NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
56 reportsClear category filter47,380 miles · Jul 7, 2014
Power TrainStructure
DUE TO THE RUSTED FRAME ISSUES THAT I REPORTED TO TOYOTA ON 04/16/2014 (MULLER TOYOTA AND TOYOTA CORPORATE) MY CLUTCH PEDAL STUCK TO THE FLOOR WHEN CROSSING AN INTERSECTION ALMOST CAUSING A CRASH WHEN THE RUSTED CLUTCH SLAVE CYLINDER STUCK . THERE ARE BIG RUST HOLES IN THE FRAME AND TOYOTA FREELY ADMITS THAT THEY ARE DEFECTIVE…
Read full complaint
DUE TO THE RUSTED FRAME ISSUES THAT I REPORTED TO TOYOTA ON 04/16/2014 (MULLER TOYOTA AND TOYOTA CORPORATE) MY CLUTCH PEDAL STUCK TO THE FLOOR WHEN CROSSING AN INTERSECTION ALMOST CAUSING A CRASH WHEN THE RUSTED CLUTCH SLAVE CYLINDER STUCK . THERE ARE BIG RUST HOLES IN THE FRAME AND TOYOTA FREELY ADMITS THAT THEY ARE DEFECTIVE FRAMES , BUT WON'T HAVE A RECALL ON THOSE MODEL TACOMAS UNTIL ENOUGH PEOPLE COMPLAIN OR GET INJURED OR KILLED ! SOMETHING SHOULD BE DONE ABOUT THESE DEFECTIVE FRAMES THAT RUST FROM THE INSIDE OUT. *JS
NHTSA ODI #10608585
75,000 miles · Jun 5, 2014
Power Train
6 SPEED TRANSMISSION LOCKED IN GEAR WHEN ATTEMPTING TO SHIFT INTO FIRST GEAR. APPEARS TO BE STUCK IN 4 TH GEAR ? WAS ABLE TO GET IN DRIVEWAY. *TR
NHTSA ODI #10596508
56,954 miles · Feb 6, 2014
EnginePower Train
I WAS SLOWLY ENTERING A PARKING SPACE. I PRESSED THE BRAKE PEDAL AND THE ENGINE SPEED INCREASED TO MAXIMUM RPM. I JAMMED THE EMERGENCY BRAKE AND THREW THE TRANSMISSION INTO "PARK." A GREAT CLOUD OF BLUE SMOKE ISSUED FORTH FROM THE SPINNING TIRES. THIS NEVER HAPPENED BEFORE AND IT'S DEFINITELY A PROBLEM WITH THE TRUCK AND NOT MY …
Read full complaint
I WAS SLOWLY ENTERING A PARKING SPACE. I PRESSED THE BRAKE PEDAL AND THE ENGINE SPEED INCREASED TO MAXIMUM RPM. I JAMMED THE EMERGENCY BRAKE AND THREW THE TRANSMISSION INTO "PARK." A GREAT CLOUD OF BLUE SMOKE ISSUED FORTH FROM THE SPINNING TIRES. THIS NEVER HAPPENED BEFORE AND IT'S DEFINITELY A PROBLEM WITH THE TRUCK AND NOT MY FOOT! SEVERAL YEARS AGO, AS A PEDESTRIAN, I SAW THE EXACT SAME THING HAPPEN TO A JEEP CHEROKEE AT A STOP SIGN. *TR
NHTSA ODI #10563264
102,000 miles · Jan 29, 2013
Power TrainVehicle Speed Control
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS COMING TO A STOP, AN ODD NOISE WAS HEARD COMING FROM THE DRIVESHAFT. THE CONTACT ALSO STATED THAT ACCELERATION SUDDENLY INCREASED UP TO 7 MPH HIGHER THAN WHAT THE SPEED CONTROL WAS SET TO. IN ADDITION, WHEN THE WIND SHIFTED THE VEHICLE, THE…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS COMING TO A STOP, AN ODD NOISE WAS HEARD COMING FROM THE DRIVESHAFT. THE CONTACT ALSO STATED THAT ACCELERATION SUDDENLY INCREASED UP TO 7 MPH HIGHER THAN WHAT THE SPEED CONTROL WAS SET TO. IN ADDITION, WHEN THE WIND SHIFTED THE VEHICLE, THE FRONT STABILIZER BAR RUBBED AGAINST THE TIRES AND CAUSED A LOUD NOISE. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THERE WAS NO FAILURE WITH THE VEHICLE. THE DEALER GAVE HIM ANOTHER VEHICLE TO TEST DRIVE AND STATED IF THAT VEHICLE HAS THE SAME ISSUE THEN THAT WAS THE DESIGN OF ALL OF THE VEHICLES. THE CONTACT TEST DROVE THE VEHICLE AND EXPERIENCED THE SAME FAILURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 102,000. UPDATED 03/07/13*LJ THE CONSUMER THE DRIVESHAFT WAS REPLACED.. THE FAILURE FELT LIKE THE VEHICLE WAS REAR-ENDED BY ANOTHER VEHICLE. *JS
NHTSA ODI #10495044
20,000 miles · Dec 11, 2012
Power TrainService BrakesWheels
DECEMBER 2006 TRUCK PARKED WITH EMERGENCY BRAKE OFF AND WOULD NOT MOVE BELOW FREEZING TEMPERATURE. ALL FOUR WHEELS LOCKED UP. TOWED TO DEALER, AFTER NUMEROUS ATTEMPTS TO FIX HE STATED THE WHEEL BEARING WERE LEAKING GREASE AND FREEZING UP SO TRUCK WOULD NOT MOVE. TRUCK OPERATES GOOD ALL YEAR TILL IT GETS BELOW FREEZING AND WHEE…
Read full complaint
DECEMBER 2006 TRUCK PARKED WITH EMERGENCY BRAKE OFF AND WOULD NOT MOVE BELOW FREEZING TEMPERATURE. ALL FOUR WHEELS LOCKED UP. TOWED TO DEALER, AFTER NUMEROUS ATTEMPTS TO FIX HE STATED THE WHEEL BEARING WERE LEAKING GREASE AND FREEZING UP SO TRUCK WOULD NOT MOVE. TRUCK OPERATES GOOD ALL YEAR TILL IT GETS BELOW FREEZING AND WHEELS LOCK UP. DEALER DOES NOT KNOW THE PROBLEM, BUT ONLY HAPPENS WHEN PARKED AND BELOW FREEZING. DECEMBER 10 2012 REAR WHEELS LOCK UP WHILE DRIVING IN BELOW FREEZING CAUSING TRUCK TO SLIDE AND MISS TWO ON COMING CARS, TRUCK ENDS UP IN DITCH. WOULD SELL VEHICLE BUT AFRAID ANYONE DRIVING IT IN COLD WEATHER WOULD BE STRANDED OR IN A FATAL WRECK. ARE OTHER TRUCKS HAVING SAME ISSUE AS I HUNT AND GO BACK 30 MILES INTO THE WOODS AND IF FREEZES I WOULD BE STRANDED. *TR
NHTSA ODI #10488035
37,400 miles · Oct 14, 2012
EnginePower Train
FOR AT LEAST 2 MOS PREVIOUS I WOULD HEAR A CHIRPING NOISE FROM THE ENGINE COMPARTMENT. IT WOULD GET LOUDER AS YOU ACCELERATED & SEAMED MORE NOTICEABLE IN WARMER WEATHER. TOOK VEHICLE IN TO DHC TORRANCE TOYOTA & SAID IT WAS MY IDLER BEARINGS. I THOUGHT THAT WAS ODD SINCE THE TRUCK ONLY HAS 37400 MILES. IT COST ME OVER $800.0…
Read full complaint
FOR AT LEAST 2 MOS PREVIOUS I WOULD HEAR A CHIRPING NOISE FROM THE ENGINE COMPARTMENT. IT WOULD GET LOUDER AS YOU ACCELERATED & SEAMED MORE NOTICEABLE IN WARMER WEATHER. TOOK VEHICLE IN TO DHC TORRANCE TOYOTA & SAID IT WAS MY IDLER BEARINGS. I THOUGHT THAT WAS ODD SINCE THE TRUCK ONLY HAS 37400 MILES. IT COST ME OVER $800.00. *TR
NHTSA ODI #10480075
86,000 miles · Nov 4, 2011
Power TrainSteeringSuspension
NOTICED RUST ON THE FRAME OF THE VEHICLE WITH HEAVIER AMOUNTS NEAR/ON WELD POINTS, & BOLT POINTS. RUST IS ACCUMULATING ON THE STEERING TIE RODS. HEAVY RUST ON REAR DIFFERENTIAL AND VARIOUS STEERING COMPONENT PARTS. I CONSIDER THE AMOUNT OF RUST ON THE FRAME AND THE ABOVE MENTIONED COMPONENTS A MANUFACTURER'S DEFECT. IF A…
Read full complaint
NOTICED RUST ON THE FRAME OF THE VEHICLE WITH HEAVIER AMOUNTS NEAR/ON WELD POINTS, & BOLT POINTS. RUST IS ACCUMULATING ON THE STEERING TIE RODS. HEAVY RUST ON REAR DIFFERENTIAL AND VARIOUS STEERING COMPONENT PARTS. I CONSIDER THE AMOUNT OF RUST ON THE FRAME AND THE ABOVE MENTIONED COMPONENTS A MANUFACTURER'S DEFECT. IF ANY OF THE COMPONENTS FAIL WHILE I AM DRIVING I COULD CRASH AND INJURE, OR KILL ANOTHER MOTORIST/MYSELF. I SPOKE WITH TOYOTA OF SD SERVICE REP WHO TOLD ME I SHOULD CONTACT TOYOTA. I HAVE A 100,000/10YR EXTENDED SERVICE PLAN AND WANT THIS RESOLVED PRIOR TO THE TIME FRAME RUNNING OUT. *TR
NHTSA ODI #10434279
85,118 miles · Dec 22, 2010
Power Train
