1996 Toyota Tacoma

RIGHT SIDE REAR LEAF SPRING BROKE IN HALF AT 79,000 MILES. RODLAND TOYOTA IN EVERETT, WA. STATED THIS IS NOT COVERED UNDER THE EXTENDED WARRANTY. THE SERVICE DEPARTMENT DID NOT MENTION THIS AS A KNOWN PROBLEM. NO OFFERS WERE EXTENDED TO CORRECT THE DEFECT. NO MENTION WAS MADE WHEN I PURCHASED THE TRUCK 6 MONTHS AGO (OCT. 03). TRUCK WAS SAID TO BE IN EXCELLENT CONDITION.

BAD REAR LEAF SPRINGS, CAUSING EXTREME INSTABILITY. VEHICLE: 1996 TOYOTA TACOMA 4X4 REGULAR CAB, REGULAR BED, 4CYLINDER. THE MIDDLE REAR LEAF SPRING HAS A TENDANCY TO BREAK, EVEN UNDER LIGHT LOADS.*AK ON MY TRUCK, THE DRIVER'S SIDE BROKE AT AROUND 100,000 MILES, THE PASSENGER SIDE BROKE AT ABOUT 110,000 MILES. THIS CREATED TWO PROBLEMS: 1) THE REAR OF THE TRUCK TENDS TO LEAVE THE GROUND ON EVEN SMALL BUMPS. 2) THERE IS LESS WEIGHT TOWARDS THE FRONT OF THE VEHICLE, CAUSING A SERIOUS DEGRADATION IN STEERING CONTROL. MY SPRINGS BROKE WITH NO LOAD, I HEARD IT HAPPEN EACH TIME. I CONTACTED A TOYOTA DEALERSHIP EXPECTING THERE IS SOME SORT OF RECALL ON THESE SPRINGS, THEY SAID NO, BUT THERE WAS A 'TECHNICAL BULLETIN' FOR REPLACEMENT OF THESE SPRINGS. TOYOTA WOULD NOT PAY FOR THE REPLACEMENT, EXCEPT IF UNDER WARRANTY. (MY WARRANTY EXPIRED AT 100,000 MILES) THEY WANTED $345 EACH SIDE, PLUS LABOR TO HAVE THE PROBLEM FIXED. THERE WAS NO WAY I COULD AFFORD IT. I DROVE AROUND WITH FOR A YEAR AND A HALF WITH A BROKEN LEAF SPRING ON EACH SIDE, WONDERING WHEN I WOULD GET IN A CRASH. HOW MANY OTHER TACOMA'S OUT THERE HAVE THIS SAME PROBLEM? MANY! I DID SOME RESEARCH INTO FIXING THE PROBLEM MYSELF. I CALLED A LOCAL TOYOTA REPAIR SHOP (NOT THE DEALERSHIP), THEY STATED THAT THIS IS A MAJOR AND VERY VERY COMMON PROBLEM WITH 1996 TACOMA'S, THAT I WAS THE FOURTH CALLER FOR THAT DAY ALONE ASKING ABOUT THE SPRINGS. DOING MORE RESEARCH ON THE INTERNET, I LEARNED ABOUT COUNTLESS CASES OF BOTH LEAF SPRINGS BREAKING, WITH AND WITHOUT A LOAD. THIS NEEDS TO BE A SAFETY RECALL BECAUSE THE SPRINGS ARE PRONE TO FAILURE AND THE VEHICLE IS EXTREMELY UNSTABLE WHEN THEY ARE BROKEN. I HAVE HIGH QUALITY DIGITAL PHOTO'S AVAILABLE, THE WEB SITE IS STILL BEING DEVELOPED HTTP://TACOMASPRINGS.HOME.COMCAST.NET EMAIL OR CALL, I CAN SEND OUT THE WHOLE CD, I HAVE MORE THAN 50 PHOTOS TOTAL, ALL TAKEN AT 3.1MEGPIXEL. OTAR@FASTERMAIL.COM THANK YOU. SEAN

REAR LEAF SPRING ON PASSENGER SIDE (# 2 LEAF) HAS CRACKED, LEADING TO UNPREDICTABLE REAR SUSPESION BEHAVIOR OVER BUMPS. THIS IS A WIDELY KNOWN PROBLEM. TOYOTA IS AWARE THAT THERE IS A HIGH FAILURE RATE ON TACOMA LEAF SPRINGS, AS ARE ALL PARTS AND SERVICE PERSONNEL THAT I HAVE SPOKEN TO. THIS IS A VERY EXPENSIVE REPAIR FOR A KNOWN PROBLEM, TOYOTA SHOULD BE PROVIDING ASSISTANCE/RECALL.

CONSUMER STATED THE HEAD GASKET BEGAN TO LEAK RED FLUID, IT WAS DETERMINED THAT BOTH HEAD GAKSKETS WERE CRACKED, CONSUMER HAS SINCE RETURED TO THE DEALER ON 3 OTHER OCCASIONS COMPLAING ABOUT AN ENGINE NOISE, CONSUMER THEN LEARNED THAT THE HEAD GASKET WAS NEVER REPLACED, CONSUMER FINALLY HAD THE GASKET REPLACED AND THE NOISE BECAME EVEN LOUDER, CONSUMER WAS INFORMED THAT AFTER HEAD GASKET WORK IS PERFORMED THAT POTENTIAL FOR LATER DAMAGE WAS COMMON.*JB