NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
614 reports1,200 miles · Jun 11, 2011
Latches/locks/linkagesStructureInjury
MY 2 YEAR OLD DAUGHTER GOT HER LEG CAUGHT IN THE BACK PART OF THE SLIDING DOOR OF A 2011 TOYOTA SIENNA. SHE WAS INSIDE THE CAR. THE DOOR WAS OPENED. HER LEG FELL INTO THE SPACE WHILE THE DOOR WAS OPENING. THE DOOR OPENED AS FAR AS IT COULD AND CONSTRICTED HER LEG. HER LEG WAS SO TIGHTLY CONSTRICTED WE COULD NOT REPOSITION H…
Read full complaint
MY 2 YEAR OLD DAUGHTER GOT HER LEG CAUGHT IN THE BACK PART OF THE SLIDING DOOR OF A 2011 TOYOTA SIENNA. SHE WAS INSIDE THE CAR. THE DOOR WAS OPENED. HER LEG FELL INTO THE SPACE WHILE THE DOOR WAS OPENING. THE DOOR OPENED AS FAR AS IT COULD AND CONSTRICTED HER LEG. HER LEG WAS SO TIGHTLY CONSTRICTED WE COULD NOT REPOSITION HER BODY TO OPEN THE DOOR. AVERILL PARK FIRE DEPT AND SAND LAKE AMBULANCE ARRIVED ON THE SCENE. SHE WAS TRAPPED(SCREAMING) FOR 20 -25 MINUTES. HER LEG WAS COLD AND TURNING BLUE BEFORE IT WAS REMOVED. WE WENT TO THE HOSPITAL CONCERNED FOR INTERNAL BLEEDING, BROKEN LEG, AND OTHER COMPLICATIONS. SHE IS DOING FINE BUT I'M VERY CONCERNED ABOUT THE DESIGN OF THE DOOR. I'VE LOOKED AT OTHER MINIVANS (EVEN THE SAME MAKE AND MODEL BUT DIFFERENT YEAR) AND THEY DON'T HAVE THE GAP IN THE BACK PART OF THE DOOR LIKE THE 2011 TOYOTA SIENNA. UPDATED IVOQ 07/27/11 *TR
NHTSA ODI #10405994
300 miles · May 27, 2011
Power TrainCrash
THE CAR ACCELERATES VERY RAPIDLY IN REVERSE AFTER A COLD START. A MORNING A FEW DAYS AFTER BUYING THE CAR, I STARTED IT UP, SHIFTED INTO REVERSE, AND SLOWLY RELEASED THE BRAKE PEDAL. THE CAR BEGAN ACCELERATE BACKWARDS SO RAPIDLY THAT I THOUGHT I MUST INADVERTENTLY PUT MY FOOT ON THE ACCELERATOR. I PULLED MY FOOT AWAY FROM THE …
Read full complaint
THE CAR ACCELERATES VERY RAPIDLY IN REVERSE AFTER A COLD START. A MORNING A FEW DAYS AFTER BUYING THE CAR, I STARTED IT UP, SHIFTED INTO REVERSE, AND SLOWLY RELEASED THE BRAKE PEDAL. THE CAR BEGAN ACCELERATE BACKWARDS SO RAPIDLY THAT I THOUGHT I MUST INADVERTENTLY PUT MY FOOT ON THE ACCELERATOR. I PULLED MY FOOT AWAY FROM THE PEDALS BUT THE CAR CONTINUED TO ACCELERATE. I SHIFTED INTO PARK, BUT BEFORE THERE WAS ANY CHANGE IN SPEED THE CAR CRASHED INTO MY NEIGHBOR'S CAR ACROSS THE STREET, CAUSING OVER $5,000 IN DAMAGE. IF THERE HAD BEEN SOMEONE STANDING ACROSS THE STREET, IT WOULD LIKELY HAVE BEEN A FATALITY. I CONTACTED TOYOTA AND THEY SENT OUT A CORPORATE REPRESENTATIVE TO EXAMINE THE CAR. HE ACKNOWLEDGED THERE WAS RAPID ACCELERATION IN REVERSE, AND STATED THAT WAS "NORMAL" OPERATION FOR THE CAR AFTER A COLD START, AND THAT IT WOULD BE EVEN FASTER IN COLD WEATHER (WE LIVE IN SOUTHERN