IllustrationTOYOTA HAS A DESIGN PROBLEM WITH THE FRONT BRAKES ON 2002 TUNDRAS. FRONT BRAKES VIBRATE WHEN APPLIED. THERE ARE MULTIPLE TSBS ON THIS PROBLEM, BUT TOYOTA WILL NOT PERFORM THE TSB 092302 WITHOUT MY PAYING $2310, TO FIX THEIR DESIGN PROBLEM!!!!!!!*JB
2002 Toyota Tundra
Owner reports · Recalls · Investigations
More warning signs than most Tundra years
Owner complaints for the 2002 Toyota Tundra are substantially higher than the model-year median of 144.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tundra years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
530–25K
4425–50K
5350–75K
5475–100K
87100–150K
79150K+
370 reports with mileage · 112 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 154 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 97 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
30 crash reports1 fire reports16 injury reports
Service Brakes, Hydraulic complaints
97 reportsTL*THE CONTACT OWNS A 2002 TOYOTA TUNDRA. WHILE DRIVING 40 MPH, THE VEHICLE VIBRATES WHEN THE BRAKES ARE APPLIED. THE CONTACT STATED THAT THE WEAR ON THE TIRES IS ABNORMAL AND THE VEHICLE FAILS TO REMAIN ALIGNED. THE BRAKES AND LOWER BALL JOINTS WERE REPLACED, BUT THE VIBRATION STILL PERSISTS. THE CONTACT STATED THAT TOYOTA …
Read full complaint
TL*THE CONTACT OWNS A 2002 TOYOTA TUNDRA. WHILE DRIVING 40 MPH, THE VEHICLE VIBRATES WHEN THE BRAKES ARE APPLIED. THE CONTACT STATED THAT THE WEAR ON THE TIRES IS ABNORMAL AND THE VEHICLE FAILS TO REMAIN ALIGNED. THE BRAKES AND LOWER BALL JOINTS WERE REPLACED, BUT THE VIBRATION STILL PERSISTS. THE CONTACT STATED THAT TOYOTA IS NOT PROPERLY REPAIRING THE VEHICLE. THE VEHICLE OPERATES NORMALLY EVERY TWO TO THREE MONTHS, BUT THE FAILURE ALWAYS RECURS. HE IS CONSTANTLY HAVING TO ROTATE THE TIRES AND ALIGN THE VEHICLE. THE FAILURES HAVE BEEN OCCURRING SINCE THE YEAR THE VEHICLE WAS PURCHASED. THE VIN AND ENGINE SIZE WERE UNKNOWN. THE CURRENT MILEAGE IS 84,000 AND FAILURE MILEAGE WAS 10,000.
WHEN APPLYING BRAKES AT SPEEDS ABOVE 50 MPH A SHAKING OCCURS IN THE FRONT BRAKES, STOPPING DISTANCE IS INCREASED AND CONTROLLABILITY IS HARDER TO MAINTAIN. TOOK VEHICLE TO TOYOTA DEALER IN TOWN, AND HE SAID THE BRAKE SYSTEM NEEDED OVERHAULING, AND THAT THERE WERE TWO TECHNICAL SERVICE BULLETINS BR004-02 AND BR003-2 DETAILING…
Read full complaint
WHEN APPLYING BRAKES AT SPEEDS ABOVE 50 MPH A SHAKING OCCURS IN THE FRONT BRAKES, STOPPING DISTANCE IS INCREASED AND CONTROLLABILITY IS HARDER TO MAINTAIN. TOOK VEHICLE TO TOYOTA DEALER IN TOWN, AND HE SAID THE BRAKE SYSTEM NEEDED OVERHAULING, AND THAT THERE WERE TWO TECHNICAL SERVICE BULLETINS BR004-02 AND BR003-2 DETAILING THE PROBLEM AND FIX. DUE TO THE FACT THAT THE TRUCK WAS OUT OF WARRANTY, IT WOULD COST. *AK
TL*THE CONTACT OWNS A 2002 TOYOTA TUNDRA. THE CONTACT STATED THAT THE BRAKE SYSTEM HAS A DESIGN FLAW. HE CAN DEPRESS THE BRAKE PEDAL AS HARD AS POSSIBLE BUT THE REAR BRAKES DO NOT ENGAGE. THIS FAILURE CAUSES THE FRONT BRAKES TO OVERWORK AND DAMAGE SEVERAL ROTORS. THE CONTACT CHANGED THE BRAKE PADS FOUR TIMES IN ALMOST FOUR Y…
Read full complaint
TL*THE CONTACT OWNS A 2002 TOYOTA TUNDRA. THE CONTACT STATED THAT THE BRAKE SYSTEM HAS A DESIGN FLAW. HE CAN DEPRESS THE BRAKE PEDAL AS HARD AS POSSIBLE BUT THE REAR BRAKES DO NOT ENGAGE. THIS FAILURE CAUSES THE FRONT BRAKES TO OVERWORK AND DAMAGE SEVERAL ROTORS. THE CONTACT CHANGED THE BRAKE PADS FOUR TIMES IN ALMOST FOUR YEARS. THE BRAKES FAIL MORE AT HIGHER SPEEDS (55 MPH) AND IT IS MORE DIFFICULT TO STOP THE VEHICLE WHEN THE ROAD IS WET. THE CURRENT MILEAGE IS 88,000 AND FAILURE MILEAGE WAS 50,000.
I BOUGHT MY 2002 TUNDRA NEW AND EXPERIENCED BRAKE VIBRATION ALMOST IMMEDIATELY. THE DEALER SAID THAT THE VIBRATION HAPPENS WHEN IT IS COLD (BOUGHT IN NOV 2001) AND IT IS NORMAL. I DID NOT BELIEVE THIS LOGIC, THEN THE DEALER SAID THERE WAS NOTHING WRONG WITH MY VEHICLE AND REFUSED TO DO ANY WORK ON IT UNDER WARRANTY (BUT WAS WILL…
Read full complaint
I BOUGHT MY 2002 TUNDRA NEW AND EXPERIENCED BRAKE VIBRATION ALMOST IMMEDIATELY. THE DEALER SAID THAT THE VIBRATION HAPPENS WHEN IT IS COLD (BOUGHT IN NOV 2001) AND IT IS NORMAL. I DID NOT BELIEVE THIS LOGIC, THEN THE DEALER SAID THERE WAS NOTHING WRONG WITH MY VEHICLE AND REFUSED TO DO ANY WORK ON IT UNDER WARRANTY (BUT WAS WILLING TO WORK ON IT IF I PAID; GO FIGURE). FIVE YEARS LATER THE PROBLEM IS GETTING WORSE AND HAD TO REPLACE MY PADS SEVERAL TIMES. STOPPING DISTANCE ON THE HIGHWAY IS GETTING LONGER AND MORE DANGEROUS. I SEE HERE THAT I'M NOT THE ONLY ONE EXPERIENCING THESE ISSUES. WHAT IS THE NHTSA WAITING FOR TO INITIATE AN INVESTIGATION? FOR A BAD ACCIDENT TO OCCUR AND SOMEONE DIES?
