2004 Toyota Tacoma

2004 TOYOTA TACOMA X-TRA CAB, 4CYL. WITH A/T DEVELOPED POWER STEERING LEAK AT 51K. THE DEALER DIAGNOSED THE PROBLEM AS BAD SEALS IN THE RACK AND PINION. WHEN I REPLACED THE RACK AND PINION, I DISCOVERED THAT A PINCH BOLT IN THE STEERING COLUMN HAD RUBBED A HOLE IN THE METAL POWER STEERING FEED LINE GOING TO THE RACK AND PINION. THIS ISSUE WAS BROUGHT TO THE DEALERS ATTENTION BUT THE DEALER REFUSED TO ACKNOWLEDGE THE PROBLEM AND I HAVE BEEN WITHOUT THE USE OF MY '04 TOYOTA TRUCK FOR 5 MONTHS. *TR

1) POWER STEERING FLUID BEGAN TO LEAK FROM AREA OF RACK AND PINION. 2) TOYOTA DEALER MIS-DIAGNOSED PROBLEM AS LEAKING SEALS IN RACK AND PINION. 3) LEAK OCCURRED IN METAL POWER STEERING LINE (ROUTED TOO CLOSE TO STEERING GEAR) , WHERE FRICTION FROM PINCH BOLT IN STEERING GEAR HAS WORN A HOLE IN METAL POWER STEERING LINE. 4) THIS CAUSES ALL FLUID TO LEAK FROM POWER STEERING SYSTEM. 5) 2004 TACOMA SR-5 XTRA CAB, 2.4 LITRE 4CYL./AUTO TRANS, 51K. *TR

PURCHASED 2004 TACOMA FOR $18,000, FROM RIGHT TOYOTA IN SCOTTSDALE, AZ IN JUNE 2006, RECEIVED BILL FOR $25,000+!! SO MUCH FOR AGREEING ON A PRICE! I ALSO PURCHASED AN EXTENDED WARRANTY FOR $2200 (INCLUDED IN THE $25,000). WEEKS AFTER GETTING THE TRUCK I NOTICED THE REAR PASSENGER SIDE SEEMED TO GIVE WHEN TURNING CORNERS. I ASSUMED I NEEDED TO ADJUST TO DRIVING A TRUCK WITH HARD SUSPENSION. UNFORTUNATELY IT PERSISTED SO I TOOK IT INTO CAMELBACK TOYOTA AND HAD THEM CHECK IT OUT. THEY ASSURED ME THAT EVERYTHING WAS IN TIP TOP SHAPE, I GOT THE FEELING THEY NEVER REALLY CHECKED ANYTHING OUT. THEY JUST ASSUMED THAT IT WOULD BE UNUSUAL TO SEE THIS STUFF BREAKDOWN, A VALID THOUGHT, BUT THEY WERE OF NO HELP. HERE IT IS NOW, A YEAR AND A HALF LATER, AND ITS JUST GETTING WORSE! SO I TOOK IT INTO EARNHARDT TOYOTA AND THE FIRST 2 VISITS THEY PERFORMED NEEDED FRONT END ALIGNMENTS AND TIRE BALANCING. THEY LOOKED AT IT RECENTLY AFTER ME YELLING AT THEM, AND TOLD ME THAT MY ENTIRE SUSPENSION SYSTEM NEEDS TO BE REPLACED. APPARENTLY MY LEAF SPRINGS ARE BAD ($1700 PURCHASE AND INSTALL), AND FRONT STRUTS ($650), AND REAR SHOCKS ($450) AS WELL! SO $2800 TO REPAIR A TRUCK THAT I PURCHASED DIRECTLY FROM TOYOTA NOT 1.5 YEARS AGO, AND EVEN PURCHASED A WARRANTY. THEY ASSURED ME THAT EVERYTHING WAS COVERED UNDER THE WARRANTY. THEY LIED. NOW I OWE $18000 ON A $14000 TRUCK! STEER CLEAR OF RIGHT TOYOTA, THEY TOTALLY SCAMMED ME. *TR

2004 TOYOTA TACOMA WILL NOT PASS INSPECTION DUE TO WORN STEERING RACK BUSHINGS. ACCORDING TO MY MECHANIC (AND CONFIRMED AS PLAUSIBLE BY DEALERSHIP SERVICE DEPT), THIS WAS CAUSED BY DEFECTIVE LOWER BALL JOINTS. ALSO, THERE IS A CURRENT SERVICE/RECALL BULLETIN FOR JUST THIS PROBLEM. HOWEVER, DEALERSHIP AND MANUFACTURER REPRESENTATIVES BOTH INSIST THE BULLETIN DOES NOT APPLY TO MY VEHICLE. THIS MAKES NO SENSE AS THE PROBLEM EXISTS. THE BUMPER TO BUMPER DOES NOT APPLY AS THE VEHICLE IS CURRENTLY 2K OVER. *JB

2004 TACOMA RACK AND PINION SYSTEM WAS REPLACED TWICE PER THE SUGGESTION OF THE MECHANIC. MECHANIC INFORMED CONSUMER THAT THE STEERING ROD WAS ALSO BROKEN. ALTHOUGH THIS PART WAS BROKEN THE DEALER RETURNED THE VEHICLE BACK TO THE CONSUMER BECAUSE THEY DIDN'T HAVE THE PART AVAILABLE TO REPAIR IT. THE DEALER SAID THERE WAS NO DANGER IN DRIVING THE VEHICLE WITH A STEERING BROKEN ROD. *TS *NM

DT*: THE CONTACT STATED THE RACK AND PINION STEERING HAS BEEN REPLACED TWICE DUE TO CRACKS. THE VEHICLE HAS BEEN TAKEN TO A SERVICE DEALER WHO DETERMINED THAT THERE WAS A FAULTY BUSHING. AFTER THE SECOND REPAIR, THERE WAS A LOT OF PLAY IN THE STEERING, CAUSING REDUCED CONTROL. THE STEERING ROD ALSO FAILED. UPDATED 04/11/06. *JB

NOISE AND EXCESS PLAY IN STEERING WHEEL WHEN DRIVING OVER BUMPY SURFACES. FOUND UPPER STEERING SHAFT SLIP JOINT IMPROPERLY MACHINED /CRIMPED RESULTING IN ABNORMAL NOISE AND EXCESS PLAY WHEN DRIVING UNDER CERTAIN CONDITIONS. DEALER REPLACED UPPER STEERING SHAFT WITH AND IDENTICAL PART. THIS PART HAS NOT BEEN REDESIGNED AND WILL FAIL AGAIN. PART IS NOT AVAILABLE AS IT WAS REPLACED UNDER WARRANTY AND THE DEALER KEPT THE OLD PART. HAVE FOUND FROM OTHERS THROUGH THE INTERNET THAT THIS PLAY AND NOISE IS VERY COMMON BUT NO ONE KNEW THE CAUSE UNTIL RECENTLY. *NM