2004 Toyota Tacoma

2004 TACOMA RACK AND PINION SYSTEM WAS REPLACED TWICE PER THE SUGGESTION OF THE MECHANIC. MECHANIC INFORMED CONSUMER THAT THE STEERING ROD WAS ALSO BROKEN. ALTHOUGH THIS PART WAS BROKEN THE DEALER RETURNED THE VEHICLE BACK TO THE CONSUMER BECAUSE THEY DIDN'T HAVE THE PART AVAILABLE TO REPAIR IT. THE DEALER SAID THERE WAS NO DANGER IN DRIVING THE VEHICLE WITH A STEERING BROKEN ROD. *TS *NM

DT*: THE CONTACT STATED THE RACK AND PINION STEERING HAS BEEN REPLACED TWICE DUE TO CRACKS. THE VEHICLE HAS BEEN TAKEN TO A SERVICE DEALER WHO DETERMINED THAT THERE WAS A FAULTY BUSHING. AFTER THE SECOND REPAIR, THERE WAS A LOT OF PLAY IN THE STEERING, CAUSING REDUCED CONTROL. THE STEERING ROD ALSO FAILED. UPDATED 04/11/06. *JB

2004 TOYOTA TACOMA [XXX] ELECTRONIC THROTTLE CONTROL SYSTEM (ETCS). ON 26 FEB 2005, 14 APR 2005, 17 APR 2005 AND 20 FEB 2005 AFTER PROLONGED DRIVING AT HIGHWAY SPEEDS WHEN STEPPING OFF THE GAS PEDAL TO MAKE A STOP THE ENGINE SPEED WOULD NOT DECREASE AND I WOULD HAVE TO APPLY BOTH FEET TO THE BRAKE PEDAL TO TRY TO SLOW DOWN, AND SWERVE TO THE SIDE TO AVOID HITTING VEHICLES IN FRONT OF ME. AFTER APPROXIMATELY 5-10 SECONDS THE ENGINE SPEED WOULD SUDDENLY DECREASE AND I COULD REGAIN CONTROL. WHILE STRUGGLING TO KEEP CONTROL DID NOT SHIFT FROM DRIVE TO NEUTRAL. IN EACH INSTANCE NO WARNING LIGHTS. BEFORE THESE 4 EVENTS OCCURRED THE ENGINE SUFFERED A CATASTROPHIC FAILURE ON 11 APR 2004 WITH ONLY 1,111 MILES. TOYOTA OF CARSON CITY NEVADA EFFECTED THE REPAIRS TO THE CATASTROPHIC ENGINE FAILURE BY REPLACING THE LOWER BLOCK AND THE CYLINDER HEADS AMONG OTHER COMPONENTS. I TOOK THE CAR TO TOYOTA OF CARLSBAD, CALIFORNIA ON 1 MAR 2005, 20 APR 2005, 5 MAY 2005 AND 23 FEB 2006 FOR THE SPEED CONTROL PROBLEM BUT THEY COULD NOT DUPLICATE IT AND WOULD NOT REPLACE ANY COMPONENTS. APPARENTLY THE COMPUTER DID NOT REGISTER/STORE ANY DIAGNOSTIC FAILURE CODES. I KNOW BY HAVING READ THE TOYOTA SERVICE MANUAL THAT THE ELECTRONIC CONTROL MODULE DOES NOT RECORD ALL FAILURES. I CANNOT TELL IF THIS PROBLEM WAS PRESENT WHEN THE CAR WAS BUILT OR WHETHER IT WAS INDUCED BY REPAIRS FOR THE CATASTROPHIC ENGINE FAILURE. WHAT I DO KNOW IS THAT I HAVE A SERIOUS SAFETY ISSUE. I AM VERY CONCERNED ABOUT NOT BEING ABLE TO AVOID HITTING A PEDESTRIAN OR ANOTHER VEHICLE. I HAVE EXHAUSTED ALL CONSUMER SUPPORT AVENUES WITH TOYOTA. REFERENCE NUMBER [XXX] WITH ELOISE TOYOTA CUSTOMER SUPPORT 1-800-331-4331 TODAY 24 FEB 2006 INDICATES THAT THEY WILL NOT DO ANYTHING ELSE. I STRONGLY SUSPECT THAT THERE ARE TWO FAILURES. FIRST, THE THROTTLE BODY IS MALFUNCTIONING INTERMITTENTLY CAUSING THE PROBLEM. SECOND, THE ECM IS FAILING TO DETECT AND RECORD THE EVENT. *NM UPDATED 07/17/2012 *JS