ADDENDUM TO MY ODI 10150678: MY REFERENCE TO1/5/2006 NAPA "REPAIR" WAS TO NO AVAIL. LARGER TUNDRA PADS ALONE DO NOT SOLVE THE VIOLENT DOWNHILL BRAKING PROBLEM THAT SO MANY OTHERS ALSO DESCRIBE. 2/20/2006 MILEAGE 35,800. 3/07/2007 MILEAGE 41850. AS CAN BE SEEN DRIVING IN COLORADO TERRAIN IS BEING DONE MOST RELUCTANTLY.*JB
I OWN A 2002 TOYOTA TUNDRA THAT HAS A MANUFACTURER'S DEFECT IN THE BRAKING SYSTEM. THIS DEFECT CAUSES THE FRONT ROTORS TO WARP, WHICH IN TURN CAUSES MY TRUCK TO SHAKE VIOLENTLY DURING BREAKING AND ALSO HINDERS OVERALL BRAKING ABILITY. AFTER HAVING MY BRAKES SERVICED SEVERAL TIMES, I LEARNED THAT TOYOTA HAS ISSUED A TECHNICAL S…
Read full complaint
I OWN A 2002 TOYOTA TUNDRA THAT HAS A MANUFACTURER'S DEFECT IN THE BRAKING SYSTEM. THIS DEFECT CAUSES THE FRONT ROTORS TO WARP, WHICH IN TURN CAUSES MY TRUCK TO SHAKE VIOLENTLY DURING BREAKING AND ALSO HINDERS OVERALL BRAKING ABILITY. AFTER HAVING MY BRAKES SERVICED SEVERAL TIMES, I LEARNED THAT TOYOTA HAS ISSUED A TECHNICAL SERVICE BULLETIN ADDRESSING THE DEFECT IN THE BRAKING SYSTEM OF MY MODEL TRUCK AND DETAILING HOW TO FIX THE PROBLEM. THE COST OF SAID REPAIRS EXCEEDS $2000. I FIND IT ABSURD THAT TOYOTA RECOGNIZES THE DEFECT BUT REFUSES TO EXECUTE A RECALL FOR THE BRAKING SYSTEM. BASICALLY, THE CONSUMER IS LEFT WITH THREE OPTIONS: 1) PAY $2000+ TO REPAIR A MANUFACTURER'S DEFECT; 2) PAY FOR BRAKE SERVICE ABOUT EVERY 2 OR 3 MONTHS; OR 3) DRIVE A VEHICLE WITH POORLY FUNCTIONING BRAKES. I, ALONG WITH MANY OTHERS WHO HAVE EXPERIENCED THE SAME PROBLEM AS I, AM CURRENTLY DRIVING A VEHICLE WITH POORLY FUNCTIONING BRAKES, BECAUSE I CANNOT AND WILL NOT AFFORD THE COST OF EITHER OF THE FIRST TWO OPTIONS. IT REMAINS BEYOND MY UNDERSTANDING HOW TOYOTA CAN GET AWAY WITH RECOGNIZING THE PROBLEM WITH THEIR VEHICLES BUT NOT ATONE FOR THEIR POOR CRAFTSMANSHIP. ADDITIONALLY, MANY OTHER OWNERS HAVE REPORTED THAT, WHILE THEIR VEHICLES WERE UNDER WARRANTY, THEIR TOYOTA SERVICE FACILITY BLAMED THE BRAKE PROBLEM ON INDIVIDUAL BRAKING HABITS. HOWEVER, AFTER THEIR WARRANTY EXPIRED, THEY INFORMED THEM OF THE DEFECT AND OFFERED TO FIX IT AT FULL COST. RIDICULOUS. *JB
BREAKS ON TOYOTA TUNDRAS ARE DEFECTIVE AND TOYOTA KNOWS ABOUT IT AS STATED IN TSB #BR004-02. MY FRONT BRAKES HAVE WORN OUT PREMATURELY. THE ONLY REASON THAT I HAVE NOT EXPERIENCED THE PROBLEM SOONER IS THAT I MAINLY USE THE TRUCK FOR OCCASIONAL LONG DISTANCE HIGHWAY TRIPS. I AM EXPERIENCING VIBRATION WHEN APPLYING THE BRAKES A…
Read full complaint
BREAKS ON TOYOTA TUNDRAS ARE DEFECTIVE AND TOYOTA KNOWS ABOUT IT AS STATED IN TSB #BR004-02. MY FRONT BRAKES HAVE WORN OUT PREMATURELY. THE ONLY REASON THAT I HAVE NOT EXPERIENCED THE PROBLEM SOONER IS THAT I MAINLY USE THE TRUCK FOR OCCASIONAL LONG DISTANCE HIGHWAY TRIPS. I AM EXPERIENCING VIBRATION WHEN APPLYING THE BRAKES AND THEY WORE OUT PREMATURELY. NUMEROUS OTHER CUSTOMERS HAVE COMPLAINED ABOUT THIS ISSUE AS WELL. BASED ON SOME OF THESE ADDITIONAL COMPLAINTS, TOYOTA IS DOING EVERYTHING POSSIBLE TO AVOID FIXING THE PROBLEM. PLEASE REFER TO THESE ADDITIONAL COMPLAINTS POSTED ON THIS BLOG: HTTP://WWW.CONSUMERAFFAIRS.COM/AUTOMOTIVE/TOYOTA_TUNDRA.HTML. *NM
I WAS DRIVING ABOUT 30 MILE PER HOUR WHEN MY BRAKE STARTED TO VIBRATE VIOLENTLY. AFTER CAREFULLY INSPECTED, I FOUND THAT THREE STUDS WERE BROKEN, TWO FROM THE FRONT LEFT AND ONE FROM THE FRONT RIGHT. A FRIEND OF MINE, AN AUTO MECHANIC, SAID THAT THE STUDS MIGHT HAVE BEEN BROKEN DUE TO UNEVEN WEAR OF THE ROTORS AND LOOSEN OF …
Read full complaint
I WAS DRIVING ABOUT 30 MILE PER HOUR WHEN MY BRAKE STARTED TO VIBRATE VIOLENTLY. AFTER CAREFULLY INSPECTED, I FOUND THAT THREE STUDS WERE BROKEN, TWO FROM THE FRONT LEFT AND ONE FROM THE FRONT RIGHT. A FRIEND OF MINE, AN AUTO MECHANIC, SAID THAT THE STUDS MIGHT HAVE BEEN BROKEN DUE TO UNEVEN WEAR OF THE ROTORS AND LOOSEN OF THE NUTS. WELL, I HAVE BEEN COMPLAINING ABOUT MY ROTORS WARPING TOO FAST TO THE DEALER, BUT I WAS TOLD THAT BRAKE SYSTEM IS NOT COVERED BY THE WARRANTY. I BROUGHT THIS PROBLEM UP SEVERAL TIME, BUT THE SAME THING ANSWER WAS GIVEN TO ME. RECENTLY, I WENT BACK TO THE DEALER AND TOLD THE SERVICE MANAGER ABOUT THE INCIDENT. THERE I FOUND OUT THAT ALL THE COMPLAINTS I MADE TO THE SERVICE DEPARTMENT WERE NOT DOCUMENTED. I WAS TOLD THAT THEY ONLY DOCUMENTED IF WORK ORDERS WERE WRITTEN. THAT MEANS I HAVE TO PAY THEM TO DOCUMENT. THE MANAGER SAID HE MAY CONSIDERED REPLACING MY BRAKE SYSTEM IF THE PROBLEM WAS DOCUMENTED BEFORE. TOYOTA HAS HEARD AND READ HUNDREDS OF COMPLAINTS ABOUT THIS BRAKE PROBLEM. THIS PROBLEM IS A SAFETY ISSUE AND IT SHOULD NOT BE IGNORED. *NM
2002 TOYOTA TUNDRA. BRAKES ARE NOT BIG ENOUGH FOR TRUCK. TRUCK VIBRATES BADLY WHEN STOPPING. THIS WILL BE MY FOURTH SET OF BRAKES IN LESS THAN 92,000 MILES. TOYOTA KNOWS THEY HAVE A PROBLEM WITH THE BRAKES BUT REFUSE TO DO ANYTHING ABOUT IT. SOMETIMES I WONDER IF THE TRUCK WILL STOP WHEN I LEAVE THE INTERSTATE. *NM
Official recalls
309V444000 · Structure:frame And Members:underbody Shields
Nov 18, 2009
TOYOTA IS RECALLING MODEL YEAR 2000-2003 TUNDRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA. EXCESSIVE CORROSION OF THE REAR CROSS MEMBER MAY CAUSE THE SEPARATION OF THE SPARE TIRE STOWED UNDER THE TRUCK BED WHICH WOULD PRESENT A ROAD HAZARD THAT COULD CAUSE A CRASH. ALSO, CORROSION OF THE REAR CROSS MEMBER COULD AFFECT THE REAR BRAKE LINES AND THE PROPORTIONING VALVE RESULTING IN DIMINISHED BRAKING CAPABILITY.
Consequence & remedy
Consequence: SEPARATION OF THE SPARE TIRE AND DIMINISHED BRAKE CAPACITY COULD INCREASE THE RISK OF A CRASH.
Remedy: TOYOTA IS ASKING OWNERS OF THE AFFECTED VEHICLES TO REMOVE THE SPARE TIRE FROM UNDER THE VEHICLE UNTIL A REMEDY CAN BE OBTAINED. DEALERS WILL INSPECT THE REAR CROSS MEMBER AND RELATED COMPONENTS, INCLUDING THE BRAKE LINES, AND REPLACE THEM IF NECESSARY. IF THE CROSS MEMBER DOES NOT NEED TO BE REPLACED, IT WILL BE SPRAYED WITH A CORROSION PROTECTION COMPOUND. THESE SERVICES WILL BE PERFORMED FREE OF CHARGE, HOWEVER MULTIPLE VISITS TO THE DEALER MAY BE REQUIRED. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT APRIL 30, 2010. OWNER MAY CONTACT TOYOTA AT 1-800-331-4331.
05V225000 · Suspension:front:control Arm:lower Ball Joint
May 17, 2005
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.
Consequence & remedy
Consequence: THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
02V129000 · Wheels
May 1, 2002
ON CERTAIN 4X2 VEHICLES EQUIPPED WITH AN ALLOY WHEEL TIRE UPGRADE (OPTIONS WM4, WM8, ZL1-ZL4, DH4, OR DH5) INSTALLED BY THE PROCESSING CENTERS IN JACKSONVILLE, FLORIDA OR COMMERCE, GEORGIA, A LABEL IDENTIFYING THE SPARE TIRE AS A TEMPORARY USE SPARE TIRE WAS NOT INSTALLED. THE UPGRADE INCLUDES 4 LARGER SIZE TIRES WITH ALLOY WHEELS. THE ORIGINAL SPARE TIRE/STEEL WHEEL IS NOT PART OF THE UPGRADE AND WAS NOT CHANGED.
Consequence & remedy
Consequence: DIFFERENT OPERATING CHARACTERISTICS CAN BE EXPERIENCED WHEN THE SPARE TIRE IS INSTALLED ON THE VEHICLE.
