NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
327 reports3,000 miles · Dec 24, 2008
Power Train
THE TRANSMISSION AND TRANSFER CASE ON OUR 2008 TUNDRA 4WD DRIVE HAS FAILED, REPEATEDLY THIS PAST WEEK WHILE OPERATING THE VEHICLE ON A PUBLIC STREET. IN THIS "FAIL" CONDITION, THE TRANSFER CASE MAKES A GRINDING NOSE, THE TRANSFER CASE ALARM BUZZER MAKES NOSE AND IRRESPECTIVE OF TRANSMISSION POSITION OR TRANSFER CASE SELECTION (…
Read full complaint
THE TRANSMISSION AND TRANSFER CASE ON OUR 2008 TUNDRA 4WD DRIVE HAS FAILED, REPEATEDLY THIS PAST WEEK WHILE OPERATING THE VEHICLE ON A PUBLIC STREET. IN THIS "FAIL" CONDITION, THE TRANSFER CASE MAKES A GRINDING NOSE, THE TRANSFER CASE ALARM BUZZER MAKES NOSE AND IRRESPECTIVE OF TRANSMISSION POSITION OR TRANSFER CASE SELECTION (2WD, 4WD HI, 4WD LO) FAILS TO ENGAGE IN LOW OR HI, AND MOST TROUBLING, THE VEHICLE WILL ROLL IN ANY GEAR, NO GEAR WILL ENGAGE, AND THE CAR CAN ROLL FORWARD OR BACKWARDS OUT OF CONTROL. I WAS ALMOST HIT A BY A CAR TODAY BECAUSE I COULD NOT GET THE TRUCK TO ENGAGE IN ANY GEAR, IN ANY SETTING, INSPITE OF ATTEMPTS TO ROLL THE VEHICLE SLIGHTLY DOWN THE HILL TO ALLOW FOR THE TRANSFER CASE TO ENGAGE, AS SUGGESTED IN THE OWNER'S MANUAL. WHILE I AM NOT PLEASED WITH THE (FAILED) CONDITION OF THE DRIVE TRAIN FOR THIS NEW TRUCK, THIS IS AN ISSUE I WILL ADDRESS DIRECTLY WITH TOYOTA. IN THE FAIL CONDITION OF 4WD, THE TRANSFER CASE MERELY 'BEEPS' AND REFUSES TO ENGAGE TRANSMISSION, RESULTING IN A FREE-ROLLING, UNCONTROLLED VEHICLE. HAD THIS FAILURE HAPPENED TODAY AS WE ATTEMPTED TO ENTER THE FREEWAY, WE WOULD HAVE LIKELY BEEN IN A ACCIDENT. THIS IS UNACCEPTABLE. I AM MOST CONCERNED THAT OTHER TUNDRA OWNERS (AND THE SIMILAR SEQUOIA) WOULD HAVE A LOSS OF VEHICLE CONTROL AND POWER, RESULTING IN INJURY OR DEATH. HOW TROUBLING TOYOTA WOULD PUT THIS VEHICLE ON THE ROAD WITHOUT ADDRESSING THIS ISSUE. *TR
NHTSA ODI #10252752
507 miles · Dec 7, 2008
StructureSuspension
ANYONE FAMILIAR WITH "SHAKEN BABY" SYNDROME WILL RECOGNIZE THIS DEFECT. ON CERTAIN SECTIONS OF PAVEMENT AND AT CERTAIN SPEEDS, THIS VEHICLE SETS UP A HARMONIC VIBRATION AND SHAKES SO VIOLENTLY THAT INFANTS ARE AT RISK. THE EVENTS ARE EASILY REPEATED AND ARE KNOWN TO THE MANUFACTURER. *TR
NHTSA ODI #10250977
100 miles · Nov 12, 2008
Structure
"08 TUNDRA" WHILE DRIVING AT 65 MPH THE BED BOUNCE ON THE TRUCK IS HORRIBLE. WHILE DRIVING YOU SOMETIMES FEEL AS IF YOU ARE GOING TO LOSE CONTROL OF THE TRUCK. PROBLEM PERSISTS AT 65MPH+. *TR
NHTSA ODI #10248537
4,000 miles · Oct 27, 2008
Suspension
THIS IS OF MAJOR CONCERN TO ME AND MANY DRIVERS CURRENTLY DRIVING 2008 TOYOTA TUNDRAS. THERE IS A MAJOR DEFECT WITH THE BED AND CABIN OF THE TRUCK BOUNCING UNCONTROLLABLY WHEN YOU DRIVE ON THE FREEWAY, MY MAIN CONCERN IS THIS UNCONTROLLABLE BED AND CABIN BOUNCE CAN CAUSE BRAIN DAMAGE TO A CHILD STRAPPED TO A CAR SEAT. SO FAR TOY…
