2005 Toyota Tacoma

VEHICLE SURGES FORWARD SLIGHTLY WHEN STOPPED AT STOPLIGHT. HAPPENS NEARLY EVERY TIME I STOP THE VEHICLE WITHOUT HAVING IT IN PARK MODE. THE SEVERITY OF THE SURGE SEEMS TO BE PROPORTIONAL WITH THE VELOCITY OF THE VEHICLE PRIOR TO STOPPING (I.E. SURGE IS MORE PRONOUNCED WHEN STOPPING FROM A HIGHER VELOCITY THAN FROM A LOWER VELOCITY). THE SURGE EVENT OCCURS ROUGHLY 2-3 SECONDS AFTER VEHICLE COMES TO A FULL STOP, AND LASTS PERHAPS 0.5 SECONDS THEN GOES AWAY. WITH THE FOOT ON THE BRAKE, THE VEHICLE DOESN'T GO VERY FAR, BUT IT'S A SAFETY CONCERN IN THE EVENT THE SURGE BECOMES UNCONTROLLABLE. CORRECTIVE ACTION HAS BEEN TO MAINTAIN A GREATER-THAN-USUAL DISTANCE FROM THE INTERSECTION OR FROM THE VEHICLE IN FRONT. *TR

TL*THE CONTACT OWNS A 2005 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 15 MPH ON NORMAL ROAD CONDITIONS, THE VEHICLE LUNGED FORWARD WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT HEARD A LOUD SQUEALING NOISE COMING FROM THE WHEELS. THE GEAR SHIFTER WAS PLACED INTO PARK IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. THE FAILURE RECURRED AND WAS TAKEN TO THE DEALER ON THREE OCCASIONS, BUT THERE WERE NO RESOLUTIONS. THE VEHICLE IS CURRENTLY OPERATING PROPERLY. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS UNAVAILABLE AND CURRENT MILEAGE WAS 45,000. SEE ALSO 10254167. DSY

I TOOK MY 2005 TOYOTA TACOMA IN FOR A SQUEAL IN THE WINDOW, UNDER WARRANTY. SUN TOYOTA TOLD ME I WOULD NEED A REGULATOR. I LEFT MY TRUCK THERE FOR FOUR HOURS, WHEN I RETURNED TO PICK IT UP, THEY INFORMED ME THAT MY CLUTCH WAS COMPLETELY WARNED OUT. I DIDN'T BRING IT IN FOR ANY KIND OF CLUTCH REPAIR, MIND THE FACT I WAS ONLY AT 26K MILES. I ASKED HOW DID THEY DETERMINED THAT. THE GUY IN THE SERVICE DEPT. SAID HE, "COULD FEEL IT WITH HIS FOOT". THAT I WOULD HAVE TO PAY $800.00 UP FRONT FOR THEM TO EVEN LOOK AT IT, AND THAT WOULD JUST TELL THEM IF THERE IS A PROBLEM AND IF IT WAS A WARRANTY ITEM OR IF I WORE IT OUT. I TOLD THEM THERE WAS NO WAY I COULD HAVE WORN OUT THE CLUTCH IN 26K MILES, THEY TOLD ME THAT TEENAGERS CAN WEAR A CLUTCH OUT AT 18K MILES, HOWEVER I AM NOWHERE NEAR A TEENAGER ANYMORE. SO ANYWAY, I DID NOT SHELL OUT $800.00. INSTEAD I TOOK MY TRUCK TO MY SERVICE MAN, THAT HAS NOTHING TO DO WITH TOYOTA, AND TOLD HIM EVERYTHING THAT HAPPENED AT TOYOTA. HE COULD NOT BELIEVE WHAT I HAD BEEN TOLD. THEN PROCEEDED TO CHECK OUT THE TRUCK, PUT IT ON A LIFT, TOOK IT DOWN AND ADJUSTED THE CLUTCH, AND TOLD ME THERE IS NOTHING WRONG WITH YOUR CLUTCH, AND HE DIDN'T CHARGE ME ANYTHING! AFTER THAT EPISODE I CONTACTED THE BBB, I TRIED TO CONTACT TOYOTA CORP., USELESS! THE BBB COULD NOT RESOLVE THIS EITHER. THE BOTTOM LINE IS, TOYOTA THE COMPANY STINKS, THEY WILL TELL YOU LIES, TO GET MONEY OUT OF YOU. THEN WHEN YOU PROVE THEM WRONG. THEY STILL WON'T ADMIT THEY MADE A MISTAKE. I LOVE MY TRUCK AND STILL OWN IT. HOWEVER NOW I TELL EVERYONE WHAT A BAD COMPANY TOYOTA IS AND TO RESEARCH IT BEFORE THEY BUY, SO FAR I'VE TALKED THREE PEOPLE OUT OF BUYING ONE. I ALSO HAVE FRIENDS THAT HAVE TOLD ME OF PROBLEMS THEY HAVE HAD WITH THEIR TOYOTA TRUCKS! *TR