Remedy: OWNERS WILL BE PROVIDED WITH A CAUTION LABEL AND AN INSERT FOR THEIR OWNER'S MANUAL. OWNER NOTIFICATION BEGAN JULY 15, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE09049 · Frame Corrosion
Opened Oct 6, 2009 · Closed Jan 26, 2010
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:mounting; Service Brakes, Hydraulic; Service Brakes, Hydraulic:foundation Components:differential Proportional Valve; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings; Structure:frame And Members; Tires:temporary/emergency Spare Tire
THIS INVESTIGATION WAS OPENED BASED ON 20 REPORTS OF MODEL YEAR (MY) 2000 AND 2001 VEHICLES EXPERIENCING SEVERE CORROSION OF THE FRAME, RESULTING IN EITHER UNDER-BODY MOUNTED SPARE TIRE SEPARATION OR REAR BRAKE FAILURE.THE FAILURE REPORT COUNTS SHOWN ABOVE ARE FOR MY 2000 AND 2001 VEHICLES ONLY.BY LETTER OF NOVEMBER 16, 2009 TOYOTA HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (09V-444) OF APPROXIMATELY 110,000 MODEL YEAR (MY) 2000 THROUGH 2003 TUNDRA VEHICLES.THE AFFECTED RECALLED VEHICLES WERE SOLD OR ARE CURRENTLY REGISTERED IN THE DISTRICT OF COLUMBIA AND THE STATES OF CT, DE, IL, IN, KY, MA, MD, ME, MI, MN, NH, NJ, NY, OH, PA, RI, VA, VT, WI, WV.TOYOTA ALLEGES HIGH AMOUNTS OF ROAD SALTS ARE USED IN THESE AREAS AND EXCESSIVE CORROSION OF THE REAR CROSS-MEMBER (TO WHICH THE SPARE TIRE IS MOUNTED) CAN OCCUR AND CAUSE THE SPARE TIRE TO SEPARATE FROM THE VEHICLE AND CAN ALSO LEAD TO REAR BRAKE FAILURE.TOYOTA STATED: TOYOTA HAS TENTATIVELY CONCLUDED THAT THE ROOT CAUSE IS A COMBINATION OF FACTORS, INCLUDING USAGE IN AREAS WHERE ROAD SALT IS APPLIED, INADEQUATE VEHICLE MAINTENANCE (I.E., NOT FOLLOWING THE RECOMMENDATIONS IN THE OWNER'S MANUAL), THE DESIGN OF THE REAR CROSS-MEMBER, AND MANUFACTURING ISSUES.THE DESIGN OF THE REAR CROSS-MEMBER IS SUCH THAT IT IS OPEN ON THE TOP SIDE AND SUSCEPTIBLE TO ACCUMULATION OF DIRT, WATER AND ROAD SALT.MANUFACTURING ISSUES OF THE REAR CROSS-MEMBER RELATED TO THE COATING PROCESS ALSO AFFECT ITS CORROSION RESISTANCE.TOYOTA ALSO STATES THAT OWNERS OF MY 2000 THROUGH 2003 VEHICLES IN STATES NOT COVERED BY THE RECALL WILL BE NOTIFIED ON HOW TO OBTAIN THE SAME INSPECTION AND REPAIR AS THE RECALLED VEHICLES, FREE OF CHARGE.FURTHER TOYOTA STATES: PLEASE NOTE THAT WHILE TOYOTA HAS NOT DETERMINED A DEFECT EXISTS IN 2004 THROUGH 2006 MY TUNDRA VEHICLES, TOYOTA PLANS ON INITIATING A FIELD ACTION IN THE NEAR FUTURE TO PREVENT FUTURE CORROSION ON THOSE VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE AFFECTED REGION AT NO COST TO THE OWNER.BY LETTER OF JANUARY 8, 2010 TOYOTA HAS NOTIFIED THE AGENCY THAT IT AMENDED ITS DEFECT INFORMATION REPORT FOR SAFETY RECALL 09V-444 TO INCLUDE THE FUEL TANK MOUNTING SYSTEM (I.E., FUEL TANK SUPPORT STRAPS AND FUEL TANK MOUNTING CROSS-MEMBERS) IN THE SAFETY RECALL.TOYOTA STATES: TOYOTA HAS NOT DECIDED THAT THE FUEL TANK MOUNTING SYSTEM IN THOSE VEHICLES CONTAINS A SAFETY-RELATED DEFECT WITHIN THE MEANING OF FEDERAL MOTOR VEHICLE SAFETY LAW.RATHER, TOYOTA IS TAKING THIS ACTION AT ODI'S REQUEST AND TO AVOID FUTURE DISAGREEMENT WITH ODI WITH RESPECT TO THIS ISSUE.MY 2007 AND NEWER TUNDRA VEHICLES ARE NOT INCLUDED IN ANY OF TOYOTA'S ACTIONS AS THE REAR CROSS-MEMBER IN THOSE VEHICLES HAVE BEEN REDESIGNED SO THAT IT IS OPEN ON THE BOTTOM.THE ACTIONS TAKEN BY TOYOTA ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE SUBJECT VEHICLES.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (8)
Fuel System, Gasoline:storage:tank Assembly:mounting
THIS INVESTIGATION WAS OPENED BASED ON 20 REPORTS OF MODEL YEAR (MY) 2000 AND 2001 VEHICLES EXPERIENCING SEVERE CORROSION OF THE FRAME, RESULTING IN EITHER UNDER-BODY MOUNTED SPARE TIRE SEPARATION OR REAR BRAKE FAILURE.THE FAILURE REPORT COUNTS SHOWN ABOVE ARE FOR MY 2000 AND 2001 VEHICLES ONLY.BY LETTER OF NOVEMBER 16, 2009 TOYOTA HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (09V-444) OF APPROXIMATELY 110,000 MODEL YEAR (MY) 2000 THROUGH 2003 TUNDRA VEHICLES.THE AFFECTED RECALLED VEHICLES WERE SOLD OR ARE CURRENTLY REGISTERED IN THE DISTRICT OF COLUMBIA AND THE STATES OF CT, DE, IL, IN, KY, MA, MD, ME, MI, MN, NH, NJ, NY, OH, PA, RI, VA, VT, WI, WV.TOYOTA ALLEGES HIGH AMOUNTS OF ROAD SALTS ARE USED IN THESE AREAS AND EXCESSIVE CORROSION OF THE REAR CROSS-MEMBER (TO WHICH THE SPARE TIRE IS MOUNTED) CAN OCCUR AND CAUSE THE SPARE TIRE TO SEPARATE FROM THE VEHICLE AND CAN ALSO LEAD TO REAR BRAKE FAILURE.TOYOTA STATED: TOYOTA HAS TENTATIVELY CONCLUDED THAT THE ROOT CAUSE IS A COMBINATION OF FACTORS, INCLUDING USAGE IN AREAS WHERE ROAD SALT IS APPLIED, INADEQUATE VEHICLE MAINTENANCE (I.E., NOT FOLLOWING THE RECOMMENDATIONS IN THE OWNER'S MANUAL), THE DESIGN OF THE REAR CROSS-MEMBER, AND MANUFACTURING ISSUES.THE DESIGN OF THE REAR CROSS-MEMBER IS SUCH THAT IT IS OPEN ON THE TOP SIDE AND SUSCEPTIBLE TO ACCUMULATION OF DIRT, WATER AND ROAD SALT.MANUFACTURING ISSUES OF THE REAR CROSS-MEMBER RELATED TO THE COATING PROCESS ALSO AFFECT ITS CORROSION RESISTANCE.TOYOTA ALSO STATES THAT OWNERS OF MY 2000 THROUGH 2003 VEHICLES IN STATES NOT COVERED BY THE RECALL WILL BE NOTIFIED ON HOW TO OBTAIN THE SAME INSPECTION AND REPAIR AS THE RECALLED VEHICLES, FREE OF CHARGE.FURTHER TOYOTA STATES: PLEASE NOTE THAT WHILE TOYOTA HAS NOT DETERMINED A DEFECT EXISTS IN 2004 THROUGH 2006 MY TUNDRA VEHICLES, TOYOTA PLANS ON INITIATING A FIELD ACTION IN THE NEAR FUTURE TO PREVENT FUTURE CORROSION ON THOSE VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE AFFECTED REGION AT NO COST TO THE OWNER.BY LETTER OF JANUARY 8, 2010 TOYOTA HAS NOTIFIED THE AGENCY THAT IT AMENDED ITS DEFECT INFORMATION REPORT FOR SAFETY RECALL 09V-444 TO INCLUDE THE FUEL TANK MOUNTING SYSTEM (I.E., FUEL TANK SUPPORT STRAPS AND FUEL TANK MOUNTING CROSS-MEMBERS) IN THE SAFETY RECALL.TOYOTA STATES: TOYOTA HAS NOT DECIDED THAT THE FUEL TANK MOUNTING SYSTEM IN THOSE VEHICLES CONTAINS A SAFETY-RELATED DEFECT WITHIN THE MEANING OF FEDERAL MOTOR VEHICLE SAFETY LAW.RATHER, TOYOTA IS TAKING THIS ACTION AT ODI'S REQUEST AND TO AVOID FUTURE DISAGREEMENT WITH ODI WITH RESPECT TO THIS ISSUE.MY 2007 AND NEWER TUNDRA VEHICLES ARE NOT INCLUDED IN ANY OF TOYOTA'S ACTIONS AS THE REAR CROSS-MEMBER IN THOSE VEHICLES HAVE BEEN REDESIGNED SO THAT IT IS OPEN ON THE BOTTOM.THE ACTIONS TAKEN BY TOYOTA ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE SUBJECT VEHICLES.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Gasoline:storage:tank Assembly
THIS INVESTIGATION WAS OPENED BASED ON 20 REPORTS OF MODEL YEAR (MY) 2000 AND 2001 VEHICLES EXPERIENCING SEVERE CORROSION OF THE FRAME, RESULTING IN EITHER UNDER-BODY MOUNTED SPARE TIRE SEPARATION OR REAR BRAKE FAILURE.THE FAILURE REPORT COUNTS SHOWN ABOVE ARE FOR MY 2000 AND 2001 VEHICLES ONLY.BY LETTER OF NOVEMBER 16, 2009 TOYOTA HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (09V-444) OF APPROXIMATELY 110,000 MODEL YEAR (MY) 2000 THROUGH 2003 TUNDRA VEHICLES.THE AFFECTED RECALLED VEHICLES WERE SOLD OR ARE CURRENTLY REGISTERED IN THE DISTRICT OF COLUMBIA AND THE STATES OF CT, DE, IL, IN, KY, MA, MD, ME, MI, MN, NH, NJ, NY, OH, PA, RI, VA, VT, WI, WV.TOYOTA ALLEGES HIGH AMOUNTS OF ROAD SALTS ARE USED IN THESE AREAS AND EXCESSIVE CORROSION OF THE REAR CROSS-MEMBER (TO WHICH THE SPARE TIRE IS MOUNTED) CAN OCCUR AND CAUSE THE SPARE TIRE TO SEPARATE FROM THE VEHICLE AND CAN ALSO LEAD TO REAR BRAKE FAILURE.TOYOTA STATED: TOYOTA HAS TENTATIVELY CONCLUDED THAT THE ROOT CAUSE IS A COMBINATION OF FACTORS, INCLUDING USAGE IN AREAS WHERE ROAD SALT IS APPLIED, INADEQUATE VEHICLE MAINTENANCE (I.E., NOT FOLLOWING THE RECOMMENDATIONS IN THE OWNER'S MANUAL), THE DESIGN OF THE REAR CROSS-MEMBER, AND MANUFACTURING ISSUES.THE DESIGN OF THE REAR CROSS-MEMBER IS SUCH THAT IT IS OPEN ON THE TOP SIDE AND SUSCEPTIBLE TO ACCUMULATION OF DIRT, WATER AND ROAD SALT.MANUFACTURING ISSUES OF THE REAR CROSS-MEMBER RELATED TO THE COATING PROCESS ALSO AFFECT ITS CORROSION RESISTANCE.TOYOTA ALSO STATES THAT OWNERS OF MY 2000 THROUGH 2003 VEHICLES IN STATES NOT COVERED BY THE RECALL WILL BE NOTIFIED ON HOW TO OBTAIN THE SAME INSPECTION AND REPAIR AS THE RECALLED VEHICLES, FREE OF CHARGE.FURTHER TOYOTA STATES: PLEASE NOTE THAT WHILE TOYOTA HAS NOT DETERMINED A DEFECT EXISTS IN 2004 THROUGH 2006 MY TUNDRA VEHICLES, TOYOTA PLANS ON INITIATING A FIELD ACTION IN THE NEAR FUTURE TO PREVENT FUTURE CORROSION ON THOSE VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE AFFECTED REGION AT NO COST TO THE OWNER.BY LETTER OF JANUARY 8, 2010 TOYOTA HAS NOTIFIED THE AGENCY THAT IT AMENDED ITS DEFECT INFORMATION REPORT FOR SAFETY RECALL 09V-444 TO INCLUDE THE FUEL TANK MOUNTING SYSTEM (I.E., FUEL TANK SUPPORT STRAPS AND FUEL TANK MOUNTING CROSS-MEMBERS) IN THE SAFETY RECALL.TOYOTA STATES: TOYOTA HAS NOT DECIDED THAT THE FUEL TANK MOUNTING SYSTEM IN THOSE VEHICLES CONTAINS A SAFETY-RELATED DEFECT WITHIN THE MEANING OF FEDERAL MOTOR VEHICLE SAFETY LAW.RATHER, TOYOTA IS TAKING THIS ACTION AT ODI'S REQUEST AND TO AVOID FUTURE DISAGREEMENT WITH ODI WITH RESPECT TO THIS ISSUE.MY 2007 AND NEWER TUNDRA VEHICLES ARE NOT INCLUDED IN ANY OF TOYOTA'S ACTIONS AS THE REAR CROSS-MEMBER IN THOSE VEHICLES HAVE BEEN REDESIGNED SO THAT IT IS OPEN ON THE BOTTOM.THE ACTIONS TAKEN BY TOYOTA ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE SUBJECT VEHICLES.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Gasoline
THIS INVESTIGATION WAS OPENED BASED ON 20 REPORTS OF MODEL YEAR (MY) 2000 AND 2001 VEHICLES EXPERIENCING SEVERE CORROSION OF THE FRAME, RESULTING IN EITHER UNDER-BODY MOUNTED SPARE TIRE SEPARATION OR REAR BRAKE FAILURE.THE FAILURE REPORT COUNTS SHOWN ABOVE ARE FOR MY 2000 AND 2001 VEHICLES ONLY.BY LETTER OF NOVEMBER 16, 2009 TOYOTA HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (09V-444) OF APPROXIMATELY 110,000 MODEL YEAR (MY) 2000 THROUGH 2003 TUNDRA VEHICLES.THE AFFECTED RECALLED VEHICLES WERE SOLD OR ARE CURRENTLY REGISTERED IN THE DISTRICT OF COLUMBIA AND THE STATES OF CT, DE, IL, IN, KY, MA, MD, ME, MI, MN, NH, NJ, NY, OH, PA, RI, VA, VT, WI, WV.TOYOTA ALLEGES HIGH AMOUNTS OF ROAD SALTS ARE USED IN THESE AREAS AND EXCESSIVE CORROSION OF THE REAR CROSS-MEMBER (TO WHICH THE SPARE TIRE IS MOUNTED) CAN OCCUR AND CAUSE THE SPARE TIRE TO SEPARATE FROM THE VEHICLE AND CAN ALSO LEAD TO REAR BRAKE FAILURE.TOYOTA STATED: TOYOTA HAS TENTATIVELY CONCLUDED THAT THE ROOT CAUSE IS A COMBINATION OF FACTORS, INCLUDING USAGE IN AREAS WHERE ROAD SALT IS APPLIED, INADEQUATE VEHICLE MAINTENANCE (I.E., NOT FOLLOWING THE RECOMMENDATIONS IN THE OWNER'S MANUAL), THE DESIGN OF THE REAR CROSS-MEMBER, AND MANUFACTURING ISSUES.THE DESIGN OF THE REAR CROSS-MEMBER IS SUCH THAT IT IS OPEN ON THE TOP SIDE AND SUSCEPTIBLE TO ACCUMULATION OF DIRT, WATER AND ROAD SALT.MANUFACTURING ISSUES OF THE REAR CROSS-MEMBER RELATED TO THE COATING PROCESS ALSO AFFECT ITS CORROSION RESISTANCE.TOYOTA ALSO STATES THAT OWNERS OF MY 2000 THROUGH 2003 VEHICLES IN STATES NOT COVERED BY THE RECALL WILL BE NOTIFIED ON HOW TO OBTAIN THE SAME INSPECTION AND REPAIR AS THE RECALLED VEHICLES, FREE OF CHARGE.FURTHER TOYOTA STATES: PLEASE NOTE THAT WHILE TOYOTA HAS NOT DETERMINED A DEFECT EXISTS IN 2004 THROUGH 2006 MY TUNDRA VEHICLES, TOYOTA PLANS ON INITIATING A FIELD ACTION IN THE NEAR FUTURE TO PREVENT FUTURE CORROSION ON THOSE VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE AFFECTED REGION AT NO COST TO THE OWNER.BY LETTER OF JANUARY 8, 2010 TOYOTA HAS NOTIFIED THE AGENCY THAT IT AMENDED ITS DEFECT INFORMATION REPORT FOR SAFETY RECALL 09V-444 TO INCLUDE THE FUEL TANK MOUNTING SYSTEM (I.E., FUEL TANK SUPPORT STRAPS AND FUEL TANK MOUNTING CROSS-MEMBERS) IN THE SAFETY RECALL.TOYOTA STATES: TOYOTA HAS NOT DECIDED THAT THE FUEL TANK MOUNTING SYSTEM IN THOSE VEHICLES CONTAINS A SAFETY-RELATED DEFECT WITHIN THE MEANING OF FEDERAL MOTOR VEHICLE SAFETY LAW.RATHER, TOYOTA IS TAKING THIS ACTION AT ODI'S REQUEST AND TO AVOID FUTURE DISAGREEMENT WITH ODI WITH RESPECT TO THIS ISSUE.MY 2007 AND NEWER TUNDRA VEHICLES ARE NOT INCLUDED IN ANY OF TOYOTA'S ACTIONS AS THE REAR CROSS-MEMBER IN THOSE VEHICLES HAVE BEEN REDESIGNED SO THAT IT IS OPEN ON THE BOTTOM.THE ACTIONS TAKEN BY TOYOTA ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE SUBJECT VEHICLES.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:foundation Components:differential Proportional Valve
THIS INVESTIGATION WAS OPENED BASED ON 20 REPORTS OF MODEL YEAR (MY) 2000 AND 2001 VEHICLES EXPERIENCING SEVERE CORROSION OF THE FRAME, RESULTING IN EITHER UNDER-BODY MOUNTED SPARE TIRE SEPARATION OR REAR BRAKE FAILURE.THE FAILURE REPORT COUNTS SHOWN ABOVE ARE FOR MY 2000 AND 2001 VEHICLES ONLY.BY LETTER OF NOVEMBER 16, 2009 TOYOTA HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (09V-444) OF APPROXIMATELY 110,000 MODEL YEAR (MY) 2000 THROUGH 2003 TUNDRA VEHICLES.THE AFFECTED RECALLED VEHICLES WERE SOLD OR ARE CURRENTLY REGISTERED IN THE DISTRICT OF COLUMBIA AND THE STATES OF CT, DE, IL, IN, KY, MA, MD, ME, MI, MN, NH, NJ, NY, OH, PA, RI, VA, VT, WI, WV.TOYOTA ALLEGES HIGH AMOUNTS OF ROAD SALTS ARE USED IN THESE AREAS AND EXCESSIVE CORROSION OF THE REAR CROSS-MEMBER (TO WHICH THE SPARE TIRE IS MOUNTED) CAN OCCUR AND CAUSE THE SPARE TIRE TO SEPARATE FROM THE VEHICLE AND CAN ALSO LEAD TO REAR BRAKE FAILURE.TOYOTA STATED: TOYOTA HAS TENTATIVELY CONCLUDED THAT THE ROOT CAUSE IS A COMBINATION OF FACTORS, INCLUDING USAGE IN AREAS WHERE ROAD SALT IS APPLIED, INADEQUATE VEHICLE MAINTENANCE (I.E., NOT FOLLOWING THE RECOMMENDATIONS IN THE OWNER'S MANUAL), THE DESIGN OF THE REAR CROSS-MEMBER, AND MANUFACTURING ISSUES.THE DESIGN OF THE REAR CROSS-MEMBER IS SUCH THAT IT IS OPEN ON THE TOP SIDE AND SUSCEPTIBLE TO ACCUMULATION OF DIRT, WATER AND ROAD SALT.MANUFACTURING ISSUES OF THE REAR CROSS-MEMBER RELATED TO THE COATING PROCESS ALSO AFFECT ITS CORROSION RESISTANCE.TOYOTA ALSO STATES THAT OWNERS OF MY 2000 THROUGH 2003 VEHICLES IN STATES NOT COVERED BY THE RECALL WILL BE NOTIFIED ON HOW TO OBTAIN THE SAME INSPECTION AND REPAIR AS THE RECALLED VEHICLES, FREE OF CHARGE.FURTHER TOYOTA STATES: PLEASE NOTE THAT WHILE TOYOTA HAS NOT DETERMINED A DEFECT EXISTS IN 2004 THROUGH 2006 MY TUNDRA VEHICLES, TOYOTA PLANS ON INITIATING A FIELD ACTION IN THE NEAR FUTURE TO PREVENT FUTURE CORROSION ON THOSE VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE AFFECTED REGION AT NO COST TO THE OWNER.BY LETTER OF JANUARY 8, 2010 TOYOTA HAS NOTIFIED THE AGENCY THAT IT AMENDED ITS DEFECT INFORMATION REPORT FOR SAFETY RECALL 09V-444 TO INCLUDE THE FUEL TANK MOUNTING SYSTEM (I.E., FUEL TANK SUPPORT STRAPS AND FUEL TANK MOUNTING CROSS-MEMBERS) IN THE SAFETY RECALL.TOYOTA STATES: TOYOTA HAS NOT DECIDED THAT THE FUEL TANK MOUNTING SYSTEM IN THOSE VEHICLES CONTAINS A SAFETY-RELATED DEFECT WITHIN THE MEANING OF FEDERAL MOTOR VEHICLE SAFETY LAW.RATHER, TOYOTA IS TAKING THIS ACTION AT ODI'S REQUEST AND TO AVOID FUTURE DISAGREEMENT WITH ODI WITH RESPECT TO THIS ISSUE.MY 2007 AND NEWER TUNDRA VEHICLES ARE NOT INCLUDED IN ANY OF TOYOTA'S ACTIONS AS THE REAR CROSS-MEMBER IN THOSE VEHICLES HAVE BEEN REDESIGNED SO THAT IT IS OPEN ON THE BOTTOM.THE ACTIONS TAKEN BY TOYOTA ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE SUBJECT VEHICLES.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
THIS INVESTIGATION WAS OPENED BASED ON 20 REPORTS OF MODEL YEAR (MY) 2000 AND 2001 VEHICLES EXPERIENCING SEVERE CORROSION OF THE FRAME, RESULTING IN EITHER UNDER-BODY MOUNTED SPARE TIRE SEPARATION OR REAR BRAKE FAILURE.THE FAILURE REPORT COUNTS SHOWN ABOVE ARE FOR MY 2000 AND 2001 VEHICLES ONLY.BY LETTER OF NOVEMBER 16, 2009 TOYOTA HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (09V-444) OF APPROXIMATELY 110,000 MODEL YEAR (MY) 2000 THROUGH 2003 TUNDRA VEHICLES.THE AFFECTED RECALLED VEHICLES WERE SOLD OR ARE CURRENTLY REGISTERED IN THE DISTRICT OF COLUMBIA AND THE STATES OF CT, DE, IL, IN, KY, MA, MD, ME, MI, MN, NH, NJ, NY, OH, PA, RI, VA, VT, WI, WV.TOYOTA ALLEGES HIGH AMOUNTS OF ROAD SALTS ARE USED IN THESE AREAS AND EXCESSIVE CORROSION OF THE REAR CROSS-MEMBER (TO WHICH THE SPARE TIRE IS MOUNTED) CAN OCCUR AND CAUSE THE SPARE TIRE TO SEPARATE FROM THE VEHICLE AND CAN ALSO LEAD TO REAR BRAKE FAILURE.TOYOTA STATED: TOYOTA HAS TENTATIVELY CONCLUDED THAT THE ROOT CAUSE IS A COMBINATION OF FACTORS, INCLUDING USAGE IN AREAS WHERE ROAD SALT IS APPLIED, INADEQUATE VEHICLE MAINTENANCE (I.E., NOT FOLLOWING THE RECOMMENDATIONS IN THE OWNER'S MANUAL), THE DESIGN OF THE REAR CROSS-MEMBER, AND MANUFACTURING ISSUES.THE DESIGN OF THE REAR CROSS-MEMBER IS SUCH THAT IT IS OPEN ON THE TOP SIDE AND SUSCEPTIBLE TO ACCUMULATION OF DIRT, WATER AND ROAD SALT.MANUFACTURING ISSUES OF THE REAR CROSS-MEMBER RELATED TO THE COATING PROCESS ALSO AFFECT ITS CORROSION RESISTANCE.TOYOTA ALSO STATES THAT OWNERS OF MY 2000 THROUGH 2003 VEHICLES IN STATES NOT COVERED BY THE RECALL WILL BE NOTIFIED ON HOW TO OBTAIN THE SAME INSPECTION AND REPAIR AS THE RECALLED VEHICLES, FREE OF CHARGE.FURTHER TOYOTA STATES: PLEASE NOTE THAT WHILE TOYOTA HAS NOT DETERMINED A DEFECT EXISTS IN 2004 THROUGH 2006 MY TUNDRA VEHICLES, TOYOTA PLANS ON INITIATING A FIELD ACTION IN THE NEAR FUTURE TO PREVENT FUTURE CORROSION ON THOSE VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE AFFECTED REGION AT NO COST TO THE OWNER.BY LETTER OF JANUARY 8, 2010 TOYOTA HAS NOTIFIED THE AGENCY THAT IT AMENDED ITS DEFECT INFORMATION REPORT FOR SAFETY RECALL 09V-444 TO INCLUDE THE FUEL TANK MOUNTING SYSTEM (I.E., FUEL TANK SUPPORT STRAPS AND FUEL TANK MOUNTING CROSS-MEMBERS) IN THE SAFETY RECALL.TOYOTA STATES: TOYOTA HAS NOT DECIDED THAT THE FUEL TANK MOUNTING SYSTEM IN THOSE VEHICLES CONTAINS A SAFETY-RELATED DEFECT WITHIN THE MEANING OF FEDERAL MOTOR VEHICLE SAFETY LAW.RATHER, TOYOTA IS TAKING THIS ACTION AT ODI'S REQUEST AND TO AVOID FUTURE DISAGREEMENT WITH ODI WITH RESPECT TO THIS ISSUE.MY 2007 AND NEWER TUNDRA VEHICLES ARE NOT INCLUDED IN ANY OF TOYOTA'S ACTIONS AS THE REAR CROSS-MEMBER IN THOSE VEHICLES HAVE BEEN REDESIGNED SO THAT IT IS OPEN ON THE BOTTOM.THE ACTIONS TAKEN BY TOYOTA ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE SUBJECT VEHICLES.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic
THIS INVESTIGATION WAS OPENED BASED ON 20 REPORTS OF MODEL YEAR (MY) 2000 AND 2001 VEHICLES EXPERIENCING SEVERE CORROSION OF THE FRAME, RESULTING IN EITHER UNDER-BODY MOUNTED SPARE TIRE SEPARATION OR REAR BRAKE FAILURE.THE FAILURE REPORT COUNTS SHOWN ABOVE ARE FOR MY 2000 AND 2001 VEHICLES ONLY.BY LETTER OF NOVEMBER 16, 2009 TOYOTA HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (09V-444) OF APPROXIMATELY 110,000 MODEL YEAR (MY) 2000 THROUGH 2003 TUNDRA VEHICLES.THE AFFECTED RECALLED VEHICLES WERE SOLD OR ARE CURRENTLY REGISTERED IN THE DISTRICT OF COLUMBIA AND THE STATES OF CT, DE, IL, IN, KY, MA, MD, ME, MI, MN, NH, NJ, NY, OH, PA, RI, VA, VT, WI, WV.TOYOTA ALLEGES HIGH AMOUNTS OF ROAD SALTS ARE USED IN THESE AREAS AND EXCESSIVE CORROSION OF THE REAR CROSS-MEMBER (TO WHICH THE SPARE TIRE IS MOUNTED) CAN OCCUR AND CAUSE THE SPARE TIRE TO SEPARATE FROM THE VEHICLE AND CAN ALSO LEAD TO REAR BRAKE FAILURE.TOYOTA STATED: TOYOTA HAS TENTATIVELY CONCLUDED THAT THE ROOT CAUSE IS A COMBINATION OF FACTORS, INCLUDING USAGE IN AREAS WHERE ROAD SALT IS APPLIED, INADEQUATE VEHICLE MAINTENANCE (I.E., NOT FOLLOWING THE RECOMMENDATIONS IN THE OWNER'S MANUAL), THE DESIGN OF THE REAR CROSS-MEMBER, AND MANUFACTURING ISSUES.THE DESIGN OF THE REAR CROSS-MEMBER IS SUCH THAT IT IS OPEN ON THE TOP SIDE AND SUSCEPTIBLE TO ACCUMULATION OF DIRT, WATER AND ROAD SALT.MANUFACTURING ISSUES OF THE REAR CROSS-MEMBER RELATED TO THE COATING PROCESS ALSO AFFECT ITS CORROSION RESISTANCE.TOYOTA ALSO STATES THAT OWNERS OF MY 2000 THROUGH 2003 VEHICLES IN STATES NOT COVERED BY THE RECALL WILL BE NOTIFIED ON HOW TO OBTAIN THE SAME INSPECTION AND REPAIR AS THE RECALLED VEHICLES, FREE OF CHARGE.FURTHER TOYOTA STATES: PLEASE NOTE THAT WHILE TOYOTA HAS NOT DETERMINED A DEFECT EXISTS IN 2004 THROUGH 2006 MY TUNDRA VEHICLES, TOYOTA PLANS ON INITIATING A FIELD ACTION IN THE NEAR FUTURE TO PREVENT FUTURE CORROSION ON THOSE VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE AFFECTED REGION AT NO COST TO THE OWNER.BY LETTER OF JANUARY 8, 2010 TOYOTA HAS NOTIFIED THE AGENCY THAT IT AMENDED ITS DEFECT INFORMATION REPORT FOR SAFETY RECALL 09V-444 TO INCLUDE THE FUEL TANK MOUNTING SYSTEM (I.E., FUEL TANK SUPPORT STRAPS AND FUEL TANK MOUNTING CROSS-MEMBERS) IN THE SAFETY RECALL.TOYOTA STATES: TOYOTA HAS NOT DECIDED THAT THE FUEL TANK MOUNTING SYSTEM IN THOSE VEHICLES CONTAINS A SAFETY-RELATED DEFECT WITHIN THE MEANING OF FEDERAL MOTOR VEHICLE SAFETY LAW.RATHER, TOYOTA IS TAKING THIS ACTION AT ODI'S REQUEST AND TO AVOID FUTURE DISAGREEMENT WITH ODI WITH RESPECT TO THIS ISSUE.MY 2007 AND NEWER TUNDRA VEHICLES ARE NOT INCLUDED IN ANY OF TOYOTA'S ACTIONS AS THE REAR CROSS-MEMBER IN THOSE VEHICLES HAVE BEEN REDESIGNED SO THAT IT IS OPEN ON THE BOTTOM.THE ACTIONS TAKEN BY TOYOTA ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE SUBJECT VEHICLES.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Structure:frame And Members
THIS INVESTIGATION WAS OPENED BASED ON 20 REPORTS OF MODEL YEAR (MY) 2000 AND 2001 VEHICLES EXPERIENCING SEVERE CORROSION OF THE FRAME, RESULTING IN EITHER UNDER-BODY MOUNTED SPARE TIRE SEPARATION OR REAR BRAKE FAILURE.THE FAILURE REPORT COUNTS SHOWN ABOVE ARE FOR MY 2000 AND 2001 VEHICLES ONLY.BY LETTER OF NOVEMBER 16, 2009 TOYOTA HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (09V-444) OF APPROXIMATELY 110,000 MODEL YEAR (MY) 2000 THROUGH 2003 TUNDRA VEHICLES.THE AFFECTED RECALLED VEHICLES WERE SOLD OR ARE CURRENTLY REGISTERED IN THE DISTRICT OF COLUMBIA AND THE STATES OF CT, DE, IL, IN, KY, MA, MD, ME, MI, MN, NH, NJ, NY, OH, PA, RI, VA, VT, WI, WV.TOYOTA ALLEGES HIGH AMOUNTS OF ROAD SALTS ARE USED IN THESE AREAS AND EXCESSIVE CORROSION OF THE REAR CROSS-MEMBER (TO WHICH THE SPARE TIRE IS MOUNTED) CAN OCCUR AND CAUSE THE SPARE TIRE TO SEPARATE FROM THE VEHICLE AND CAN ALSO LEAD TO REAR BRAKE FAILURE.TOYOTA STATED: TOYOTA HAS TENTATIVELY CONCLUDED THAT THE ROOT CAUSE IS A COMBINATION OF FACTORS, INCLUDING USAGE IN AREAS WHERE ROAD SALT IS APPLIED, INADEQUATE VEHICLE MAINTENANCE (I.E., NOT FOLLOWING THE RECOMMENDATIONS IN THE OWNER'S MANUAL), THE DESIGN OF THE REAR CROSS-MEMBER, AND MANUFACTURING ISSUES.THE DESIGN OF THE REAR CROSS-MEMBER IS SUCH THAT IT IS OPEN ON THE TOP SIDE AND SUSCEPTIBLE TO ACCUMULATION OF DIRT, WATER AND ROAD SALT.MANUFACTURING ISSUES OF THE REAR CROSS-MEMBER RELATED TO THE COATING PROCESS ALSO AFFECT ITS CORROSION RESISTANCE.TOYOTA ALSO STATES THAT OWNERS OF MY 2000 THROUGH 2003 VEHICLES IN STATES NOT COVERED BY THE RECALL WILL BE NOTIFIED ON HOW TO OBTAIN THE SAME INSPECTION AND REPAIR AS THE RECALLED VEHICLES, FREE OF CHARGE.FURTHER TOYOTA STATES: PLEASE NOTE THAT WHILE TOYOTA HAS NOT DETERMINED A DEFECT EXISTS IN 2004 THROUGH 2006 MY TUNDRA VEHICLES, TOYOTA PLANS ON INITIATING A FIELD ACTION IN THE NEAR FUTURE TO PREVENT FUTURE CORROSION ON THOSE VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE AFFECTED REGION AT NO COST TO THE OWNER.BY LETTER OF JANUARY 8, 2010 TOYOTA HAS NOTIFIED THE AGENCY THAT IT AMENDED ITS DEFECT INFORMATION REPORT FOR SAFETY RECALL 09V-444 TO INCLUDE THE FUEL TANK MOUNTING SYSTEM (I.E., FUEL TANK SUPPORT STRAPS AND FUEL TANK MOUNTING CROSS-MEMBERS) IN THE SAFETY RECALL.TOYOTA STATES: TOYOTA HAS NOT DECIDED THAT THE FUEL TANK MOUNTING SYSTEM IN THOSE VEHICLES CONTAINS A SAFETY-RELATED DEFECT WITHIN THE MEANING OF FEDERAL MOTOR VEHICLE SAFETY LAW.RATHER, TOYOTA IS TAKING THIS ACTION AT ODI'S REQUEST AND TO AVOID FUTURE DISAGREEMENT WITH ODI WITH RESPECT TO THIS ISSUE.MY 2007 AND NEWER TUNDRA VEHICLES ARE NOT INCLUDED IN ANY OF TOYOTA'S ACTIONS AS THE REAR CROSS-MEMBER IN THOSE VEHICLES HAVE BEEN REDESIGNED SO THAT IT IS OPEN ON THE BOTTOM.THE ACTIONS TAKEN BY TOYOTA ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE SUBJECT VEHICLES.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Tires:temporary/emergency Spare Tire
THIS INVESTIGATION WAS OPENED BASED ON 20 REPORTS OF MODEL YEAR (MY) 2000 AND 2001 VEHICLES EXPERIENCING SEVERE CORROSION OF THE FRAME, RESULTING IN EITHER UNDER-BODY MOUNTED SPARE TIRE SEPARATION OR REAR BRAKE FAILURE.THE FAILURE REPORT COUNTS SHOWN ABOVE ARE FOR MY 2000 AND 2001 VEHICLES ONLY.BY LETTER OF NOVEMBER 16, 2009 TOYOTA HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (09V-444) OF APPROXIMATELY 110,000 MODEL YEAR (MY) 2000 THROUGH 2003 TUNDRA VEHICLES.THE AFFECTED RECALLED VEHICLES WERE SOLD OR ARE CURRENTLY REGISTERED IN THE DISTRICT OF COLUMBIA AND THE STATES OF CT, DE, IL, IN, KY, MA, MD, ME, MI, MN, NH, NJ, NY, OH, PA, RI, VA, VT, WI, WV.TOYOTA ALLEGES HIGH AMOUNTS OF ROAD SALTS ARE USED IN THESE AREAS AND EXCESSIVE CORROSION OF THE REAR CROSS-MEMBER (TO WHICH THE SPARE TIRE IS MOUNTED) CAN OCCUR AND CAUSE THE SPARE TIRE TO SEPARATE FROM THE VEHICLE AND CAN ALSO LEAD TO REAR BRAKE FAILURE.TOYOTA STATED: TOYOTA HAS TENTATIVELY CONCLUDED THAT THE ROOT CAUSE IS A COMBINATION OF FACTORS, INCLUDING USAGE IN AREAS WHERE ROAD SALT IS APPLIED, INADEQUATE VEHICLE MAINTENANCE (I.E., NOT FOLLOWING THE RECOMMENDATIONS IN THE OWNER'S MANUAL), THE DESIGN OF THE REAR CROSS-MEMBER, AND MANUFACTURING ISSUES.THE DESIGN OF THE REAR CROSS-MEMBER IS SUCH THAT IT IS OPEN ON THE TOP SIDE AND SUSCEPTIBLE TO ACCUMULATION OF DIRT, WATER AND ROAD SALT.MANUFACTURING ISSUES OF THE REAR CROSS-MEMBER RELATED TO THE COATING PROCESS ALSO AFFECT ITS CORROSION RESISTANCE.TOYOTA ALSO STATES THAT OWNERS OF MY 2000 THROUGH 2003 VEHICLES IN STATES NOT COVERED BY THE RECALL WILL BE NOTIFIED ON HOW TO OBTAIN THE SAME INSPECTION AND REPAIR AS THE RECALLED VEHICLES, FREE OF CHARGE.FURTHER TOYOTA STATES: PLEASE NOTE THAT WHILE TOYOTA HAS NOT DETERMINED A DEFECT EXISTS IN 2004 THROUGH 2006 MY TUNDRA VEHICLES, TOYOTA PLANS ON INITIATING A FIELD ACTION IN THE NEAR FUTURE TO PREVENT FUTURE CORROSION ON THOSE VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE AFFECTED REGION AT NO COST TO THE OWNER.BY LETTER OF JANUARY 8, 2010 TOYOTA HAS NOTIFIED THE AGENCY THAT IT AMENDED ITS DEFECT INFORMATION REPORT FOR SAFETY RECALL 09V-444 TO INCLUDE THE FUEL TANK MOUNTING SYSTEM (I.E., FUEL TANK SUPPORT STRAPS AND FUEL TANK MOUNTING CROSS-MEMBERS) IN THE SAFETY RECALL.TOYOTA STATES: TOYOTA HAS NOT DECIDED THAT THE FUEL TANK MOUNTING SYSTEM IN THOSE VEHICLES CONTAINS A SAFETY-RELATED DEFECT WITHIN THE MEANING OF FEDERAL MOTOR VEHICLE SAFETY LAW.RATHER, TOYOTA IS TAKING THIS ACTION AT ODI'S REQUEST AND TO AVOID FUTURE DISAGREEMENT WITH ODI WITH RESPECT TO THIS ISSUE.MY 2007 AND NEWER TUNDRA VEHICLES ARE NOT INCLUDED IN ANY OF TOYOTA'S ACTIONS AS THE REAR CROSS-MEMBER IN THOSE VEHICLES HAVE BEEN REDESIGNED SO THAT IT IS OPEN ON THE BOTTOM.THE ACTIONS TAKEN BY TOYOTA ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE SUBJECT VEHICLES.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA04024 · Ball Joint Separation
Opened Aug 20, 2004 · Closed Jul 8, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
ODI RECEIVED 3 CONSUMER REPORTS OF ALLEGED BALL JOINT SEPARATION ON MY 2002 TUNDRA VEHICLES.THE COMPLAINTS ALLEGE THAT A FRONT SUSPENSION BALL JOINT SEPARATED WHILE DRIVING, WHICH CAUSED THE SUSPENSION TO COLLAPSE AND RESULTED IN A LOSS OF VEHICLE CONTROL.BASED ON THESE COMPLAINTS, ODI OPENED PE02-040 AND LATER UPGRADED TO EA04-024 FOR MY 2002 TUNDRA VEHICLES.DURING EA04-024, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE. ON MAY 16, 2005, TOYOTA NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2002-2004 TUNDRA AND SEQUOIA VEHICLES (PRODUCED BETWEEN AUGUST 1, 2001 AND SEPTEMBER 30, 2003), MY 2001-2004 TACOMA VEHICLES (PRODUCED BETWEEN JULY 31, 2001 AND DECEMBER 23, 2003), AND MY 2001-2002 4RUNNER VEHICLES (PRODUCED BETWEEN MAY 22, 2001 AND AUGUST 23, 2002).THE NOTIFICATION STATED THAT DUE TO A MANUFACTURING ISSUE WITH THE FRONT SUSPENSION LOWER BALL JOINTS (WHICH CONNECT THE LOWER CONTROL ARMS TO THE STEERING KNUCKLES OF THE FRONT WHEELS) THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED.SUCH SCRATCHES MAY RESULT IN SIGNIFICANTLY ACCELERATED WEAR OF THE JOINT. ACCORDING TO TOYOTA, IF THE [SUBJECT] VEHICLE IS OPERATED FOR AN EXTENDED PERIOD OF TIME IN THIS CONDITION, THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT, REDUCED VEHICLE SELF-CENTERING, AND NOISE IN THE FRONT SUSPENSION.IN EXTREME CASES, WHEN THE DRIVER CONTINUES TO OPERATE THE VEHICLE IN THIS CONDITION, THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING A LOSS OF VEHICLE STEERING CONTROL. TOYOTA WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY TOYOTA DEALER FOR REPLACEMENT OF THE FRONT SUSPENSION LOWER BALL JOINTS.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (4)
Suspension:front:control Arm:lower Arm
ODI RECEIVED 3 CONSUMER REPORTS OF ALLEGED BALL JOINT SEPARATION ON MY 2002 TUNDRA VEHICLES.THE COMPLAINTS ALLEGE THAT A FRONT SUSPENSION BALL JOINT SEPARATED WHILE DRIVING, WHICH CAUSED THE SUSPENSION TO COLLAPSE AND RESULTED IN A LOSS OF VEHICLE CONTROL.BASED ON THESE COMPLAINTS, ODI OPENED PE02-040 AND LATER UPGRADED TO EA04-024 FOR MY 2002 TUNDRA VEHICLES.DURING EA04-024, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE. ON MAY 16, 2005, TOYOTA NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2002-2004 TUNDRA AND SEQUOIA VEHICLES (PRODUCED BETWEEN AUGUST 1, 2001 AND SEPTEMBER 30, 2003), MY 2001-2004 TACOMA VEHICLES (PRODUCED BETWEEN JULY 31, 2001 AND DECEMBER 23, 2003), AND MY 2001-2002 4RUNNER VEHICLES (PRODUCED BETWEEN MAY 22, 2001 AND AUGUST 23, 2002).THE NOTIFICATION STATED THAT DUE TO A MANUFACTURING ISSUE WITH THE FRONT SUSPENSION LOWER BALL JOINTS (WHICH CONNECT THE LOWER CONTROL ARMS TO THE STEERING KNUCKLES OF THE FRONT WHEELS) THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED.SUCH SCRATCHES MAY RESULT IN SIGNIFICANTLY ACCELERATED WEAR OF THE JOINT. ACCORDING TO TOYOTA, IF THE [SUBJECT] VEHICLE IS OPERATED FOR AN EXTENDED PERIOD OF TIME IN THIS CONDITION, THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT, REDUCED VEHICLE SELF-CENTERING, AND NOISE IN THE FRONT SUSPENSION.IN EXTREME CASES, WHEN THE DRIVER CONTINUES TO OPERATE THE VEHICLE IN THIS CONDITION, THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING A LOSS OF VEHICLE STEERING CONTROL. TOYOTA WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY TOYOTA DEALER FOR REPLACEMENT OF THE FRONT SUSPENSION LOWER BALL JOINTS.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Suspension:front:control Arm:lower Ball Joint
ODI RECEIVED 3 CONSUMER REPORTS OF ALLEGED BALL JOINT SEPARATION ON MY 2002 TUNDRA VEHICLES.THE COMPLAINTS ALLEGE THAT A FRONT SUSPENSION BALL JOINT SEPARATED WHILE DRIVING, WHICH CAUSED THE SUSPENSION TO COLLAPSE AND RESULTED IN A LOSS OF VEHICLE CONTROL.BASED ON THESE COMPLAINTS, ODI OPENED PE02-040 AND LATER UPGRADED TO EA04-024 FOR MY 2002 TUNDRA VEHICLES.DURING EA04-024, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE. ON MAY 16, 2005, TOYOTA NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2002-2004 TUNDRA AND SEQUOIA VEHICLES (PRODUCED BETWEEN AUGUST 1, 2001 AND SEPTEMBER 30, 2003), MY 2001-2004 TACOMA VEHICLES (PRODUCED BETWEEN JULY 31, 2001 AND DECEMBER 23, 2003), AND MY 2001-2002 4RUNNER VEHICLES (PRODUCED BETWEEN MAY 22, 2001 AND AUGUST 23, 2002).THE NOTIFICATION STATED THAT DUE TO A MANUFACTURING ISSUE WITH THE FRONT SUSPENSION LOWER BALL JOINTS (WHICH CONNECT THE LOWER CONTROL ARMS TO THE STEERING KNUCKLES OF THE FRONT WHEELS) THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED.SUCH SCRATCHES MAY RESULT IN SIGNIFICANTLY ACCELERATED WEAR OF THE JOINT. ACCORDING TO TOYOTA, IF THE [SUBJECT] VEHICLE IS OPERATED FOR AN EXTENDED PERIOD OF TIME IN THIS CONDITION, THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT, REDUCED VEHICLE SELF-CENTERING, AND NOISE IN THE FRONT SUSPENSION.IN EXTREME CASES, WHEN THE DRIVER CONTINUES TO OPERATE THE VEHICLE IN THIS CONDITION, THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING A LOSS OF VEHICLE STEERING CONTROL. TOYOTA WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY TOYOTA DEALER FOR REPLACEMENT OF THE FRONT SUSPENSION LOWER BALL JOINTS.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Suspension:front:control Arm
ODI RECEIVED 3 CONSUMER REPORTS OF ALLEGED BALL JOINT SEPARATION ON MY 2002 TUNDRA VEHICLES.THE COMPLAINTS ALLEGE THAT A FRONT SUSPENSION BALL JOINT SEPARATED WHILE DRIVING, WHICH CAUSED THE SUSPENSION TO COLLAPSE AND RESULTED IN A LOSS OF VEHICLE CONTROL.BASED ON THESE COMPLAINTS, ODI OPENED PE02-040 AND LATER UPGRADED TO EA04-024 FOR MY 2002 TUNDRA VEHICLES.DURING EA04-024, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE. ON MAY 16, 2005, TOYOTA NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2002-2004 TUNDRA AND SEQUOIA VEHICLES (PRODUCED BETWEEN AUGUST 1, 2001 AND SEPTEMBER 30, 2003), MY 2001-2004 TACOMA VEHICLES (PRODUCED BETWEEN JULY 31, 2001 AND DECEMBER 23, 2003), AND MY 2001-2002 4RUNNER VEHICLES (PRODUCED BETWEEN MAY 22, 2001 AND AUGUST 23, 2002).THE NOTIFICATION STATED THAT DUE TO A MANUFACTURING ISSUE WITH THE FRONT SUSPENSION LOWER BALL JOINTS (WHICH CONNECT THE LOWER CONTROL ARMS TO THE STEERING KNUCKLES OF THE FRONT WHEELS) THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED.SUCH SCRATCHES MAY RESULT IN SIGNIFICANTLY ACCELERATED WEAR OF THE JOINT. ACCORDING TO TOYOTA, IF THE [SUBJECT] VEHICLE IS OPERATED FOR AN EXTENDED PERIOD OF TIME IN THIS CONDITION, THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT, REDUCED VEHICLE SELF-CENTERING, AND NOISE IN THE FRONT SUSPENSION.IN EXTREME CASES, WHEN THE DRIVER CONTINUES TO OPERATE THE VEHICLE IN THIS CONDITION, THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING A LOSS OF VEHICLE STEERING CONTROL. TOYOTA WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY TOYOTA DEALER FOR REPLACEMENT OF THE FRONT SUSPENSION LOWER BALL JOINTS.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Suspension
ODI RECEIVED 3 CONSUMER REPORTS OF ALLEGED BALL JOINT SEPARATION ON MY 2002 TUNDRA VEHICLES.THE COMPLAINTS ALLEGE THAT A FRONT SUSPENSION BALL JOINT SEPARATED WHILE DRIVING, WHICH CAUSED THE SUSPENSION TO COLLAPSE AND RESULTED IN A LOSS OF VEHICLE CONTROL.BASED ON THESE COMPLAINTS, ODI OPENED PE02-040 AND LATER UPGRADED TO EA04-024 FOR MY 2002 TUNDRA VEHICLES.DURING EA04-024, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE. ON MAY 16, 2005, TOYOTA NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2002-2004 TUNDRA AND SEQUOIA VEHICLES (PRODUCED BETWEEN AUGUST 1, 2001 AND SEPTEMBER 30, 2003), MY 2001-2004 TACOMA VEHICLES (PRODUCED BETWEEN JULY 31, 2001 AND DECEMBER 23, 2003), AND MY 2001-2002 4RUNNER VEHICLES (PRODUCED BETWEEN MAY 22, 2001 AND AUGUST 23, 2002).THE NOTIFICATION STATED THAT DUE TO A MANUFACTURING ISSUE WITH THE FRONT SUSPENSION LOWER BALL JOINTS (WHICH CONNECT THE LOWER CONTROL ARMS TO THE STEERING KNUCKLES OF THE FRONT WHEELS) THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED.SUCH SCRATCHES MAY RESULT IN SIGNIFICANTLY ACCELERATED WEAR OF THE JOINT. ACCORDING TO TOYOTA, IF THE [SUBJECT] VEHICLE IS OPERATED FOR AN EXTENDED PERIOD OF TIME IN THIS CONDITION, THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT, REDUCED VEHICLE SELF-CENTERING, AND NOISE IN THE FRONT SUSPENSION.IN EXTREME CASES, WHEN THE DRIVER CONTINUES TO OPERATE THE VEHICLE IN THIS CONDITION, THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING A LOSS OF VEHICLE STEERING CONTROL. TOYOTA WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY TOYOTA DEALER FOR REPLACEMENT OF THE FRONT SUSPENSION LOWER BALL JOINTS.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
PE04040 · Front Suspension Ball Joint Breakage
Opened Apr 13, 2004 · Closed Aug 20, 2004
Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint; Suspension:front:control Arm:upper Ball Joint
ODI OPENED PE04-040 BASED ON THREE CONSUMER REPORTS OF ALLEGED BALL JOINT FAILURE.THE COMPLAINTS ALLEGE THAT A FRONT SUSPENSION BALL JOINT SEPARATED WHILE DRIVING, WHICH CAUSED THE SUSPENSION TO COLLAPSE AND RESULTED IN A LOSS OF VEHICLE CONTROL.ALL OF THESE COMPLAINTS INVOLVED THE FAILURE OF A LOWER BALL JOINT.DURING THE INVESTIGATION, TOYOTA IDENTIFIED A TOTAL OF 15 COMPLAINTS OF LOWER BALL JOINT SEPARATION, ONE OF WHICH RESULTED IN A CRASH, AND 28 WARRANTY CLAIMS RELATED TO LOWER BALL JOINT WEAR.ODI'S ANALYSIS SHOWED THAT OF THE 15 SEPARATIONS, 11 WERE ON FOUR-WHEEL DRIVE VEHICLES (24.2 PER 100,000 VEHICLES), WHICH MAKE UP APPROXIMATELY 40% OF THE 2002 MY POPULATION (45,448 VEHICLES).ODI'S ANALYSIS ALSO SHOWED THAT SOME DRIVERS LOST FRONT BRAKING ABILITY AS THE BRAKE LINE SEVERED WHEN THE FRONT SUSPENSION COLLAPSED.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS ISSUE, TO ASSESS THE SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Additional source detail variants (2)
Suspension:front:control Arm:lower Ball Joint
ODI OPENED PE04-040 BASED ON THREE CONSUMER REPORTS OF ALLEGED BALL JOINT FAILURE.THE COMPLAINTS ALLEGE THAT A FRONT SUSPENSION BALL JOINT SEPARATED WHILE DRIVING, WHICH CAUSED THE SUSPENSION TO COLLAPSE AND RESULTED IN A LOSS OF VEHICLE CONTROL.ALL OF THESE COMPLAINTS INVOLVED THE FAILURE OF A LOWER BALL JOINT.DURING THE INVESTIGATION, TOYOTA IDENTIFIED A TOTAL OF 15 COMPLAINTS OF LOWER BALL JOINT SEPARATION, ONE OF WHICH RESULTED IN A CRASH, AND 28 WARRANTY CLAIMS RELATED TO LOWER BALL JOINT WEAR.ODI'S ANALYSIS SHOWED THAT OF THE 15 SEPARATIONS, 11 WERE ON FOUR-WHEEL DRIVE VEHICLES (24.2 PER 100,000 VEHICLES), WHICH MAKE UP APPROXIMATELY 40% OF THE 2002 MY POPULATION (45,448 VEHICLES).ODI'S ANALYSIS ALSO SHOWED THAT SOME DRIVERS LOST FRONT BRAKING ABILITY AS THE BRAKE LINE SEVERED WHEN THE FRONT SUSPENSION COLLAPSED.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS ISSUE, TO ASSESS THE SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Suspension:front:control Arm:upper Ball Joint
ODI OPENED PE04-040 BASED ON THREE CONSUMER REPORTS OF ALLEGED BALL JOINT FAILURE.THE COMPLAINTS ALLEGE THAT A FRONT SUSPENSION BALL JOINT SEPARATED WHILE DRIVING, WHICH CAUSED THE SUSPENSION TO COLLAPSE AND RESULTED IN A LOSS OF VEHICLE CONTROL.ALL OF THESE COMPLAINTS INVOLVED THE FAILURE OF A LOWER BALL JOINT.DURING THE INVESTIGATION, TOYOTA IDENTIFIED A TOTAL OF 15 COMPLAINTS OF LOWER BALL JOINT SEPARATION, ONE OF WHICH RESULTED IN A CRASH, AND 28 WARRANTY CLAIMS RELATED TO LOWER BALL JOINT WEAR.ODI'S ANALYSIS SHOWED THAT OF THE 15 SEPARATIONS, 11 WERE ON FOUR-WHEEL DRIVE VEHICLES (24.2 PER 100,000 VEHICLES), WHICH MAKE UP APPROXIMATELY 40% OF THE 2002 MY POPULATION (45,448 VEHICLES).ODI'S ANALYSIS ALSO SHOWED THAT SOME DRIVERS LOST FRONT BRAKING ABILITY AS THE BRAKE LINE SEVERED WHEN THE FRONT SUSPENSION COLLAPSED.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS ISSUE, TO ASSESS THE SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.