2004 TOYOTA TACOMA 4X4 WITH 3.4L ENGINE AND MANUAL TRANS. HAVING THROTTLE BODY ISSUES. THE ACCELERATOR POSITION SENSOR IS FAILING CAUSING THE TRUCK TO STALL FOR A SECOND AND THEN PICK BACK UP. TRUCK DOES NOT THROW A CHECK ENGINE CODE WHEN THIS OCCURS, SO DEALER HAS INFORMED ME ON DIFFERENT OCCASIONS THAT NOTHING IS WRONG. I WAS ALMOST RAN OVER THE OTHER DAY TRYING TO PULL OUT INTO TRAFFIC WHEN THE THROTTLE BODY FAILED. THIS IS A SAFETY CONCERN AND TOYOTA NEEDS TO ADDRESS IT IMMEDIATELY!!!!!!!! WHAT'S IT GOING TO TAKE, SOMEONE GETTING SERIOUSLY INJURED OR A HEALTHY LOW SUIT FOR TOYOTA TO TAKE ACTION? *JB

I HAVE A 2004 TOYOTA TACOMA 4X4 WITH A 3.4 LITER V6. I HAVE ALREADY FILED 1 COMPLAINT BUTT IN FRUSTRATION WILL TRY THIS AGAIN. THE ELECTRONIC THROTTLE BODIES THAT COME ON 2003 AND 2004 TOYOTA TACOMAS ARE FLAWED AND NEED TO BE INVESTIGATED AND RECALLED DUE TO SAFETY CONCERNS. THE PROBLEM IS THAT THE ACCELERATOR POSITION SENSORS ON THESE THROTTLE BODIES ARE GOING OUT, CAUSING THE ACCELERATOR TO BECOME USELESS UNLESS DEPRESSED GREATER THAN 60%. I HAVE ALL MOST BEEN IN 2 ACCIDENTS WHILE PULLING OUT INTO TRAFFIC AND HAVING THIS OCCUR. WHEN THE SENSOR FAILS THE THROTTLE VALVE CLOSES LEAVING THE PERSON DRIVING THE VEHICLE WITHOUT ENOUGH ACCELERATION TO GET OUT OF THE WAY OF ON COMING TRAFFIC. IN VEHICLES WITH MANUAL TRANSMISSION IT IS ESPECIALLY DANGEROUS WHEN ON AN INCLINE (VERY DIFFICULT NOT TO ROLE BACKWARDS AND HIT SOMETHING BEHIND YOU). ALSO, NO CHECK ENGINE LIGHT HAS CAME ON WHEN THIS HAS OCCURRED. I HAVE READ HUNDREDS OF LETTERS ON THE INTERNET FROM PEOPLE HAVING THE SAME PROBLEM. IS IT GOING TO TAKE SOMEONE GETTING KILLED OR A HEALTHY LAW SUIT TO MAKE TOYOTA TAKE ACTION? *NM

