OUR 2005 TOYOTA TACOMA'S GAS TANK HAD FALLEN OFF THE FRAME DUE TO CORRODED STRAPS WHILE THE VEHICLE WAS MOVING AT SLOW SPEED ON OUR PROPERTY. THE VEHICLE HAS LESS THAN 140,000 MILES ON IT. THE VEHICLE NEEDED TO BE TOWED TO A LOCAL TOYOTA DEALERSHIP. THERE WAS NO SERIOUS INJURY. HOWEVER, HAD THE TANK SEPARATED WHILE BEING DRIVEN …
Read full complaint
OUR 2005 TOYOTA TACOMA'S GAS TANK HAD FALLEN OFF THE FRAME DUE TO CORRODED STRAPS WHILE THE VEHICLE WAS MOVING AT SLOW SPEED ON OUR PROPERTY. THE VEHICLE HAS LESS THAN 140,000 MILES ON IT. THE VEHICLE NEEDED TO BE TOWED TO A LOCAL TOYOTA DEALERSHIP. THERE WAS NO SERIOUS INJURY. HOWEVER, HAD THE TANK SEPARATED WHILE BEING DRIVEN IT IS VERY POSSIBLE AND PROBABLE THAT THIS COULD HAVE RESULTED IN IGNITION, FIRE, EXPLOSION AND LOSS OF CONTROL OF THE VEHICLE, SERIOUS INJURY OR DEATH. THE DEALERSHIP HAD GIVEN US AN AN INITIAL ESTIMATE OF $1,800 OUT OF POCKET EXPENSE TO PAY FOR THE REPAIRS STATING THAT THE CORROSION IS 'PART OF WINTER DRIVING' THIS IS FAR FROM A PLAUSIBLE AND ACCEPTABLE EXPLANATION. GAS TANKS SHOULD NOT FALL OFF VEHICLES AND POSE SUCH A SIGNIFICANT SAFETY THREAT. TOYOTA CORPORATE REFUSED TO PAY FOR MORE THAN ROUGHLY $400 IN REPAIRS TO THE OUT OF POCKET EXPENSES. THE FINAL BILL OUT OF POCKET EXPENSES WERE $2,300 IN COSTS FOR REPAIR.
NHTSA ODI #11138919
Mileage unknown · Apr 11, 2017
Fuel/propulsion SystemFire
TL* THE CONTACT OWNED A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE THE DRIVER WAS DRIVING AT 35 MPH, THE CONTACT WAS SIGNALED THAT THE REAR OF THE VEHICLE WAS EMITTING SMOKE. THE CONTACT PULLED THE VEHICLE TO A SHOULDER LANE AND CONFIRMED THE REAR DRIVER SIDE OF THE VEHICLE WAS EMITTING SMOKE. AS A RESULT, THE VEHICLE CAU…
Read full complaint
TL* THE CONTACT OWNED A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE THE DRIVER WAS DRIVING AT 35 MPH, THE CONTACT WAS SIGNALED THAT THE REAR OF THE VEHICLE WAS EMITTING SMOKE. THE CONTACT PULLED THE VEHICLE TO A SHOULDER LANE AND CONFIRMED THE REAR DRIVER SIDE OF THE VEHICLE WAS EMITTING SMOKE. AS A RESULT, THE VEHICLE CAUGHT FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND IT WAS UNKNOWN IF A POLICE/FIRE REPORT WAS FILED. NO INJURIES WERE SUSTAINED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 08/22/17*LJ *CN
NHTSA ODI #10971808
161,000 miles · Mar 23, 2017
Fuel/propulsion SystemVehicle Speed ControlCrash
I WAS APPROACHING A RED;IGHT IN PHOENIX, A TRUCK WAS IN FRONT OF ME I APPLIED THE BRAKE AND THE ACCELERATOR AMPED UP. THE GUY I REARENDED SAID HE SAW MER CROW HOPPING AS MY TRUCK WAS DOING THIS. I HAD MY FOOT FIRMLY PRESSED ON THE BRAKE AS HARD AS I COULD. I ONLY STOPPED WHEN I REAR ENDED HIM. I WAS ON A CITY STREET IN PHOENIX…
Read full complaint
I WAS APPROACHING A RED;IGHT IN PHOENIX, A TRUCK WAS IN FRONT OF ME I APPLIED THE BRAKE AND THE ACCELERATOR AMPED UP. THE GUY I REARENDED SAID HE SAW MER CROW HOPPING AS MY TRUCK WAS DOING THIS. I HAD MY FOOT FIRMLY PRESSED ON THE BRAKE AS HARD AS I COULD. I ONLY STOPPED WHEN I REAR ENDED HIM. I WAS ON A CITY STREET IN PHOENIX.