CALIFORNIA). HE STATED THEY HAD INCREASED THE CAR IDLE SPEED AFTER COLD STARTS FOR POLLUTION CONTROL PURPOSES, AND THIS WAS THE RESULT. I CAREFULLY REVIEWED THE OWNER'S MANUAL AND INSIDE OF THE CABIN FOR ANY WARNING ABOUT RAPID ACCELERATION IN REVERSE AFTER A COLD START, AND THERE WAS NONE. I HAVE ALWAYS BEEN A CAREFUL DRIVER WHO HAS MAINTAINED A GOOD DRIVER DISCOUNT, AND NOTHING REMOTELY LIKE THIS HAS EVER HAPPENED TO ME BEFORE. AT THE VERY LEAST, BECAUSE THE COMPANY IS AWARE OF THIS ISSUE THEY SHOULD PROMINENTLY PROVIDE WARNINGS TO NEW CAR BUYERS AND OWNERS. I AM CONCERNED THAT THIS IS A DESIGN DEFECT WILL RESULT IN INJURY AND DEATH IF NOT ADDRESSED PROMPTLY. *TR
NHTSA ODI #10402983
20,400 miles · May 26, 2011
Vehicle Speed ControlCrashInjury
TL*THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT WAS DRIVING 10 MPH INTO THE RESIDENTS DRIVEWAY WHEN PRESSURE WAS APPLIED TO THE BRAKE PEDAL AND THE VEHICLE UNEXPECTEDLY ACCELERATED WITH THE RPMS RAPIDLY INCREASING. THE VEHICLE FAILED TO SLOW DOWN AND CRASHED INTO THE STONE STRUCTURE OF THE GARAGE. THE FRONT SEAT PASSENGER …
Read full complaint
TL*THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT WAS DRIVING 10 MPH INTO THE RESIDENTS DRIVEWAY WHEN PRESSURE WAS APPLIED TO THE BRAKE PEDAL AND THE VEHICLE UNEXPECTEDLY ACCELERATED WITH THE RPMS RAPIDLY INCREASING. THE VEHICLE FAILED TO SLOW DOWN AND CRASHED INTO THE STONE STRUCTURE OF THE GARAGE. THE FRONT SEAT PASSENGER SUFFERED A MINOR INJURY TO THE SHOULDER. THE FRONT PASSENGER SIDE FENDER WAS DAMAGED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER. A POLICE REPORT WAS FILED. THE CAUSE OF FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE UNINTENDED ACCELERATION. THE APPROXIMATE FAILURE MILEAGE WAS 20,400.
NHTSA ODI #10402883
850 miles · May 9, 2011
Service Brakes, HydraulicCrash
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE DRIVING 3 MPH IN REVERSE. THE BRAKES WERE ENGAGED AND DEPRESSED INTO THE FLOORBOARD ABNORMALLY AND THE VEHICLE DID NOT RESPOND. THE CONTACT WAS UNABLE TO STOP THE VEHICLE AND WAS INVOLVED IN A CRASH. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. TH…
Read full complaint
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE DRIVING 3 MPH IN REVERSE. THE BRAKES WERE ENGAGED AND DEPRESSED INTO THE FLOORBOARD ABNORMALLY AND THE VEHICLE DID NOT RESPOND. THE CONTACT WAS UNABLE TO STOP THE VEHICLE AND WAS INVOLVED IN A CRASH. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE MANUFACTURER SENT AN INVESTIGATOR TO INSPECT THE VEHICLE FOR THE FAILURE, HOWEVER, THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE CURRENT MILEAGE WAS 3,500 AND THE FAILURE MILEAGE WAS 850.
