IllustrationTL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR AN UNRELATED REPAIR. THE TECHNICIAN STATED THAT THE SUBFRAME OF THE VEHICLE WAS CORRODED AND RUSTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 81,000.
2005 Toyota Tacoma
Owner reports · Recalls · Investigations
More warning signs than most Tacoma years
Owner complaints for the 2005 Toyota Tacoma are substantially higher than the model-year median of 228.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tacoma years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1040–25K
6325–50K
7250–75K
7875–100K
112100–150K
106150K+
535 reports with mileage · 172 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 260 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 137 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 93 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
47 crash reports4 fire reports14 injury reports
What owners actually said
707 reportsI RECENTLY PURCHASED A 2005 TOYOTA TACOMA TRD SPORT DOUBLE CAB AND DISCOVERED IT HAD SEVERE AND DANGEROUS FRAME RUST. IT HAS A HOLE RUSTED THROUGH THE FRAME IN THE FRONT AND LARGE RUST FLAKES ARE FALLING OFF IN OTHER VARIOUS PLACES. UPON DOING RESEARCH, I FOUND OUT ABOUT THE MASSIVE RECALLS REGARDING FRAME RUST ON TOYOTA TRUCK…
Read full complaint
I RECENTLY PURCHASED A 2005 TOYOTA TACOMA TRD SPORT DOUBLE CAB AND DISCOVERED IT HAD SEVERE AND DANGEROUS FRAME RUST. IT HAS A HOLE RUSTED THROUGH THE FRAME IN THE FRONT AND LARGE RUST FLAKES ARE FALLING OFF IN OTHER VARIOUS PLACES. UPON DOING RESEARCH, I FOUND OUT ABOUT THE MASSIVE RECALLS REGARDING FRAME RUST ON TOYOTA TRUCKS. I SPOKE WITH TOYOTA AND THEY SAID THE FRAME WOULD BE REPLACED IF IT WERE CURRENTLY REGISTERED IN A COLD CLIMATE STATE. I AM TRYING TO GET THEM TO EMAIL ME THAT STATEMENT SO I CAN HAVE IT FOR MY RECORDS. THE TRUCK CAME FROM A COLD CLIMATE STATE. IT IS CURRENTLY REGISTERED IN NORTH CAROLINA. THEY SAID THEY WON'T HELP ME ONLY BECAUSE IT IS IN NC, NO MATTER HOW DANGEROUS THE RUST. IS THAT LEGAL FOR THEM EXCLUDE ME FOR THAT REASON? I HAVE PICTURES TO PROVE THAT MY FRAME IS JUST AS BAD AS THE TRUCKS BEING REPAIRED. IT IS DEFINITELY A SAFETY CONCERN BECAUSE IT IS NOT A MATTER OF IF, BUT WHEN THE FRAME BREAKS. THANKS FOR YOUR HELP. *TR
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE FRAME WAS PERFORATED DUE TO RUST. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS CONFIRMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE AND CURRENT MILEAGE WAS 1…
Read full complaint
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE FRAME WAS PERFORATED DUE TO RUST. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS CONFIRMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE AND CURRENT MILEAGE WAS 189,000.
I HAVE A 2005 TOYOTA TACOMA. THIS IS MY SECOND TOYOTA TRUCK AND I DO REALLY LOVE MY TRUCK. MY LAST PICKUP WAS A 1999 EXT PICKUP WITH A LOT OF RUST ON IT WHEN I QUALIFIED FOR A BUYBACK DEAL. LAST WEEK I BROUGHT MY 2005 INTO THE KENNY ROSS TOYOTA DEALER IN CORAOPLIS, PA TO HAVE THEM INSPECT MY VEHICLE. THE INSPECTION REVEALED A…
Read full complaint
I HAVE A 2005 TOYOTA TACOMA. THIS IS MY SECOND TOYOTA TRUCK AND I DO REALLY LOVE MY TRUCK. MY LAST PICKUP WAS A 1999 EXT PICKUP WITH A LOT OF RUST ON IT WHEN I QUALIFIED FOR A BUYBACK DEAL. LAST WEEK I BROUGHT MY 2005 INTO THE KENNY ROSS TOYOTA DEALER IN CORAOPLIS, PA TO HAVE THEM INSPECT MY VEHICLE. THE INSPECTION REVEALED A LARGE STRUCTURAL HOLE IN THE FRAME OF THE VEHICLE. IT IS ON THE DRIVER'S SIDE WHERE THE FRAME RAIL CURVES DOWN. THIS IS ONE THING THAT IS KEEPING IT FROM GETTING A INSPECTION STICKER. THIS IS A MAJOR SAFETY ISSUE AND I WOULD NOT RECOMMEND DRIVING THE VEHICLE IN ITS CURRENT CONDITION DUE TO THE STRUCTURE OF THE FRAME. THIS IS A SERIOUS SAFETY ISSUE. IF THIS SECTION OF MY FRAME WAS TO FAIL, WHICH I BELIEVE IS COMPLETELY POSSIBLE; IT WILL RESULT IN A MAJOR ACCIDENT. I WOULD LIKE TO BELIEVE THAT I CAN TRUST TOYOTA USA TO TAKE CARE OF THIS ISSUE. I AM AT THIS POINT BASICALLY LEFT WITH A BEAUTIFUL, GREAT RUNNING AND COMPLETELY UNSAFE TOYOTA TACOMA. I FEEL STRANGLED, VIOLATED, AND TAKEN ADVANTAGE OF. $25,000 PLUS INVESTMENT ON A TRUCK THAT IS A POSSIBLE SCRAP HEAP AT 9 YEARS AND 167K MILES. I CAN'T SELL IT AND GET A FAIR VALUE KNOWING THE FRAME IS ROTTEN. THE DEALER WON'T TAKE IT BACK ON A TRADE IN EITHER. I PUT IN A CLAIM THAT TOYOTA BEARS NO RESPONSIBILITY FOR THE FRAME SINCE IT IS OUT OF WARRANTY. ALL THEY IS OFFERED ME $1500 TOWARD A NEW TOYOTA VEHICLE WHICH DOESN'T HELP MY CURRENT PROBLEM. THE DEALERSHIP SEEN POTENTIAL FRAME ISSUE AND DIDN'T EVEN TAKE ANY PHOTOS OF IT AND/OR THEN PASS THEM ONTO A FIELD REP. AS I UNDERSTAND, IF THE FIELD REP DEEMS THE PHOTOS OF INTEREST, AN APPOINTMENT WILL BE SCHEDULED FOR WHEN S/HE IS NEXT AT THE DEALERSHIP. THE FIELD REP CAN EITHER THEN REJECT OR ESCALATE IT. *TR
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT AFTER REFUELING, ONE OF THE FUEL TANK STRAPS FRACTURED AS A RESULT OF CORROSION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MIL…
Read full complaint
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT AFTER REFUELING, ONE OF THE FUEL TANK STRAPS FRACTURED AS A RESULT OF CORROSION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 85,000. UPDATED 06/17/14*LJ THE CONSUMER STATED ONE OF THE TWO STRAPS THAT SECURED THE GAS TANK FAILED UNDER THE WEIGHT OF THE TANK. THE TANK WAS TILTED AS A RESULT. THE STRAP FAILED AS A RESULT OF CORROSION. UPDATED 06/24/14
WHILE TURNING INTO A MILD CORNER,STEERING STARTED BINDING UP,HAD TO REALLY PULL ON THE WHEEL, AS IF POWER STEERING WENT AWAY. STEERING WHEEL WOULD NOT RETURN,HAD TO PULL IT BACK TO STRAIGHTEN OUT. I KNOW MY WIFE WOULD NOT HAVE BEEN ABLE TO PULL IT TO GET THROUGH CORNER. *JS
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE ENGINE RPMS INCREASED ABNORMALLY AS THE VEHICLE LUNGED FORWARD, CAUSING THE CONTACT TO CRASH INTO ANOTHER VEHICLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED, BUT HE WAS ON SITE. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOS…
Read full complaint
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE ENGINE RPMS INCREASED ABNORMALLY AS THE VEHICLE LUNGED FORWARD, CAUSING THE CONTACT TO CRASH INTO ANOTHER VEHICLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED, BUT HE WAS ON SITE. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 130,000.
NORMAL DRIVING ON THE STREET I NOTICED A NOISE ON THE REAR RIGHT SIDE OF MY VEHICLE AND I STOPPED TO VERIFY WHAT HAPPEN WHEN AND I REALIZE THAT THE REAR RIGHT SPRING ASSEMBLY WAS BROKEN ( SPLIT APART IN TWO SECTIONS). *TR
THE AIRBAG WARNING LIGHT CAME ON AND HAS MOSTLY STAYED ON FOR QUITE A WHILE. TOYOTA ISSUED A RECALL FOR THE SPIRAL/CLOCKSPRING CABLE ON MY VEHICLE IN MARCH 2012, WHICH ADDRESSED THIS PROBLEM. HOWEVER, MY VIN WAS NOT INCLUDED IN THE RECALL. THE PROBLEM ON MY VEHICLE HAS GOTTEN WORSE. I TOOK IT TO A TOYOTA DEALER SHOP AND THEY …
Read full complaint
THE AIRBAG WARNING LIGHT CAME ON AND HAS MOSTLY STAYED ON FOR QUITE A WHILE. TOYOTA ISSUED A RECALL FOR THE SPIRAL/CLOCKSPRING CABLE ON MY VEHICLE IN MARCH 2012, WHICH ADDRESSED THIS PROBLEM. HOWEVER, MY VIN WAS NOT INCLUDED IN THE RECALL. THE PROBLEM ON MY VEHICLE HAS GOTTEN WORSE. I TOOK IT TO A TOYOTA DEALER SHOP AND THEY INDICATED THAT IT WAS PROBABLY THE SPIRAL CABLE, AS WELL. SINCE THAT TIME, TOYOTA JUST ISSUED ANOTHER RECALL (APRIL 2014), AGAIN FOR THE SAME PROBLEM ON THE TACOMA AND OTHER VEHICLES. AGAIN, MY VIN WAS NOT INCLUDED IN THE SECOND RECALL. I CONTACTED TOYOTA HQ TO ADDRESS THE PROBLEM. THEY NOTED IT, BUT HAVE TAKEN NO ACTION. MY VEHICLE HAS THE PROBLEM IDENTIFIED IN BOTH RECALLS FOR THE SAME VEHICLE, YET MY VIN IS NOT INCLUDED. I'M CONCERNED ABOUT MY SAFETY AND OTHERS SINCE THIS PROBLEM CAN PREVENT THE AIRBAG FROM DEPLOYING IN AN ACCIDENT. I BELIEVE THERE COULD BE A GAP IN THE SCOPE OF TOYOTA'S RECALL FOR THIS PROBLEM. PLEASE HELP. *TR
FRAME RUST NOTICED WHILE CONDUCTING ROUTINE MAINTENANCE ON TRUCK. THE WHOLE FRAME IS NOT RUSTED BUT THERE IS A LARGE WHOLE JUST BEHIND THE DRIVERS SIDE TIRE NEAR THE CATALYTIC CONVERTER. *TT
Official recalls
1014V604000 · Suspension:rear:springs:leaf Spring Assembly:leaf
Sep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
13V337000 · Seat Belts
Aug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
12V092000 · Air Bags:frontal
Mar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
09V223000 · Equipment:other:labels
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
06V096000 · Air Bags
Apr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
05V302000 · Air Bags
Jun 28, 2005
ON CERTAIN REGULAR CAB PICKUP TRUCKS EQUIPPED WITH A BENCH SEAT, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR CONNECTOR PINS ARE INCORRECTLY POSITIONED DUE TO A WIRE HARNESS MANUFACTURING PROCESS ERROR.
Consequence & remedy
Consequence: IN THIS CONDITION, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR MAY NOT FUNCTION AS DESIGNED, AFFECTING THE ADAPTIVE AIR BAG DEPLOYMENT, WHICH IF THE VEHICLE IS INVOLVED IN A CRASH, COULD RESULT IN IMPROPER OCCUPANT RESTRAINT.
Remedy: DEALERS WILL INSPECT THE SEAT POSITION AND SEAT BELT FASTENING CONDITION SENSOR CONNECTOR. AN ADDITIONAL SUB-WIRE HARNESS WILL BE INSTALLED TO CORRECT THE CONNECTOR PIN MANUFACTURING ERROR, IF NECESSARY. THE RECALL BEGAN ON JULY 25, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-431-4331.
05V050000 · Parking Brake
Feb 11, 2005
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THERE IS A POSSIBILITY THAT THE PARKING BRAKE PEDAL CABLE LOCK NUT MAY NOT HAVE BEEN TIGHTENED TO THE PROPER TORQUE SPECIFICATION. IN THIS CONDITION, THE LOCK NUT MAY LOOSEN AND COME OFF, WHICH WILL REDUCE THE EFFECTIVENESS OF THE PARKING BRAKE.
Consequence & remedy
Consequence: THIS CONDITION COULD ALLOW THE VEHICLE TO ROLL IF THE TRANSMISSION IS NOT PLACED INTO THE "PARK" POSITION AND THE VEHICLE IS PARKED ON A SLOPE, THUS RAISING THE POSSIBILITY OF A CRASH.
Remedy: DEALERS WILL INSPECT AND TIGHTEN THE PARKING BRAKE PEDAL CABLE LOCK NUT TO THE PROPER TORQUE SPECIFICATION FREE OF CHARGE. THE RECALL BEGAN ON MARCH 3, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.