THE EVENTS LEADING UP TO THE INCIDENT WAS DRIVING MY VEHICLE ON VACATION. THE MOTOR MOUNT ON THE VEHICLE BROKE, AND THE ENGINE WAS LEANING TO THE DRIVER SIDE. TOYOTA REFUSED COVERAGE FOR A NUMBER OF REASONS, INCLUDING SAYING IT WASN'T COVERED UNDER WARRANTY, MY AFTERMARKET SHOCKS CAUSED THE MOTOR MOUNT TO BREAK, MY HEAVY FRONT BUMPER CAUSED THE PROBLEM, AND THEY SAID I DROVE THE TRUCK TO HARD. UNDER THE MAGNUSSON-MOSS ACT, I ASKED THEM TO PROVE THAT MY AFTERMARKET PRODUCTS CAUSED THE FAILURE. THEY EXPLAINED THAT THEY COULDN'T DO THAT AND OFFERED ME ARBITRATION. BECAUSE OF THE COST OF RENTING A CAR WHILE WAITING FOR ARBITRATION, I DECIDED TO FIX THE TRUCK OUT OF MY OWN POCKET AND TAKE TOYOTA TO SMALL CLAIMS COURT. I WON MY CASE, AND TOYOTA WAS ORDERED TO PAY ME $2,900.00. SINCE MY COURT CASE, I HAVE JOINED AN INTERNET FORUM IN WHICH THERE HAS BEEN AT LEAST 5 OTHER 2005 TACOMAS WITH THE SAME EXACT ISSUE; MOST RECENTLY LAST WEEK. TOYOTA NEEDS TO RECOGNIZE THIS IS A PROBLEM BEFORE SOMEONE DIES BEHIND THE WHEEL AS A RESULT OF ENGINE MOUNT FAILURE. *TR

2005 TACOMA, TRD SPORT PKG, 6 SPEED MANUAL BEHIND A V6. AT ABOUT 27K THE CLUTCH PEDAL STARTED MAKING THIS HORRENDOUS SQUEAK. THE DEALER PERFORMED A TSB TO REPLACE THE CLUTCH PEDAL ASSEMBLY. SQUEAK WAS GONE FOR ABOUT 6K MILES BUT THE PEDAL STICKS. SINCE THAT FIRST REPLACEMENT OF THE PEDAL ASSEMBLY, THE DEALER GREASES IT EVERY 6-8K MILES BECAUSE THE SQUEAK KEEPS RETURNING AND THE PEDAL STILL STICKS! THEY DID REPLACE THE PEDAL ASSEMBLY A SECOND TIME HOWEVER NOW THE PEDAL FEELS LIKE IT IS GOING TO FALL OFF AND IT STILL STICKS. THE LAST STRAW WAS WHEN I BROUGHT IT TO THE DEALER AND THEY TOLD ME THAT IT WAS "EXCESSIVE USE OF THE PEDAL, THE TRUCK WAS NOT MADE TO DRIVE IN TRAFFIC". WHAT THE HECK WAS IT MADE FOR?? I DRIVE THE HIGHWAY EVERYDAY TO WORK AND YES, I OCCASIONALLY GET CAUGHT IN TRAFFIC DUE TO AN ACCIDENT, BUT THAT MIGHT HAPPEN ONCE EVERY OTHER WEEK! TOYOTA CORPORATE WAS NO HELP, THEY SAID I WOULD HAVE TO WORK WITH THE DEALER BECAUSE I WAS OUT OF WARRANTY. THE DEALER DOESN'T RETURN PHONE CALLS AND I AM STUCK WITH A TRUCK THAT HAS A BAD CLUTCH PEDAL! *TR

MY 2005 TACOMA HAS HAD A CLUTCH SQUEAL SINCE IT WAS BRAND NEW. TOYOTA HAS REPLACED 2 CLUTCHES AFTER 2 RELEASE BEARING FAILURES IN LESS THEN 1 YEARS TIME. AFTER THE SECOND CLUTCH THE SQUEAL CAME BACK WITHIN 3,000 MILES. THE DEALER LUBED THE SLAVE CYLINDER / CLUTCH FORK INTERSECTION POINT. AFTER SEVERAL TRIPS FROM 48 HRS TO 1 MONTH INTERVALS THEY LUBED IT NUMEROUS TIMES. FED UP I INFORMED THEM I WOULD NOT BE COMING IN CONSTANTLY TO HAVE THE TRANSMISSION LUBED. THEY REPLACED THE SLAVE CYLINDER AND CLUTCH FORK. WITHIN 48 HRS THE SQUEAL WAS BACK. AFTER HAVING THE VEHICLE IN FOR A TOYOTA FIELD TECH TO LOOK AT THE REPLACED THE CLUTCH RETURN SPRING. WITHIN 24 HOURS THE SQUEAL WAS BACK. DURING ALL THE INCIDENTS I CONTACTED TOYOTA TO KEEP THEM INFORMED OF THE ISSUES. THE LATEST CALL RESULTED IN ESCALATION AS I HAVE REQUESTED REPLACEMENT OF THE TRANSMISSION AS THERE IS APPARENTLY A DEFECT IN THE CASTING OF THE TRANSMISSION OR AN INTERNAL ISSUE. TOYOTA CALLED ME BACK TO SAY THEY WOULD WORK OUT A PLAN WITH MY DEALER TO FIX THE VEHICLE. (THIS IS AFTER 13 TRIPS TO THE DEALER FOR THE SAME PROBLEM BETWEEN REPAIRS AND LUBE TRIPS.) I WAS INFORMED I WOULD BE CALLED BACK NO LATER THEN THURSDAY NOV 14TH. AS OF THIS POINT THERE HAS BEEN NO CONTACT AND I'M TAKING LEGAL ACTIONS. *TR

UPON COMING TO A STOP (MOST OF THE TIME...PERHAPS MORE THEN 50%), THE VEHICLE WILL 'LURCH' FORWARD SLIGHTLY...EVEN WHEN THE BRAKE IS DEPRESSED. THIS WAS REPORTED TO THE DEALER A YEAR AGO (AND IS ON FILE WITH THEM). I WAS TOLD THAT THIS CONDITION WAS 'NORMAL'. NO ACTION HAS BEEN TAKEN BY THE DEALER TO CORRECT OR OTHERWISE STOP THIS CONDITION. IT HAS NOT BEEN SO BAD THAT I COULD NOT STOP THE VEHICLE (JUST PRESS THE BRAKE PEDAL HARDER). STILL, IF NOT PAYING ATTENTION, A COLLISION MIGHT READILY OCCUR IN STOPPED TRAFFIC. *JB