NHTSA ODI #10399598
10,000 miles · May 6, 2011
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2011 TOYOTA SIENNA. WHILE DRIVING APPROXIMATELY 10 MPH AND COMING TO A STOP, THE CONTACT HEARD A LOUD BANGING NOISE IN THE REAR OF THE VEHICLE. THE CONTACT STATED THE FAILURE OCCURRED AT DIFFERENT SPEEDS AND MORE FREQUENTLY WHEN DRIVING ON THE HIGHWAY. WHILE DRIVING AT HIGHWAY SPEEDS THE VEHICLE BEGAN TO S…
Read full complaint
TL*THE CONTACT OWNS A 2011 TOYOTA SIENNA. WHILE DRIVING APPROXIMATELY 10 MPH AND COMING TO A STOP, THE CONTACT HEARD A LOUD BANGING NOISE IN THE REAR OF THE VEHICLE. THE CONTACT STATED THE FAILURE OCCURRED AT DIFFERENT SPEEDS AND MORE FREQUENTLY WHEN DRIVING ON THE HIGHWAY. WHILE DRIVING AT HIGHWAY SPEEDS THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIANS WERE UNABLE TO DETERMINE THE FAILURE. THE TECHNICIANS SUGGESTED THE REAR BRAKES, ROTORS, AND CALIPERS BE REPLACED. AFTER THE REPAIRS WERE PERFORMED THE REAR PASSENGER SIDE TIRE LOCKED TWICE. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE TECHNICIANS STATED THE VEHICLE SHOWED EXTENSIVE WEAR AND OVER HEATING OF THE PARKING BRAKE DUE TO DRIVING WHILE THE PARKING BRAKE WAS ENGAGED. THE CONTACT STATED THE PARKING BRAKE WAS NOT ENGAGED WHILE DRIVING AND THE OVERHEATING ONLY OCCURRED TO THE REAR PASSENGER SIDE BRAKES. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 10,000.
NHTSA ODI #10399303
18,200 miles · Apr 20, 2011
Electrical SystemExterior Lighting
FAILURE OF DRIVER'S CABIN LAMP OVERRIDE SWITCH TO EXTINGUISH CABIN READING LIGHTS OBSCURED DRIVER'S VISION AT NIGHT DURING HIGH-SPEED MERGE MANEUVER: I WAS ATTEMPTING A HIGH-SPEED HIGHWAY MERGE, AT NIGHT, ENTERING ROUTE 29 FROM THE LEFT SIDE OF THE HIGHWAY, WHEN MY THREE-YEAR-OLD SON DISCOVERED THAT HE WAS NOW TALL ENOUGH TO OP…
Read full complaint
FAILURE OF DRIVER'S CABIN LAMP OVERRIDE SWITCH TO EXTINGUISH CABIN READING LIGHTS OBSCURED DRIVER'S VISION AT NIGHT DURING HIGH-SPEED MERGE MANEUVER: I WAS ATTEMPTING A HIGH-SPEED HIGHWAY MERGE, AT NIGHT, ENTERING ROUTE 29 FROM THE LEFT SIDE OF THE HIGHWAY, WHEN MY THREE-YEAR-OLD SON DISCOVERED THAT HE WAS NOW TALL ENOUGH TO OPERATE HIS OVERHEAD PERSONAL READING LIGHT. MY VISION OF MERGING TRAFFIC TO THE RIGHT WAS SUDDENLY OBSCURED BY THE UNEXPECTED OPERATION OF THE CABIN READING LAMP, AND THE SITUATION WAS COMPOUNDED BY MY INABILITY TO QUICKLY