NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
56 reportsClear category filter22,000 miles · Jan 28, 2010
Engine And Engine CoolingPower Train
2006 TOYOTA TACOMA REGULARLY SURGES FORWARD WHEN AT FULL STOP WITH BRAKES APPLIED. THIS HAPPENS UNPREDICTABLY AND WHETHER A/C IS ON OR NOT. IT IS NOT IDLE SPEED INCREASE ASSOCIATED WITH COMPRESSOR TURN ON, AND CAUSES THE VEHICLE TO MOVE FORWARD- NO OTHER VEHICLE THAT I HAVE HAD HAS DONE THIS. THIS IS VERY LIKELY A SOFTWARE IS…
Read full complaint
2006 TOYOTA TACOMA REGULARLY SURGES FORWARD WHEN AT FULL STOP WITH BRAKES APPLIED. THIS HAPPENS UNPREDICTABLY AND WHETHER A/C IS ON OR NOT. IT IS NOT IDLE SPEED INCREASE ASSOCIATED WITH COMPRESSOR TURN ON, AND CAUSES THE VEHICLE TO MOVE FORWARD- NO OTHER VEHICLE THAT I HAVE HAD HAS DONE THIS. THIS IS VERY LIKELY A SOFTWARE ISSUE WITH THE ECU AND NEEDS TO BE ADDRESSED IN THIS MANNER. YOUR PREVIOUS INVESTIGATION MAY NOT HAVE BEEN DESIGNED TO FIND A SOFTWARE DEFECT, WHICH BY NATURE, CAN BE INTERMITTENT AND DIFFICULT TO FIND. RESEARCH INTO THE CODE IS REQUIRED. (I AM AN ENGINEER INVOLVED IN AVIATION SOFTWARE- THESE ABNORMALITIES MUST BE PROPERLY RESEARCHED.) *TW
NHTSA ODI #10302906
45,000 miles · Oct 20, 2009
Power Train
REAR AXLE SEALS CONTINUE TO LEAK AFTER BEING REPAIRED BY THE DEALER TWICE. *TR
NHTSA ODI #10289122
Mileage unknown · May 27, 2009
Power Train
I HAVE A 2006 TOYOTA TACOMA X-RUNNER TRIM AND IT HAS HAD AN ISSUE WITH THE TRANSMISSION SINCE I BOUGHT IT. THE TRANSMISSION WILL NOT SHIFT FROM 1ST TO 2ND AND 2ND TO 3RD AND CAN EASILY BE REPEATED EVEN THOUGH TOYOTA TECH'S ALWAYS STATE THAT THE PROBLEM COULD NOT BE DUPLICATED EVEN THOUGH I HAVE DONE IT WITH TWO TECHS TEST RIDE…
Read full complaint
I HAVE A 2006 TOYOTA TACOMA X-RUNNER TRIM AND IT HAS HAD AN ISSUE WITH THE TRANSMISSION SINCE I BOUGHT IT. THE TRANSMISSION WILL NOT SHIFT FROM 1ST TO 2ND AND 2ND TO 3RD AND CAN EASILY BE REPEATED EVEN THOUGH TOYOTA TECH'S ALWAYS STATE THAT THE PROBLEM COULD NOT BE DUPLICATED EVEN THOUGH I HAVE DONE IT WITH TWO TECHS TEST RIDES. ALSO, IT CANNOT BE DOWNSHIFTED EASILY. IF I AM MERGING I CANNOT SHIFT INTO THE NEXT GEAR AND HAVE HAD A FEW CLOSE CALLS. ALSO, MORE RECENTLY I CANNOT SHIFT INTO REVERSE WHICH SEEMS LIKE THE SAME FORWARD SHIFTING, EXCEPT I AM NOT MOVING. I HAD RECENTLY PARKED IN A SPOT THAT HAD A SLIGHT INCLINE AND WHEN IT CAME TIME TO BACK OUT, I COULD NOT GET IT INTO GEAR AND KEPT ROLLING FORWARD MORE AND MORE EACH TIME TILL I HIT THE BUMP STOP IN THE PARKING STALL AND DAMAGED THE UNDERSIDE OF THE FRONT BUMPER AND FROM WHICH I HAD TO GET SOME HELP TO PUSH IT BACKWARDS OUT OF THE SPOT. *TR
NHTSA ODI #10270074
30,000 miles · Apr 10, 2009
Power Train
THERE WAS NO EVENTS LEADING UP, IT JUST STARTED ONE DAY. YOU PUT THE BRAKE ON AND ALL OF A SUDDEN THE TRUCK WOULD TRY TO LEAP FORWARD WITH A LOUD THUNK. THE LONGER YOU HOLD THE BRAKE THE LOUDER THE SOUND WOULD BE. NOW WHEN YOU LET UP ON THE BRAKE, IT DOES IT. NOT WHEN HOLDING THE BRAKE DOWN. WHEN YOU LET UP ON THE BRAKE, IT THUN…
Read full complaint
THERE WAS NO EVENTS LEADING UP, IT JUST STARTED ONE DAY. YOU PUT THE BRAKE ON AND ALL OF A SUDDEN THE TRUCK WOULD TRY TO LEAP FORWARD WITH A LOUD THUNK. THE LONGER YOU HOLD THE BRAKE THE LOUDER THE SOUND WOULD BE. NOW WHEN YOU LET UP ON THE BRAKE, IT DOES IT. NOT WHEN HOLDING THE BRAKE DOWN. WHEN YOU LET UP ON THE BRAKE, IT THUNKS HARD AND LOUD FORWARD. *TR
NHTSA ODI #10264950
Mileage unknown · Oct 21, 2008
Power Train
MY 2006 DOUBLE CAB TACOMA TRD OFF ROAD TENDS TO LUNGE FORWARD AS I AM COMING TO A STOP. IT HAS NEVER CAUSED ME TO WRECK BUT IT COULD SOME DAY. IT SEEMS TO BE A TRANSMISSION ISSUE WITH THE DECELERATION OR SOMETHING. *TR
NHTSA ODI #10246210
Mileage unknown · Oct 14, 2008
Engine And Engine CoolingPower Train
I PURCHASED A TOYOTA TACOMA 2006 NEW AND FROM DAY ONE HAD PROBLEMS WITH THE VEHICLE OVER REVVING ON START UP, WHICH IS VERY DAMAGING TO AN ENGINE IN COLD CLIMATES. IT ALSO BETWEEN SHIFTING FROM 3RD TO 4TH, AND 4TH TO 5TH GEARS THE RPM'S WILL NOT COME DOWN TO ENABLE ONE TO SHIFT PROPERLY AND NOT ONLY MAKES FOR A ROAD DANGEROUS CO…
Read full complaint
I PURCHASED A TOYOTA TACOMA 2006 NEW AND FROM DAY ONE HAD PROBLEMS WITH THE VEHICLE OVER REVVING ON START UP, WHICH IS VERY DAMAGING TO AN ENGINE IN COLD CLIMATES. IT ALSO BETWEEN SHIFTING FROM 3RD TO 4TH, AND 4TH TO 5TH GEARS THE RPM'S WILL NOT COME DOWN TO ENABLE ONE TO SHIFT PROPERLY AND NOT ONLY MAKES FOR A ROAD DANGEROUS CONDITION BUT IT ALSO CAUSES DAMAGE TO THE ENTIRE DRIVE TRAIN. I'VE BEEN UNSUCCESSFUL AT TRYING TO TAKE CARE OF THIS PROBLEM WITH TOYOTA, QUITE FRANKLY THEY HAVE A VERY BAD ATTITUDE WITH THIS WHOLE MATTER AND TO GIVE YOU AN EXAMPLE, I WAS TOLD BY ONE DEALERSHIP THAT MAYBE I SHOULD LEARN HOW TO SHIFT FASTER. PLEASE ASSIST ME . *TR
NHTSA ODI #10245349
11,000 miles · Aug 15, 2008
Power TrainCrash
MY 2006 4 DOOR 4X4 TOYOTA TACOMA HAS AN UNINTENDED ACCELERATION PROBLEM. THE FIRST INCIDENT: I WAS DRIVING DOWN THE RAMP OF A PARKING GARAGE WHEN THE TACOMA SUDDENLY STARTED ACCELERATING OUT OF CONTROL. MY FOOT WAS COVERING THE BRAKE WHEN THE ACCELERATION BEGAN AND WHEN I PUT HARD PRESSURE ON THE BRAKES THE TRUCK WAS STILL ACCEL…
Read full complaint
MY 2006 4 DOOR 4X4 TOYOTA TACOMA HAS AN UNINTENDED ACCELERATION PROBLEM. THE FIRST INCIDENT: I WAS DRIVING DOWN THE RAMP OF A PARKING GARAGE WHEN THE TACOMA SUDDENLY STARTED ACCELERATING OUT OF CONTROL. MY FOOT WAS COVERING THE BRAKE WHEN THE ACCELERATION BEGAN AND WHEN I PUT HARD PRESSURE ON THE BRAKES THE TRUCK WAS STILL ACCELERATING. NOTHING SLOWED IT DOWN, I WAS SLAMMING THROUGH THE (AUTOMATIC) GEARS DESPERATELY TRYING TO STOP THE TRUCK. I HAD TO GO OVER WALK WAYS AND CURBS TO AVOID PEDESTRIANS AND CEMENT BARRIERS. I FINALLY CAME TO A STOP AGAINST A LINCOLN TOWN CAR. THE SECOND INCIDENT (YESTERDAY) I WAS DRIVING THROUGH AN INTERSECTION WHEN THE TRUCK SUDDENLY FELT LIKE IT WAS FLOORED AND TOOK OFF. I WAS SLAMMING THE BRAKES AND GOING THROUGH THE AUTO GEARS AND IT CONTINUED FOR ABOUT 30 SECONDS UNTIL IT CAME TO A STOP. I AM VERY DISAPPOINTED TO READ THAT TOYOTA IS DENYING THIS ISSUE. PEOPLES LIVES ARE AT STAKE AND THE PROBLEM REALLY DOES EXIST ACCORDING TO THE 423 COMPLAINTS. I HAVE ALWAYS LOVED TOYOTA TRUCKS BUT I AM SAD TO SAY THIS ONE IS GOING TO HAVE TO GO. WHAT IF THE TOYOTA TACOMA KILLS SOMEONE NEXT TIME THIS HAPPENS? I WISH SOMEONE COULD DO SOMETHING ABOUT THIS...HOW MANY ACCIDENTS WILL IT TAKE? *TR
NHTSA ODI #10238349
Mileage unknown · Mar 6, 2008
Power Train
I WANT TO EXPRESS MY CONCERNS WITH MY 2006 TOYOTA TACOMA. I ALSO HAVE A LURCHING PROBLEM ONCE AT A COMPLETE STOP WITH MY FOOT ON THE BRAKE. I HAVE NEVER HIT ANYTHING, BUT THERE TIMES WHEN IT FEELS LIKE SOMEONE HAS TAPPED MY REAR BUMPER. I DON'T KNOW THAT THIS IS A MAJOR PROBLEM FOR ME, BUT I'VE READ THAT OTHERS HAVE ACTUALLY…
Read full complaint
I WANT TO EXPRESS MY CONCERNS WITH MY 2006 TOYOTA TACOMA. I ALSO HAVE A LURCHING PROBLEM ONCE AT A COMPLETE STOP WITH MY FOOT ON THE BRAKE. I HAVE NEVER HIT ANYTHING, BUT THERE TIMES WHEN IT FEELS LIKE SOMEONE HAS TAPPED MY REAR BUMPER. I DON'T KNOW THAT THIS IS A MAJOR PROBLEM FOR ME, BUT I'VE READ THAT OTHERS HAVE ACTUALLY HIT OTHER CARS DUE TO THIS PROBLEM. THIS IS NOT NORMAL, IN MY OPINION. AND TOYOTA NEEDS TO ADDRESS THIS PROBLEM BEFORE MORE PEOPLE GET HURT. I PURCHASED THIS TRUCK BECAUSE OF TOYOTAS REPUTATION FOR QUALITY AND DEPENDABILITY. THIS LURCHING OCCURS ALMOST EVERY DAY, SO THE INCIDENT DATE IS THE LAST DAY THAT THIS HAPPENED. *TR
NHTSA ODI #10220212
25,445 miles · Dec 7, 2007
Power Train
WHEN STOPPING THE VEHICLE SOMETIMES ONCE STOPPED THE TRUCK WILL LURCH FORWARD FOR NO REASON. THE TRUCK FEELS AS THOUGH IT IS GOING TO GET AWAY FROM ME. THIS HAS HAPPENED SEVERAL TIMES AND NO ONE SEEMS TO BE ABLE TO HELP. *TR
NHTSA ODI #10211187
42,000 miles · Sep 1, 2007
Power Train
ON JULY 27TH OF THIS YEAR MY 2006 TOYOTA TACOMA HAD A PRESSURE PLATE FAILURE THAT CAUSED MY TRUCK TO HAVE TO BE TOWED. MY TRUCK WAS TOWED TO A LOCAL DEALERSHIP WHO TOLD ME MY CLUTCH WAS BURNED UP AND WOULD COST $1450 TO BE FIXED AND WOULD NOT BE COVERED BY WARRANTY. I KNEW THIS WAS NOT TRUE AND HAD MY TRUCK TOWED TO A TRANSMISSI…
Read full complaint
ON JULY 27TH OF THIS YEAR MY 2006 TOYOTA TACOMA HAD A PRESSURE PLATE FAILURE THAT CAUSED MY TRUCK TO HAVE TO BE TOWED. MY TRUCK WAS TOWED TO A LOCAL DEALERSHIP WHO TOLD ME MY CLUTCH WAS BURNED UP AND WOULD COST $1450 TO BE FIXED AND WOULD NOT BE COVERED BY WARRANTY. I KNEW THIS WAS NOT TRUE AND HAD MY TRUCK TOWED TO A TRANSMISSION SHOP WHO FOUND MY PRESSURE PLATE HAD FAILED WITH NO SIGN OF ABUSE. I HAD THE PARTS REPLACED WITH TOYOTA FACTORY REPLACEMENT PARTS. WHEN THE SHOP RECEIVED THESE PARTS THEY CALLED ME TO TELL ME THESE PARTS WERE A DIFFERENT DESIGN THEN THE PARTS THAT FAILED IN MY TRUCK. AFTER SOME RESEARCH I FOUND OUT TOYOTA CHANGED THESE PARTS AND PART #S IN 2006 AFTER I BOUGHT MY TRUCK. I FOUND SEVERAL OTHER COMPLAINTS OF CLUTCH FAILURE ON THE DESIGN IN MY TRUCK. EVEN THOUGH I HAVE PROOF OF THIS TOYOTA DENIES THAT THERE WAS A PART CHANGE OR PROBLEM WITH MY TRUCK AND HAS NOT OFFERED ME ANY ASSISTANCE WITH THE $1300 IN BILLS I HAVE IN INCURRED WITH HAVING TO CHANGE THIS PART. *TR
NHTSA ODI #10201661
Official recalls
11Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Sep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Aug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
Mar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Apr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
Mar 2, 2006
ON CERTAIN PICKUP TRUCKS, THE BEAD OF THE TIRE MAY BE DAMAGED DUE TO IMPROPER ASSEMBLY OF THE TIRES ONTO THE WHEELS.
Consequence & remedy
Consequence: IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT A BULGE MAY BE FORMED ON THE SIDEWALL AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE TIRES AND REPLACE IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 27, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP08001 · Sudden And Uncontrolled Acceleration
Opened Jan 31, 2008 · Closed Aug 27, 2008
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal; Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (3)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Illustration