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THE VEHICLE HAS HAD PROBLEMS WITH THE CRUISE CONTROL. THE FAILURE BEGAN AFTER THE CONTACT HAD THE TRANSMISSION SERVICED AND THE TRANSMISSION WAS NOT REFILLED PROPERLY. AFTER THE SERVICE, THE CONTACT STATED THAT THE CRUISE CONTROL STARTED TO ACCELERATE PASS THE SPEED T…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THE VEHICLE HAS HAD PROBLEMS WITH THE CRUISE CONTROL. THE FAILURE BEGAN AFTER THE CONTACT HAD THE TRANSMISSION SERVICED AND THE TRANSMISSION WAS NOT REFILLED PROPERLY. AFTER THE SERVICE, THE CONTACT STATED THAT THE CRUISE CONTROL STARTED TO ACCELERATE PASS THE SPEED THAT IT WAS SET WITH BEING RESET BY THE DRIVER. THE VEHICLE WAS TAKEN TO THE DEALER AGAIN AND REPAIRS WERE MADE TO THE ELECTRONIC CONTROL UNIT, WHICH HAS CAUSED THE RPMS TO IDLE EITHER EXCESSIVELY LOW OR EXCESSIVELY HIGH. THE CONTACT STATED THE VEHICLE WILL ALSO DOWNSHIFT FROM FIFTH GEAR TO SECOND GEAR WHEN DRIVING WITH THE CRUISE CONTROL SET TO 55 MPH AND ABOVE. THE FAILURE MILEAGE WAS 85,118 AND THE CURRENT MILEAGE WAS 85,557.
NHTSA ODI #10372082
57,859 miles · Dec 6, 2010
Power Train
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED WHILE DRIVING 30 MPH, HE NOTICED AN ABNORMAL CLAPPING SOUND COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN STATED THAT THE DIFFERENTIAL UNIT WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED WHILE DRIVING 30 MPH, HE NOTICED AN ABNORMAL CLAPPING SOUND COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN STATED THAT THE DIFFERENTIAL UNIT WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 57,859.
NHTSA ODI #10369310
Mileage unknown · Jun 12, 2010
Power Train
2006 TOYOTA TACOMA WITH AUTOMATIC TRANSMISSION. SAME COMPLAINT AS OTHERS. LOW END RUMBLING SOUND AND VIBRATION IN FRONT END BETWEEN 55 AND 65 MPH. FRONT DIFFERENTIAL BEARINGS, WHERE FRONT AXLES ENTER THE DIFFERENTIAL CASE, HAVE EXCESSIVE PLAY (SLOP) IN THE BEARINGS. DEALER REFUSES TO REPAIR THE BEARINGS EVEN THOUGH IT IS STILL…
Read full complaint
2006 TOYOTA TACOMA WITH AUTOMATIC TRANSMISSION. SAME COMPLAINT AS OTHERS. LOW END RUMBLING SOUND AND VIBRATION IN FRONT END BETWEEN 55 AND 65 MPH. FRONT DIFFERENTIAL BEARINGS, WHERE FRONT AXLES ENTER THE DIFFERENTIAL CASE, HAVE EXCESSIVE PLAY (SLOP) IN THE BEARINGS. DEALER REFUSES TO REPAIR THE BEARINGS EVEN THOUGH IT IS STILL UNDER WARRANTY. I HAVE VIDEO TAPED THE CONDITION AS WELL AS THE MILEAGE AND WILL KEEP RECORDS OF MY MULTIPLE VISITS TO THE DEALER. I HAVE ALSO FOUND OTHER USED TACOMA TRUCKS ON DEALER LOTS WITH AS LITTLE AS 20,000 MILES THAT HAVE THIS SAME PROBLEM. I BELIEVE TOYOTA ENGINEERED THESE DIFFERENTIALS TO LAST ONLY 60,000 MI AND MOST OWNERS MAY NOT NOTICE THE PROBLEM UNTIL WARRANTY IS OVER. MY 1992 TOYOTA PICKUP 4X4 WITH 238,000 MILES HAS LESS BEARING SLOP IN IT THAN THE '06. *TR
NHTSA ODI #10335906
Official recalls
11Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Sep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Aug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
Mar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Apr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
Mar 2, 2006
ON CERTAIN PICKUP TRUCKS, THE BEAD OF THE TIRE MAY BE DAMAGED DUE TO IMPROPER ASSEMBLY OF THE TIRES ONTO THE WHEELS.
Consequence & remedy
Consequence: IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT A BULGE MAY BE FORMED ON THE SIDEWALL AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE TIRES AND REPLACE IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 27, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP08001 · Sudden And Uncontrolled Acceleration
Opened Jan 31, 2008 · Closed Aug 27, 2008
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal; Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (3)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Illustration