OVERRIDE THE LAMP FROM THE DRIVER'S POSITION, IN THE MANNER AS DIRECTED ON PAGE 526 OF THE OWNER'S MANUAL. THE READING LIGHT ABOVE MY SON'S HEAD STAYED ON. ACCORDING TO THE SIENNA 2011 OWNER'S MANUAL ON PAGE 526, THE DOOR LIGHT BUTTON, ABOVE THE DRIVER'S HEAD, ALSO SERVES AS AN OVERRIDE FOR ALL THE PERSONAL CABIN READING LIGHTS WHEN THE "DOOR" FUNCTION IS DISABLED: PAGE 526: "REAR ON/OFF: REAR PERSONAL/INTERIOR LIGHTS TURN ON [UPON ACTIVATION OF THE ILLUSTRATED INDIVIDUAL READING LAMP BUTTONS AT EACH SEATING POSITION] WHEN THE PERSONAL/INTERIOR MAIN SWITCH IS IN DOOR POSITION." THE DUAL FUNCTIONALITY OF THE DOOR LIGHT BUTTON IS CONFIRMED; ON PAGE 525 OF THE MANUAL, THE OTHER WELL-KNOWN PURPOSE OF THE DOOR BUTTON IS SEPARATELY AND INDEPENDENTLY DESCRIBED TO ACTIVATE AUTOMATIC CABIN ILLUMINATION WHEN ENTERING/EXITING THE VEHICLE: PAGE 525: "DOOR POSITION: THE PERSONAL/INTERIOR LIGHTS AND REAR INTERIOR LIGHT COME ON WHEN A DOOR IS OPENED. THEY TURN OFF WHEN THE DOORS ARE CLOSED." THEREFORE, THE REFERENCE TO THE DOOR BUTTON ON PAGE 526 IS FOR THE SEPARATE OVERRIDE FEATURE. THANK YOU FOR YOUR CONSIDERATION. I RECOMMEND TOYOTA RECALL THE AFFECTED VEHICLES, TO CORRECT THE FUNCTIONING OF THE CABIN LAMP OVERRIDE SWITCH AS THIS IS AN ESSENTIAL SAFETY FEATURE OF THE VEHICLE FOR NIGHTTIME DRIVING WITH PASSENGERS.
NHTSA ODI #10397688
100 miles · Apr 13, 2011
Structure
TL*THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT NOTICED THAT THE REAR SLIDING DOOR REMAINED STUCK IN AN OPEN POSITION INTERMITTENTLY. THE FAILURE OCCURRED WHILE USING THE MANUAL OPERATION OR POWER ASSIST BUTTON. THE VEHICLE WAS TAKEN TO THE DEALER ON FIVE OCCASIONS AND THEY WERE UNABLE TO DUPLICATE THE FAILURE. A COMPLAI…
Read full complaint
TL*THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT NOTICED THAT THE REAR SLIDING DOOR REMAINED STUCK IN AN OPEN POSITION INTERMITTENTLY. THE FAILURE OCCURRED WHILE USING THE MANUAL OPERATION OR POWER ASSIST BUTTON. THE VEHICLE WAS TAKEN TO THE DEALER ON FIVE OCCASIONS AND THEY WERE UNABLE TO DUPLICATE THE FAILURE. A COMPLAINT WAS FILED WITH THE MANUFACTURER AND THEY ADVISED THE CONTACT THAT A REMEDY WOULD BE AVAILABLE IN MARCH 2011; HOWEVER, WHEN THE VEHICLE WAS TAKEN TO THE DEALER TO BE REPAIRED THE DEALER INFORMED THE CONTACT THAT THE PART WAS NOT AVAILABLE. THE CURRENT MILEAGE WAS 5,200 AND THE FAILURE MILEAGE WAS 100.
NHTSA ODI #10395795
6,400 miles · Apr 13, 2011
Structure
TL*THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE VEHICLE WAS PARKED WITH THE REAR LIFT GATE OPEN; HOWEVER, THE CONTACT PRESSED THE BUTTON TO CLOSE THE LIFT GATE AND SHE ATTEMPTED TO TAKE AN ITEM FROM INSIDE THE VEHICLE AND NEARLY SUSTAINED AN INJURY WHEN THE LIFT GATE CONTINUED TO CLOSE. THE CONTACT THOUGHT THERE WOULD BE AN AUTOMA…
Read full complaint
TL*THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE VEHICLE WAS PARKED WITH THE REAR LIFT GATE OPEN; HOWEVER, THE CONTACT PRESSED THE BUTTON TO CLOSE THE LIFT GATE AND SHE ATTEMPTED TO TAKE AN ITEM FROM INSIDE THE VEHICLE AND NEARLY SUSTAINED AN INJURY WHEN THE LIFT GATE CONTINUED TO CLOSE. THE CONTACT THOUGHT THERE WOULD BE AN AUTOMATIC OVERRIDE SYSTEM IN PLACE TO STOP THE LIFT GATE FROM CLOSING IF AN OBJECT WAS OBSTRUCTING ITS PATH. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT EQUIPPED WITH A FEATURE TO AUTOMATICALLY STOP THE DOOR FROM CLOSING. THE FAILURE AND CURRENT MILEAGES WERE 6,400. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10395706
60 miles · Apr 10, 2011
Structure
PURCHASED 2011 SIENNA LE VAN IN OCTOBER 2010. ALMOST IMMEDIATELY THE POWER SLIDING DOORS INTERMITTENTLY OPEN AN INCH OR LESS & ALARM SOUNDS. YOU CAN'T OPEN OR CLOSE DOOR AT THIS POINT. YOU HAVE TO MAN-HANDLE IT TO CLOSE. EVEN TURNING OFF THE POWER DOOR WITH THE SWITCH DOES NOT HELP. TOOK IT TO THE DEALER & THEY SAID TOYOTA…
Read full complaint
PURCHASED 2011 SIENNA LE VAN IN OCTOBER 2010. ALMOST IMMEDIATELY THE POWER SLIDING DOORS INTERMITTENTLY OPEN AN INCH OR LESS & ALARM SOUNDS. YOU CAN'T OPEN OR CLOSE DOOR AT THIS POINT. YOU HAVE TO MAN-HANDLE IT TO CLOSE. EVEN TURNING OFF THE POWER DOOR WITH THE SWITCH DOES NOT HELP. TOOK IT TO THE DEALER & THEY SAID TOYOTA CORP. KNOWS ABOUT IT BUT NO IDEA HOW TO REPAIR. I SHOULD JUST CHECK BACK AT NEXT 5000 MILES CHECK. WHAT IF DOOR GETS STUCK OPEN & IT'S RAINING.... ONLY OPTION IS TO SHUT OFF THE POWER DOORS & USE MANUALLY. I BOUGHT THIS MODEL BECAUSE OF THE POWER SLIDING DOORS! *TR
NHTSA ODI #10395399
2,100 miles · Mar 25, 2011
Electrical SystemLatches/locks/linkages
MY NEW 2011 TOYOTA SIENNA LE AUTOMATIC POWER SLIDING DOOR ON THE DRIVER SIDE STOPPED WORKING. IT WON'T OPEN OR CLOSE USING REMOTE CONTROL AS WELL AS TOP CONSOLE/PILLAR SWITCHES. IF I TRY TO OPEN USING REMOTE CONTROL OR SWITCHES THEN IT WILL TRY TO OPEN BUT CLOSE IMMEDIATELY AND MAKE BEEPING SOUNDS. I TOOK THE VEHICLE TO THE LOC…
Read full complaint
MY NEW 2011 TOYOTA SIENNA LE AUTOMATIC POWER SLIDING DOOR ON THE DRIVER SIDE STOPPED WORKING. IT WON'T OPEN OR CLOSE USING REMOTE CONTROL AS WELL AS TOP CONSOLE/PILLAR SWITCHES. IF I TRY TO OPEN USING REMOTE CONTROL OR SWITCHES THEN IT WILL TRY TO OPEN BUT CLOSE IMMEDIATELY AND MAKE BEEPING SOUNDS. I TOOK THE VEHICLE TO THE LOCAL TOYOTA DEALER COUPLE OF TIMES BUT THEY SIMPLY SAID THERE IS NO PROBLEM. FINALLY, WHEN I CALLED TOYOTA DIRECTLY THEN THE SAME DEALER DIAGNOSED IT FURTHER AND FOUND A FAULT CODE C224 IN THE SYSTEM. TOYOTA REFUSED TO FIX THE ISSUE PROMPTLY UNTIL WE FILED FOR ARBITRATION TO REPLACE THE CAR OR REFUND VEHICLE PURCHASE PRICE. TOYOTA FINALLY REPLACED POWER SLIDING DOOR MOTORS FOR BOTH LEFT AND RIGHT SIDE TO ADDRESS THE ISSUE. *TR
NHTSA ODI #10392924
Official recalls
