NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
147 reportsClear category filter500 miles · Mar 7, 2007
Engine And Engine CoolingVehicle Speed Control
I WANTED TO WRITE YOU TO LET YOU KNOW THAT I HAVE A '06 TACOMA DOUBLE CAB AND I AM EXPERIENCING THE "LURCH" PROBLEM. I HAVE AROUND 2000 MILES ON MY TRUCK. I THOUGHT IT WAS JUST ME BEING PICKY, BUT IT ACTUALLY FEELS LIKE IT DOESN'T WANT TO STOP AT TIMES. I HAVE NOTICED THAT WITH THE AC OR HEAT ON, IF I ARE SITTING AT A RED LIGHT,…
Read full complaint
I WANTED TO WRITE YOU TO LET YOU KNOW THAT I HAVE A '06 TACOMA DOUBLE CAB AND I AM EXPERIENCING THE "LURCH" PROBLEM. I HAVE AROUND 2000 MILES ON MY TRUCK. I THOUGHT IT WAS JUST ME BEING PICKY, BUT IT ACTUALLY FEELS LIKE IT DOESN'T WANT TO STOP AT TIMES. I HAVE NOTICED THAT WITH THE AC OR HEAT ON, IF I ARE SITTING AT A RED LIGHT, AND DON'T HAVE MY FOOT FIRMLY, I MEAN FIRMLY PLANTED ON THE BRAKE, IT WANTS TO JUMP FORWARD. IT WILL DO THIS A COUPLE OF TIMES IF THE LIGHT IS RED FOR A WHILE. ALSO, IF I AM DRIVING THROUGH A PARKING LOT AT SLOW SPEEDS, IT TENDS TO "LURCH" FORWARDS AT TIMES, THUS CAUSING ME TO "PLAY" WITH THE BRAKE AND GAS. NOT SURE IF THIS IS RELATED OR NOT, BUT ALSO, IF I AM RIDING AT ABOUT 34-45 MPH AND THEN RELEASE THE GAS, THE ENGINE FEELS LIKE IT STALLS, BUT IT DOESN'T. THE RPMS DROP, THEN LEVEL OFF AGAIN AS IT COAST. *JB
NHTSA ODI #10184416
500 miles · Mar 6, 2007
Power TrainVehicle Speed Control
I HAVE AN '06 TOYOTA TACOMA THAT "LURCHES" WHEN AT A STOP BUT STILL IN DRIVE. AFTER A FEW SECONDS FROM COMING TO A STOP, THE VEHICLE IDLES HIGHER AND IF THE BRAKES ARE NOT DEPRESSED TO THE FLOOR THE VEHICLE WILL MOVE FORWARD. *JB
NHTSA ODI #10184375
6,000 miles · Mar 6, 2007
Vehicle Speed ControlCrash
I HAVE EXPERIENCED A LURCHING PROBLEM IN MY 2006 SPORT 4 DOOR TACOMA. THE FIRST TIME IT HAPPENED, I REAR ENDED A VEHICLE CAUSING $1500 DAMAGE TO THE TACOMA AND $1200 TO THE OTHER VEHICLE. I ALSO HAD A WITNESS THAT SAW MY FOOT ON THE BRAKE PEDAL AFTER IMPACT. THE VEHICLE WAS TOWED TO THE DEALERSHIP AND THE ACCIDENT REPORTED TO T…
Read full complaint
I HAVE EXPERIENCED A LURCHING PROBLEM IN MY 2006 SPORT 4 DOOR TACOMA. THE FIRST TIME IT HAPPENED, I REAR ENDED A VEHICLE CAUSING $1500 DAMAGE TO THE TACOMA AND $1200 TO THE OTHER VEHICLE. I ALSO HAD A WITNESS THAT SAW MY FOOT ON THE BRAKE PEDAL AFTER IMPACT. THE VEHICLE WAS TOWED TO THE DEALERSHIP AND THE ACCIDENT REPORTED TO TOYOTA CANADA AND THE MINISTRY OF TRANSPORTATION. A THIRD PARTY INVESTIGATOR/ENGINEERING WAS SENT TO CHECK THE VEHICLE AND FOUND NO ERROR CODES. I WAS TOLD THERE WAS NO PROBLEM. TWO MONTHS LATER THE TRUCK LURCHED AGAIN AT AN INTERSECTION. THIS TIME I SHOVED THE TRUCK INTO NEUTRAL. I OBSERVED THE RPMS CLIMB TO 3000 RPM THEN DROP OFF. THE TOYOTA DEALERSHIP (NORTHSIDE TOYOTA) CHECKED THE VEHICLE OVER AND SAID THEY FOUND NO PROBLEM. NOTE: THE VEHICLE HAD ROUGHLY 10,000 KILOMETERS AT THAT TIME. I ALSO FOUND MYSELF RIDING THE BRAKES MORE THEN I HAVE EVER ON ANY VEHICLE I'VE OWNED. WE HAVE SINCE TRADED THE VEHICLE IN FOR A 2007 TACOMA THINKING THIS PROBLEM IS ONE OF A KIND ISSUE. I TOLD THE DEALERSHIP WHY I WAS TRADING IT IN. WE NO LONGER TRUSTED THE 2006. THEY HAD NO QUALMS DOING THE TRADE, OBVIOUSLY THINKING THERE WAS NO ISSUE. I TOOK A MAJOR HIT FOR DEPRECIATION ON A TRUCK THAT HAD ONE OIL CHANGE. THAT 2006 IS STILL SITTING ON THEIR LOT. TO SAY THE LEAST I AM NOT PLEASED, BUT DON'T HAVE THE MEANS TO PURSUE THIS. ALSO THE STRESS GOT TO US. *JB
NHTSA ODI #10184332
1,000 miles · Feb 22, 2007
Engine And Engine CoolingLatches/locks/linkagesVehicle Speed Control
TL*- THE CONTACT OWNS A 2006 TOYOTA TACOMA , CAB. CRUISE CONTROL MALFUNCTIONED. WHILE DRIVING AT 60 MPH THE VEHICLE SURGED AT 5100 RPMS, AND DOWN SHIFTED BEFORE ADDING FUEL. THE FAILURE ALMOST CAUSED THE VEHICLE TO CRASH INTO A BARRIER. A PRODUCT ENGINEER INSPECTED THE VEHICLE, AND STATED THAT IT PERFORMED AS DESIGNED…
Read full complaint
TL*- THE CONTACT OWNS A 2006 TOYOTA TACOMA , CAB. CRUISE CONTROL MALFUNCTIONED. WHILE DRIVING AT 60 MPH THE VEHICLE SURGED AT 5100 RPMS, AND DOWN SHIFTED BEFORE ADDING FUEL. THE FAILURE ALMOST CAUSED THE VEHICLE TO CRASH INTO A BARRIER. A PRODUCT ENGINEER INSPECTED THE VEHICLE, AND STATED THAT IT PERFORMED AS DESIGNED AND ACCORDING TO THE CONTACT THE DESIGN WAS INCORRECT. THIS FAILURE OCCURRED SINCE AUGUST 2006. THE CONTACT STATED THAT THE DOOR SHOULD LOCK AFTER ENGAGING THE GEARS. THE DEALER STATED IT WAS DESIGNED THAT WAY, AND THEY'RE UNABLE TO REPROGRAM IT TO MAKE IT AUTO LOCK. THE OWNER MAILED A DETAILED FAILURE REPORT TO THE PRESIDENT OF TOYOTA. THE FAILURE MILEAGE WAS 8000, AND THE CURRENT MILEAGE WAS 15100.*AK
NHTSA ODI #10183271
Mileage unknown · Feb 22, 2007
Vehicle Speed Control
YESTERDAY GOING HOME, I TOOK THE INTERSTATE. TRYING THE LOWER SPEED (FOR BETTER MILEAGE), I WAS GOING 60 MPH WITH THE CC SET. TRAFFIC CAME UP ON ME AND I FELT MY TRUCK WAS IN DANGER, SO I USED MY FOOT TO INCREASE TO 70 MPH. WHEN I REACHED 70 MPH, I PRESSED SET ON THE CC SWITCH FOR IT TO SET THE CRUISE AT 70 MPH. I REMOVED MY FOO…
Read full complaint
YESTERDAY GOING HOME, I TOOK THE INTERSTATE. TRYING THE LOWER SPEED (FOR BETTER MILEAGE), I WAS GOING 60 MPH WITH THE CC SET. TRAFFIC CAME UP ON ME AND I FELT MY TRUCK WAS IN DANGER, SO I USED MY FOOT TO INCREASE TO 70 MPH. WHEN I REACHED 70 MPH, I PRESSED SET ON THE CC SWITCH FOR IT TO SET THE CRUISE AT 70 MPH. I REMOVED MY FOOT FROM THE PEDAL AND MY TRUCK SLOWED DOWN TO 60 MPH, THEN DOWN SHIFTED AND SCREAMED LIKE CRAZY UNTIL IT HAD PASSED 70 MPH, THEN SLOWED BACK DOWN TO 70 MPH. I WAS ABOUT TO REPRODUCE IT 3 MORE TIMES BEFORE GETTING OFF THE INTERSTATE. I'M SURE IT WOULD DO THE SAME AT LOWER SPEEDS, BUT DID NOT HAVE A CHANCE TO CHECK IT. *NM
NHTSA ODI #10183253
Mileage unknown · Feb 20, 2007
Vehicle Speed Control
ME AND MY FAMILY WAS OUT ON 2/13/07 AND WAS COMING UP TO A STOP LIGHT. THE GAS ON MY 2006 TOYOTA TACOMA WOULD NOT LET OFF. I APPLIED BRAKES, THIS WOULD NOT DISENGAGE THE GAS. A CAR WAS IN FRONT OF ME. I WAS ABLE TO PUT THE TRUCK IN NEUTRAL AND TURN INTO A SIDE ROAD BEFORE HITTING CAR. WHILE IN NEUTRAL RPM'S WERE HIGH CAUSING …
Read full complaint
ME AND MY FAMILY WAS OUT ON 2/13/07 AND WAS COMING UP TO A STOP LIGHT. THE GAS ON MY 2006 TOYOTA TACOMA WOULD NOT LET OFF. I APPLIED BRAKES, THIS WOULD NOT DISENGAGE THE GAS. A CAR WAS IN FRONT OF ME. I WAS ABLE TO PUT THE TRUCK IN NEUTRAL AND TURN INTO A SIDE ROAD BEFORE HITTING CAR. WHILE IN NEUTRAL RPM'S WERE HIGH CAUSING THE REV LIMITER TO KICK IN. CUT IGNITION SWITCH OFF. RESTARTED TRUCK AND WAS OKAY. TOOK THIS TRUCK TO DEALERSHIP ON 2-14-07 THEY COULD NOT MAKE IT HAPPEN AGAIN. THEY CONTACTED TOYOTA. ON 2-15-07 TOYOTA HAD NOT CONTACTED THEM BACK. I CALLED TOYOTA MYSELF AND WAS GIVEN A CASE NUMBER ON 2-15-07. THIS IS 2-20-07 AND TOYOTA HAS NOT CONTACTED ME ON THIS ISSUE. I HAVE CALLED THEM BACK AND E-MAILED WITH NO RESPONSE. THIS IS A VERY SERIOUS SITUATION AND COULD GET SOMEONE KILLED. THIS HAS HAPPENED AGAIN SINCE THEN. *NM
NHTSA ODI #10183012
Mileage unknown · Dec 12, 2006
Vehicle Speed Control
ERRATIC CRUISE CONTROL. WILL NOT SET CONSISTENTLY. SHIFTS AND ACCELERATES VIOLENTLY. *NM
NHTSA ODI #10175997
25,000 miles · Oct 28, 2006
Vehicle Speed Control
SUDDEN ACCELERATION FOR THE THIRD TIME IN THIS VEHICLE. DRIVING ON A MOUNTAINOUS ROAD ABOUT 30 MPH. TRUCK MOVED TO THE SIDE GOING UP AN INCLINE FOR MY HUSBAND TO PASS HIM. HE ACCELERATED AND THE GAS PEDAL "STUCK". APPLIED THE BRAKES WITH NO DISENGAGING OF THE GAS PEDAL. TURNED THE KEY OFF AND ON SO AS NOT TO LOSE THE POWER …
Read full complaint
SUDDEN ACCELERATION FOR THE THIRD TIME IN THIS VEHICLE. DRIVING ON A MOUNTAINOUS ROAD ABOUT 30 MPH. TRUCK MOVED TO THE SIDE GOING UP AN INCLINE FOR MY HUSBAND TO PASS HIM. HE ACCELERATED AND THE GAS PEDAL "STUCK". APPLIED THE BRAKES WITH NO DISENGAGING OF THE GAS PEDAL. TURNED THE KEY OFF AND ON SO AS NOT TO LOSE THE POWER STEERING. THIS CONTINUED FOR SEVERAL MINUTES. WHEN WE WERE ON A STRAIGHTAWAY, HE TURNED THE KEY OFF AND FINALLY THE GAS PEDAL DISENGAGED. TWO TIMES PREVIOUSLY TOYOTA HAS REPLACED THE CRUISE CONTROL. THIS IS NOT A CRUISE CONTROL ISSUE. THIS IS A GAS PEDAL ISSUE. I WAS TOLD PREVIOUSLY THE MAT WAS UNDER THE GAS PEDAL. THIS IS HARDLY THE PROBLEM. THE BRAKES WERE AGAIN RED HOT WHEN MY HUSBAND TRIED TO STOP THE TRUCK. WE WILL BE IN TOUCH WITH TOYOTA AGAIN THIS A.M. THIS VEHICLE IS A DEATH TRAP AND NEEDS TO BE PUT DOWN! *NM SEE ALSO ODI 10158925 AND 10149327 *DSY
NHTSA ODI #10172030
100 miles · Sep 11, 2006
Power TrainVehicle Speed Control
ERRATIC, SOMETIMES DANGEROUS TRANSMISSION SHIFTING WHILE USING THE CRUISE CONTROL. *NM
NHTSA ODI #10167905
Mileage unknown · Sep 11, 2006
Vehicle Speed Control
CRUISE CONTROL VERY ERRATIC, WILL ACCELERATE AND DECELERATE VIOLENTLY AT TIMES. ESPECIALLY ON UNEVEN TERRAIN. *JB
NHTSA ODI #10167860
Official recalls
11Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Sep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Aug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
Mar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Apr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
Mar 2, 2006
ON CERTAIN PICKUP TRUCKS, THE BEAD OF THE TIRE MAY BE DAMAGED DUE TO IMPROPER ASSEMBLY OF THE TIRES ONTO THE WHEELS.
Consequence & remedy
Consequence: IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT A BULGE MAY BE FORMED ON THE SIDEWALL AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE TIRES AND REPLACE IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 27, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP08001 · Sudden And Uncontrolled Acceleration
Opened Jan 31, 2008 · Closed Aug 27, 2008
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal; Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (3)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Illustration