2025 Toyota Tacoma

MY 2025 TACOMA is part of a recall by Toyota, I was notified of the potential issue on early November 2025 and told Toyota was working on a remedy. On December 3rd, 2025 while using 4-wheel drive during a snow storm the drive shaft (recall issue) broke. On December 4th, 2025, the local Toyota dealer checked my Tacoma and found it unsafe to drive - they kept my Tacoma and provided a loaner vehicle. Toyota reported at this time the remedy would be available by the end of 4th quarter (December). As of today, February 21, 2026 -- there is still no remedy for the issue, my Tacoma is still sitting at the dealer, and I do not have my truck. Toyota reports a remedy will be available during the 1st quarter of the year but nothing yet. I called brand engagement recently and asked them to extend my warranty, Toyota care, and other free trials that were included with my purchase. However, Toyota refuses to do anything further - as they said a loaner car is enough - to make the issue more acceptable even though my new vehicle is losing this coverage.

The contact owns a 2025 Toyota Tacoma. The contact received notification of NHTSA Campaign Number: 25V656000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Driving up the 15 freeway from Diamond bar CA to Victorville CA the car gave me a warning that the transmission is overheating and to pull over to cool it down keep in mind I was on a paved freeway with no trailer and nothing in the bed of the truck so no unusual weight so with the car being brand new (only 1500 miles) I played it safe and pulled to the side of the freeway for about 15 minutes to allow for cooling then the sign went away and it was driving normal. A few days later I took the car into the shop for transmission, hard shift issue and I had them look at the overheating as well and they found an overheating was caused from “harsh acceleration” i’ve had many cars and no car has ever had a transmission overheating light come on unless if I was on the track or off roading I went up to Victorville again the following weekend and the overheating light came on again but the dealership is saying it’s normal but going up a paid freeway and having to stop on the side of the road to let the transmission cool down is not safe

The contact owns a 2025 Toyota Tacoma. The contact received notification of NHTSA Campaign Number: 25V656000 (POWER TRAIN); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

The contact owns a 2025 Toyota Tacoma. The contact received notification of NHTSA Campaign Number: 25V656000 (Power Train); however, parts for the recall repair were not yet available. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue, and a case was opened for a potential buyback option. The contact had not experienced a failure.

The vehicle was being operated in 4-wheel-drive, mode 4H, and when turning to the left at low speed, there was a grinding noise from the front of the vehicle and it would not proceed. The vehicle had to be put back in 2-wheel-drive, mode 2H, put in reverse, backed up a short distance, and then put back in drive, and then it was able to proceed. This is likely the CV joint issue reported in other 2024 and 2025 Toyota Tacomas. The dealer has been notified, and the vehicle will be taken in for service.

•What component or system failed or malfunctioned, and is it available for inspection upon request? I purchased a 2025 Toyota Tacoma from Carver Toyota of Columbus, IN, 47280 brand new with only 15 miles. I also purchased the 100,000-mile bumper to bumper warranty that covers third party parts. After driving the vehicle for 5,000 miles, I noticed problems with Transmission or the Powertrain System whenever I would shift from 2nd to 3rd gear, down shift, shift to reverse, and would slip acceleration whenever the vehicle is sitting idle. •How was your safety or the safety of others put at risk? This has impacted my safety and the safety of others by not properly shifting into gear. When accelerating it engages harshly from 2nd to 3rd gear. I can’t properly accelerate whenever the vehicle is idle; thus causing safety concerns when operating this vehicle. •Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, on [XXX], I took the vehicle into to Carver Toyota Service Center with only 10,639. My warranty covers 100,000 miles bumper to bumper. •Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The Service Member with Carver Toyota “test drove” and confirmed that the vehicle shifted harshly from park to reverse and from 2nd to 3rd gear. The vehicle fluids were checked and were found to be low. The fluids were “topped off” and the vehicle was returned back to me within one day of my delivering it to them. •Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? At the time of my reporting this issue with Carver, there were no warnings or error codes indicted by the vehicle. However, this is a well known issue with this make and model of the Toyota Tacoma. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle was set in tow/haul mode. Tow/haul mode provides higher acceleration by changing the operation of transmission. Vehicle was towing 2500lb cargo trailer on interstate. Driver stopped at rest area and turned off engine and left vehicle. Driver returned to vehicle 5 minutes later. Driver started engine and proceeded to leave the rest area. Driver was on highway entrance ramp. Entrance ramp merges with right lanr Driver attempted to accelerate to enter highway in such a way that there would be safe distance between end of trailer and car on highway approaching end of trailer. Vehicle would not accelerate as quickly as it was accelerating for the past 2 hours. Driver was surprised and distracted. Margin of safety between rear end of trailer and car on highway was greatly reduced. Some time after the incident Driver realized that car forgot it was in tow haul mode whenever engine is turned off. There is no warning that mode changed. This means that car does not behave as reasonably expected after an ignition cycle