14Oct 17, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Additional source detail variants (2)
Air Bags:frontal:passenger Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Air Bags:frontal:driver Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Jan 9, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2014-2016 Toyota 4Runner, 2014-2015 Scion xB, Lexus IS350C, IS250C, 2014 Toyota Sienna, Lexus IS-F, and 2014-2017 Lexus GX460 vehicles sold, or ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Toyota is also recalling certain 2011-2013 Toyota Corolla, Corolla Matrix, Lexus IS250, IS350, 2011-2016 4Runner, 2011-2015 Scion xB, Lexus IS350C, IS250C, 2011-2014 Toyota Sienna, Lexus IS-F, 2011-2017 Lexus GX460, and 2011-2012 Lexus ES350 vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Toyota is also recalling certain 2010-2013 Toyota Corolla, Corolla Matrix, Lexus IS350, 2010-2016 4Runner, 2010-2013 Lexus IS250, 2010-2015 Scion xB, Lexus IS350C, IS250C, 2010-2017 Lexus GX460, 2010-2014 Lexus IS-F, and 2010-2012 Lexus ES350 vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules, used as original equipment or replacement equipment (such as after a vehicle crash necessitating replacement of the original air bags), that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator, or replace the air bag assembly. The recall began February 15, 2019. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are "Zone A" Toyota: G0P, Lexus: GLG; "Zone B" Toyota: G0R, Lexus GLH; "Zone C" Toyota: H0A, and Lexus: HLA.
Nov 29, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2011-2016 Toyota Sienna minivans manufactured January 4, 2010, to August 12, 2016. If the power sliding door is unable to be opened when commanded, such as if the door is frozen shut, the door may subsequently open unexpectedly, possibly while the vehicle is moving.
Consequence & remedy
Consequence: If door opens while the vehicle is moving, there would be an increased risk of injury to the vehicle occupants.
Remedy: Toyota will notify owners, and dealers will replace the junction block, rear sliding door wire harnesses, and install two sub wire harnesses, free of charge. The recall began on July 28, 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G04.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
May 23, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2011 Scion xB and Lexus IS F, 2009-2011 Toyota Corolla and Corolla Matrix, 2006-2011 Toyota Yaris, Lexus IS250 and Lexus IS350, 2010-2011 Toyota 4Runner, Lexus IS250C, Lexus IS350C and Lexus GX460, 2011 Sienna, 2007-2011 Lexus ES350, and 2009-2010 Pontiac Vibe vehicles, originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Toyota is recalling certain model year 2008 Scion xB and Lexus IS F, 2007-2008 Toyota Yaris, 2006-2008 Lexus IS250 and Lexus IS350 and 2007-2008 Lexus ES350 vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Toyota will notify the Toyota and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. The recall began on December 6, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for interim notification for this campaign are G1P (Toyota Zone A), G1R (Toyota Zone B), G2G (Lexus Zone A), and G2H (Lexus Zone B). Toyota's numbers for final remedy for this campaign are G0P (Toyota Zone A), G0R (Toyota Zone B), GLG (Lexus Zone A), and GLH (Lexus Zone B).