NHTSA ODI #10968182
Mileage unknown · Jun 3, 2015
Fuel/propulsion SystemSuspension
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT THE LEAF SPRING FRACTURED WITHOUT WARNING AND THERE WAS A PUNCTURED HOLE, WHICH DAMAGED THE FUEL TANK. PRIOR TO THE FAILURE, THE CONTACT TRIED FOR SEVERAL MONTHS TO SCHEDULE A REPAIR. THE DEALER INDICATED THAT THEY DID NOT HAVE A REMEDY FOR SEVERAL MONTHS. THE VE…
Read full complaint
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT THE LEAF SPRING FRACTURED WITHOUT WARNING AND THERE WAS A PUNCTURED HOLE, WHICH DAMAGED THE FUEL TANK. PRIOR TO THE FAILURE, THE CONTACT TRIED FOR SEVERAL MONTHS TO SCHEDULE A REPAIR. THE DEALER INDICATED THAT THEY DID NOT HAVE A REMEDY FOR SEVERAL MONTHS. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V604000 (SUSPENSION), 12V092000 (AIR BAGS), AND 09V388000 (VEHICLE SPEED CONTROL). THE DEALER DID NOT KNOW WHEN THE PARTS WOULD BECOME AVAILABLE TO SCHEDULE THE RECALL REPAIRS. THE VEHICLE WAS TAKEN TO A REPAIR SHOP AND THE LEAF SPRINGS AND FUEL TANK WERE REPLACED AS A TEMPORARY REMEDY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #10723213
140,500 miles · Apr 10, 2015
EngineFuel/propulsion SystemPower Train
MY FATHER HAS AN '05 TACOMA SR5 V6 WITH THE TRD OFF-ROAD PACKAGE. HIS TRUCK IS A 6-SPEED MANUAL. WHEN PRESSING THE GAS PEDAL 1/2 WAY, THE ENGINE RESPONDS WITH A SEMI-VIOLENT JERK, AND THEN GOES. THIS SCARES ME, AS I COULDN'T EVEN IMAGINE MY FATHER GOING FULLY DOWN ON THE PEDAL. THIS IS VERY UNSAFE. PLEASE FIX THIS TOYOTA. …
Read full complaint
MY FATHER HAS AN '05 TACOMA SR5 V6 WITH THE TRD OFF-ROAD PACKAGE. HIS TRUCK IS A 6-SPEED MANUAL. WHEN PRESSING THE GAS PEDAL 1/2 WAY, THE ENGINE RESPONDS WITH A SEMI-VIOLENT JERK, AND THEN GOES. THIS SCARES ME, AS I COULDN'T EVEN IMAGINE MY FATHER GOING FULLY DOWN ON THE PEDAL. THIS IS VERY UNSAFE. PLEASE FIX THIS TOYOTA. *TR
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
ON CERTAIN REGULAR CAB PICKUP TRUCKS EQUIPPED WITH A BENCH SEAT, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR CONNECTOR PINS ARE INCORRECTLY POSITIONED DUE TO A WIRE HARNESS MANUFACTURING PROCESS ERROR.
Consequence & remedy
Consequence: IN THIS CONDITION, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR MAY NOT FUNCTION AS DESIGNED, AFFECTING THE ADAPTIVE AIR BAG DEPLOYMENT, WHICH IF THE VEHICLE IS INVOLVED IN A CRASH, COULD RESULT IN IMPROPER OCCUPANT RESTRAINT.
Remedy: DEALERS WILL INSPECT THE SEAT POSITION AND SEAT BELT FASTENING CONDITION SENSOR CONNECTOR. AN ADDITIONAL SUB-WIRE HARNESS WILL BE INSTALLED TO CORRECT THE CONNECTOR PIN MANUFACTURING ERROR, IF NECESSARY. THE RECALL BEGAN ON JULY 25, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-431-4331.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THERE IS A POSSIBILITY THAT THE PARKING BRAKE PEDAL CABLE LOCK NUT MAY NOT HAVE BEEN TIGHTENED TO THE PROPER TORQUE SPECIFICATION. IN THIS CONDITION, THE LOCK NUT MAY LOOSEN AND COME OFF, WHICH WILL REDUCE THE EFFECTIVENESS OF THE PARKING BRAKE.
Consequence & remedy
Consequence: THIS CONDITION COULD ALLOW THE VEHICLE TO ROLL IF THE TRANSMISSION IS NOT PLACED INTO THE "PARK" POSITION AND THE VEHICLE IS PARKED ON A SLOPE, THUS RAISING THE POSSIBILITY OF A CRASH.
Remedy: DEALERS WILL INSPECT AND TIGHTEN THE PARKING BRAKE PEDAL CABLE LOCK NUT TO THE PROPER TORQUE SPECIFICATION FREE OF CHARGE. THE RECALL BEGAN ON MARCH 3, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Toyota Tacoma Problems, Complaints & Recalls | Skip That Year
Illustration