Read full complaint
THIS IS OF MAJOR CONCERN TO ME AND MANY DRIVERS CURRENTLY DRIVING 2008 TOYOTA TUNDRAS. THERE IS A MAJOR DEFECT WITH THE BED AND CABIN OF THE TRUCK BOUNCING UNCONTROLLABLY WHEN YOU DRIVE ON THE FREEWAY, MY MAIN CONCERN IS THIS UNCONTROLLABLE BED AND CABIN BOUNCE CAN CAUSE BRAIN DAMAGE TO A CHILD STRAPPED TO A CAR SEAT. SO FAR TOYOTA HAS REFUSED TO ACKNOWLEDGE THIS PROBLEM. YOU CAN SEE THIS ON YOUTUBE MANY PEOPLE HAVE SUBMITTED VIDEO ON THIS ISSUE. *TR UPDATED 01/21/10. UPDATED 02/02/10 *BF UPDATED 02/02/10.*JB UPDATED 02/05/10.
NHTSA ODI #10246876
8,500 miles · Oct 26, 2008
Electrical SystemVehicle Speed Control
I HAVE A 2008 TOYOTA TUNDRA TRUCK 5.7 V8 EXTENDED CAB 4X4 MY WIFE AND I DROVE FROM CHANDLER AZ TO IDAHO ,THEN TO YELLOWSTONE, THEN BACK TO SALT LAKE AND THEN TO PHOENIX AZ TILL THEN EVER THING WAS GREAT THE TRUCK RAN VERY WELL. WE COMING DOWN INTERSTATE 17 FROM FLAGSTAFF TO PHOENIX ABOUT 3/4 OF THE TO PHOENIX. …
Read full complaint
I HAVE A 2008 TOYOTA TUNDRA TRUCK 5.7 V8 EXTENDED CAB 4X4 MY WIFE AND I DROVE FROM CHANDLER AZ TO IDAHO ,THEN TO YELLOWSTONE, THEN BACK TO SALT LAKE AND THEN TO PHOENIX AZ TILL THEN EVER THING WAS GREAT THE TRUCK RAN VERY WELL. WE COMING DOWN INTERSTATE 17 FROM FLAGSTAFF TO PHOENIX ABOUT 3/4 OF THE TO PHOENIX. I WAS TRAVELING AT THE SPEED LIMIT AT 75 MPH AND HAD JUST PUNCHED THE ACCELERATOR PEDAL TO PASS A CAR WHILE GOING UP HILL. THE ACCELERATOR PEDAL WENT DOWN TO THE FLOOR AND WOULD NOT RELEASE BACK AS NORMAL . THE TRUCK PROCEED TO ACCELERATE TO 90 MPH AND AT THIS POINT I AGAIN PUSHED 5-6 TIMES ON THE ACCELERATOR PEDAL TO HAVE IT RELEASE BUT IT CONTINUED TO GO FASTER TO 100 MPH AT THIS POINT I KNEW WE IN DEEP TROUBLE AND DANGER. I WAS PUSHING HARD ON THE BRAKE AND TRYING TO MOVE FROM THE LEFT LANE IN TRAFFIC AT NIGHT TO THE RIGHT LANE TO TRY AND STOP THE TRUCK . I GOT TO THE RIGHT LANE AND TO THE SHOULDER AND HIT THE EMERGENCY BRAKE AND WAS STAMPING HARD ON THE BREAK PEDAL AND TRYING TO SHIFT OUT OF GEAR TO NEUTRAL . IN THE PANIC I AM NOT SURE WHAT ALL HAPPENED BUT THE TRUCK LUNGED FORWARD VERY HARD THEN DIED / ENGINE STOPPED . I STARED THE ENGINE AND TESTED THE ACCELERATOR PEDAL AND IT SEEMED TO BE FINE , I CHECKED FOR THE LOGICAL THINGS LIKE THE HEAVY RUBBER FLOOR MAT, HAD IT GOT PUSHED UP ON THE PEDAL BUT THIS WAS NOT THE CASE AS IT WAS 4 INCHES AWAY AND IT HAS RUBBER KNOBS OR STUDS THAT PUSH INTO THE CARPET AND WILL NOT SLIDE ALSO MY LEFT FOOT WAS FIRMLY PLANTED ON THE MAT AT ALL TIMES . NO WAY THAT MAT WAS THE PROBLEM. THERE WAS NO DIRT ETC AS THE ACCELERATOR HAS A HEAVY SPRING AND THE PEDAL IS 3-4 INCHES OFF THE CARPET. I DO NOT FEEL SAFE DRIVING THIS AS IT SCARED US A LOT AND WE HAVE LOST CONFIDENCE IN THIS TRUCK AND TOYOTA. *TR ALSO, THE BATTERY SHORTED OUT INTERNALLY. UPDATED 11/13/09