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
May 22, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence & remedy
Consequence: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Remedy: Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Nov 30, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 THROUGH 2012 SIENNA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 110, "TIRE SELECTIONS AND RIMS." THESE VEHICLES DO NOT MEET THE REQUIREMENT FOR DISPLAYING THE CORRECT VEHICLE CAPACITY WEIGHT AS THE RATED LOAD FOR THE COMBINATION OF CARGO AND OCCUPANTS.
Consequence & remedy
Consequence: INCORRECT INFORMATION ON THE VEHICLE PLACARD MAY LEAD TO TIRE OVERLOADING AND POSSIBLY CAUSE TIRE FAILURE INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND WILL PROVIDE A REMEDY WHEN IT IS AVAILABLE. TOYOTA WILL MAIL OUT A CORRECTED PLACARD TO CUSTOMERS ALONG WITH REVISED OWNER MANUAL INFORMATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 27, 2013. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Nov 22, 2011
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010-2011 COROLLA VEHICLES EQUIPPED WITH A NON-TOYOTA, BLUE TOOTH HANDS FREE DEVICE OR NAVIGATION UNIT AND CERTAIN MODEL YEAR 2011 TOYOTA SIENNA VEHICLES EQUIPPED WITH A NON-TOYOTA, OVERHEAD ENTERTAINMENT SYSTEM AND/OR BLUETOOTH HANDS FREE DEVICE. THERE IS A POSSIBILITY THAT THE FRONT A-PILLAR TRIM PANEL RETENTION CLIP MAY HAVE BEEN DAMAGED DURING THE INSTALLATION OF THE AFTERMARKET ACCESSORY.
Consequence & remedy
Consequence: A DAMAGED A-PILLAR TRIM PANEL RETENTION CLIP MAY ALLOW THE TRIM PANEL TO COME LOOSE AND INJURE AN OCCUPANT IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE A-PILLAR TRIM PANEL RETENTION CLIP AND REPLACE IT IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 30, 2011. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jun 1, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 VENZA AND SIENNA PASSENGER CARS MANUFACTURED FROM MARCH 7, THROUGH MARCH 10, 2011. THERE IS A POSSIBILITY THAT THE FRONT, RIGHT, DRIVE SHAFT MAY BREAK DUE TO INSUFFICIENT HEAT TREATMENT.
Consequence & remedy
Consequence: SHOULD THE DRIVE SHAFT BREAK DURING VEHICLE OPERATION, THE VEHICLE WILL LOSE POWER WITHOUT PRIOR WARNING. LOSS OF MOTIVE POWER WITHOUT WARNING MAY INCREASE THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE DRIVE SHAFT, AND, IF THE DRIVE SHAFT IS IDENTIFIED AS ONE THAT MAY NOT HAVE BEEN CORRECTLY MANUFACTURED, IT WILL BE REPLACED WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL BEGAN ON JUNE 22, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Dec 13, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 SIENNA VEHICLES. THE BRAKE STOP LAMP SWITCH IS MOUNTED ON A SMALL BRACKET WELDED ON THE LEFT SIDE OF THE SERVICE BRAKE PEDAL SUPPORT ASSEMBLY. DUE TO ITS PROXIMITY TO THE PARKING BRAKE PEDAL, IN LIMITED CIRCUMSTANCES THE STOP LAMP SWITCH BRACKET COULD BE DAMAGED BY THE OPERATOR'S FOOT DURING PARKING BRAKE APPLICATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN BRAKE DRAG WITH ASSOCIATED BRAKE NOISE, VIBRATION, AND/OR ILLUMINATION OF THE BRAKE WARNING LIGHT. BRAKING EFFECTIVENESS COULD BE REDUCED INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE BRACKET ASSEMBLY FREE OF CHARGE. TOYOTA PLANS TO MAIL AN INTERIM OWNER NOTIFICATION IN THE MIDDLE OF JANUARY 2011, TO ADVISE OWNERS OF THE RECALL. A SECOND LETTER WILL BE MAILED WHEN PARTS ARE AVAILABLE TO COMPLETE REPAIRS. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration