NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
21 reportsClear category filter195,000 miles · Jan 8, 2020
Unknown Or Other
WHILE TRAVELING AT 70 MPH ON A CONGESTED HIGHWAY, THE ENGINE SUDDENLY MADE LOUD NOISE THEN STALLED. NO ENGINE OR MAINTENANCE LIGHTS ILLUMINATED AND THERE WAS NO WARNING. THE VEHICLE WAS VERY NARROWLY ABLE TO BE CONTROLLED TO A STOP. BRAKING WAS DIMINISHED DUE TO ENGINE STALL AND STEERING WAS ALSO COMPROMISED. ONCE REMOVED TO A S…
Read full complaint
WHILE TRAVELING AT 70 MPH ON A CONGESTED HIGHWAY, THE ENGINE SUDDENLY MADE LOUD NOISE THEN STALLED. NO ENGINE OR MAINTENANCE LIGHTS ILLUMINATED AND THERE WAS NO WARNING. THE VEHICLE WAS VERY NARROWLY ABLE TO BE CONTROLLED TO A STOP. BRAKING WAS DIMINISHED DUE TO ENGINE STALL AND STEERING WAS ALSO COMPROMISED. ONCE REMOVED TO A SAFE LOCATION IT WAS DISCOVERED THAT THE LEFT INTAKE SPRING BROKE IN HALF ALLOWING THE VALVE TO DESCEND INTO THE CYLINDER, STRUCK THE PISTON, REBOUNDED, STRUCKTHE CAM SHAFT AND BENT. THE COST OF REPAIRS ARE ESTIMATED AT 9K. INTERNET RESEARCH HAS INDICATED MULTIPLE COMPLAINTS FROM ACROSS THE COUNTRY OF IDENTICAL FAILURES.
NHTSA ODI #11297976
116,000 miles · Jun 2, 2019
EngineUnknown Or Other
TUNDRA WON'T ACCELERATE AS ENGINE GOES INTO LIMP MODE WHICH RESTRICTS SPEED CAPABILITY OF VEHICLE. THIS IS RELATED TO AIR INJECTION PUMP FAILURE AND RELATED ALSO TO AIR SWITCHING VALVES. LIMP MODE ON A TOYOTA RESTRICTS SPEED AT WHICH YOU CAN DRIVE, SHIFTING AND TOP SPEED ARE RESTRICTED. SLOWS TO POINT IF ENTERING HIGHWAY OR TRYI…
Read full complaint
TUNDRA WON'T ACCELERATE AS ENGINE GOES INTO LIMP MODE WHICH RESTRICTS SPEED CAPABILITY OF VEHICLE. THIS IS RELATED TO AIR INJECTION PUMP FAILURE AND RELATED ALSO TO AIR SWITCHING VALVES. LIMP MODE ON A TOYOTA RESTRICTS SPEED AT WHICH YOU CAN DRIVE, SHIFTING AND TOP SPEED ARE RESTRICTED. SLOWS TO POINT IF ENTERING HIGHWAY OR TRYING TO KEEP UP WITH SPEED OVER 50 MPH COULD NOT DO IT. TOYOTA IS AWARE AND HAS A CUSTOMER SUPPORT PROGRAM ZTQ BUYING VEHICLE USED NOT AWARE OF THIS OR ANYTHING ABOUT IT. I SLOWED TRAFFIC AND CAUSED BACK UP ON THE STREET WAS TRAVELING COULD NIT DO MORE THAN 20-30 MPH ON ROAD POSTED AT 50 MPH. GLAD NOT ENTERING FREEWAY. PLENTY OF U TUBE VIDEOS DETAILING REPAIR AND PROBLEM. THE TOYOTA DOCUMENTATION SAYS 477,000 TUNDRA VEHICLES WERE COVERED BY THIS ENHANCED WARRANTY PROGRAM. PREVIOUS OWNER DID COMPLAIN TO TOYOTA AND HAD COMPUTER REPLACED ON VEHICLE.
NHTSA ODI #11217403
122,000 miles · Nov 20, 2018
Unknown Or Other
HEATER BLEND DOORS MALFUNCTION AND ACCORDING TO 2 DEALERSHIPS THIS IS A COMMON PROBLEM. THAT TOYOTA IS NO ADDRESSING. IT IS A SAFETY HAZARD BECAUSE THE HEATER BLEND DOORS NOT WORKING AND BREAKING FOR NO APPARENT REASON CAUSES IMMEDIATE DANGER TO OPERATOR PASSENGERS AND OTHER VECHICLES AND OTHER PEDESTRIANS. WINDOWS FROST UP, STE…
Read full complaint
HEATER BLEND DOORS MALFUNCTION AND ACCORDING TO 2 DEALERSHIPS THIS IS A COMMON PROBLEM. THAT TOYOTA IS NO ADDRESSING. IT IS A SAFETY HAZARD BECAUSE THE HEATER BLEND DOORS NOT WORKING AND BREAKING FOR NO APPARENT REASON CAUSES IMMEDIATE DANGER TO OPERATOR PASSENGERS AND OTHER VECHICLES AND OTHER PEDESTRIANS. WINDOWS FROST UP, STEAM UP WHICH CAUSES THE DRIVER NOT TO BE TO SEE AND BEAWARE OF THE SURROUNDINGS. SEARCH ENGINE @ TOYOTA : TOYOTA U.S>TUNDRA>2008>NAP.4-ELECTRICAL GROUP>87-14- HEATING & AIR CONDITIONING- COOLER UNIT PART # 87050THIS IS ALL WHAT HAPPENED TO MY TUNDRA WHEN I WAS DRIVING AND A BUMP WAS IN THE ROAD AND I HIT IT AND INSTANTLY LOST MY HEAT. I WAS ON A SIDE STREET IN MY TOWN.
NHTSA ODI #11152885
186,000 miles · Jan 11, 2018
Unknown Or Other
I WAS DRIVING ON THE HIGHWAY WITH NO OTHER CARS AROUND AND MY SUNROOF SHATTERED ON ME RAINING GLASS DOWN ON THE INSIDE OF MY TRUCK. I CALLED A LOCAL TOYOTA DEALER AND THEY TOLD ME THAT THEY DIDN'T BELIEVE ME AND THAT A ROCK MUST HAVE HIT IT. THEY OFFERED ME NO HELP WHATSOEVER.
NHTSA ODI #11062244
50,000 miles · May 10, 2017
Unknown Or Other
FRAME WHERE FUEL TANK STRAP IS RUSTING CAUSING STRAP TO COME LOSE AND FRONT OF FUEL TANK FELL AND HIT ROAD WHILE TRAVELING ON ROUTE 62 HWY. TOOK TRUCK BACK TO DEALERSHIP TO HAVE THE ISSUE FIXED AND ON MY WAY HOME IT FELL OFF AGAIN SO I HAD TO PUT A LARGER BOLT IN THE RUST HOLE JUST TO GET MY FUEL TANK TO STAY ON.
NHTSA ODI #10984629
160,000 miles · Mar 14, 2017
Unknown Or Other
WE BOUGHT THE TRUNK BRAND NEW IN 2008 AND WE HAVE HAD TO REPLACE THE ALTERNATOR TWICE. ONCE IN 2012 AND NOW IN 2017. SEEMS THE ALTERNATOR ONLY LASTS 4 YEARS BEFORE GIVING OUT. ALSO, THE POWER LOCKS STOPPED WORKING IN 2013.
NHTSA ODI #10965896
89,000 miles · Jun 13, 2015
SuspensionUnknown Or Other
LEAF SPRINGS GIVING OUT, NEVER PUT HALF OF THE MAX WEIGHT CAPACITY, CALLED TOYOTA THEY TOLD ME NOTHING THEY CAN DO AND THEY STAND BEHIND THEIR PRODUCT EVEN THOUGH I PERSONALLY KNOW SOMEONE THAT HAD THEIRS REPAIRED AT NO CHARGE TOYOTA WOULD NOT FIX IT FOR FREE IF THEY DID NOT KNOW THE PRODUCT WAS BAD AND FAULTY. NOISE COMING FROM…
Read full complaint
LEAF SPRINGS GIVING OUT, NEVER PUT HALF OF THE MAX WEIGHT CAPACITY, CALLED TOYOTA THEY TOLD ME NOTHING THEY CAN DO AND THEY STAND BEHIND THEIR PRODUCT EVEN THOUGH I PERSONALLY KNOW SOMEONE THAT HAD THEIRS REPAIRED AT NO CHARGE TOYOTA WOULD NOT FIX IT FOR FREE IF THEY DID NOT KNOW THE PRODUCT WAS BAD AND FAULTY. NOISE COMING FROM FRONT END OF VEHICLE WHILE DRIVING BETWEEN 10 TO 30 MPH. I WAS TOLD NEEDED ENTIRE NEW FRONT END, AND OTHER COMPONENTS FOR THE REPAIR. I DID NOT KNOW TOYOTA DID NOT CARE ABOUT THE PUBLIC SO MUCH TO LET UNSAFE VEHICLES TO BE OUT ON THE ROAD. CANNOT DRIVE VEHICLE UNTIL THESE REPAIRS ARE DONE FOR WORRY OF SAFETY FOR ME AND MY FAMILY.
NHTSA ODI #10725106
58,000 miles · Jun 27, 2012
Unknown Or Other
RECEIVE P2440 AND P2441 CODES FOR SECONDARY AIR INJECTION PUMP FAILURE. *TR
NHTSA ODI #10463251
149,500 miles · Jul 24, 2011
Engine And Engine CoolingUnknown Or Other
THE ENGINE CHECK LIGHT CAME ON AND THE ENGINE WENT INTO LIMP MODE, WHICH REDUCES ENGINE POWER MAKING IT DANGEROUS TO DRIVE. THE CHECK ENGINE LIGHT CAME ON FROM THE EMISSIONS VALVE SET FAILING. WHEN REPAIRED BY DEALER THEY ALSO DISCOVERED A CRACKED MANIFOLD. THIS EMISSIONS VALVE SET FAILURE SEEMS TO BE VERY COMMON ON 2008 TUNDRAS…
Read full complaint
THE ENGINE CHECK LIGHT CAME ON AND THE ENGINE WENT INTO LIMP MODE, WHICH REDUCES ENGINE POWER MAKING IT DANGEROUS TO DRIVE. THE CHECK ENGINE LIGHT CAME ON FROM THE EMISSIONS VALVE SET FAILING. WHEN REPAIRED BY DEALER THEY ALSO DISCOVERED A CRACKED MANIFOLD. THIS EMISSIONS VALVE SET FAILURE SEEMS TO BE VERY COMMON ON 2008 TUNDRAS AND IS VERY EXPENSIVE TO REPAIR. TO MY SURPRISE THE MANIFOLD WAS CRACKED AND THAT IS A VERY EXPENSIVE REPAIR AND MAY HAVE CONTRIBUTED TO THE EMISSIONS VALVE SET FAILURE. TOYOTA SHOULD RECALL THEIR EMISSIONS VALVE SET AND REDESIGN IT SO IT DOES NOT FAIL, AND IS LESS EXPENSIVE TO REPLACE, AND FINALLY THEY SHOULD NOT PROGRAM THE ENGINE TO GO INTO LIMP MODE IF THIS FAILURE OCCURS, AS IT CAN CAUSE YOU TO LOSE POWER WHILE DRIVING IN VARIOUS CONDITIONS THAT REQUIRE POWER TO GET OFF THE ROAD SAFELY.
NHTSA ODI #10415809
Mileage unknown · Jun 9, 2009
Unknown Or Other
HEAT/A.C/VENTILATION SYSTEM ALLOWS RODENTS TO ENTER FROM ENGINE COMPARTMENT INTO THE DUCTWORK INSIDE THE VEHICLE MEANING ALL AIR CONSUMED BY OCCUPANTS IS LACED WITH RODENT FECES/EXCREMENT WHICH IS UNHEALTHFUL FOR OCCUPANTS TO BREATHE AND IN SOME CONDITIONS WILL LEAD TO DEATH VIA ANTIVIRUS. *TR
NHTSA ODI #10273261
Official recalls
12Nov 23, 2021
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence & remedy
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Additional source detail variants (2)
Steering:hydraulic Power Assist System
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Steering:rack And Pinion
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Oct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Consequence & remedy
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
May 12, 2011
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2007-2011 TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEMS." THE TPMS ON SOME VEHICLES MAY NOT HAVE BEEN PROPERLY CALIBRATED AND AS A RESULT THE LOW TIRE PRESSURE WARNING LAMP MAY NOT ILLUMINATE SHOULD THE INFLATION PRESSURE IN ONE OR MORE OF THE VEHICLE'S TIRES FALL BELOW THE THRESHOLD FOR WHEN THE LOW TIRE PRESSURE WARNING LAMP SHOULD ILLUMINATE.
Consequence & remedy
Consequence: DRIVERS WILL NOT RECEIVE A WARNING FROM THE TIRE PRESSURE MONITOR THAT ONE OR MORE TIRES ARE UNDERINFLATED, INCREASING THE RISK THAT THE VEHICLE WILL BE DRIVEN WITH ONE OR MORE UNDERINFLATED TIRES, INCREASING THE RISK OF A TIRE FAILURE THAT MAY LEAD TO A CRASH.
Remedy: DEALERS WILL RECALIBRATE THE TIRE PRESSURE MONITORING SYSTEM IN ACCORDANCE WITH THE REGULATION FREE OF CHARGE. THE SAFETY RECALL BEGAN DURING JULY 2011. OWNERS MAY CONTACT SOUTHEAST TOYOTA CUSTOMER ASSISTANCE CENTER TOLL FREE AT 1-800-301-6859, MONDAY THROUGH FRIDAY, 8:30 AM TO 5:00 PM, EASTERN STANDARD TIME.
Mar 4, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FJ CRUISER, LAND CRUISER, TACOMA, SEQUOIA AND TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEM (TPMS)." WHEN FACTORY-INSTALLED WHEELS AND TIRES WERE REPLACED WITH TOYOTA AUTHORIZED ACCESSORY WHEELS AND LT TIRES PRIOR TO FIRST SALE, THE TIRE PRESSURE MONITORING SYSTEMS WERE NOT RE-CALIBRATED CORRECTLY AND THEREFORE DO NOT START ILLUMINATING THE LOW TIRE PRESSURE WARNING TELLTALE AT THE REQUIRED MINIMUM ACTIVATION PRESSURE.
Consequence & remedy
Consequence: FAILURE TO WARN OF TIRE DEFLATIONS IS A NON-COMPLIANCE WITH FMVSS 138 AND COULD LEAD TO TIRE FAILURE INCREASING THE RISK OF A CRASH.
Remedy: FOR THE LAND CRUISER, SEQUOIA, TACOMA AND TUNDRA VEHICLES, THE DEALER WILL RE-CALIBRATE THE TIRE PRESSURE MONITORING SYSTEM ON AFFECTED VEHICLES AND INSTALL AN UPDATED TIRE AND LOADING INFORMATION LABEL AT NO CHARGE. FOR THE FJ CRUISER VEHICLES, THE TPMS CANNOT BE RESET SO THE ELECTRONIC CONTROL UNIT (ECU) FOR THE TPMS WILL BE REPLACED. TOYOTA IS CURRENTLY DEVELOPING THE REMEDY ECU. IF AN OWNER IS NOT CERTAIN WHETHER HIS OR HER VEHICLE IS EQUIPPED WITH THESE ACCESSORIES, PLEASE CONTACT ANY TOYOTA DEALER FOR AN INSPECTION AT NO CHARGE. THE SAFETY RECALL BEGAN ON MARCH 31, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jan 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.
Consequence & remedy
Consequence: THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration