Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
870–25K
1025–50K
150–75K
375–100K
1100–150K
1150K+
103 reports with mileage · 115 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel/propulsion System. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports1 fire reports5 injury reports
What owners actually said
218 reports
Mileage unknown · Jun 20, 2021
Forward Collision AvoidancePower Train
Transmission shifts when it should not shift! It also jerks when accelerating and maintaining speeds. While in cruse control the truck drops in 20mph in speed really concerning when it would cause a bad wreck while it drops it constantly still jerks and it also floors the truck to get back up to the preselected speed and transmi…
Read full complaint
Transmission shifts when it should not shift! It also jerks when accelerating and maintaining speeds. While in cruse control the truck drops in 20mph in speed really concerning when it would cause a bad wreck while it drops it constantly still jerks and it also floors the truck to get back up to the preselected speed and transmission jerks and studders and drops and speeds back up and so it sounds like it could blow up from it flooring and dropping in speed and flooring it in cruse control This needs fixed and worked out! Transmission shouldn’t be jerking or hunting for gears
NHTSA ODI #11421554
Mileage unknown · Jun 2, 2021
Electrical SystemEngineFireInjury
I was driving my truck a 2019 TRD off road Tacoma from San Diego to LA I was on the 605 freeway in the fast lane when I noticed smoke smell and then I noticed fire flames by the air conditioner and the phone charging plate I proceed to Exit the freeway thankfully I did not get in a car accident with any other vehicles however I…
Read full complaint
I was driving my truck a 2019 TRD off road Tacoma from San Diego to LA I was on the 605 freeway in the fast lane when I noticed smoke smell and then I noticed fire flames by the air conditioner and the phone charging plate I proceed to Exit the freeway thankfully I did not get in a car accident with any other vehicles however I was unable to stop and put out the fire. It's very upsetting because at no fault of my own I am now lob obligated to find another vehicle and I am not in the financial or credit position that I was when I bought my truck that is now a total loss by my insurance it covers my loan but not much after that so the fact that I've heard that this has been an issue for a few other Tacoma's And it's not even listed yet there's a problem the fact that this is not within my control as to what happened and there's nothing but oh well good luck getting another car Something needs to change.
NHTSA ODI #11419291
Mileage unknown · May 31, 2021
Fuel/propulsion System
Received notice of a recall on the low pressure fuel pump in November 2020; still have not been notified to bring my truck in for repairs. I don't feel safe driving more than 20 or 30 miles from home as I don't want to be stranded if the fuel pump fails.
NHTSA ODI #11419112
Mileage unknown · May 8, 2021
Fuel/propulsion System
LOCAL TOYOTA DEALERSHIP IN SIERRA VISTA, ARIZONA HAS STATED ON MULTIPLE OCCASIONS THAT THEY DO NOT HAVE THE PARTS AND ARE NOT ORDERING THEM.
NHTSA ODI #11415686
20,000 miles · Apr 29, 2021
Unknown Or Other
NOISE WHEN IS ACCELERATED, RUNS SLOWLY WHEN IS TRYING TO BE ACCELERATE, RUNS SLOW OR CAN NOT DEVELOP VELOCITY
NHTSA ODI #11414515
19,520 miles · Apr 27, 2021
Air BagsSeat BeltsUnknown Or Other
THE PASSENGER SEATBELT LIGHT KEEPS BLINKING WHEN SEAT BELT IS BUCKLED AND IT SAYS PASSENGER AIRBAG IS OFF WHILE THERE IS SOMEONE IN THERE AND BUCKLED UP. THIS HAPPENS WHEN PARKED OR DRIVING, WE HAVE UNHOOKED THE BATTERY TO TRY TO RESET IT. NO LUCK. I AM AFRAID IF WE WERE TO GET IN AN ACCIDENT THE PASSENGER AIRBAG WOULD NOT DEPL…
Read full complaint
THE PASSENGER SEATBELT LIGHT KEEPS BLINKING WHEN SEAT BELT IS BUCKLED AND IT SAYS PASSENGER AIRBAG IS OFF WHILE THERE IS SOMEONE IN THERE AND BUCKLED UP. THIS HAPPENS WHEN PARKED OR DRIVING, WE HAVE UNHOOKED THE BATTERY TO TRY TO RESET IT. NO LUCK. I AM AFRAID IF WE WERE TO GET IN AN ACCIDENT THE PASSENGER AIRBAG WOULD NOT DEPLOY.
NHTSA ODI #11414204
Mileage unknown · Apr 10, 2021
Fuel/propulsion System
WELL THE VEHICLE HAS A MANUFACTURER RECALL NUMBER 20TA02 AND I'VE CONTACTED THE DEALER AND STILL HAVEN'T TAKEN CARE OF IT FOR REASONS UNKNOWN.
NHTSA ODI #11407350
37 miles · Apr 8, 2021
Steering
WANDERING WHILE DRIVING
NHTSA ODI #11407029
25,200 miles · Apr 3, 2021
Power Train
TRUCK STARTING LUNGE FORWARD WHILE IN HIGHWAY GOING SPEED LIMIT ALMOST LIKE IT'S SLIPPING GEARS
NHTSA ODI #11406199
41,900 miles · Mar 29, 2021
Service Brakes
MULTIPLE OCCURANCES - 2019 TACOMA 42XXX MILES AND ON THE 3RD ISSUE OF WARPING FRONT ROTORS. VEHICLE IS HIGHWAY DRIVEN PRIMARILY AND ROTORS WARP AND CAUSE SHAKING WHILE BRAKING AT OR AROUND 3000 MILES AFTER HAVING THEM CUT OR REPLACED. SHAKING IS VIOLENT WHEN SLOWING FROM 65-70MPH AND LIGHTLY PRESENT DURRING CITY DRIVING. THIS IS…
Read full complaint
MULTIPLE OCCURANCES - 2019 TACOMA 42XXX MILES AND ON THE 3RD ISSUE OF WARPING FRONT ROTORS. VEHICLE IS HIGHWAY DRIVEN PRIMARILY AND ROTORS WARP AND CAUSE SHAKING WHILE BRAKING AT OR AROUND 3000 MILES AFTER HAVING THEM CUT OR REPLACED. SHAKING IS VIOLENT WHEN SLOWING FROM 65-70MPH AND LIGHTLY PRESENT DURRING CITY DRIVING. THIS ISSUE WAS ALSO A PROBLEM ON MY PREVIOUS 2019 TACOMA, MY 2018 TOYOTA CHR, AND MY 2014 TOYOTA COROLLA LEADING ME TO BELIEVE THIS IS NOT A MODEL SPECIFIC ISSUE. ON PAST VEHICLE THE CONCERN WAS RESOLVED BY SWITCHING TO A NON OEM ROTOR. EVERY TOYOTA I HAVE DRIVEN THAT WAS 20110 OR NEWER ALSO HAS A HEAVY FRONT BIAS TO ITS BRAKE PRESSURE DISTRIBUTION WHICH IS MORE THANK LIKELY A KEY COMPONENT TO THE CAUSE OF THIS ONGOING CONCERN.
Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.
Toyota Motor Engineering & Manufacturing (Toyota) recalled certain 2018-2019 4Runner, Highlander, Camry, Land Cruiser, Sequoia, Sienna, Tacoma and Tundra, and Lexus RC 300, RC 350, GS 350, GX 460, IS 300, LC 500, LS 500, LX 570, RX 350L, and 2019 Toyota Avalon and Corolla, and certain Lexus NX 300, and ES 350 vehicles on January 13, 2020. On March 4, 2020, Toyota expanded the recall to include certain 2014-2015 Toyota 4Runner and Land Cruiser, 2018 Avalon, Corolla, 2014 FJ Cruiser, 2017 Sienna and Lexus 2018 ES 350, 2018-2019 GS 300, 2013-2014 GS350, 2014-2015 GX 460, IS 350 and LX 570, 2014 IS F, 2018-2019 IS 350, LC 500H and LS 500H, 2013-2015 LS 460, 2015 NX 200T and RC350, 2017 RC 200T and RX 350. Toyota also removed the 2018-2019 Toyota 4Runner and Land Cruiser and 2018-2019 Lexus GX 460 and LX 570 and 2019 NX300 from inclusion in this recall. On March 19, 2020, Toyota expanded the recall to include 2015 Lexus GS350 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the fuel pump, free of charge. The recall began May 4, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are 20TB02 and 20TA02 for Toyota vehicles and 20LB01 and 20LA01 for Lexus vehicles.
Gulf States Toyota (GST) is recalling certain 2019 C-HR, 4Runner, Avalon, Avalon Hybrid, Camry, Camry Hybrid, Highlander, Land Cruiser, Prius, RAV4, Sequoia, Tacoma, Sienna, Tundra and Yaris vehicles. The text on the load capacity label may become illegible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: If the driver cannot read the label, they may unknowingly overload the vehicle, increasing the risk of a crash.
Remedy: GST will notify owners, and dealers will provide corrected load carrying capacity modification labels, free of charge. The recall began May 24, 2019. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 19R1.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 Toyota Tacoma vehicles. Improper machining of the brake master cylinder may result in internal damage of one of the seals, affecting brake performance.
Consequence & remedy
Consequence: Reduced brake performance can lengthen the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the brake master cylinder, free of charge. The recall began January 28, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's numbers for this recall are J16/J06.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA19001 · Electrical Overstress
Opened Apr 19, 2019 · Closed Sep 19, 2024
Status: closed (inferred from source dates) · Air Bags: Air Bag/restraint Control Module
The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicles may be equipped with an airbag control unit (ACU) for the supplemental restraint system (SRS) Electronic Control Unit (ECU) manufactured by ZF-TRW. The ECU receives signals from crash sensors mounted in the vehicle and deploys the vehicle air bags and seat belt pretensioners in accordance with manufacturer design specifications. The ECU in the subject vehicles contains a model DS84 application-specific integrated circuit (ASIC) which controls the communication of the crash sensor signal, firing commands (i.e., when to deploy the airbag(s) and/or pretensioners), and fault information (e.g., diagnostic trouble codes). In September 2016, FCA announced recall 16V-668 for certain model year (MY) 2010 to 2014 Chrysler, Dodge and Jeep products manufactured with the subject ZF-TRW ACU. In this recall, FCA discussed an EOS condition that resulted in a failure of the subject DS84 ASIC, which caused air bag non-deployment. FCA noted that the defect condition had only been observed in vehicles equipped with sensor harnessing routed across the front of the vehicle. Other FCA vehicles that also used the subject ACU, but were not equipped with cross-car harnessing, had not experienced EOS failures, despite similar time in service. During the course of this investigation, ODI sent two separate Information Request (IR) letters to six vehicle manufactures (including FCA, Hyundai, Honda, Kia, Mitsubishi, and Toyota) and one IR letter to ZF-TRW. These IR letters resulted in ODI receiving comprehensive data from these manufacturers and suppliers. Studies of this data found that the DS84 ASIC does not have sufficient protection against negative electrical transients or electrical overstress (“EOS”) that can be generated in certain severe crashes. An electrical transient occurs when the electrical power supplied to a circuit changes momentarily over a short duration of time. In these severe crash cases, the crash sensors and other powered wiring can be damaged and short circuited so as to create a negative electrical transient of sufficient intensity and duration (that are outside the vehicle manufacturer's specification) to damage the ASIC before the restraint device deployment signal is received by the SRS ECU. This damaged signal can lead to incomplete or nondeployment of the air bags and/or pretensioners. Airbag non-deployment and/or lack of pretensioner operation can increase the risk or severity of injury in a crash.A total of 8 fatalities and 14 injuries were associated with known EOS events. The common element in all investigated manufacturers vehicles is the SRS ECU containing a DS84 ASIC manufactured by ZF-TRW. The risk associated with the ASIC is equally shared among all OEMS involved in the investigation. The actual real-world risk can be mitigated by other factors which were assessed by ODI during this investigation. The first mitigating factor involves protections built into the ACU design which protect the DS84 ASIC from damage. There are multiple strategies and levels of protection employed by different OEMs that provide effective EOS mitigation. The two most common strategies at the ACU level are circuit protection diodes on the remote senor signal lines, and current limiting resistors that protect critical components. The second mitigating factor is found at the vehicle level and involves the location and routing of the wires leading from the crash sensors to the SRS ECU. If the wires are well protected in a crash and are not routed with other power wires carrying large currents, the risk for an EOS event is significantly reduced or eliminated. These design specific factors combine to produce a spectrum of risk for the vehicles equipped with ACUs using the DS84 ASIC. Given the many of years of field exposure, it is possible to divide the subject population into two groups; vehicles which have experienced EOS events, and vehicles which have not experienced EOS field events. Four of the six OEMs involved in this investigation have experienced EOS field events on at least one of their models equipped with a DS84 ASIC. All vehicle models (including the Toyota models identified in the Failure Report Summary of the opening resume for this investigation) with field events have been recalled. In an abundance of caution, ODI kept this investigation open five years to monitor field performance and did not identify any field events on vehicles not included in existing safety recalls. Given the spectrum of risk identified in this investigation and that all vehicles with a demonstrated unreasonable risk have been recalled, ODI is closing this investigation. ODI is closing this investigation with the following manufacturer safety recalls: 16V-668, 18E-043, 18V-137, 18V-363, and 20V-024. With the recall actions taken by the subject vehicle and equipment manufacturers, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exists on other model or model year vehicles outside of the recall scopes. The agency reserves the right to take further action if warranted by the circumstances.
2019 Toyota Tacoma Problems, Complaints & Recalls | Skip That Year
Illustration