#1. 2004 TACOMA DBL CAB TRD: I'M ON MY 3RD SET OF ROTORS AND DRUMS AT JUST 40,000 MILES. EACH SET OF ROTORS WARPED AT JUST OVER 10,000 MILES CAUSING THE EXPECTED PULSING AND BOUNCING. I'M EXPECTING THE 3RD SET TO DO THE SAME. #2. SINCE ABOUT 10,000 MILES, I HAVE EXPERIENCED A "THUMPING" WITH A CORRESPONDING JOLT OF THE GEAR SHIFT UPON FINISHING A BREAKING CYCLE. THIS ALSO HAPPENS OCCASIONALLY WHEN RELEASING THE FOOT BRAKE. SOMETIMES IT IS QUITE LOUD AND VIOLENT. I AM AWARE THAT ALL THE LATE MODEL AUTOMATICS DO THIS. THE FACTORY HAS ACKNOWLEDGED THAT THERE IS A PROBLEM BECAUSE THEIR "FIX" WAS TO DRILL A HOLE IN THE TWO-PIECE DRIVE SHAFT TO "VENT" THE TRAPPED AIR. THIS VERY TEMPORARILY SOLVED THE PROBLEM. AGAIN TODAY, THE DEALER ACKNOWLEDGED THE "THUMP" AND TOLD ME THAT THIS IS "THE WAY THE TRUCK IS SUPPOSED TO OPERATE" AND THAT I SHOULD "CHANGE MY BRAKING HABITS". ON A 15 MINUTE TEST DRIVE IT PROBABLY DOESN'T SEEM TOO BAD. BUT I HAVE TO DRIVE THE VEHICLE ALL THE TIME AND IT IS VERY ANNOYING (AND THIS WAS NOT HAPPENING WHEN I TEST DROVE THE VEHICLE BEFORE I PURCHASED IT). PERHAPS THIS IS NOT A "SAFETY" ISSUE, BUT IT IS INSULTING TO BE TOLD THAT THIS IS "NORMAL". THEY MUST THINK I'M AN IDIOT OR SOMETHING. JUST BECAUSE ALL THE LATE MODEL TACOMAS DO IT, DOES NOT MAKE IT RIGHT! IT'S SO ARROGANT FOR THEM TO EXPECT US TO LIVE WITH THIS DEFECT IN DESIGN. I ALSO BELIEVE THAT THIS SAME PROBLEM IS RELATED TO THE SOMETIMES VIOLENT SHIFTS ESPECIALLY FROM 1ST TO 2ND GEAR. #3. THERE IS ALSO A VIBRATION THAT COMES UP THROUGH THE STEERING WHEEL AT ABOUT 40 MILES PER HOUR. IT IS THE FREQUENCY OF THE DRIVE SHAFT, NOT THE TIRES. I CAN ALWAYS TELL WHEN I'M AT 40 MPH WITHOUT EVEN LOOKING AT THE SPEEDOMETER. *JB

I WAS DRIVING ON THE ROAD IN MY 2004 TOYOTA TACOMA WHEN I SAW MY TIRE GO ROLLING AHEAD OF MY VEHICLE, THE TRUCK LEANED OVER TO THE LEFT, SKIDDED SIDEWAYS AND THEN STOPPED IN THE MIDDLE OF THE ROAD. I GOT OUT OF THE TRUCK AND MY TIRE WAS IN THE DITCH AND MY CHASSIS WAS ON THE GROUND ON THE LEFT SIDE. I CALLED A TOW TRUCK AND THEY SAID IT LOOKED LIKE MY BALL JOINTS JUST SEPARATED. I HAD THE VEHICLE TOWED TO MY MECHANIC AND HE SAID THE BALL JOINTS LOOKED LIKE THEY GAVE WAY AND THIS ALLOWED THE WHEEL TO FALL OFF. I HAVE MECHANICAL BREAKDOWN THROUGH MY INSURANCE COMPANY GIEICO AND THEY TOLD ME I WOULD HAVE TO GET A LETTER FROM TOYOTA STATING IF IT WASN'T UNDER WARRANTY FROM OUR LOCAL DEALERSHIP IN TALLAHASSEE, FLORIDA LEGACY AND SPOKE WITH A SERVICE MEMBER (ROBB) HE TOLD MY THAT THERE WASN'T A RECALL ON 2004 TOYOTA TACOMAS AND I WOULD HAVE TO PAY TO HAVE IT TOWED IN TO CHECK AND SEE IF IT WAS STILL UNDER WARRANTY. THIS OCCURRED ON 12/13/05 AND AS OF 12/15/2005 THERE STILL WASN'T A DETERMINATION WHETHER OR NOT IT IS UNDER WARRANTY. MY CONCERN IS AFTER READING ABOUT A RECALL ON THE INTERNET STATING THAT THE BALL JOINT MAY SEPARATE FROM THE KNUCKLE, THAT MY VEHICLE SHOULD BE A PART OF THE RECALL AND THE WHEEL FALLING OFF COULD BE A RESULT FROM A DEFECT. THE DEALERSHIP ISN'T ACCEPT RESPONSIBILITY FOR THE RECALL OR EVEN LOOKING AT THE VEHICLE IN THIS REGARDS. IF THEY DON'T WARRANTY THE BALL JOINTS, THEN MY MECHANIC WILL FIX THE PROBLEM, BUT I WILL KEEP ALL OF THE OLD PARTS IN CASE THEY NEED TO BE EXAMINED. *JB