (EA24004) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles.The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 292 reports that may relate to the alleged defect in MY 2018-2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers.The rate of unique incident reports alleging AEB inadvertent activation in MY 2018 Volkswagen Atlas vehicles was comparable to their Volkswagen peers. To date, ODI has received a total of 69 consumer complaints of inadvertent activation of Front Assist in MY 2018-2019 Volkswagen Atlas vehicles. In total, ODI reviewed 264 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include eight reports of incidents involving an alleged injury and two reports involving a crash. PE23017 has been upgraded to an Engineering Analysis (EA24004) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE21008 · Fuel Injector Leak
Opened Mar 29, 2021 · Closed Oct 3, 2022
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:fuel Injection System:injectors
On March 29, 2021, the Office of Defects Investigations (ODI) opened PE21-008 to investigate instances of fuel injectors leaking in the engine compartment in model year (MY) 2018 through 2020 Volkswagen Atlas and Atlas Cross Sport SUVs. These vehicles are equipped with either a 3.6 or 2.0 liter engine. The subject investigation concerns vehicles equipped with 3.6L engines. Prior to opening the investigation, ODI also observed that warranty data for the fuel system from TREAD reporting was an outlier for the MY 2018 Atlas.The allegation involved fuel injectors leaking fuel near engine compartment components that operate at high temperatures. Consumers allege a fuel leak, fuel odor, and/or an illuminated check engine malfunction indicator light (MIL) on that alerts them to the condition. Fuel leaking in the engine compartment has a higher potential risk of fire as nearby components are operating at higher temperatures compared to other areas of the vehicle. No fires have been connected to this issue to date.The 3.6L engine is a VR6 type engine. Due to its specific design, the VR6 has two types of injectors with different designs installed. Cylinders 1, 3, and 5 use long injectors and cylinders 2, 4, and 6 use short injectors. Unlike the short injectors, the long injectors require an extension pipe necessary to reach cylinders 1, 3, and 5. Volkswagen stated that the potential root cause for a leaking injector is typically either a damaged, misaligned, or missing supporting ring or a damaged O-ring. These rings assist in connecting the injector to the extension pipe. If one of these conditions is present in a vehicle, the O-ring has difficulty withstanding fuel pressure over time.Volkswagen stated that an analysis of warranty data related to leaking injectors in vehicles equipped with 3.6L engines showed that the vast majority of leaking allegations were related to internal leaks. Fuel can leak into the cylinder causing misfiring in the affected cylinders. This condition would not cause fuel to enter into the engine compartment. Volkswagen states that these internal leaks pose no unreasonable risk to motor vehicle safety.Analysis of all relevant data indicates that the subject condition is an early-life failure with a relatively low failure rate. The average failure mileage calculated from all data sources was determined to be approximately 14,000 miles. Only two failures were reported outside of the vehicles' warranty coverage period. The average time to failure for the subject vehicle population is approximately 12 months in service (MIS). The majority of failures were below the average of 14,000 miles or 12 MIS. Analysis of reported failures showed that the failure rate is approximately 0.08% or 0.8 incidents per thousand vehicles (IPTV).To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate of failure, the nature of early-life failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11446833, 11438403, 11382958, 11298402, 11291955, 11218819, 11218780
Additional source detail variants (2)
Fuel System, Gasoline:fuel Injection System:injectors
On March 29, 2021, the Office of Defects Investigations (ODI) opened PE21-008 to investigate instances of fuel injectors leaking in the engine compartment in model year (MY) 2018 through 2020 Volkswagen Atlas and Atlas Cross Sport SUVs. These vehicles are equipped with either a 3.6 or 2.0 liter engine. The subject investigation concerns vehicles equipped with 3.6L engines. Prior to opening the investigation, ODI also observed that warranty data for the fuel system from TREAD reporting was an outlier for the MY 2018 Atlas.The allegation involved fuel injectors leaking fuel near engine compartment components that operate at high temperatures. Consumers allege a fuel leak, fuel odor, and/or an illuminated check engine malfunction indicator light (MIL) on that alerts them to the condition. Fuel leaking in the engine compartment has a higher potential risk of fire as nearby components are operating at higher temperatures compared to other areas of the vehicle. No fires have been connected to this issue to date.The 3.6L engine is a VR6 type engine. Due to its specific design, the VR6 has two types of injectors with different designs installed. Cylinders 1, 3, and 5 use long injectors and cylinders 2, 4, and 6 use short injectors. Unlike the short injectors, the long injectors require an extension pipe necessary to reach cylinders 1, 3, and 5. Volkswagen stated that the potential root cause for a leaking injector is typically either a damaged, misaligned, or missing supporting ring or a damaged O-ring. These rings assist in connecting the injector to the extension pipe. If one of these conditions is present in a vehicle, the O-ring has difficulty withstanding fuel pressure over time.Volkswagen stated that an analysis of warranty data related to leaking injectors in vehicles equipped with 3.6L engines showed that the vast majority of leaking allegations were related to internal leaks. Fuel can leak into the cylinder causing misfiring in the affected cylinders. This condition would not cause fuel to enter into the engine compartment. Volkswagen states that these internal leaks pose no unreasonable risk to motor vehicle safety.Analysis of all relevant data indicates that the subject condition is an early-life failure with a relatively low failure rate. The average failure mileage calculated from all data sources was determined to be approximately 14,000 miles. Only two failures were reported outside of the vehicles' warranty coverage period. The average time to failure for the subject vehicle population is approximately 12 months in service (MIS). The majority of failures were below the average of 14,000 miles or 12 MIS. Analysis of reported failures showed that the failure rate is approximately 0.08% or 0.8 incidents per thousand vehicles (IPTV).To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate of failure, the nature of early-life failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11446833, 11438403, 11382958, 11298402, 11291955, 11218819, 11218780
Fuel System, Gasoline
On March 29, 2021, the Office of Defects Investigations (ODI) opened PE21-008 to investigate instances of fuel injectors leaking in the engine compartment in model year (MY) 2018 through 2020 Volkswagen Atlas and Atlas Cross Sport SUVs. These vehicles are equipped with either a 3.6 or 2.0 liter engine. The subject investigation concerns vehicles equipped with 3.6L engines. Prior to opening the investigation, ODI also observed that warranty data for the fuel system from TREAD reporting was an outlier for the MY 2018 Atlas.The allegation involved fuel injectors leaking fuel near engine compartment components that operate at high temperatures. Consumers allege a fuel leak, fuel odor, and/or an illuminated check engine malfunction indicator light (MIL) on that alerts them to the condition. Fuel leaking in the engine compartment has a higher potential risk of fire as nearby components are operating at higher temperatures compared to other areas of the vehicle. No fires have been connected to this issue to date.The 3.6L engine is a VR6 type engine. Due to its specific design, the VR6 has two types of injectors with different designs installed. Cylinders 1, 3, and 5 use long injectors and cylinders 2, 4, and 6 use short injectors. Unlike the short injectors, the long injectors require an extension pipe necessary to reach cylinders 1, 3, and 5. Volkswagen stated that the potential root cause for a leaking injector is typically either a damaged, misaligned, or missing supporting ring or a damaged O-ring. These rings assist in connecting the injector to the extension pipe. If one of these conditions is present in a vehicle, the O-ring has difficulty withstanding fuel pressure over time.Volkswagen stated that an analysis of warranty data related to leaking injectors in vehicles equipped with 3.6L engines showed that the vast majority of leaking allegations were related to internal leaks. Fuel can leak into the cylinder causing misfiring in the affected cylinders. This condition would not cause fuel to enter into the engine compartment. Volkswagen states that these internal leaks pose no unreasonable risk to motor vehicle safety.Analysis of all relevant data indicates that the subject condition is an early-life failure with a relatively low failure rate. The average failure mileage calculated from all data sources was determined to be approximately 14,000 miles. Only two failures were reported outside of the vehicles' warranty coverage period. The average time to failure for the subject vehicle population is approximately 12 months in service (MIS). The majority of failures were below the average of 14,000 miles or 12 MIS. Analysis of reported failures showed that the failure rate is approximately 0.08% or 0.8 incidents per thousand vehicles (IPTV).To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate of failure, the nature of early-life failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11446833, 11438403, 11382958, 11298402, 11291955, 11218819, 11218780
Illustration