NHTSA ODI #10246750
11,600 miles · Oct 14, 2008
Power TrainService Brakes, HydraulicVehicle Speed Control
TRUCK WAS IN CRUISE CONTROL. ACCELERATED TO PASS SLOWER TRAFFIC. LET OFF THROTTLE. TRUCK WENT TO FULL THROTTLE. COULD NOT GET TRUCK TO DECELERATE. HAD TO STAND ON BRAKES TO BRING TO A STOP. TRUCK NEEDS NEW ROTORS AND PADS TOYOTA WILL NOT HELP. OCCURRED ONCE. *TR THE CONSUMER STATED THE FLOOR MAT AND GAS PEDAL CAN INTERACT. WHEN…
Read full complaint
TRUCK WAS IN CRUISE CONTROL. ACCELERATED TO PASS SLOWER TRAFFIC. LET OFF THROTTLE. TRUCK WENT TO FULL THROTTLE. COULD NOT GET TRUCK TO DECELERATE. HAD TO STAND ON BRAKES TO BRING TO A STOP. TRUCK NEEDS NEW ROTORS AND PADS TOYOTA WILL NOT HELP. OCCURRED ONCE. *TR THE CONSUMER STATED THE FLOOR MAT AND GAS PEDAL CAN INTERACT. WHEN THE ALL WEATHR MAT IS NOT CLIPPED IN PLACE, AND IS MOVED UNDER THE GAS PEDAL, IT WILL BECOME FULLY DEPRESSED. THE MAT CAN TRAP THE PEDAL. UPDATED 11/13/09 UPDATED 03/29/10 *BF
NHTSA ODI #10245488
1 miles · Oct 13, 2008
Structure
PAINT ON 2008 TUNDRA CREWMAX IS TERRIBLE QUALITY. "THIS IS MY FIRST NEW VEHICLE PURCHASE AND I AM FOR THE MOST PART VERY HAPPY WITH MY 08 PYRITE MICA CREWMAX PURCHASE. MY ONLY PROBLEM WITH THIS TRUCK IS YOU GOT IT, THE PAINT JOB. DON'T GET ME WRONG ITS A BEAUTIFUL COLOR, BUT MAN IS THIS PAINT FRAGILE. I HAVE 408 MILES ON THIS …
Read full complaint
PAINT ON 2008 TUNDRA CREWMAX IS TERRIBLE QUALITY. "THIS IS MY FIRST NEW VEHICLE PURCHASE AND I AM FOR THE MOST PART VERY HAPPY WITH MY 08 PYRITE MICA CREWMAX PURCHASE. MY ONLY PROBLEM WITH THIS TRUCK IS YOU GOT IT, THE PAINT JOB. DON'T GET ME WRONG ITS A BEAUTIFUL COLOR, BUT MAN IS THIS PAINT FRAGILE. I HAVE 408 MILES ON THIS TRUCK AND HAVE LEANED AGAINST IT A FEW TIMES LOADING AND UNLOADING ITEMS FROM THE SIDE AND HAVE SCRATCHES THAT ARE VERY NOTICEABLE FROM BRUSHING AGAINST THE SIDE WITH BLUE JEANS. FOR A TRUCK WITH A 44,000 MSRP, YOU WOULD THINK IT WOULD HAVE A BETTER QUALITY PAINT JOB THAN THIS, THIS IS BS. MY 98 CHEVY ORIGINAL PAINT IS MUCH TOUGHER THAN THIS. TOYOTA IS GOING HAVE TO DO BETTER THAN THIS IF THEY EXPECT A REPEAT PURCHASE FROM ME. I REALIZE CERTAIN CHEMICALS HAVE BEEN BANNED FROM THE PAINTING PROCESS IN THE STATES, BUT WE'VE GOT TO DO BETTER WITH TODAY'S TECHNOLOGY THIS SHOULDN'T BE HAPPENING." *TR
NHTSA ODI #10245242
Mileage unknown · Sep 9, 2008
Tires
TOYOTA IS PUTTING BF GOODRICH RUGGED TRAIL T/A TIRES ON THEIR 2008 TOYOTA TUNDRA CREWMAX TRUCKS IN SIZE P275/65R18 BUT ARE USING MICHELIN LTX A/S AS A SPARE IN SIZE P255/70R18. THE MICHELIN IS APPROXIMATELY 3/8" SMALLER IN DIAMETER. I HAVE ASKED FOR A TIRE THAT MATCHES THE OTHERS AS A SPARE BUT THEY REFUSE EVEN THOUGH I BELIEV…
Read full complaint
TOYOTA IS PUTTING BF GOODRICH RUGGED TRAIL T/A TIRES ON THEIR 2008 TOYOTA TUNDRA CREWMAX TRUCKS IN SIZE P275/65R18 BUT ARE USING MICHELIN LTX A/S AS A SPARE IN SIZE P255/70R18. THE MICHELIN IS APPROXIMATELY 3/8" SMALLER IN DIAMETER. I HAVE ASKED FOR A TIRE THAT MATCHES THE OTHERS AS A SPARE BUT THEY REFUSE EVEN THOUGH I BELIEVE IT TO BE A SAFETY ISSUE IN INCLEMENT WEATHER. *TR
NHTSA ODI #10241467
1,000 miles · Sep 2, 2008
Suspension
2008 TOYOTA TUNDRA DOUBLE CAB 5.7L V8. CERTAIN AREAS OF FREEWAY IN & AROUND RIVERSIDE, CA HAVE WHAT IS KNOW AS "WASHBOARD", I.E. THE SURFACE UNULATES SIMILAR TO THE SURFACE OF A WASHBOARD. MY TUNDRA SHAKES VIOLENTLY WHEN GOING OVER THIS. WHILE THE WASHBOARD EFFECT IS NOTICEABLE IN OTHER VEHICLES, IT IS FRIGHTENING IN THE TUN…
Read full complaint
2008 TOYOTA TUNDRA DOUBLE CAB 5.7L V8. CERTAIN AREAS OF FREEWAY IN & AROUND RIVERSIDE, CA HAVE WHAT IS KNOW AS "WASHBOARD", I.E. THE SURFACE UNULATES SIMILAR TO THE SURFACE OF A WASHBOARD. MY TUNDRA SHAKES VIOLENTLY WHEN GOING OVER THIS. WHILE THE WASHBOARD EFFECT IS NOTICEABLE IN OTHER VEHICLES, IT IS FRIGHTENING IN THE TUNDRA. THIS COULD BE A REAL SAFETY HAZARD. *TR
NHTSA ODI #10240648
800 miles · Aug 28, 2008
Suspension
I JUST BOUGHT MY 2008 TUNDRA AND HAVE NOTICED AN INCREDIBLE BOUNCE WHILE DRIVING ON THE FREEWAY. THIS DOES NOT SEEM NORMAL AND CONCERNS ME. THE TIRES HAVE BEEN ROTATED AND BALANCED AND THIS DOESN'T SEEM TO CHANGE THE BOUNCE EFFECT. AFTER READING ONLINE, IT APPEARS THAT TOYOTA IS FAMILIAR WITH THIS PROBLEM. I HOPE THEY FIX IT…
Read full complaint
I JUST BOUGHT MY 2008 TUNDRA AND HAVE NOTICED AN INCREDIBLE BOUNCE WHILE DRIVING ON THE FREEWAY. THIS DOES NOT SEEM NORMAL AND CONCERNS ME. THE TIRES HAVE BEEN ROTATED AND BALANCED AND THIS DOESN'T SEEM TO CHANGE THE BOUNCE EFFECT. AFTER READING ONLINE, IT APPEARS THAT TOYOTA IS FAMILIAR WITH THIS PROBLEM. I HOPE THEY FIX IT SOON. *TR
NHTSA ODI #10240084
Official recalls
12Nov 23, 2021
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence & remedy
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Additional source detail variants (2)
Steering:hydraulic Power Assist System
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Steering:rack And Pinion
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Oct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Consequence & remedy
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
May 12, 2011
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2007-2011 TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEMS." THE TPMS ON SOME VEHICLES MAY NOT HAVE BEEN PROPERLY CALIBRATED AND AS A RESULT THE LOW TIRE PRESSURE WARNING LAMP MAY NOT ILLUMINATE SHOULD THE INFLATION PRESSURE IN ONE OR MORE OF THE VEHICLE'S TIRES FALL BELOW THE THRESHOLD FOR WHEN THE LOW TIRE PRESSURE WARNING LAMP SHOULD ILLUMINATE.
Consequence & remedy
Consequence: DRIVERS WILL NOT RECEIVE A WARNING FROM THE TIRE PRESSURE MONITOR THAT ONE OR MORE TIRES ARE UNDERINFLATED, INCREASING THE RISK THAT THE VEHICLE WILL BE DRIVEN WITH ONE OR MORE UNDERINFLATED TIRES, INCREASING THE RISK OF A TIRE FAILURE THAT MAY LEAD TO A CRASH.
Remedy: DEALERS WILL RECALIBRATE THE TIRE PRESSURE MONITORING SYSTEM IN ACCORDANCE WITH THE REGULATION FREE OF CHARGE. THE SAFETY RECALL BEGAN DURING JULY 2011. OWNERS MAY CONTACT SOUTHEAST TOYOTA CUSTOMER ASSISTANCE CENTER TOLL FREE AT 1-800-301-6859, MONDAY THROUGH FRIDAY, 8:30 AM TO 5:00 PM, EASTERN STANDARD TIME.
Mar 4, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FJ CRUISER, LAND CRUISER, TACOMA, SEQUOIA AND TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEM (TPMS)." WHEN FACTORY-INSTALLED WHEELS AND TIRES WERE REPLACED WITH TOYOTA AUTHORIZED ACCESSORY WHEELS AND LT TIRES PRIOR TO FIRST SALE, THE TIRE PRESSURE MONITORING SYSTEMS WERE NOT RE-CALIBRATED CORRECTLY AND THEREFORE DO NOT START ILLUMINATING THE LOW TIRE PRESSURE WARNING TELLTALE AT THE REQUIRED MINIMUM ACTIVATION PRESSURE.
Consequence & remedy
Consequence: FAILURE TO WARN OF TIRE DEFLATIONS IS A NON-COMPLIANCE WITH FMVSS 138 AND COULD LEAD TO TIRE FAILURE INCREASING THE RISK OF A CRASH.
Remedy: FOR THE LAND CRUISER, SEQUOIA, TACOMA AND TUNDRA VEHICLES, THE DEALER WILL RE-CALIBRATE THE TIRE PRESSURE MONITORING SYSTEM ON AFFECTED VEHICLES AND INSTALL AN UPDATED TIRE AND LOADING INFORMATION LABEL AT NO CHARGE. FOR THE FJ CRUISER VEHICLES, THE TPMS CANNOT BE RESET SO THE ELECTRONIC CONTROL UNIT (ECU) FOR THE TPMS WILL BE REPLACED. TOYOTA IS CURRENTLY DEVELOPING THE REMEDY ECU. IF AN OWNER IS NOT CERTAIN WHETHER HIS OR HER VEHICLE IS EQUIPPED WITH THESE ACCESSORIES, PLEASE CONTACT ANY TOYOTA DEALER FOR AN INSPECTION AT NO CHARGE. THE SAFETY RECALL BEGAN ON MARCH 31, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jan 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.
Consequence & remedy
Consequence: THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration